2018 Ford Escape

The contact owns a 2018 Ford Escape. The contact stated that upon starting the vehicle, the message "High Engine Temperature - Service Now" was displayed. The vehicle was taken to a local dealer where the vehicle was diagnosed, and the contact was informed that there was coolant intrusion into the engine and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 77,852.

At approximately 53000, our 2018 Ford Escape began experiencing engine misfires, rough idling, and visible white smoke from the exhaust. After inspection, the dealer confirmed that coolant was leaking into the combustion chamber due to a known design flaw in the 1.5L EcoBoost engine — a condition widely reported by other Escape and Fusion owners. This issue was previously covered under Ford’s Customer Satisfaction Program (CSP 21N12), which extended short block replacement for this exact problem. However, Ford has denied coverage, citing that the vehicle is now just outside the 7-year eligibility window, despite the low mileage and the fact that this is a documented manufacturing defect, not normal wear and tear. Coolant intrusion into the engine is a critical safety risk, as it can cause sudden engine failure, stalling, and loss of power — all of which create dangerous driving conditions, especially at highway speeds. Thousands of owners are reporting identical issues online, and many have suffered catastrophic engine failure well before 100,000 miles. Request: I’m submitting this complaint to formally document the safety concern and urge the NHTSA to investigate this widespread issue and consider a recall. The current extended warranty program is inadequate, as it leaves many consumers — like myself — with no recourse for a known, dangerous defect.

the check-engine light started coming on just over mile 100k, codes came back as a cylinder misfire. Due to faulty coolant supply systems, the coolant would be used up very quickly, which could cause the engine to overheat and become dead in the water, effectively endangering anyone driving it. The vehicle has had several repairs to the engine, all for the light to come on several times more.

The contact owns a 2018 Ford Escape. The contact stated that the engine was running roughly while driving at various speeds. While driving approximately 40-50 MPH and attempting to accelerate, the vehicle failed to respond and decelerated instead. The contact was able to continue driving off the highway at a slower speed. The following day while starting the vehicle, there was white smoke coming out of the exhaust pipe. The “WRENCH” warning light was illuminated, indicating the vehicle needed to be serviced. The vehicle was taken to a certified mechanic who diagnosed the vehicle with engine failure due to a coolant leak in cylinder #2. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The dealer was contacted and confirmed that the VIN was not under recall. The vehicle was included in NHTSA Campaign Number: 22V413000 (Power Train); however, the vehicle was not taken to the dealer for the recall repair. The manufacturer was informed of the failure and provided a reference number from the dealer for the failure. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 90,000.

The contact owns a 2018 Ford Escape. The contact stated that while starting the vehicle, the check engine warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed that the purge valve had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 129,000.

The contact owns a 2018 Ford Edge. The contact stated that while her husband was driving 60 MPH, the vehicle jerked, and the temperature gauge went to hot(H). The contact stated that the check engine and two unknown warning lights were illuminated. The vehicle was steered to the side of the road, and when the hood was opened, the contact and her husband smelled a burning odor. The vehicle was towed to an independent mechanic, where it was diagnosed that the coolant had gone through the exhaust and the engine needed to be replaced. The vehicle was not repaired. The vehicle was taken to a dealer, where it was diagnosed that there was coolant intrusion into two cylinders from a cracked engine block, allowing coolant vapor out of the exhaust, and the long block needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 116,000.

Check engine light first appeared early May 2025 days after the car started running very roughly, then bucking upon startup; local mechanic said may need engine but should go to dealer; dealer towed a couple of days later as engine light had begun to blink and said it couldn't be driven; a few days later dealer reported coolant leaking into combustion chamber and would need a new engine at $12,860. Apparently a known failure as reported in Technical Service Bulletin 22-2229, date 6/9/2022 for vehicles including my 2018 Ford Escape Titanium 2.0 L Ecoboost with only 44k miles, final assembly Louisville KY. Reported danger of engine failure while driving, possible fire.

The contact owns a 2018 Ford Escape. The contact stated that when the vehicle was started, the check engine warning light illuminated. The vehicle was parked for several hours and then started, and the check engine warning light was no longer illuminated. The contact stated that while driving at an undisclosed speed, the vehicle started shaking, lost motive power, and the engine warning light started flashing. The contact pulled over to the side of the road, restated the vehicle and the check engine warning light became illuminated. The vehicle was taken to the residence. The vehicle was then taken to a dealer where it was diagnosed and determined that the spark plugs needed to be replaced. Additionally, the mechanic observed coolant leaking into the engine and determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 61,000.

The contact owns a 2018 Ford Escape. The contact stated that upon start the vehicle, the check engine warning light illuminated. The vehicle was taken to a local independent mechanic where the vehicle was diagnosed with a cylinder #2 misfire. The local dealer was contacted; however, the vehicle was not diagnosed because the VIN was not under recall. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 96,000.

The contact owns a 2018 Ford Escape. The contact stated that while driving on several occasions at various speeds, the vehicle was shuddering and shaking abnormally. The check engine waning light was illuminated. The vehicle was taken to an independent mechanic where it was diagnosed and determined that the EVAP purge valve needed to be replaced. The vehicle was repaired but the failure reoccurred two days later. The vehicle was taken back to the independent mechanic where it was diagnosed and determined that the spark plugs needed to be replaced. The vehicle was repaired but the failure persisted. The vehicle was then taken to a dealer where it was diagnosed with coolant intrusion into the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 129,000.