TL* THE CONTACT OWNS A 2008 MERCURY GRAND MARQUIS. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS AT NIGHT, THE HEADLIGHTS INTERMITTENTLY FAILED TO OPERATE WITHOUT WARNING. THE CONTACT ALSO STATED THAT THE INSTRUMENT PANEL WENT BLANK WHILE EXPERIENCING THE FAILURE. THE CONTACT STATED THAT THE HEADLIGHTS RESUMED NORMAL O…
Read full complaint
TL* THE CONTACT OWNS A 2008 MERCURY GRAND MARQUIS. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS AT NIGHT, THE HEADLIGHTS INTERMITTENTLY FAILED TO OPERATE WITHOUT WARNING. THE CONTACT ALSO STATED THAT THE INSTRUMENT PANEL WENT BLANK WHILE EXPERIENCING THE FAILURE. THE CONTACT STATED THAT THE HEADLIGHTS RESUMED NORMAL OPERATION A FEW MINUTES AFTER FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THE VIN WAS NOT UNDER RECALL. THE MANUFACTURER REFERRED THE CONTACT TO A LOCAL DEALER TO HAVE THE VEHICLE INSPECTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 72,000.
NHTSA ODI #11403459
110,000 miles · Jun 29, 2020
Electrical System
ODOMETER FADES OUT MOST OF THE TIME...SOMETIMES IT WILL BRIGHTEN UP SO YOU CAN SEE IT..BUT SOON FADES OUT AGAIN..FORD WANTS $600 TO FIX IT...2008 IS THE ONLY YEAR THAT FITS AND THERE ARE 4 DIFFERENT ONES THAT FIT..CAN'T FIND A USED ONE
NHTSA ODI #11331378
57,600 miles · Oct 9, 2019
Electrical SystemExterior Lighting
FIRST TRIED THE HAZARD WARNING LIGHTS WHILE PARKED ON THE SIDE OF A HIGHWAY AND THEY DID NOT WORK. WHEN I DROVE OFF I PUT THE HEADLIGHTS ON AND TURNED ON THE WINDSHIELD WIPERS. WHEN I GOT HOME I TURNED OFF THE WIPERS AND THE HEADLIGHTS BUT THE HEADLIGHTS STAYED ON. I DISCONNECTED THE BATTERY CABLE AND 2 DAYS LATER I DROVE TO THE…
Read full complaint
FIRST TRIED THE HAZARD WARNING LIGHTS WHILE PARKED ON THE SIDE OF A HIGHWAY AND THEY DID NOT WORK. WHEN I DROVE OFF I PUT THE HEADLIGHTS ON AND TURNED ON THE WINDSHIELD WIPERS. WHEN I GOT HOME I TURNED OFF THE WIPERS AND THE HEADLIGHTS BUT THE HEADLIGHTS STAYED ON. I DISCONNECTED THE BATTERY CABLE AND 2 DAYS LATER I DROVE TO THE FORD DEALERSHIP. WHILE DRIVING I NOTICED THAT MY TURN SIGNALS WERE NOT WORKING. WHEN I GOT TO THE DEALERSHIP I POINTED OUT THESE PROBLEMS TO THE SERVICE MANAGER. I LEFT THE CAR AND THEY DIAGNOSED A BAD LIGHT CONTROL MODULE. MY CAR IS 2008 MERCURY GRAND MARQUIS LS WITH 57,628 MILES. THEY CHARGED ME $740 TO REPLACE THE MODULE. I RESEARCHED RECALLS AND I SAW A RECALL 15S39 WITH # 15V861000 FOR THIS EXACT PROBLEM BUT IT ONLY APPLIED TO THESE SAME CARS THRU CY 2005. MY CAR IS A 2008. I TALKED TO THE DEALER AND THE FORD CUSTOMER REPRESENTATIVE AT 866 436 7332 AND THEY SAID THE NHTSA DETERMINES THE EFFECTED VIN NUMBER VEHICLES. THERE IS ALSO A FORD CUSTOMER SATISFACTION PROGRAM 14N01 WHICH DEALT WITH THIS SETTLEMENT FOR VEHICLES THRU CY 2005. I BELIEVE THEY EXTENDED THE WARRANTY FOR THE LCM MODULE FOR 15 YEARS AND 250,000 MILES FOR THE EFFECTED VEHICLES THRU CY 2005 AND THEY EVEN RECOMPENSATED CUSTOMER'S WHO PAID FOR EXORBITANT REPAIR BILLS FOR THE LIGHT CONTROL MODULE. MY DEALER INVOICE # IS 460317 WITH KELLY FORD, INC, 776 S. MAGNOLIA AVE, MELBOURNE, FL. 32935 (321) 254-4283
NHTSA ODI #11267217
37,000 miles · Dec 13, 2016
Electrical System
HEATING UNIT DOES NOT RESPOND WHEN HEAT OPTION . FLOOR , MIX ,DEFROST OPTIONS ARE SELECTED AND TEMPERATURE CONTROL IS AT MAXIMUM HOT
NHTSA ODI #10935103
Mileage unknown · Dec 12, 2016
Electrical System
THE DIGITAL SPEEDOMETER AND FUEL READINGS KEEP FLASHING ON AND OFF SOMETIMES STAYING OFF FOR SHORT PERIODS OF TIME WHILE ENGINE IS RUNNING. IS THIS SOMETHING UNDER WARRANTY.
NHTSA ODI #10934693
Mileage unknown · Oct 1, 2014
Electrical SystemPower TrainSteeringCrash
2008 MERCURY GRAND MARQUIS. CONSUMER STATES VEHICLE WAS RECALLED FOR POOR STEERING. THE CONSUMER WAS IN AN ACCIDENT WHEREBY HE WAS UNABLE TO TURN THE IGNITION KEY OFF AND SHIFT THE GEAR . *TGW
NHTSA ODI #10638927
53,850 miles · Jan 20, 2012
Electrical System
LOW BEAM HEADLIGHTS DO NOT WORK. HIGH BEAM WORKS AS WELL AS DAYTIME RUNNING LIGHTS. THE DEALER SAID THE LCM MODULE NEEDS TO BE REPLACED BUT DID NOT HAVE ONE IN STOCK AND WILL CALL ME WHEN IT COMES IN. MY CONCERN IS THIS PROBLEM HAS BEEN GOING ON SINCE AT LEAST THE YEAR 2000. NOW I HAVE A 100 DEDUCTIBLE SERVICE WARRANTY ON T…
Read full complaint
LOW BEAM HEADLIGHTS DO NOT WORK. HIGH BEAM WORKS AS WELL AS DAYTIME RUNNING LIGHTS. THE DEALER SAID THE LCM MODULE NEEDS TO BE REPLACED BUT DID NOT HAVE ONE IN STOCK AND WILL CALL ME WHEN IT COMES IN. MY CONCERN IS THIS PROBLEM HAS BEEN GOING ON SINCE AT LEAST THE YEAR 2000. NOW I HAVE A 100 DEDUCTIBLE SERVICE WARRANTY ON THIS 2008 MERCURY GRAND MARQUIS SO IT WILL NOT BE A GREAT EXPENSE FOR ME AS IT WOULD BE FOR OTHERS. THIS ISSUE SHOULD HAVE BEEN RESOLVED BY NOW. MY GUESS HERE IS FORD IS USING OVERSTOCKED EARLIER YEAR MODEL PARTS IN THE NEW MODELS BEING BUILT. I UNDERSTAND THIS IS A DEFECTIVE SOLDERING ISSUE. WHY NO RECALL? *TT
NHTSA ODI #10444628
64,316 miles · Aug 7, 2011
Electrical SystemEquipment
THE AA CONTROL WENT OUT IN APRIL 2010. I HAD BOUGHT A FORD CERTIFIED 2008 GRAND MARQUIS THAT WAS OVER ON THE MILAGE WARRENTY BUT STILL UNDER THE TIME WARENTY. THE BLOWER WOULD ONLY BLOW AIR THROUGHT THE DEFROSTERS UNDER THE WINDSHIELD. I BROUGHT IT TI THE DEALER WERE I PURCHASED IT AND AFTER INSPECTION DETERMONED THAT THE AC …
Read full complaint
THE AA CONTROL WENT OUT IN APRIL 2010. I HAD BOUGHT A FORD CERTIFIED 2008 GRAND MARQUIS THAT WAS OVER ON THE MILAGE WARRENTY BUT STILL UNDER THE TIME WARENTY. THE BLOWER WOULD ONLY BLOW AIR THROUGHT THE DEFROSTERS UNDER THE WINDSHIELD. I BROUGHT IT TI THE DEALER WERE I PURCHASED IT AND AFTER INSPECTION DETERMONED THAT THE AC CONTROL UNIT #3W7Z*19980 WENT BAD AND WAS TOLD IT NEEDED TO BE REPLACED @650.00 FORD WOULD NOT HONOR THE WARRENTY. I HAD IT RELACED. IN FEB. 2011 IT WENT OUT AGAIN. THE PART WAS COVERED UNDER THE 1 YEAR WARRENTY BUT SINCE I DRIVE FOR A LIVING FORD WOULD NOT COVER IT BEAUSE OF THE MILES. THATS ANOTHER PROBLEM THAT SHOULD BE LOOKED INTO. I LOOKED ON THE INTERNET AND FOUND THAT THERE WERE NUMEROUS TIMES THE OWNERS WERE HAVING THE SAME PROBLEM WITH THIS UNIT. MY COMPLAINT IS THIS IS A PART THAT SHOULD NEVER GO BAD IN A 2 YR. TIME FRAME THEN GO BAD AGIN IN LESS THAN A YEAR. WHATS GOING ON HERE? *TT
NHTSA ODI #10417867
6,992 miles · Oct 28, 2008
Electrical System
2008 MERCURY GRAND MARQUIS LS HAD AN ELECTRICAL OUTAGE. *NJ THE CONSUMER STATED THE TRUNK LID WOULD NOT OPEN USING THE REMOTE CONTROL OR BY PUSHING THE BUTTON. ALL OF THE LIGHTS WENT OUT ON THE INSTRUMENT PANEL AND THE HEADLIGHTS WENT OUT AS WELL. *JB
Ford Motor Company (Ford) is recalling certain model year 2005-2011 Ford Crown Victoria, 2005-2011 Mercury Grand Marquis vehicles manufactured March 23, 2004, to August 30, 2011, and 2005-2011 Lincoln Town Car vehicles manufactured March 8, 2004, to August 30, 2011, and on which the upper intermediate shaft was serviced during the course of safety recall 13V-385. The prior repairs may not have been correctly performed.
Consequence & remedy
Consequence: Improper servicing of the upper intermediate shaft could cause the shaft to separate, which can then result in a loss of steering control, and increasing the risk of a crash.
Remedy: Ford will notify the owners of vehicles whose repair records reflect that the upper intermediate steering shaft was repaired during the course of the prior recall 13V-385. Dealers will inspect and replace the upper immediate shaft if necessary free of charge. The recall began November 17, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S25.
Ford is recalling certain model year 2005-2011 Ford Crown Victoria (including Crown Victoria Police Interceptors), Mercury Grand Marquis, and Lincoln Town Car vehicles. The affected vehicles are currently registered or were originally sold in Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, and Wisconsin. Severe corrosion can seize the lower intermediate shaft which may cause the upper intermediate shaft to collapse and the steering column lower bearing to separate.
Consequence & remedy
Consequence: If the lower bearing separates, the vehicle may experience a loss of steering, increasing the risk of a crash.
Remedy: Ford will notify owners and dealers will replace the lower intermediate shaft, free of charge. The upper intermediate shaft and steering column lower bearing will be inspected to identify any damage that may have occurred as a result of lower intermediate shaft corrosion, and repaired or replaced as necessary. If the steering column lower bearing has separated, a retainer clip will be installed. The recall began on October 23, 2013. Owners may contact Ford at 1-866-436-7332. Ford's recall number is 13S08.
ON CERTAIN PASSENGER VEHICLES, A FRONT WHEEL BEARING AND HUB ASSEMBLY MAY FRACTURE DUE TO IMPROPER HEAT TREATMENT.
Consequence & remedy
Consequence: IF A HUB FRACTURES, IT MAY POTENTIALLY DETACH FROM THE WHEEL KNUCKLE, RESULTING IN THE WHEEL BEING RETAINED ONLY BY THE BRAKE CALIPER ASSEMBLY. AS A RESULT, THE WHEEL MAY SEPARATE FROM THE VEHICLE POTENTIALLY RESULTING IN A CRASH.
Remedy: DEALERS WILL INSPECT BOTH FRONT WHEEL BEARING AND HUB ASSEMBLIES AND REPLACE THEM FREE OF CHARGE. THE RECALL BEGAN ON JUNE 22, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE08060 · Tire Valve Cracking
Opened Oct 14, 2008 · Closed Apr 9, 2009
Status: closed (inferred from source dates) · Tires:valve
ON OCTOBER 14, 2008, ODI OPENED PE08-060 TO INVESTIGATE ALLEGATIONS OF CRACKED AND LEAKING SNAP-IN TIRE VALVES IN MODEL YEAR (MY) 2007 VEHICLES MANUFACTURED BY FORD MOTOR COMPANY.THE VALVES WERE SUPPLIED TO FORD BY TOPSEAL AUTO-PARTS, A SUBSIDIARY OF THE SHANGHAI BAOLONG AUTOMOTIVE CORPORATION IN CHINA.VALVES MADE BY TOPSEAL FOR AFTERMARKET SALE WERE THE SUBJECT OF TWO RECENT SAFETY RECALLS BY TECH INTERNATIONAL (08T-018) AND DILL AIR CONTROLS (08T-028), THE LATTER OF WHICH WAS INVESTIGATED BY ODI IN PE08-036 AND EA08-022.THE DEFECT CONDITIONS ADDRESSED BY THE AFTERMARKET TIRE VALVE RECALLS BOTH INVOLVED INADEQUATE RESISTANCE TO OZONE CRACKING DUE TO ISSUES WITH THE SUPPLY OF ANTI-OZONANT CHEMICALS TO TOPSEAL FOR A PERIOD FROM JULY TO MID-NOVEMBER 2006.THE AFTERMARKET VALVES WERE COMPOUNDED WITH A BLEND OF EPDM AND NATURAL RUBBER, USING A RELATIVELY LOW PERCENTAGE OF EPDM (EPDM PROVIDES INHERENT RESISTANCE TO OZONE CRACKING).HENCE, THE NEED FOR ANTI-OZONANT CHEMICALS AND THE PROBLEMS WITH CRACKING WHEN THOSE CHEMICALS WERE MISSING OR OUT OF SPECIFICATION IN SOME LOTS OF VALVES.BOTH RECALL CAMPAIGNS INVOLVED INSPECTION PROGRAMS TO IDENTIFY AND REPLACE VALVES WITH VISIBLE SURFACE CRACKING.ALTHOUGH THE TOPSEAL VALVES SUPPLIED TO FORD ALSO APPEAR TO HAVE BEEN AFFECTED BY THE ANTI-OZONANT SUPPLY ISSUES IN MID TO LATE-2006, FORD INDICATED THAT ITS VALVES WERE MADE AT A DIFFERENT TOPSEAL PRODUCTION LINE AND WERE COMPOUNDED WITH A HIGHER PERCENTAGE OF EPDM RUBBER TO MEET MORE STRINGENT SPECIFICATIONS FROM FORD.ODI'S ANALYSIS OF COMPLAINT AND WARRANTY DATA PROVIDED BY FORD SHOWED THAT PROBLEMS WITH CRACKED TIRE VALVES WERE SIGNIFICANTLY HIGHER FOR MY 2007 VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007.FORD RESPONDED BY IMPLEMENTING CHANGES IN ITS MATERIAL SPECIFICATIONS FOR SNAP-IN RUBBER TIRE VALVES AND ALSO INCREASING THE QUALITY AND ACCEPTANCE STANDARDS FOR VALVES IMPORTED FOR USE IN ITS VEHICLES.WHILE THE COMPLAINT AND WARRANTY CLAIM RATES ARE ELEVATED FOR SUBJECT VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007, THE RATES OF LEAKING VALVES ARE WELL BELOW ONE PERCENT OF PRODUCTION FOR EACH OF THE PEAK MONTHS FOR ALL OF THE AFFECTED MODELS.A SUBSTANTIAL MAJORITY OF THE SUBJECT VEHICLES ARE EQUIPPED WITH TIRE PRESSURE MONITORING SYSTEMS (TPMS) WHICH WARN THE DRIVER WHEN ANY TIRE PRESSURES DROPS BELOW 25 PERCENT OF RECOMMENDED INFLATION PRESSURE. AS OUTLINED IN A LETTER TO ODI DATED APRIL 6, 2009, FORD HAS AGREED TO SEND LETTERS TO OWNERS OF CERTAIN MY 2007 AND 2008 FORD, LINCOLN AND MERCURY VEHICLES TO PROVIDE INFORMATION ABOUT THE CRACKING CONCERN. LETTERS WILL BE SENT TO OWNERS OF VEHICLES BUILT FROM NOVEMBER 2006 THROUGH MAY 2007.OWNERS CAN OPT FOR A FREE DEALER INSPECTION.VALVES EXHIBITING SURFACE CRACKS OR AIR LEAKAGE RELATED TO OZONE ATTACK WILL BE REPLACED BY FORD UNDER ITS NORMAL WARRANTY TERMS.FORD EXPECTS TO SEND THE LETTER BY APPROXIMATELY MID-MAY 2009. BASED ON THE USE OF TPMS IN THE MAJORITY OF SUBJECT VEHICLES AND THE RELATIVELY LOW RATES OF REPAIRS ASSOCIATED WITH LEAKING VALVES AND RESULTANT TIRE DAMAGE, ODI BELIEVES THAT THE ACTIONS FORD HAS AGREED TO TAKE WILL PROVIDE EFFECTIVE AND EXPEDITIOUS RESOLUTION FOR VEHICLES THAT WERE BUILT DURING THE PERIOD WHEN VALVES WITH INADEQUATE RESISTANCE TO OZONE CRACKING WERE MOST LIKELY TO HAVE BEEN USED IN VEHICLE PRODUCTION.FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO
2008 Mercury Grand Marquis Problems, Complaints & Recalls | Skip That Year
Illustration