2025 Ford Explorer

Just dropped off my [XXX] and [XXX] to elementary school drove to get gas and the passenger backseat behind the driver side fell forward and slid forward. I put it back in place drove again. It did it again and it is not staying in place. I called FORD. They told me they were supposed to be a remedy for it mid September. It is mid September but I can’t have my [XXX] getting hurt with a default seat and when I called today XXX at approximately 1:20 PM mountain time the lady on the phone told me pretty much. There’s nothing that they can do about it until there’s parts to replace it even though it opposes a danger to my child. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2025 Ford Explorer. The contact received notification of NHTSA Campaign Number: 26V122000 (Engine and Engine Cooling). The contact scheduled an appointment at the local dealer after being notified of the recall. The dealer initially stated that the part would be available within a week, but the contact was subsequently informed that the part was on backorder and there was no estimated date when the part would be available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure.

I am reporting recurring engine misfires involving my 2025 Ford Explorer Platinum equipped with the 2.3L EcoBoost engine. The vehicle currently has approximately 15,700 miles. The first incident occurred approximately five months ago. The check-engine warning appeared and the vehicle was diagnosed by an authorized Ford dealership with DTC P0303, indicating a cylinder 3 misfire. The cylinder 3 spark plug was replaced. A second misfire subsequently occurred at approximately 15,700 miles. The vehicle again exhibited an engine misfire/check-engine warning and was transported through Ford Roadside Assistance for service. An authorized Ford dealership diagnosed DTC P0301, indicating a cylinder 1 misfire. I was advised that the cylinder 1 spark plug was physically damaged and that a portion/cap of the plug had broken off and was not present. I am concerned because this represents two spark-plug-related misfires involving two different cylinders of the same engine within approximately five months and at relatively low mileage. Ford has issued technical service information addressing P0301-P0304 misfires on certain 2025 Explorer vehicles equipped with the 2.3L EcoBoost engine. I am not claiming that this establishes the cause of my vehicle's failures; I am reporting the recurring condition so NHTSA can document it and evaluate it alongside any similar reports. Both incidents were diagnosed by authorized Ford dealerships. Repair documentation and manufacturer/dealership correspondence concerning the incidents have been retained and can be provided if requested. The vehicle/component may be available for further inspection if requested, subject to its current repair status.

On XXX, my 2025 Ford Explorer Platinum experienced a complete unexplained no-start failure while approximately six hours from home. The vehicle had less than 1/4 tank of fuel but was not empty and was parked on a slight decline. It remote-started normally and ran for approximately 10 minutes before automatically shutting off. Afterward, it would not restart, repeatedly displayed "Accessory Power Only," and later displayed and audibly announced "System Failure, Contact Dealer." Multiple jump-start attempts failed and the vehicle required towing to Lugoff Ford in [XXX]. Lugoff Ford documented fuel and transmission-related codes and initially advised that the vehicle appeared to need a transmission replacement. That explanation later changed, and the vehicle was returned without an identified cause or repair. I subsequently took the vehicle to Cleveland Ford in [XXX] for a second evaluation. Their repair order specifically states that Ford connected data showed a fuel-pressure code on the day of the failure, but they found no active DTCs and could not duplicate the condition. The vehicle was again returned without diagnosis or repair. I am concerned that an intermittent defect involving the fuel system, transmission controls, electrical system, software, or related components could cause another sudden disabling event. Two Ford dealers have evaluated the vehicle, evidence of the original failure exists, and the underlying cause remains unidentified and unrepaired. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2025 Ford Explorer. The contact stated that while the vehicle was parked, the vehicle was started and the doors were unlocked and the contact walked over to the front passenger’s side door to put her purse inside the vehicle; however, after the contact walked over to the rear driver’s side door to place a child into the car seat, the doors inadvertently locked and the child was trapped and locked inside the vehicle. The key fob failed to operate as designed, and the contact was unable to unlock the doors. The contact broke the rear driver’s side window to remove the child from the vehicle. No warning lights were illuminated. The vehicle was taken to a dealer, and the dealer stated that the failure might be related to a software malfunction; however, the cause of the failure was not yet determined. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 4,000.

The contact owns a 2025 Ford Explorer. The contact stated that while driving 50 MPH, the brake pedal was depressed; however, the vehicle failed to stop as intended. The vehicle crashed into the driver's side of another vehicle. The air bags failed to deploy. The vehicle was towed to a local tow yard. The contact was transported to the local medical center for medical attention. The contact sustained bruises and contusions during the crash. The contact sustained a continuous headache after the crash. The contact was receiving continuous medical treatment. A Police report was filed. The vehicle was scheduled for an inspection by the insurance company within days. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 20,000.

Steering fails to self-center after slight bear-left such as lane change manuver or steering to track a gentle left bend in road, typically holding ~10 degree left position of the steering wheel. Center feel is "notchy." Behavior is almost completely a bear-left problem and only a slight similar behavior in bear-right condition. Self-centering from hard left seems to be correct in fully returning wheel to center. This behavior has been confirmed by many owners' complaints posted online, and is a problem unique to the Explorer model and 2020+ generation. Video demonstrating problem while driving: [XXX] Explorer ST Owner Forum post confirms similar behavior by others: [XXX] My dealer is treating this as "not a problem, they all do this." No other vehicle in my life (dozens) has ever exhibited this behaviour of steering not returning to center while moving. After delivery I returned the car almost immediately to the dealer on noticing the steering just felt "weird." They found nothing. I narrowed the behavior down to the specific circumstance of bear-left and notchy on-center feel, returned it again, and again they found nothing. With ~3000mi, no change in behavior --"break-in" is long past. I know how to correct for the issue, but if I loan out the car? While it can be called a fit and finish flaw, on the outside it could be a safety issue for unfamiliar drivers. Answers to General Guidelines questions >>> Dealer has identified no failed components or need for repair after two attempts and multiple discussions of the problem. >>> Safety? Issue results in fatigue after long use of the vehicle. Drivers unfamiliar with non-return-to-center behavior may not give the neccesary corrective input to return steering to center. >>> Two dealer repair visits, both inconclusive. >>>No warning lamps etc. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

This vehicle was a rental car. The rear door opens and closes at random times. On multiple occasions even after locking the car, we would come out to the door being open. The door came down on its own and smacked my wife as well as hitting my [XXX] daughter in the head. While driving down the highway that rear door decided to open on its own putting my family in immediate grave danger. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

On repeated occasions the vehicle’s braking system has malfunctioned without driver input, including uncommanded automatic brake engagement at highway speed and, most recently, a failure of the braking system to respond as commanded. These malfunctions occur without warning and directly impede my ability to control and safely operate the vehicle. On at least one occasion the malfunction occurred while I was driving on the highway with my three minor children in the vehicle and nearly resulted in a major collision.

On XXX at approximately 4:30pm, while driving through a parking lot (between 5-10mph), I tapped my brakes and then the parking brake activated and caused several errors on my dash, such as the ABS light, a brake failure error, a service Advance-Trac error, and others. The brakes became incredibly stiff and would not work when I pressed them. The car would continue to roll and stop randomly. I was able to pull into a parking spot out of traffic and when attempting to disable to parking brake, it would not work. I had to attempt to disable it, turn off my car, and then turn it back on. After a few seconds, the parking brake audibly unlocked and then my brake pedal became usable again. I called Two Rivers Ford in [XXX] the next day and they advised that they would look at it, but it would be the end of July before they had a service loaner available. I brushed it off as an electrical glitch. On XXX at approximately 7:30pm, my car did the exact same thing again while coming to a stop on a highway. This again occurred around 10mph. I was able to get off the highway and reset the parking brake again by turning the car on and off and was able to begin driving again with no issues. On XXX I called the same dealership again and they were able to provide me with an emergency service loaner same day due to the urgency of the situation. They advised that this had happened to 5 other Explorers in the country prior, the first step is to reset the ABS Module, if that doesn't fix it, they will replace the brake booster. On XXX at approximately 9:45am, while braking prior to turning in an intersection, at approximately 30mph, the same issue occurred again. This time I rolled into the middle of the intersection, because my brakes wouldn't work. On XXX, I called the dealership and they provided me with another service loaner to attempt to replace the brake booster. This is a major safety issue due to loss of brakes. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)