NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
30 reportsClear category filterMileage unknown · Sep 9, 2026
Engine
The check engine light was on. A Ford dealership diagnosed the issue as a coolant intrusion manufacturer defect. There are a number of safety concerns associated with this issue. The primary danger of the coolant intrusion defect is catastrophic engine failure. Severe overheating, internal damage, misfires, fire hazard and oil c…
Read full complaint
The check engine light was on. A Ford dealership diagnosed the issue as a coolant intrusion manufacturer defect. There are a number of safety concerns associated with this issue. The primary danger of the coolant intrusion defect is catastrophic engine failure. Severe overheating, internal damage, misfires, fire hazard and oil contamination. There are no active recalls\campaigns\TSB for 2022 Ford Explorer XLT 2.3L EcoBoost engine. The car is available for inspection. Although, the vehicle has not been inspected by the manufacturer, police or insurance agent, the issue was presented to Ford and a claim was submitted to the insurance company that services my Mechanical Breakdown Insurance. So far the insurance company is not authorizing the work without an engine breakdown. They are not excepting the P0300 and P0316 code or the results of a barascope and other test. The Ford corporation will not provide a written statement that confirms the dealerships diagnosis is accurate. Some doctrine that states the engine long block had to be replaced to fix the coolant intrusion defect. Ford has recalled coolant intrusion issues on other engine models. I requested a formal Tiered Goodwill Review based on the Miller v. Ford framework and resolution terms. Since the service center’s portal does not display an automatic, VIN-specific internal factory code for a long block replacement. The request was denied. While the Miller v. Ford litigation established corporate accountability for structural block and cylinder coolant intrusion faults in 2.0L blocks, my 2022 2.3L engine shares a highly similar open-deck block geometry and suffers from the exact same systemic coolant failure. Furthermore, Ford has acknowledged manufacturing line coolant and block defects on 2021–2023 2.3L engines through Customer Satisfaction Programs 23B42 and 23B08. Yet there are no recalls associated with my VIN.
NHTSA ODI #11762952
Mileage unknown · Sep 5, 2026
EngineFuel/propulsion System
I have a loss of fuel pressure and flow from the fuel tank due to fuel pump failure. Sometimes my engine stalls while driving, and when I go to fill my tank with gas, the engine will not start. I have to engage it for about 15 minutes before it will start. My check engine light comes on, and I will get the low fuel indicator li…
Read full complaint
I have a loss of fuel pressure and flow from the fuel tank due to fuel pump failure. Sometimes my engine stalls while driving, and when I go to fill my tank with gas, the engine will not start. I have to engage it for about 15 minutes before it will start. My check engine light comes on, and I will get the low fuel indicator light. But more importantly I cannot pass inspection. I need my car, I am a health care professional I have contacted my dealership, a Ford Motor company representative, and the only response and action I get in return is that they are still waiting on the part to come in. It has been over a year. I need this recall to be completed as indicated by Ford Motor corporation and its dealerships, please. My contact information is [XXX], [XXX], my email is [XXX]. My vehicle is the 2022 FORD EXPLORER, VIN: [XXX], my Cell number is [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11762330
Mileage unknown · Sep 4, 2026
EngineFuel/propulsion System
Pursuant to recall 24S55 engine valve crack causing catastrophic damage. Misfire codes given and addressed independently giving brief changes however car reverted back to "limp" mode on major Dallas hwy causing extreme safety issues. Conditions confirmed by Freedom Ford Greenville Texas. Estimated replacement costs exceeds 14k.
NHTSA ODI #11762222
Mileage unknown · Aug 6, 2026
Electrical SystemEnginePower Train
RECALL COMPLIANCE & SAFETY DEFECT DESCRIPTION: The vehicle was transported via roadside assistance to a licensed manufacturer dealership due to severe engine overheating under an active manufacturer safety recall. Service personnel systematically modified intake paperwork to alter the true mechanical state upon arrival, removing…
Read full complaint
RECALL COMPLIANCE & SAFETY DEFECT DESCRIPTION: The vehicle was transported via roadside assistance to a licensed manufacturer dealership due to severe engine overheating under an active manufacturer safety recall. Service personnel systematically modified intake paperwork to alter the true mechanical state upon arrival, removing safety recall and towing documentation. Intake files were falsified with the notation stating that the customer reported a bad battery, executed solely to evade mandatory factory safety recall tracking protocols and obscure dealer liability for subsequent failures. UNAUTHORIZED SHOP-FLOOR HAZARDS & MECHANICAL DAMAGE: Following custody transfer, shop technicians induced severe physical damage to the vehicle's twin-turbocharger assembly, resulting in a snapped turbo stud and a torn engine air filter. The vehicle was subsequently operated on public roads by shop personnel for 75 to 80 unauthorized miles under active engine overheating conditions without correcting thermal or safety recall failures, creating an immediate risk of catastrophic engine block structural cracking. The safety failures triggered 13 critical system fault codes across powertrain, electrical, and battery systems, which went entirely unaddressed while the shop attempted to compel payment under an altered repair estimate. CYBER SABOTAGE OF OUTBOUND SAFETY TELEMATICS: To actively obstruct diagnostic tracking and safety verification, shop staff executed a forced remote network reset of the vehicle's cellular modem. This reset deliberately severed user profile access and entirely deactivated the outbound telematics pipeline to systematically block the outbound transmission of the 13 powertrain and thermal fault messages to the user and manufacturer databases.
NHTSA ODI #11755278
Mileage unknown · Aug 5, 2026
Engine
Exhaust manifold turbo charged cracked while driving. Exposing everyone in the vehicle to raw exhaust inside the vehicle every time it is driven. The replacement part is back ordered until September 16th from the dealership. I was told this is an extremely common issue with ford explorers. I don’t understand how this part is not…
Read full complaint
Exhaust manifold turbo charged cracked while driving. Exposing everyone in the vehicle to raw exhaust inside the vehicle every time it is driven. The replacement part is back ordered until September 16th from the dealership. I was told this is an extremely common issue with ford explorers. I don’t understand how this part is not recalled. It has slowly gotten worse and worse. No warning lamps came on. You can hear the engine or manifold rattling/ticking while the vehicle is running. The vehicle is available for inspection. I brought the vehicle to a repair shop called MIDAS. Where I was told exactly what was wrong with it. The problem is reproduced every single time the vehicle is on. The replacement part is also not covered under fords “emissions warranty”. Even though it is part of the emissions.
NHTSA ODI #11755072
60,000 miles · Aug 4, 2026
EngineFuel System, Gasoline
The contact owns a 2022 Ford Explorer. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from the vehicle before the engine seized. The check engine warning light was illuminated. The vehicle restarted after several attempts and was driven to the residence. The contact's minor gran…
Read full complaint
The contact owns a 2022 Ford Explorer. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from the vehicle before the engine seized. The check engine warning light was illuminated. The vehicle restarted after several attempts and was driven to the residence. The contact's minor grandchild was an occupant in the vehicle when the failure occurred. The contact stated that the temperature was extremely hot outside when the failure occurred. The failure was a persistent failure. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The manufacturer was not made aware of the failure. The failure mileage was approximately 60,000.
NHTSA ODI #11754722
64,598 miles · May 27, 2026
EngineFuel System, Gasoline
The contact owns a 2022 Ford Explorer. The contact stated while driving at 55 MPH, the vehicle was driving unusually rough and the vehicle stalled. In addition, the check engine warning light illuminated, and the vehicle lost motive power. The vehicle was driven to the shoulder of the road. The contact stated while attempting to…
Read full complaint
The contact owns a 2022 Ford Explorer. The contact stated while driving at 55 MPH, the vehicle was driving unusually rough and the vehicle stalled. In addition, the check engine warning light illuminated, and the vehicle lost motive power. The vehicle was driven to the shoulder of the road. The contact stated while attempting to start the vehicle, the vehicle failed to stall as intended. The vehicle was towed to the independent mechanic where it was diagnosed with a failed low pressure fuel pump. The contact was informed that the low pressure fuel pump needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure and a case was filed. The contact referenced a recall, NHTSA Campaign Number: 25V455000 (Fuel System,Gasoline) however the contact's VIN was not associated. The failure mileage was approximately 64,598.
NHTSA ODI #11740416
Mileage unknown · May 24, 2026
Electrical SystemEngineUnknown Or Other
Unknown! sometimes the rear back up camera goes into a black screen and then once in drive the info screens stays black for about 30 seconds. the cars shifting is hard at times especially when going from slow to fast like for instance on a highway on ramp the shifting is very sluggish. the cupholder are a real hazard my cupholde…
Read full complaint
Unknown! sometimes the rear back up camera goes into a black screen and then once in drive the info screens stays black for about 30 seconds. the cars shifting is hard at times especially when going from slow to fast like for instance on a highway on ramp the shifting is very sluggish. the cupholder are a real hazard my cupholder bottomed out and my drink fell thru luckily there was no liquid in the cup otherwise it could have spilled into the electrical since it is right where the gear shift is. the the car not accelarating is dangerous when you trying to get on the highway. rear camera going blank sometimes and not being able to see whats behind you even when looking around you just can not see the blindspot which the camera could if it would not go black sometimes. if the car does not shift right when it is supposed to makes it really hard to go with flow of traffic on the highway. there never have been any warning lamps, message or anything else during these incidents and it does not happen all the time but when it does it is not safe
NHTSA ODI #11739777
Mileage unknown · Apr 10, 2026
EngineFuel/propulsion SystemVisibility/wiper
There are three active recall on my car, all of which say there are not remedy available and NHTSA Recall Number 25V455 can cause engine failure that leads to a crash, was reported in July 2025, and STILL has no remedy. The other 2 recalls are NHTSA Recall Number 26V123 and NHTSA Recall Number 26V117.
NHTSA ODI #11730431
Mileage unknown · Nov 11, 2025
EngineFuel/propulsion SystemPower Train
Ford Explorer Recall – Ongoing Safety Hazard In July 2025, Ford issued a recall notice for my vehicle. Shortly after, the check engine light came on. Starting October 15, 2025, my vehicle began failing to start after refueling—making noise and taking multiple attempts to start. The same issue occurred repeatedly on October 2…
Read full complaint
Ford Explorer Recall – Ongoing Safety Hazard In July 2025, Ford issued a recall notice for my vehicle. Shortly after, the check engine light came on. Starting October 15, 2025, my vehicle began failing to start after refueling—making noise and taking multiple attempts to start. The same issue occurred repeatedly on October 23 and October 30, worsening each time. On November 3, we brought the car to a Ford dealership. They confirmed there is no available fix for the recall and said there’s “nothing they can do.” I explained this was a safety issue since I drive my son with a disability to therapy daily. They told me I would have to pay out of pocket for repairs even though the problem is linked to the recall. On November 8, while driving in Arizona, my vehicle again failed to start after refueling. Later that day, it lost power on the road, the speed dropped suddenly, and it would not accelerate. The same stalling and jerking occurred again on November 10 while my husband was driving. We contacted Ford Corporate and NHTSA, but both said nothing could be done because the recall label says the car is “still drivable.” This is inaccurate and dangerous. The car stalls and loses acceleration randomly, creating a serious risk of an accident. On November 21, the car again failed to start after refueling. This has happened multiple times each week, and Ford continues to delay a fix. My vehicle is unsafe to drive, and this unresolved recall poses an ongoing safety hazard to my family and others on the road.
NHTSA ODI #11698789
Official recalls
24Jul 14, 2026
Ford Motor Company (Ford) is recalling certain 2020-2027 Aviator and 2020-2026 Explorer vehicles. The switch for the easy-entry second-row outer seats may bind or stick, resulting in the seats unlatching, tipping, or sliding unexpectedly.
Consequence & remedy
Consequence: A seat that moves unexpectedly may not properly restrain an occupant during a crash, increasing the risk of injury.
Remedy: Dealers will inspect and replace the bezel around the switch as necessary, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model and model years. Interim letters explaining the safety risk were mailed August 19, 2026. Additional letters will be sent once the remedy is available, anticipated in January 2027. Lincoln Aviator owner notification letters were mailed August 21, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S52. This recall expands Recall 25V393. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 16, 2026.
Mar 17, 2026
Ford Motor Company (Ford) is recalling certain 2020-2026 Explorer and Lincoln Aviator vehicles. The seat belt anchor bolts at the second-row outer seating positions may be improperly secured.
Consequence & remedy
Consequence: A loose seat belt buckle may not properly restrain an occupant during a crash, increasing the risk of injury.
Remedy: Dealers will inspect the second-row outer seat belt lower anchor bolts and replace or repair them as necessary, free of charge. Owner notification letters were mailed March 30, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C18. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 19, 2026.
Mar 3, 2026
Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer, Escape, Lincoln Aviator, and Lincoln Corsair vehicles. The windshield wiper motor may fail and prevent the windshield wipers from operating properly.
Consequence & remedy
Consequence: Windshield wipers that fail to operate properly can reduce visibility, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the front wiper motors as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed April 2, 2026. Additional letters will be sent once the final remedy is available, anticipated in October 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S14. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 4, 2026.
Mar 3, 2026
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape, Lincoln Corsair, 2020-2024 Lincoln Aviator, and Explorer vehicles. The image on the center display may flip or invert, resulting in an incorrectly displayed rearview image when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: An incorrectly displayed rearview image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will update the accessory protocol interface module (APIM) software, free of charge. Owner notification letters were mailed June 23, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C11. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 5, 2026.
Oct 10, 2025
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
Consequence & remedy
Consequence: An electrical short circuit can increase the risk of a fire.
Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
Jul 7, 2025
Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco, Explorer, Lincoln Aviator, F-250 SD, F-350 SD, F-450 SD, F-550 SD, 2021-2022 Lincoln Navigator, Mustang, F-150, and 2022 Expedition vehicles. The low-pressure fuel pump may fail, which can result in an engine stall while driving.
Consequence & remedy
Consequence: An engine stall increases the risk of a crash.
Remedy: Dealers will replace the low pressure fuel pump on super duty vehicles and update the powertrain control module (PCM) software on all other affected vehicles, free of charge. Owner notification letters were mailed July 27, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S75.
Jun 27, 2025
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
Consequence & remedy
Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
Jun 13, 2025
Ford Motor Company (Ford) is recalling certain 2020-2025 Aviator, and Explorer vehicles. The switch for the easy-entry second-row outer seats may bind or stick, resulting in the seats unlatching, folding, or sliding unexpectedly while driving.
Consequence & remedy
Consequence: A seat that moves unexpectedly may not properly restrain an occupant during a crash, increasing their risk of injury.
Remedy: Dealers will inspect the second-row seat switch, and replace the bezel around the switch as necessary, free of charge. Owner notification letters were mailed August 7, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S67.
Mar 14, 2025
Ford Motor Company (Ford) is recalling certain 2020-2023 Explorer, Lincoln Aviator, and 2020-2022 Lincoln Corsair vehicles previously repaired incorrectly under recall number 23V-342. The video output may fail, preventing the rearview camera image from displaying.
Consequence & remedy
Consequence: Loss of the rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will update the Image Processing Module software, free of charge. Owner notification letters were mailed April 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S27.
Mar 14, 2025
Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles previously repaired incorrectly under recall numbers 23V-199 or 22V-255. The rear axle horizontal mounting bolt may fracture and cause the driveshaft to disconnect.
Consequence & remedy
Consequence: A disconnected driveshaft can result in vehicle rollaway when the vehicle is placed in park without the parking brake applied. A disconnected driveshaft can also result in a loss of drive power. Either of these scenarios can increase the risk of a crash.
Remedy: Dealers will update the powertrain control module (PCM) software, free of charge. Owner notification letters were mailed April 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S22.
Nov 8, 2024
Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.
Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.
Aug 23, 2024
Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco, F-150, Edge, Explorer, Lincoln Nautilus, and Lincoln Aviator vehicles equipped with either a 2.7L or 3.0L Nano EcoBoost engine. The engine intake valves may break while driving, which can result in engine failure and a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will perform an engine cycle test and replace the engine as necessary, free of charge. Owner notification letters were mailed July 3, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S55.
Aug 9, 2024
Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles equipped with the Police Interceptor Utility Package. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.
Consequence & remedy
Consequence: An engine compartment fire increases the risk of injury.
Remedy: Owners are advised to park and shut off the engine as promptly as possible upon hearing unexpected engine noises, or after experiencing an unexpected engine power reduction, or seeing smoke from the engine compartment. Dealers will update the Powertrain Control Module (PCM) software. In addition, dealers will inspect for connecting rod bearing failure and if necessary, replace the engine long block. All inspections and repairs will be performed free of charge. Owner notification letters were mailed August 15, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S52.
Oct 6, 2023
Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles. The rear axle horizontal mounting bolt may fracture and cause the driveshaft to disconnect.
Consequence & remedy
Consequence: A disconnected driveshaft can result in a loss of drive power or a vehicle rollaway if the parking brake is not applied. Either of these scenarios can increase the risk of a crash.
Remedy: Dealers will replace the subframe bushing and rear axle bolt. They will also inspect the rear axle cover for damage near the bolt hole location and replace with a new cover if any damage is found. Repairs will be performed free of charge. Owner notification letters were mailed January 19, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S55.
Sep 8, 2023
Ford Motor Company (Ford) is recalling certain 2020-2022 Lincoln Aviator and Ford Explorer vehicles equipped with 3.0L PHEV engines. A manufacturing defect in one or more of the high voltage battery cells may result in an internal short circuit and battery failure.
Consequence & remedy
Consequence: Battery failure can cause a loss of drive power, increasing the risk of a crash. Battery failure can also increase the risk of a fire.
Remedy: Dealers will perform a Battery Energy Control Module (BECM) diagnostic test and replace the high voltage battery pack, as necessary, free of charge. Owner notification letters were mailed on April 8, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford Motor Company's number for this recall is 23S53.
May 12, 2023
Ford Motor Company (Ford) is recalling certain 2020-2023 Explorer, Lincoln Aviator, and 2020-2022 Lincoln Corsair vehicles equipped with a 360-degree camera. The video output may fail, preventing the rearview camera image from displaying.
Consequence & remedy
Consequence: Loss of the rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will replace the 360-degree camera, free of charge. Owner notification letters were mailed November 10, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S23. This recall expands and replaces NHTSA recall number 23V-022. Vehicles previously repaired under 23V-022 will need to have the new remedy performed.
Apr 28, 2023
Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer Police Interceptor Utility vehicles equipped with a 12.1-inch Integrated Computer Screen (ICS). When the Display On/Off Button is used to turn the display to "Off" prior to placing the vehicle in reverse, the backup camera rearview image will not appear on the display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: A rearview camera that does not display an image can reduce the driver's rear view, increasing the risk of a crash or injury.
Remedy: Dealers will update the ICS software, free of charge. Owner notification letters were mailed July 27, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C14.
Mar 24, 2023
Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles equipped with a 2.3L RWD, 3.3L GAS, 3.3L FHEV, or 3.0L ST powertrain. The previous powertrain control module (PCM) update completed under recall 22V-255 did not include the automatic electronic parking brake feature when the vehicle is shifted to park, as intended. In addition, the rear axle horizontal mounting bolt may fracture and cause the driveshaft to disconnect.
Consequence & remedy
Consequence: Without the electronic parking brake applied, the vehicle could rollaway if the driveshaft disconnects. A disconnected driveshaft can also result in a loss of drive power. Either of these scenarios can increase the risk of a crash.
Remedy: Dealers will update the PCM software, free of charge. Owner notification letters were mailed on May 31, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S16.
Additional source detail variants (2)
Parking Brake:electrical
Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles equipped with a 2.3L RWD, 3.3L GAS, 3.3L FHEV, or 3.0L ST powertrain. The previous powertrain control module (PCM) update completed under recall 22V-255 did not include the automatic electronic parking brake feature when the vehicle is shifted to park, as intended. In addition, the rear axle horizontal mounting bolt may fracture and cause the driveshaft to disconnect.
Consequence: Without the electronic parking brake applied, the vehicle could rollaway if the driveshaft disconnects. A disconnected driveshaft can also result in a loss of drive power. Either of these scenarios can increase the risk of a crash.
Remedy: Dealers will update the PCM software, free of charge. Owner notification letters were mailed on May 31, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S16.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles equipped with a 2.3L RWD, 3.3L GAS, 3.3L FHEV, or 3.0L ST powertrain. The previous powertrain control module (PCM) update completed under recall 22V-255 did not include the automatic electronic parking brake feature when the vehicle is shifted to park, as intended. In addition, the rear axle horizontal mounting bolt may fracture and cause the driveshaft to disconnect.
Consequence: Without the electronic parking brake applied, the vehicle could rollaway if the driveshaft disconnects. A disconnected driveshaft can also result in a loss of drive power. Either of these scenarios can increase the risk of a crash.
Remedy: Dealers will update the PCM software, free of charge. Owner notification letters were mailed on May 31, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S16.
Feb 10, 2023
Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles equipped with a 2.3L engine and 10R60 automatic transmission. An unintentional powertrain control module (PCM) reset may occur while the vehicle is in motion and result in park system damage.
Consequence & remedy
Consequence: A park system that is damaged may not shift into "PARK," resulting in a vehicle rollaway and increasing the risk of injury or crash.
Remedy: Dealers will inspect the park system for damage and repair as necessary, free of charge. Owner notification letters were mailed March 28, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S05.
Feb 10, 2023
Ford Motor Company (Ford) is recalling certain 2022-2023 F-150, Mustang, Explorer, Bronco, and 2023 Lincoln Aviator vehicles equipped with automatic transmissions. The transmission may contain a loose bolt which could prevent the transmission from engaging the park gear, although the gear shifter position may indicate that the vehicle has been shifted to "PARK."
Consequence & remedy
Consequence: The inability to secure the vehicle in the park position can result in a rollaway, increasing the risk of a crash or injury.
Remedy: Dealers will inspect and, if necessary, replace the transmissions, free of charge. Owner notification letters were mailed April 25, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S06.
Jan 23, 2023
Ford Motor Company (Ford) is recalling certain 2020-2023 Explorer, Lincoln Aviator, and 2020-2022 Lincoln Corsair vehicles equipped with a 360-degree camera. The video output may fail, preventing the rearview camera image from displaying.
Consequence & remedy
Consequence: Loss of the rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will update the image processing module (IPMB) software, free of charge. Interim owner notification letters informing owners of the safety risk were mailed April 25, 2023. Owner notification letters were mailed February 13, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S02. This recall expands and replaces NHTSA recall number 21V-735. Vehicles previously repaired under 21V-735 will need to have the new remedy performed.
Sep 14, 2022
Ford Motor Company (Ford) is recalling certain 2022 Explorer and Ranger vehicles equipped with 2.3L engines. The fuel line may be loose due to improper tightening of the fuel line connection.
Consequence & remedy
Consequence: An improperly tightened fuel line connection may result in a fuel leak, increasing the risk of fire.
Remedy: Ford will inspect and replace the fuel line assembly, if needed, free of charge. Owner notification letters were mailed September 29, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S60.
Jun 24, 2022
Ford Motor Company (Ford) is recalling certain 2022 Lincoln Aviator and Ford Explorer vehicles. The engine rails may have been improperly heat-treated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 208, "Occupant Crash Protection" and 301, "Fuel System Integrity."
Consequence & remedy
Consequence: Improperly heat-treated engine rails may reduce the vehicle's structural protection in a crash, increasing the risk of injury. In addition, an engine rail may detach and contact the road while driving, increasing the risk of a crash.
Remedy: Dealers will perform an engine rail strength test and replace the rails as necessary, free of charge. If the engine rails require replacement, owners will have the option for a vehicle replacement or buyback. Owner notification letters were mailed August 22, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22C13.
Additional source detail variants (2)
Engine
Ford Motor Company (Ford) is recalling certain 2022 Lincoln Aviator and Ford Explorer vehicles. The engine rails may have been improperly heat-treated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 208, "Occupant Crash Protection" and 301, "Fuel System Integrity."
Consequence: Improperly heat-treated engine rails may reduce the vehicle's structural protection in a crash, increasing the risk of injury. In addition, an engine rail may detach and contact the road while driving, increasing the risk of a crash.
Remedy: Dealers will perform an engine rail strength test and replace the rails as necessary, free of charge. If the engine rails require replacement, owners will have the option for a vehicle replacement or buyback. Owner notification letters were mailed August 22, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22C13.
Structure:frame And Members
Ford Motor Company (Ford) is recalling certain 2022 Lincoln Aviator and Ford Explorer vehicles. The engine rails may have been improperly heat-treated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 208, "Occupant Crash Protection" and 301, "Fuel System Integrity."
Consequence: Improperly heat-treated engine rails may reduce the vehicle's structural protection in a crash, increasing the risk of injury. In addition, an engine rail may detach and contact the road while driving, increasing the risk of a crash.
Remedy: Dealers will perform an engine rail strength test and replace the rails as necessary, free of charge. If the engine rails require replacement, owners will have the option for a vehicle replacement or buyback. Owner notification letters were mailed August 22, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22C13.
Feb 16, 2022
Ford Motor Company (Ford) is recalling certain 2022 Explorer and Lincoln Aviator vehicles. The fuel filler tube may detach during a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 301, "Fuel System Integrity."
Consequence & remedy
Consequence: A detached fuel filler tube can result in a fuel leak, increasing the risk of a fire.
Remedy: Dealers will install a fuel vapor line redundant locking clip, free of charge. Owner notification letters were mailed on April 4, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22C02.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA23002 · Loss Of Motive Power
Opened Sep 29, 2023 · Closed Oct 31, 2024
Status: closed (inferred from source dates) · Engine
On July 22, 2022, the Office of Defects Investigation (ODI) granted a Defect Petition (DP22001) and opened a Preliminary Evaluation (PE22007) to investigate allegations of loss of motive power in model year (MY) 2021 Ford Bronco vehicles equipped with 2.7L EcoBoost engines. Complainants were reporting sudden engine failure while driving resulting in a loss of motive power, often without the ability to restart. During PE22007, the cause of engine failure and loss of motive power in the subject vehicles was determined to be intake valve fracture, and the full scope of vehicles affected by the subject defect was identified as all MY 2021-2022 Ford and Lincoln models equipped with either the 2.7L or 3.0L EcoBoost engines, referred to as the “Nano” engine family. If an intake valve fractures in the subject engines, it may drop into the cylinder and contact the piston, often resulting in catastrophic engine damage. On September 29, 2023, PE22007 was upgraded to an Engineering Analysis (EA23002) to further investigate the subject defect across the full scope of affected vehicles. During EA23002, ODI visited Ford facilities to review technical information related to intake valve fracture in “Nano” engines, coordinated with NHTSA’s Vehicle Research and Testing Center (VRTC), and analyzed updated field data relating the subject defect. Forensic analysis of fractured intake valves demonstrated that the defective components exhibited “grinding burn” or out of specification hardness in the area of the keeper grooves. The presence of grinding burn is evidence that during the groove grinding phase of production, the temperature of the valve became sufficiently high to alter the microstructure of the material and is indicative that the valve supplier’s manufacturing processes were not within control specifications. Grinding burn results in a hard, brittle microstructure and high residual stresses toward the surface of the valve. Through normal engine loading, a valve with grinding burn will likely fracture at the area of highest vulnerability, which is the third keeper groove. In its response to the EA23002 Information Request (IR) letter, Ford provided evidence of 396 customer complaints (including field reports), 825 warranty claims, and 936 engine exchanges. When considering both ODI and manufacturer failure report data, there have been reports representing 1066 unique vehicles within the subject vehicle population. Analysis of the failure report data demonstrates that vehicles equipped with potentially defective intake valves were built within a production “spike period” of May 2021 – October 2021. The beginning of the spike period corresponds to a ramp up in production at the valve supplier manufacturing facility, and the end of the spike period aligns with the implementation of several mid-production process improvements and the decision to change the metal alloy used to produce intake valves from “Silchrome Lite” to “Silchrome 1”. Ford began investigating the subject defect in July 2021, determined the root cause, and took corrective measures for the new production vehicles. Analysis of the failure report data demonstrates that these corrective actions were successful in eliminating the risk of intake valve fracture for subject vehicles produced after October 2021. However, Ford did not take any field action to address vehicles produced during the spike period, and in the several months following the implementation of the production changes, a significant number of field failures continued to occur. It is Ford’s assessment that not all valves produced during the spike period are defective, and that failures associated with the subject defect occur at low time in service. Analysis of the failure report data demonstrates that the vast majority of failures have occurred before 20,000 miles with over half of all reported failures occurring before 5,000 miles. The rate of reported failures related to the subject defect has steadily decreased since November 2021. ODI coordinated with NHTSA’s National Center for Statistics and Analysis (NCSA) to conduct statistical analysis and predict the number of future failures associated with the subject defect. The results of this analysis, and the trends identified through the failure report data are generally consistent with Ford’s assessment that defective intake valves will likely fail at a low time in service and indicate that the majority of subject vehicles equipped with defective valves have already experienced a failure. On August 23, 2024, Ford submitted recall 24V635 for subject vehicles equipped with “Nano” engines and built within the production spike period identified above (total population 90,736 vehicles). The remedy includes an inspection at a Ford/Lincoln dealership where the lifetime engine cycles of the vehicle will be determined. If a vehicle does not meet a threshold for lifetime engine cycles, the dealership will conduct a high RPM engine cycle accumulation procedure, which aims to identify if the vehicle is equipped with defective intake valves. Any vehicle that fails the accumulation procedure will receive an engine replacement under the recall. In addition to recall 24V635, Ford has stated that it will launch customer satisfaction campaign 24N12, which will provide extended warranty coverage to the subject vehicles through the earlier of 10 years or 150,000 miles. In view of the recall action being taken by Ford, ODI is closing this Engineering Analysis. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ23002 · Rear Axle Bolt Failure
Opened Jun 20, 2023 · Closed Feb 15, 2024
Status: closed (inferred from source dates) · Power Train:axle Assembly; Power Train:driveline:differential Unit
On July 17, 2023, the Office of Defect Investigation (ODI) opened this Recall Query (RQ) after receiving 2 consumer complaints alleging loss of vehicle forward power and/or loss of transmission torque of the rear wheels in model year (MY) 2020-2022 Ford Explorer vehicles (subject vehicles). The RQ was opened to focus on the effectiveness of the remedies of Recalls 22V-255 and 23V-199 related to the alleged problem. Recall 22V-255 involved replacing the bushing and axle cover in the following subject vehicles: 3.3L FHEV Police built before October 14, 2020, and 3.3L Gas Police vehicle built before January 31, 2021. For 2.3L RWD, 3.0L PHEV, 3.3LFHEV, and 3.0LST retail (non-police) vehicles, the recall provided an PCM software update to engage the Electronic Park Brake (EPB) when Park is commanded. The recall addressed a breakage of the rear axle bolt that can cause the driveshaft/half shafts to disconnect, resulting in a loss of transmission torque to the rear wheels necessary to hold park. If the parking brake is not applied, the loss of the primary park torque will allow the vehicle to roll in park increasing the risk of crash and injury. Recall 23V-199 addressed 674 of the subject vehicles produced from February 2, 2019 to April 4, 2022, which received an incorrect remedy under Recall 22V-255. The affected vehicles had received a previous Powertrain Control Module (PCM) update which did not include an automatic EPB engagement when vehicle is shifted to park. On October 17, 2023, Ford filed a new safety recall (Recall 23V-675) covering 238,364 MY 2020-2022 Explorer vehicles with the following powertrains: 3.3L FHEV Police, 3.3L Gas Police, 3.0L Gas Police, 2.3L RWD, 3.0L PHEV, 3.3L FHEV, 3.0L RWD and 3.0L AWD, produced from October 22, 2018 to July 6, 2022, equipped with a 3-point mounted axle design. Ford stated that the cause of the bolt fracture is due to joint design not robust to peak axle input torques and manufacturing variability. The primary contributor is insufficient bearings for maximum joint loads. This can result in bearing deformation, increasing bending stress on the bolt, which may lead to fatigue failure. On January 19, 2023, Ford amended Recall 23V-675 to add 1,942 MY 2020-2022 Explorer vehicles with the following powertrain: 3.0L RWD Platinum and King Ranch variant, produced from October 22, 2018 to July 6, 2022, equipped with a 3-point mounted axle design. In addition to the safety recall, Ford will conduct a customer satisfaction program for the following MY 2020-2022 Explorer vehicles with the following powertrains: 2.3L AWD, 3.3L Gas Retail, 3.0L Gas AWD Platinum and King Ranch, produced from October 22, 2018 to July 6, 2022. Ford stated that the Explorer powerpack variants not covered under Recalled 23V-675 do not present an unreasonable risk to motor vehicle safety due to the combination of lower peak torque levels and torque management strategies to share inputs between front and rear axles, reducing occurrence of higher torque. According to Ford, this is also evidenced by the lower current and projected failure rates. In view of the recall action being taken by Ford, ODI is closing this RQ. NHTSA will continue to monitor complaints from the customer satisfaction program vehicles and reopen this issue, if necessary. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Power Train:axle Assembly
On July 17, 2023, the Office of Defect Investigation (ODI) opened this Recall Query (RQ) after receiving 2 consumer complaints alleging loss of vehicle forward power and/or loss of transmission torque of the rear wheels in model year (MY) 2020-2022 Ford Explorer vehicles (subject vehicles). The RQ was opened to focus on the effectiveness of the remedies of Recalls 22V-255 and 23V-199 related to the alleged problem. Recall 22V-255 involved replacing the bushing and axle cover in the following subject vehicles: 3.3L FHEV Police built before October 14, 2020, and 3.3L Gas Police vehicle built before January 31, 2021. For 2.3L RWD, 3.0L PHEV, 3.3LFHEV, and 3.0LST retail (non-police) vehicles, the recall provided an PCM software update to engage the Electronic Park Brake (EPB) when Park is commanded. The recall addressed a breakage of the rear axle bolt that can cause the driveshaft/half shafts to disconnect, resulting in a loss of transmission torque to the rear wheels necessary to hold park. If the parking brake is not applied, the loss of the primary park torque will allow the vehicle to roll in park increasing the risk of crash and injury. Recall 23V-199 addressed 674 of the subject vehicles produced from February 2, 2019 to April 4, 2022, which received an incorrect remedy under Recall 22V-255. The affected vehicles had received a previous Powertrain Control Module (PCM) update which did not include an automatic EPB engagement when vehicle is shifted to park. On October 17, 2023, Ford filed a new safety recall (Recall 23V-675) covering 238,364 MY 2020-2022 Explorer vehicles with the following powertrains: 3.3L FHEV Police, 3.3L Gas Police, 3.0L Gas Police, 2.3L RWD, 3.0L PHEV, 3.3L FHEV, 3.0L RWD and 3.0L AWD, produced from October 22, 2018 to July 6, 2022, equipped with a 3-point mounted axle design. Ford stated that the cause of the bolt fracture is due to joint design not robust to peak axle input torques and manufacturing variability. The primary contributor is insufficient bearings for maximum joint loads. This can result in bearing deformation, increasing bending stress on the bolt, which may lead to fatigue failure. On January 19, 2023, Ford amended Recall 23V-675 to add 1,942 MY 2020-2022 Explorer vehicles with the following powertrain: 3.0L RWD Platinum and King Ranch variant, produced from October 22, 2018 to July 6, 2022, equipped with a 3-point mounted axle design. In addition to the safety recall, Ford will conduct a customer satisfaction program for the following MY 2020-2022 Explorer vehicles with the following powertrains: 2.3L AWD, 3.3L Gas Retail, 3.0L Gas AWD Platinum and King Ranch, produced from October 22, 2018 to July 6, 2022. Ford stated that the Explorer powerpack variants not covered under Recalled 23V-675 do not present an unreasonable risk to motor vehicle safety due to the combination of lower peak torque levels and torque management strategies to share inputs between front and rear axles, reducing occurrence of higher torque. According to Ford, this is also evidenced by the lower current and projected failure rates. In view of the recall action being taken by Ford, ODI is closing this RQ. NHTSA will continue to monitor complaints from the customer satisfaction program vehicles and reopen this issue, if necessary. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Power Train:driveline:differential Unit
On July 17, 2023, the Office of Defect Investigation (ODI) opened this Recall Query (RQ) after receiving 2 consumer complaints alleging loss of vehicle forward power and/or loss of transmission torque of the rear wheels in model year (MY) 2020-2022 Ford Explorer vehicles (subject vehicles). The RQ was opened to focus on the effectiveness of the remedies of Recalls 22V-255 and 23V-199 related to the alleged problem. Recall 22V-255 involved replacing the bushing and axle cover in the following subject vehicles: 3.3L FHEV Police built before October 14, 2020, and 3.3L Gas Police vehicle built before January 31, 2021. For 2.3L RWD, 3.0L PHEV, 3.3LFHEV, and 3.0LST retail (non-police) vehicles, the recall provided an PCM software update to engage the Electronic Park Brake (EPB) when Park is commanded. The recall addressed a breakage of the rear axle bolt that can cause the driveshaft/half shafts to disconnect, resulting in a loss of transmission torque to the rear wheels necessary to hold park. If the parking brake is not applied, the loss of the primary park torque will allow the vehicle to roll in park increasing the risk of crash and injury. Recall 23V-199 addressed 674 of the subject vehicles produced from February 2, 2019 to April 4, 2022, which received an incorrect remedy under Recall 22V-255. The affected vehicles had received a previous Powertrain Control Module (PCM) update which did not include an automatic EPB engagement when vehicle is shifted to park. On October 17, 2023, Ford filed a new safety recall (Recall 23V-675) covering 238,364 MY 2020-2022 Explorer vehicles with the following powertrains: 3.3L FHEV Police, 3.3L Gas Police, 3.0L Gas Police, 2.3L RWD, 3.0L PHEV, 3.3L FHEV, 3.0L RWD and 3.0L AWD, produced from October 22, 2018 to July 6, 2022, equipped with a 3-point mounted axle design. Ford stated that the cause of the bolt fracture is due to joint design not robust to peak axle input torques and manufacturing variability. The primary contributor is insufficient bearings for maximum joint loads. This can result in bearing deformation, increasing bending stress on the bolt, which may lead to fatigue failure. On January 19, 2023, Ford amended Recall 23V-675 to add 1,942 MY 2020-2022 Explorer vehicles with the following powertrain: 3.0L RWD Platinum and King Ranch variant, produced from October 22, 2018 to July 6, 2022, equipped with a 3-point mounted axle design. In addition to the safety recall, Ford will conduct a customer satisfaction program for the following MY 2020-2022 Explorer vehicles with the following powertrains: 2.3L AWD, 3.3L Gas Retail, 3.0L Gas AWD Platinum and King Ranch, produced from October 22, 2018 to July 6, 2022. Ford stated that the Explorer powerpack variants not covered under Recalled 23V-675 do not present an unreasonable risk to motor vehicle safety due to the combination of lower peak torque levels and torque management strategies to share inputs between front and rear axles, reducing occurrence of higher torque. According to Ford, this is also evidenced by the lower current and projected failure rates. In view of the recall action being taken by Ford, ODI is closing this RQ. NHTSA will continue to monitor complaints from the customer satisfaction program vehicles and reopen this issue, if necessary. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration