2023 Honda CR-V

While driving my 2023 Honda CR-V Hybrid at approximately 40-45 mph, the vehicle began hesitating and not accelerating smoothly. A Check Engine/Emissions System warning also appeared. The vehicle had approximately 31,873 miles. I took the vehicle to an authorized Honda dealership for diagnosis. The dealer recommended replacement of all fuel injectors and the spark plugs. The vehicle has not yet been repaired and the components remain available for inspection. I am concerned about the safety risk because the hesitation/loss of smooth power occurs while the vehicle is being driven and could affect the ability to accelerate normally in traffic. Honda has issued Service Bulletin 25-044 applicable to 2023-2024 CR-V Hybrid vehicles concerning leaking fuel injectors that can cause an excessively rich air/fuel mixture, foul spark plugs, illuminate the malfunction indicator lamp, and cause drivability problems. The repair procedure can include replacement of the fuel injectors and affected spark plugs. My vehicle has very low mileage for this type of fuel-system failure. I am reporting this incident so NHTSA can evaluate whether similar fuel injector failures and resulting drivability problems in 2023-2024 Honda CR-V Hybrid vehicles represent a broader safety defect.

My car is experiencing a failure of the shutter grill motor. It’s a motor that opens and closes the shutters to let air through a cooling radiator. The car is not getting hot. The shutters are fully open. I assume this is an energy efficiency mechanism. However: Since the motor is not working, and the shutters cannot adjust properly, the car is derating my power. THIS IS DANGEROUS. I cannot climb mountains on the interstate at proper speeds. I have also almost had a few wrecks trying to pull into traffic due to loss of power, thus acceleration. The computer is choosing to derate my power and acceleration, but it isn’t necessary. I would like to fix the issue, but it is expensive and I don’t have the money. Why would Honda punish me with dangerous conditions for my inability to pay for a fix on an energy efficiency issue!?!?

I was driving my 2023 Honda CRV Hybrid on the [XXX] on Sunday, XXX. 5 minutes prior to reaching the interchange where the [XXX] connects to the [XXX], all of the lights on my dashboard flash on, but the car was still running. I got onto the [XXX] and prior to reaching the [XXX] exit, my car suddenly stops accelerating at full power. As I push on the accelerator, I can barely move my car. I pull over to the side of the highway and put my car in park. Quietly panicking (not to stress out my [XXX] old who was sleeping in the backseat), I put my car back in drive and see that I can slowly move forward. I get back onto the freeway and exit via the [XXX] exit. There is a park right there so I slowly circled around until I found a spot to park my car. I called AAA and they came and tested my battery and said there weren't any issues. They advised me not to drive my car anymore and called a tow, and brought my car to the Honda Dealership back near me home 45 minutes away. The dealership was closed, but they called me on Monday and said they would need to diagnose my car. I preferred that my mechanic take care of my car, so I had my car towed there instead. The issue he diagnosed is provided in the screenshots: "P2101 Electric Throttle Control System (ECTS) Malfunction". Both my mechanic and I looked online and there seems to be an open investigation into this (NHTSA ID 11556108) and when you look online, there are MANY other owners complaining about the same thing happening, some with much less miles on their car than mine. There is clearly an issue and something needs to be done. Having your car all of a sudden slow down drastically while driving on an extremely busy [XXX] highway with a [XXX] in your backseat was terrifying. Please investigate this further, I know I'm not the only one who has experienced this with the same model of car. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Vehicle was brought in for steering gearbox recall repair. After the recall was performed, the vehicle developed a loud thumping noise from the front passenger side. Upon returning to the dealer for diagnosis, the dealer found the passenger front wheel was missing 3 lug nuts and had only 1 lug nut holding the wheel on. The lug lock was also loose. The vehicle was driven at highway speeds in this condition. The dealer's own work order confirms these findings. The missing lug nuts were a direct result of the recall repair service.

The contact owns a 2023 Honda CR-V. The contact stated that while operating the vehicle, several warning lights remained illuminated, including the Tire Pressure Monitoring System (TPMS), power steering, and check engine warning lights. Additionally, the steering wheel became difficult to turn in either direction. The vehicle was taken to a local dealer, where it was diagnosed that the steering rack needed replacement. The vehicle was not yet repaired. The manufacturer was not notified of the failure. The failure mileage was 48,000.

Battery overheats and emits visible smoke from positive terminal and strong sulfur (rotten egg) odor. Notices the problem a few days ago. Called AAA for assistance on Sunday August 23 and technician stated that a lot of Hondas have had this issue including his own and it is due to a recall. A search online shows a recall issued for approximately 98 2023 Honda crv hybrids for Electrical system: Propulsion system: Traction battery date 2024-10-02 Recall no. 24V745000 Honda (American Honda Motor Co.) is recalling certain 2023 Honda CR-V Hybrid vehicles. The high voltage battery modules may have been manufactured incorrectly, which can cause the battery terminal or busbar to break and spark.

I own a 2023 Honda CR-V EX-L 1.5L turbo. My vehicle has repeatedly displayed an “Active Grille Shutter System Problem” warning while driving. Diagnostic trouble code P16E8 has also been associated with the active grille shutter system. The problem has occurred multiple times, particularly during hot weather and while driving on steep grades. When the active grille shutter warning occurs, the vehicle can go into reduced-power mode, significantly limiting its performance. Turning the vehicle off and restarting it may temporarily clear the warning and restore normal operation, but the problem can return. The vehicle has not been overheating when this occurs. I am concerned because unexpectedly entering reduced-power mode while driving, especially on a highway or steep grade, could create a safety hazard. I am reporting this issue so NHTSA can document and investigate whether there is a recurring defect involving the active grille shutter system on 2023 Honda CR-V vehicles and determine whether a safety recall or other action is warranted.

The contact owns a 2023 Honda CR-V equipped with Michelin Tires, Tire Line: Michelin, Tire Size: 235/55/19, DOT Number: (N/A). The contact stated that the vehicle was serviced and the tires were rotated; the technician became aware that the tires were not properly aligned. The local dealer was contacted. The vehicle was taken to the dealer, where it was diagnosed and determined that all four tires needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and opened a case. The failure mileage was approximately 30,000.

I purchased this vehicle in November 2025. There was an existing recall remedy under NHTSA 24V-744. In December 2025 I took my vehicle to Brickell Honda to have the official steering gearbox safety recall performed. However, the dangerous "sticky" and binding steering sensation remained. On July 30, 2026, the dealership diagnosed the car and confirmed that the entire power steering rack is bad and must be replaced at a cost of over $4,400.00. The dealership offered a 50% goodwill split, leaving me with a $2,251.00 out-of-pocket expense. I formally declined the 50% offer, and I requested that Honda Corporate cover 100% of the parts and labor to replace the steering rack. The initial recall remedy failed to resolve the safety hazard in my vehicle.