2023 Honda CR-V

While driving my 2023 Honda CR-V Hybrid at approximately 40-45 mph, the vehicle began hesitating and not accelerating smoothly. A Check Engine/Emissions System warning also appeared. The vehicle had approximately 31,873 miles. I took the vehicle to an authorized Honda dealership for diagnosis. The dealer recommended replacement of all fuel injectors and the spark plugs. The vehicle has not yet been repaired and the components remain available for inspection. I am concerned about the safety risk because the hesitation/loss of smooth power occurs while the vehicle is being driven and could affect the ability to accelerate normally in traffic. Honda has issued Service Bulletin 25-044 applicable to 2023-2024 CR-V Hybrid vehicles concerning leaking fuel injectors that can cause an excessively rich air/fuel mixture, foul spark plugs, illuminate the malfunction indicator lamp, and cause drivability problems. The repair procedure can include replacement of the fuel injectors and affected spark plugs. My vehicle has very low mileage for this type of fuel-system failure. I am reporting this incident so NHTSA can evaluate whether similar fuel injector failures and resulting drivability problems in 2023-2024 Honda CR-V Hybrid vehicles represent a broader safety defect.

My car is experiencing a failure of the shutter grill motor. It’s a motor that opens and closes the shutters to let air through a cooling radiator. The car is not getting hot. The shutters are fully open. I assume this is an energy efficiency mechanism. However: Since the motor is not working, and the shutters cannot adjust properly, the car is derating my power. THIS IS DANGEROUS. I cannot climb mountains on the interstate at proper speeds. I have also almost had a few wrecks trying to pull into traffic due to loss of power, thus acceleration. The computer is choosing to derate my power and acceleration, but it isn’t necessary. I would like to fix the issue, but it is expensive and I don’t have the money. Why would Honda punish me with dangerous conditions for my inability to pay for a fix on an energy efficiency issue!?!?

On my 2023 Honda CR-V with 79,567 miles, the engine experienced a cylinder 1 misfire while driving, causing the vehicle to lose power and enter limp mode. At the same time, every warning light on the dashboard illuminated. The sudden loss of power created a serious safety risk because I was unable to accelerate normally and had to safely maneuver the vehicle out of traffic, increasing the risk of a collision. I took the vehicle to an authorized Honda dealership, where the problem was confirmed and the engine was diagnosed with a blown head gasket. The vehicle has been inspected by the Honda dealership but has not been inspected by police, insurance representatives, or any other parties. Prior to this incident, there were no warning lights or messages indicating a problem.

Woke up at [XXX] [XXX] to neighbor banging on door and yelling your car is on fire. Vehicle is parked in front driveway, front part of the car where engine is ablazed. Neighbor said he heard "pops" like firecrackers/gunshot when he went to look out his window the fire was reflected on the fence across the car. I did google search for possible fire causes and search returned with Recall notice for fuel pump, battery and battery cladding on model. Contacted Honda but Aileen just promised to send inspector for joint inspection with USAA inspector but hasn't been responsive to call or emails for follow up. Fortuntaely, didn't park in the garage or we would have been burned down with the house also quite fortunate that car was driving on the road. Vehicle is being inspected by insurance USAA and will get report on insurance details with AMERICAN HONDA not responding to Report Case #[XXX] they keep fobbing me off by asking to call back 1-800-999-1009 x 88146 or email ahmcustomersupport@ahm.honda.com. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

In February 2025 with around 56k miles, started noticing a vibration which I thought was a wheel balancing issue. After having the wheels balanced multiple times. I also replaced the tires twice but the vibration still persists. I started noticing the vibration became more consistent at low speeds 20-23 mph. At this time I am now out of engine warranty. It felt like a bad torque converter, which this vehicle doesn’t have. I brought the vehicle to three different dealerships and they all said the car has no issues. At no point did the car throw a check engine light or code. About five days after visiting the last dealership in October 2025 I was headed to work. Once the engine kicks in there was a loud rattling noise coming from the engine for about 5 seconds then it went away. Now every time the car sits, the first time the engine kicks in is rattles for a few seconds. At no point there were any check engine lights. I took the car back to the dealership and the determined that the injectors and head gasket failed. Not having a check engine light coming on for this issue could have caused an accident if the engine stalled on the highway. Honda would not assist in anyway.

Dear Sir/Madam, I am writing to report a serious safety concern with my 2023 Honda CR-V All-Wheel Drive, regular gasoline version. On three separate occasions while driving at high speed on the highway, my vehicle suddenly lost power and the engine stalled without warning. When this occurred, the starter would not engage, the vehicle had no electrical power, and multiple warning messages appeared on the dashboard, including Emission System Problem and All-Wheel Drive System Problem. This type of sudden stall while driving at highway speed creates an extremely dangerous situation and puts both the driver and other motorists at serious risk. I am aware that Honda has issued fuel pump recalls for the 2023 CR-V Hybrid models. However, my vehicle is the regular gasoline version, and based on my experience, I strongly believe that a similar fuel pump defect exists in these models as well. I respectfully request that this issue be investigated as a potential safety defect, and that Honda initiates a recall for the regular gasoline CR-V models to address this problem.

I am writing to formally express my deep disappointment and concern regarding the reliability of my 2023 Honda CR-V Sport Hybrid, which I purchased with approximately 10,000 miles on it. The vehicle currently has around 85,000 miles and has already required major, unexpected repairs — most notably a head gasket failure, in addition to other mechanical issues earlier this year that totaled $2,000 out of pocket. The fact that a relatively new Honda with an excellent service history and primarily highway miles would require a head gasket replacement this early in its lifespan is extremely troubling and calls into question the long-term reliability of the CR-V Hybrid platform. While I appreciate that Honda agreed to cover the head gasket repair through a goodwill arrangement, this situation has caused me considerable stress, financial hardship, and a loss of confidence in the vehicle — and, frankly, in Honda’s reputation for durability. Further compounding this frustration, the vehicle has recently begun exhibiting renewed roughness and vibration at various speeds, despite recent service, and I remain worried that I’m going to be saddled with ongoing problems that I should never have had to deal with on a vehicle this new. As a loyal Honda customer, I expected better. I chose this vehicle specifically for its reputation, fuel efficiency, and dependability. What I’ve experienced instead feels like a breakdown of quality control and corporate accountability. I am now significantly upside down on a vehicle that I can no longer rely on with confidence — yet I cannot afford to walk away from it.

2023 CRV Purchased 04/20/2023 April 28, 2025, 51,109 miles. I was having misfires on start up but no warning lights. Then while driving down the highway the vehicle lost power and the dash lite up. I dropped it into S and put on my hazards. I was close to the dealership so I drove it directly there while on the phone with them. They said it was a bad spark plugs. Replaced the plug and reset the codes. Drove it for two more weeks. One morning upon start up every light on the dash was on and the sensor warnings were cycling. Called the dealership they said because the check engine light is solid and not blinking and I live close by to drive it in. Drove it in, dropped it off. Diagnosis: Blown Head gasket. Under warranty Might get it back within 4 days. 23hr $6,000.00 job.