Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
340–25K
1325–50K
1150–75K
575–100K
12100–150K
2150K+
77 reports with mileage · 19 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Tires. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Structure. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Vehicle Speed Control. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
6 crash reports0 fire reports1 injury reports
What owners actually said
96 reports
Mileage unknown · Dec 27, 2025
Steering
Called Walker Ford in Clearwater, FL on 12/27/2025 at 09:35 am. I reported to them that two recalls that would pertain to my car, 13S08 and 13R01 needed to be performed as my steering bearing retainer has failed. They informed me it was repaired, but it has failed again. According to my research, regardless if its been performed…
Read full complaint
Called Walker Ford in Clearwater, FL on 12/27/2025 at 09:35 am. I reported to them that two recalls that would pertain to my car, 13S08 and 13R01 needed to be performed as my steering bearing retainer has failed. They informed me it was repaired, but it has failed again. According to my research, regardless if its been performed or not, Ford is still liable to fix it again. A possible loss of steering could result in death or injury if not addressed. My contact info is [XXX] Thanks! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11707228
Mileage unknown · Mar 5, 2024
Electrical SystemExterior Lighting
The instrument lights/gauges work intermittently. The digital odometer won't display.
NHTSA ODI #11575541
100,000 miles · Mar 29, 2022
Engine
The contact owns a 2007 Mercury Grand Marquis. The contact stated that while the vehicle was idling, the RPM’s revved up and the vehicle lunged forward. The contact depressed the brake pedal and the RPM’s decreased. There were no warning lights illuminated. The vehicle was not diagnosed or repaired. The manufacturer was not not…
Read full complaint
The contact owns a 2007 Mercury Grand Marquis. The contact stated that while the vehicle was idling, the RPM’s revved up and the vehicle lunged forward. The contact depressed the brake pedal and the RPM’s decreased. There were no warning lights illuminated. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 100,000.
NHTSA ODI #11458779
122,000 miles · Jul 1, 2020
Fuel/propulsion System
SMELLED GAS WHEN EXITING THE VEHICLE. CONFIRMED A FUEL LEAK IN THE FUEL TANK BY OBSERVING A FUEL DRIP. CONTINUED DRIVING THE CAR FOR A FEW DAYS. ON JUNE 15, 2020, I NOTICED A STRANGE NOISE AS I DROVE, SOMETHING RUBBING OR BUMPING ON THE FRAME UNDER THE CAR. WHILE DRIVING, THE NOISE INCREASED AND INTENSIFIED. I WAS FORCED TO PULL…
Read full complaint
SMELLED GAS WHEN EXITING THE VEHICLE. CONFIRMED A FUEL LEAK IN THE FUEL TANK BY OBSERVING A FUEL DRIP. CONTINUED DRIVING THE CAR FOR A FEW DAYS. ON JUNE 15, 2020, I NOTICED A STRANGE NOISE AS I DROVE, SOMETHING RUBBING OR BUMPING ON THE FRAME UNDER THE CAR. WHILE DRIVING, THE NOISE INCREASED AND INTENSIFIED. I WAS FORCED TO PULL OVER AND CHECK UNDER THE CAR. TO MY HORROR I SAW THE GAS TANK DRAGGING ON THE ROAD. A TOW TRUCK WOULD NOT TOW THE VEHICLE. MY BROTHER AND I TIED THE TANK UP UNDER THE CAR USING A NYLON STRAP TO GET THE CAR HOME. I CALLED THE DEALERSHIP TO FIX THE CAR. I NOW HAVE AN AFTERMARKET TANK ON MY CAR. FORD DOES NOT MAKE THE TANK ANYMORE.THE CAR WAS IN MOTION ON A CITY STREET WHEN THE TANK FELL. I BELIEVE THE PROBLEM WAS CAUSED BY A FUEL TANK STRAP FAILURE. THE FUEL LEAK WAS ALSO DIRECTLY RELATED TO THE STRAP SUPPORTING THE TANK. *TR
NHTSA ODI #11331987
Mileage unknown · Apr 29, 2020
Steering
VEHICLE WAS STATIONARY STEERING WHEEL WENT ROUND AND ROUND BUT WHEELS DID NOT TURN IF I WOULD HAVE BEEN DRIVING I WOULD HAVE CRASHED.
NHTSA ODI #11322741
140,000 miles · Jan 30, 2020
Engine
TL* THE CONTACT OWNS A 2007 MERCURY GRAND MARQUIS. THE CONTACT STATED THAT WHEN THE VEHICLE WAS STARTED, THE CHECK ENGINE LIGHT ILLUMINATED AND FLASHED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE INTAKE MANIFOLD FRACTURED ANTI-FREEZE LEAKED INTO THE OIL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER…
Read full complaint
TL* THE CONTACT OWNS A 2007 MERCURY GRAND MARQUIS. THE CONTACT STATED THAT WHEN THE VEHICLE WAS STARTED, THE CHECK ENGINE LIGHT ILLUMINATED AND FLASHED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE INTAKE MANIFOLD FRACTURED ANTI-FREEZE LEAKED INTO THE OIL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 140,000.
NHTSA ODI #11302984
116,699 miles · May 17, 2019
Exterior Lighting
TL* THE CONTACT OWNS A 2007 MERCURY GRAND MARQUIS. WHILE DRIVING APPROXIMATELY 50 MPH AT NIGHT, THE HEADLIGHTS TURNED OFF WITHOUT WARNING. THE CONTACT UTILIZED THE HIGH BEAM HEADLIGHTS. THE CONTACT TOOK THE VEHICLE TO MOFFITT'S FORD LINCOLN (515-432-6336, LOCATED AT 1819 SE MARSHALL ST, BOONE, IA 50036) WHERE IT WAS DIAGNOSED TH…
Read full complaint
TL* THE CONTACT OWNS A 2007 MERCURY GRAND MARQUIS. WHILE DRIVING APPROXIMATELY 50 MPH AT NIGHT, THE HEADLIGHTS TURNED OFF WITHOUT WARNING. THE CONTACT UTILIZED THE HIGH BEAM HEADLIGHTS. THE CONTACT TOOK THE VEHICLE TO MOFFITT'S FORD LINCOLN (515-432-6336, LOCATED AT 1819 SE MARSHALL ST, BOONE, IA 50036) WHERE IT WAS DIAGNOSED THAT THE LIGHTING SYSTEM NEEDED TO BE REPLACED. THE PART WAS ORDERED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 116,699.
NHTSA ODI #11208289
230,000 miles · Apr 22, 2019
Exterior Lighting
TL* THE CONTACT OWNS A 2007 MERCURY GRAND MARQUIS. WHILE OPERATING THE VEHICLE, THE HEADLIGHTS SUDDENLY SHUT OFF. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE HEADLIGHT MODULE WAS FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. AN UNKNOWN DEALER AND THE MANUFACTURER WERE NOTIFIED OF THE…
Read full complaint
TL* THE CONTACT OWNS A 2007 MERCURY GRAND MARQUIS. WHILE OPERATING THE VEHICLE, THE HEADLIGHTS SUDDENLY SHUT OFF. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE HEADLIGHT MODULE WAS FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. AN UNKNOWN DEALER AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURE, BUT NO ASSISTANCE WAS OFFERED. THE CONTACT INDICATED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED FOR THE SAME FAILURE, BUT THE FAILURE RECURRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 230,000.
NHTSA ODI #11202798
98,000 miles · Nov 23, 2018
Fuel/propulsion System
GAS TANK FELL DOWN AT HOME IN THE DRIVEWAY. VEHICLE WAS STATIONARY AND FULL TANK OF GAS.
Ford Motor Company (Ford) is recalling certain model year 2005-2011 Ford Crown Victoria, 2005-2011 Mercury Grand Marquis vehicles manufactured March 23, 2004, to August 30, 2011, and 2005-2011 Lincoln Town Car vehicles manufactured March 8, 2004, to August 30, 2011, and on which the upper intermediate shaft was serviced during the course of safety recall 13V-385. The prior repairs may not have been correctly performed.
Consequence & remedy
Consequence: Improper servicing of the upper intermediate shaft could cause the shaft to separate, which can then result in a loss of steering control, and increasing the risk of a crash.
Remedy: Ford will notify the owners of vehicles whose repair records reflect that the upper intermediate steering shaft was repaired during the course of the prior recall 13V-385. Dealers will inspect and replace the upper immediate shaft if necessary free of charge. The recall began November 17, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S25.
Ford is recalling certain model year 2005-2011 Ford Crown Victoria (including Crown Victoria Police Interceptors), Mercury Grand Marquis, and Lincoln Town Car vehicles. The affected vehicles are currently registered or were originally sold in Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, and Wisconsin. Severe corrosion can seize the lower intermediate shaft which may cause the upper intermediate shaft to collapse and the steering column lower bearing to separate.
Consequence & remedy
Consequence: If the lower bearing separates, the vehicle may experience a loss of steering, increasing the risk of a crash.
Remedy: Ford will notify owners and dealers will replace the lower intermediate shaft, free of charge. The upper intermediate shaft and steering column lower bearing will be inspected to identify any damage that may have occurred as a result of lower intermediate shaft corrosion, and repaired or replaced as necessary. If the steering column lower bearing has separated, a retainer clip will be installed. The recall began on October 23, 2013. Owners may contact Ford at 1-866-436-7332. Ford's recall number is 13S08.
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 212, 'WINDSHIELD MOUNTING.' THE WINDSHIELD MAY NOT BE PROPERLY SECURED TO THE VEHICLE BODY.
Consequence & remedy
Consequence: IF THE WINDSHIELD IS NOT PROPERLY RETAINED TO THE VEHICLE, WIND NOISE, SQUEAK/RATTLES AND/OR WATER LEAKS MAY OCCUR. ALSO, LOSS OF WINDSHIELD RETENTION MAY REDUCE OCCUPANT PROTECTION IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE THE WINDSHIELD FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 22, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
PE14021 · Steering Column Shaft Obstruction
Opened Jul 7, 2014 · Closed Nov 21, 2014
Status: closed (inferred from source dates) · Engine And Engine Cooling:exhaust System; Steering
On July 7, 2014 the Office of Defects Investigation (ODI) opened a preliminary evaluation based on five complaints (VOQs) alleging incidents ofinterference between dislodged exhaust manifold heat shields and the lower steering shaft/knuckle, including one alleging the interference resulted in a crash on a highway entrance ramp. Since opening this investigation, ODI has received four additional owner complaints.One indicated that the shield was removed before binding could occur.The other three occurred at low speed and produced some momentary steering binding that was overcome by the driver when additional steering effort was applied.Once the shield was repaired or removed, the steering returned to normal.The single incident ODI identified as a possible crash (VOQ No. 10578715) related to this condition could not be verified and the description of the crash in the complaint was not supported by the police accident report.No additional crash allegations have been identified related to the alleged defect condition.Information provided by Ford in its September 10, 2014 response to ODI's information request letter identified 10 additional incidents resulting in a low rate of 1.6 incidents per 100,000 vehicles sold in vehicles ranging from 7 to 11 years in service.Six of these incidents were reported by a single source, a state police fleet that corrected the problems in March 2011 and has not reported any additional failures since.Ford also reported 5 warranty claims, but these incidents occurred at very low mileages and appeared to be caused by loose or missing heat shield attachment hardware rather than the corrosion condition that was the cause of the more recent incidents and the focus of this investigation.This investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.The following VOQs are associated with this investigation:10643753, 10615584, 10611362, 10610451, 10578715, 10479681, 10471833, 10317493.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System
On July 7, 2014 the Office of Defects Investigation (ODI) opened a preliminary evaluation based on five complaints (VOQs) alleging incidents ofinterference between dislodged exhaust manifold heat shields and the lower steering shaft/knuckle, including one alleging the interference resulted in a crash on a highway entrance ramp. Since opening this investigation, ODI has received four additional owner complaints.One indicated that the shield was removed before binding could occur.The other three occurred at low speed and produced some momentary steering binding that was overcome by the driver when additional steering effort was applied.Once the shield was repaired or removed, the steering returned to normal.The single incident ODI identified as a possible crash (VOQ No. 10578715) related to this condition could not be verified and the description of the crash in the complaint was not supported by the police accident report.No additional crash allegations have been identified related to the alleged defect condition.Information provided by Ford in its September 10, 2014 response to ODI's information request letter identified 10 additional incidents resulting in a low rate of 1.6 incidents per 100,000 vehicles sold in vehicles ranging from 7 to 11 years in service.Six of these incidents were reported by a single source, a state police fleet that corrected the problems in March 2011 and has not reported any additional failures since.Ford also reported 5 warranty claims, but these incidents occurred at very low mileages and appeared to be caused by loose or missing heat shield attachment hardware rather than the corrosion condition that was the cause of the more recent incidents and the focus of this investigation.This investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.The following VOQs are associated with this investigation:10643753, 10615584, 10611362, 10610451, 10578715, 10479681, 10471833, 10317493.
Steering
On July 7, 2014 the Office of Defects Investigation (ODI) opened a preliminary evaluation based on five complaints (VOQs) alleging incidents ofinterference between dislodged exhaust manifold heat shields and the lower steering shaft/knuckle, including one alleging the interference resulted in a crash on a highway entrance ramp. Since opening this investigation, ODI has received four additional owner complaints.One indicated that the shield was removed before binding could occur.The other three occurred at low speed and produced some momentary steering binding that was overcome by the driver when additional steering effort was applied.Once the shield was repaired or removed, the steering returned to normal.The single incident ODI identified as a possible crash (VOQ No. 10578715) related to this condition could not be verified and the description of the crash in the complaint was not supported by the police accident report.No additional crash allegations have been identified related to the alleged defect condition.Information provided by Ford in its September 10, 2014 response to ODI's information request letter identified 10 additional incidents resulting in a low rate of 1.6 incidents per 100,000 vehicles sold in vehicles ranging from 7 to 11 years in service.Six of these incidents were reported by a single source, a state police fleet that corrected the problems in March 2011 and has not reported any additional failures since.Ford also reported 5 warranty claims, but these incidents occurred at very low mileages and appeared to be caused by loose or missing heat shield attachment hardware rather than the corrosion condition that was the cause of the more recent incidents and the focus of this investigation.This investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.The following VOQs are associated with this investigation:10643753, 10615584, 10611362, 10610451, 10578715, 10479681, 10471833, 10317493.
PE08060 · Tire Valve Cracking
Opened Oct 14, 2008 · Closed Apr 9, 2009
Status: closed (inferred from source dates) · Tires:valve
ON OCTOBER 14, 2008, ODI OPENED PE08-060 TO INVESTIGATE ALLEGATIONS OF CRACKED AND LEAKING SNAP-IN TIRE VALVES IN MODEL YEAR (MY) 2007 VEHICLES MANUFACTURED BY FORD MOTOR COMPANY.THE VALVES WERE SUPPLIED TO FORD BY TOPSEAL AUTO-PARTS, A SUBSIDIARY OF THE SHANGHAI BAOLONG AUTOMOTIVE CORPORATION IN CHINA.VALVES MADE BY TOPSEAL FOR AFTERMARKET SALE WERE THE SUBJECT OF TWO RECENT SAFETY RECALLS BY TECH INTERNATIONAL (08T-018) AND DILL AIR CONTROLS (08T-028), THE LATTER OF WHICH WAS INVESTIGATED BY ODI IN PE08-036 AND EA08-022.THE DEFECT CONDITIONS ADDRESSED BY THE AFTERMARKET TIRE VALVE RECALLS BOTH INVOLVED INADEQUATE RESISTANCE TO OZONE CRACKING DUE TO ISSUES WITH THE SUPPLY OF ANTI-OZONANT CHEMICALS TO TOPSEAL FOR A PERIOD FROM JULY TO MID-NOVEMBER 2006.THE AFTERMARKET VALVES WERE COMPOUNDED WITH A BLEND OF EPDM AND NATURAL RUBBER, USING A RELATIVELY LOW PERCENTAGE OF EPDM (EPDM PROVIDES INHERENT RESISTANCE TO OZONE CRACKING).HENCE, THE NEED FOR ANTI-OZONANT CHEMICALS AND THE PROBLEMS WITH CRACKING WHEN THOSE CHEMICALS WERE MISSING OR OUT OF SPECIFICATION IN SOME LOTS OF VALVES.BOTH RECALL CAMPAIGNS INVOLVED INSPECTION PROGRAMS TO IDENTIFY AND REPLACE VALVES WITH VISIBLE SURFACE CRACKING.ALTHOUGH THE TOPSEAL VALVES SUPPLIED TO FORD ALSO APPEAR TO HAVE BEEN AFFECTED BY THE ANTI-OZONANT SUPPLY ISSUES IN MID TO LATE-2006, FORD INDICATED THAT ITS VALVES WERE MADE AT A DIFFERENT TOPSEAL PRODUCTION LINE AND WERE COMPOUNDED WITH A HIGHER PERCENTAGE OF EPDM RUBBER TO MEET MORE STRINGENT SPECIFICATIONS FROM FORD.ODI'S ANALYSIS OF COMPLAINT AND WARRANTY DATA PROVIDED BY FORD SHOWED THAT PROBLEMS WITH CRACKED TIRE VALVES WERE SIGNIFICANTLY HIGHER FOR MY 2007 VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007.FORD RESPONDED BY IMPLEMENTING CHANGES IN ITS MATERIAL SPECIFICATIONS FOR SNAP-IN RUBBER TIRE VALVES AND ALSO INCREASING THE QUALITY AND ACCEPTANCE STANDARDS FOR VALVES IMPORTED FOR USE IN ITS VEHICLES.WHILE THE COMPLAINT AND WARRANTY CLAIM RATES ARE ELEVATED FOR SUBJECT VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007, THE RATES OF LEAKING VALVES ARE WELL BELOW ONE PERCENT OF PRODUCTION FOR EACH OF THE PEAK MONTHS FOR ALL OF THE AFFECTED MODELS.A SUBSTANTIAL MAJORITY OF THE SUBJECT VEHICLES ARE EQUIPPED WITH TIRE PRESSURE MONITORING SYSTEMS (TPMS) WHICH WARN THE DRIVER WHEN ANY TIRE PRESSURES DROPS BELOW 25 PERCENT OF RECOMMENDED INFLATION PRESSURE. AS OUTLINED IN A LETTER TO ODI DATED APRIL 6, 2009, FORD HAS AGREED TO SEND LETTERS TO OWNERS OF CERTAIN MY 2007 AND 2008 FORD, LINCOLN AND MERCURY VEHICLES TO PROVIDE INFORMATION ABOUT THE CRACKING CONCERN. LETTERS WILL BE SENT TO OWNERS OF VEHICLES BUILT FROM NOVEMBER 2006 THROUGH MAY 2007.OWNERS CAN OPT FOR A FREE DEALER INSPECTION.VALVES EXHIBITING SURFACE CRACKS OR AIR LEAKAGE RELATED TO OZONE ATTACK WILL BE REPLACED BY FORD UNDER ITS NORMAL WARRANTY TERMS.FORD EXPECTS TO SEND THE LETTER BY APPROXIMATELY MID-MAY 2009. BASED ON THE USE OF TPMS IN THE MAJORITY OF SUBJECT VEHICLES AND THE RELATIVELY LOW RATES OF REPAIRS ASSOCIATED WITH LEAKING VALVES AND RESULTANT TIRE DAMAGE, ODI BELIEVES THAT THE ACTIONS FORD HAS AGREED TO TAKE WILL PROVIDE EFFECTIVE AND EXPEDITIOUS RESOLUTION FOR VEHICLES THAT WERE BUILT DURING THE PERIOD WHEN VALVES WITH INADEQUATE RESISTANCE TO OZONE CRACKING WERE MOST LIKELY TO HAVE BEEN USED IN VEHICLE PRODUCTION.FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO
2007 Mercury Grand Marquis Problems, Complaints & Recalls | Skip That Year
Illustration