The steering has become “Sticky”. It almost feels like it gets locked into place for about 10 seconds and then will release and will repeat this same process over and over. When the car is completely off, you can move the steering wheel and it almost feels like a rack and pinion issue. This has been going on for about 6 months. …
Read full complaint
The steering has become “Sticky”. It almost feels like it gets locked into place for about 10 seconds and then will release and will repeat this same process over and over. When the car is completely off, you can move the steering wheel and it almost feels like a rack and pinion issue. This has been going on for about 6 months. It doesn’t matter the speed you are driving at, you can feel it “catching” anytime. My husband has a 2023 Honda Accord and has no steering issues, so it’s definitely noticeable when I drive my vehicle vs driving his car. I drive on a very windy road to and from work everyday, and I worry that an accident will occur if this issue isn’t resolved. Which also brings me to worry, if it is resolved, do I have to worry about this arising in the future?
NHTSA ODI #11563841
7,995 miles · Jan 5, 2024
Steering
The contact owns a 2023 Honda CR-V. The contact stated that on several occasions while driving at various speeds, the steering wheel jerked. The vehicle was taken to a dealer where it was diagnosed that the steering gearbox had malfunctioned and needed to be replaced. The vehicle was not repaired. The manufacturer was notified o…
Read full complaint
The contact owns a 2023 Honda CR-V. The contact stated that on several occasions while driving at various speeds, the steering wheel jerked. The vehicle was taken to a dealer where it was diagnosed that the steering gearbox had malfunctioned and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 7,995.
NHTSA ODI #11563825
Mileage unknown · Jan 5, 2024
Steering
Steering the vehicle became difficult. It would feel catchy or sticking which would lead to oversteer. Honda dealer service manager performed test drive and determined vehicle is unsafe to drive.
NHTSA ODI #11563693
Mileage unknown · Jan 5, 2024
Steering
1. Steering 2. My 2023 Honda CRV EXL Steering is pulling, sticking with a jerk while driving at any speed. 3. The problem has been confirmed at a Honda dealership 4. Yes, it has been inspected at a Honda dealership 5. No warnings or messages have been displayed
NHTSA ODI #11563664
Mileage unknown · Jan 4, 2024
Steering
When driving about 30mph the steering wheel begins to “stick” and has some resistance when steering. Subtle now, but fear it may get worse .
NHTSA ODI #11563653
Mileage unknown · Jan 4, 2024
Steering
There is an intermittent problem when making slight adjustments to steering. It feels like the steering wheel is slightly "catching on something" or the steering is not smooth. It happens when the vehicle is moving and stationary. The dealer could not feel it. They only said that since it is electronically controlled steerin…
Read full complaint
There is an intermittent problem when making slight adjustments to steering. It feels like the steering wheel is slightly "catching on something" or the steering is not smooth. It happens when the vehicle is moving and stationary. The dealer could not feel it. They only said that since it is electronically controlled steering, it is not going to be smooth. I could not believe this and I am worried that it could become worse or something could completely fail in the future. The problem was not present upon purchase of the vehicle, but began after about 5000 miles.
NHTSA ODI #11563437
Mileage unknown · Jan 2, 2024
Steering
Vehicle only has 21000 miles on it. At the 19000 mile range the steering started to stick while making normal highway adjustments. Took it to the dealer this morning and was told it’s normal. This is not normal!!! This steering problem has been getting worse. Help!!!!!!!!!!
NHTSA ODI #11563141
Mileage unknown · Jan 2, 2024
Steering
During routine driving at all speeds the steering wheel will randomly move between 1/8 to 1/4 of an inch causing a slight movement of the car. Took car to Honda dealership and was advised that the EPS rack is bad. Car has approximately 15,000 miles and has no accident history. My concern is that, according to the dealer, is that…
Read full complaint
During routine driving at all speeds the steering wheel will randomly move between 1/8 to 1/4 of an inch causing a slight movement of the car. Took car to Honda dealership and was advised that the EPS rack is bad. Car has approximately 15,000 miles and has no accident history. My concern is that, according to the dealer, is that the replacement parts will not be available for several months. I was advised that they have another customer with the same issue that was identified in October and the part is due to arrive in April. I was advised that the car is safe to drive, however my concern is it will get progressively worse in the six months it will take the replacement part to arrive. At what point does a known steering issue become unsafe?
NHTSA ODI #11563001
Mileage unknown · Dec 31, 2023
SteeringUnknown Or Other
When driving, especially on the interstate/high speeds, my steering wheel feels to be locked into place. I am unable to easily turn left or right to stay in my lane without a jerk/sticky feeling in the wheel. It feels like I have cranked the wheel as far as it will go, but the wheel is centered. The steering wheel will also occa…
Read full complaint
When driving, especially on the interstate/high speeds, my steering wheel feels to be locked into place. I am unable to easily turn left or right to stay in my lane without a jerk/sticky feeling in the wheel. It feels like I have cranked the wheel as far as it will go, but the wheel is centered. The steering wheel will also occasionally randomly jerk small amounts either left or right. It makes interstate driving feel very unsafe and like I do not have full control. I had my alignment fixed a few months ago, but I have not taken it back to the dealership for this issue. No warning lights/messages.
NHTSA ODI #11562830
Mileage unknown · Dec 31, 2023
Steering
Driving on 1000 mile road trip on 12/30. Vehicle has 6800 miles. First noticed very minor twitching, then as day went own by the time I stopped for night the steering had noticeably gotten worse. It went from twitching about half hour after I was on highway to four hours later it was very prominently sticking or catching at the…
Read full complaint
Driving on 1000 mile road trip on 12/30. Vehicle has 6800 miles. First noticed very minor twitching, then as day went own by the time I stopped for night the steering had noticeably gotten worse. It went from twitching about half hour after I was on highway to four hours later it was very prominently sticking or catching at the slightest turn in road. Both left and right. I am terrified if it’s safe to drive the last 400 miles and Honda dealership is closed until Jan 2. There is something very very wrong with this make/model. It’s all over the internet and people are saying the steering part is on back order for months!!! Why is there no recall yet? There is no doubt this is a safety issue. I can’t drive thru the mountains not knowing if my steering is going to out.
Honda (American Honda Motor Co.) is recalling certain 2023-2025 Acura Integra, Civic Type R, CR-V Hybrid, CR-V, HR-V, 2022-2025 Civic, Civic Hatchback, 2024-2025 Acura Integra Type S, 2025 CR-V Fuel Cell EV, Civic Hybrid, and Civic Hatchback Hybrid vehicles. The steering gearbox assembly may have been manufactured incorrectly, which can cause excessive internal friction and lead to difficulty steering the vehicle.
Consequence & remedy
Consequence: Difficulty steering can increase the risk of a crash.
Remedy: Dealers will replace the worm gear spring and redistribute or add grease as necessary, free of charge. Owner notification letters were mailed November 18, 2024. Owners may contact Honda Customer Service at 1-888-234-2138. Honda's numbers for this recall are SJS, MJU, QJT and VJV.
Honda (American Honda Motor Co.) is recalling certain 2013-2023 Honda Accord, Civic Coupe, Civic Sedan, Civic Hatchback, Civic Type R, CR-V, HR-V, Ridgeline, Odyssey, Acura ILX, MDX, MDX Hybrid, RDX, RLX, TLX, 2019-2022 Honda Insight, Passport, 2020 Honda CR-V Hybrid, 2018-2019 Honda Clarity PHEV, Fit, and 2015-2020 Honda Accord Hybrid, Pilot, Acura NSX vehicles. The fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the fuel pump module, free of charge. Owner letters were mailed September 6, 2024. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KGC and KGD. This recall is an expansion of NHTSA recall numbers 21V-215 and 20V-314.
Honda (American Honda Motor Co.) is recalling certain 2023 CR-V vehicles. The front passenger seat back frame may not have been welded properly, which can cause the seat back position to fail in the event of a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 207, "Seating Systems" and 201, "Occupant Protection in Interior Impact."
Consequence & remedy
Consequence: A seat back position that fails may not adequately restrain the occupant during a crash, increasing the risk of injury.
Remedy: Dealers will replace the front passenger seat back frame assembly, free of charge. Owner notification letters were mailed March 27, 2023. Owners may contact Honda customer service at 1-888-234-2138. Honda's number for this recall is 6PK.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
EA23003 · Momentary Increased Steering Effort
Opened Nov 29, 2023 · Closed Jan 28, 2025
Status: closed (inferred from source dates) · Steering
On November 29, 2023, the Office of Defects Investigation (ODI) opened this Engineering Analysis (EA23003) to assess allegations of momentary increase in steering effort in model years (MY) 2022-2023 Honda Civic, 2023MY Honda CR-V, and 2023MY Acura Integra vehicles (subject vehicles). The complaints received by ODI alleged that the subject vehicles experienced a momentary increase in required steering effort (described as “sticky steering”) occurring mostly at highway speeds after driving for an extended amount of time; these complaints could not be duplicated during dealer service technicians’ quick test drives. The complaints had been received over the previous two years with most occurring with low vehicle mileage. The steering gear of these vehicles is aided by an electrical power assist unit. This power assist unit inputs force on the steering rack via a worm gear and worm wheel assembly. During PE23005, Honda stated this condition of momentary increase in steering effort occurs due to two factors within this power assist unit. First, during manufacturing, the steering worm wheel goes through annealing and component conditioning processes. These processes cause internal stress and strain within the steering worm wheel. This strain is slowly released over the first few months of the vehicle life. Over time, the released strain causes deformation of the teeth on the worm wheel, causing the worm gear to catch on the worm wheel. This catching results in the driver’s momentary increased steering effort. Second, the manufacturing process did not guarantee consistent grease application and, therefore, some subject vehicles received insufficient grease which contributed to the momentary increase in steering effort. During EA23003, ODI further analyzed the potential safety related consequences of the momentary increase in steering effort. NHTSA’s Vehicle Research and Test Center (VRTC) duplicated the allegations of increased steering effort. In addition, VRTC discovered the steering worm wheel and worm gear tended to push grease out of the meshing area, resulting in large amounts of grease resting on top of the worm wheel. Information Request responses collected and reviewed by ODI showed Honda had also discovered this additional root cause during NHTSA’s EA. In addition, Honda discovered the preload of the worm wheel gear spring was set too high, increasing the gear slide load and resulting in higher friction and increased torque fluctuation when steering. The number of consumer complaints made to ODI continued to increase with the expansion of scope from the PE to the EA. Additionally, during EA23003, ODI received ten complaints alleging a crash, in addition to the 13 complaints ODI had received as of the time it opened EA23003. In total, 23 crashes have been reported to ODI due to this alleged defect. On October 3, 2024, Honda filed NHTSA Recall No. 24V-744 to address this defect. The recall will provide consumers with a new steering worm wheel gear spring with a decreased load. Additionally, dealerships will add additional grease and relocate any grease sitting on top of the worm wheel back into the meshing area. The scope of this recall includes all Honda vehicles that were manufactured with this specific improperly produced steering worm wheel and spring. In view of the recall action being taken by Honda, ODI is closing EA23003. NHTSA reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration