COMPONENT SPOTLIGHT

Ford Explorer transmission problems

2,441 distinct owner reports with a transmission-specific component in this snapshot.

General power-train reports are not automatically counted as transmission problems. Related recalls and investigations must also name this component; they are not linked by narrative keyword alone.

89 crash reports24 fire reports36 injury reports

Reports by model year

Recall and investigation columns show each year’s full history. A report naming several years can appear in more than one row.

When problems were reported

Mileage at the reported incident

242

0–25K

245

25–50K

392

50–75K

339

75–100K

321

100–150K

150K+

1,608 reports with mileage · 833 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What owners actually said

2,441 reports

2002 model year · 105,622 miles · Apr 28, 2009

Power Train

TRANSMISSION FAILURE. *TR

NHTSA ODI #10267157

2004 model year · 3,000 miles · Apr 28, 2009

Power Train

Read full complaint

MY 2004 FORD EXPLORER HAS A TRANSMISSION PROBLEM. I NEVER KNOW IF AND WHEN IT WILL GO INTO REVERSE OR PARK. IT HESITATES AND I THEN FIND OUT WHAT GEAR IT IS IN. THIS EXPLORER IS A ONE-OWNER CAR. 32,000+- MILES ON IT. WEEKENDS ONLY. YES, I WENT THROUGH THE EARLIER RECALL, BUT IT DID LITTLE IF ANYTHING TO CORRECT THE PROBLEM,. AT THE TIME, I FIGURED THAT I HAD BEEN SCREWED INTO BUYING A DEFECTIVE CAR WHOSE TRANSMISSIONS WOULDN'T LAST AFTER THE WARRANTY RAN OUT. SOMETIMES, THE TRANSMISSION DOESN'T ENGAGE RIGHT AWAY AND THEN JUMPS HARD INTO REVERSE. OTHER TIMES, IT HESITATES BEFORE GOING INTO DRIVE AND/OR PARK. I NEVER KNOW. I AM 57 YEARS OLD. PLEASE TELL FORD FOR ME ----NOT TO PEE ON MY LEG AND TELL ME THAT IT IS RAINING. THEY DIDN'T FIX THE PROBLEM. AND I BELIEVE IT TO BE DANGEROUS. AND SINCE BUSH ISN'T PRESIDENT ANYMORE, MAYBE YOUR AGENCY CAN STAND UP AGAIN FOR AMERICAN CONSUMERS. OR WILL YOU? FEEL FREE TO CONTACT ME OR FOR FORD TO CONTACT ME. THE TRUTH IS THE TRUTH. *TR

NHTSA ODI #10267167

2002 model year · 107,123 miles · Apr 24, 2009

Power TrainSteering

Read full complaint

COMPLAINANT HAS HAD DIFFICULTY SHIFTING INTO PARK SINCE THE VEHICLE WAS PURCHASED USED IN DECEMBER 2007. DECEMBER 2008 JUST AFTER CHRISTMAS VEHICLE ROLLED BACKWARDS DOWN A SLIGHT INCLINED DRIVEWAY. THE COMPLAINANT PARKED THE VEHICLE AND WAS IN THE HOME FOR APPROXIMATELY 35-45 MINUTES WHEN THE COMPLAINANTS WIFE ASKED WHERE WAS THE VEHICLE WHY WASN'T IT IN THE DRIVEWAY. THE CONSUMER WENT OUTSIDE AND FOUND THE VEHICLE ROLLED BACKWARDS DOWN THE DRIVEWAY AND CAME TO REST IN THE YARD (GRASS). THE COMPLAINANT ALSO NOTED AND ADDITIONAL INCIDENT WHERE THE VEHICLE STALLED AND THE COMPLAINANT COULD NOT GET THE VEHICLE IN PARK. *TR

NHTSA ODI #10266585

2004 model year · 60,000 miles · Apr 24, 2009

Power Train

Read full complaint

TL*-THE CONTACT OWNS A 2004 FORD EXPLORER. THE CONTACT STARTED THE IGNITION ON A WARM ENGINE, AND THEN MOVED THE GEAR SHIFT FROM THE "PARK" POSITION INTO THE "REVERSE" POSITION. IMMEDIATELY, THE TRANSMISSION EXHIBITED EXTREMELY HARD SHIFTING. THERE WERE NO PRIOR WARNINGS. THE FAILURE OCCURRED INTERMITTENTLY. THE VEHICLE WAS ABLE TO PROCEED TO NORMAL OPERATION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTS. THE TECHNICIAN STATED THE FAILURE WAS RELATED TO THE AUTOMATIC TRANSMISSION SOLENOID PACK. THE SOLENOID PACK WAS REPLACED FOR THE MALFUNCTION. THE CONTACT HAD CONCERN ON THE SAFETY RISK INVOLVED. THE FAILURE MILEAGE WAS 60,000. THE CURRENT MILEAGE WAS 81,000. UPDATED 05/15/09 *BF UPDATED 05/18/09.*JB

NHTSA ODI #10266588

2004 model year · 39,000 miles · Apr 23, 2009

Power TrainCrash

Read full complaint

TL*THE CONTACTS OWNS A 2004 FORD EXPLORER. AFTER DRIVING IN REVERSE AND PARKING THE VEHICLE IT BEGAN TO MOVE AFTER THE BACK DOOR WAS OPENED. SHE WAS ABLE TO ENGAGE THE BRAKE PEDAL TO STOP THE VEHICLE FROM MOVING AND CONFIRMED THAT THE GEAR SHIFT WAS IN PARK. THE BODY SHOP MECHANIC WAS UNABLE TO DUPLICATE OR DIAGNOSE THE FAILURE. THE CONTACT STATED THAT IT WAS CAUSED DUE TO SLIPPAGE OF THE GEARS AND ALTHOUGH THE GEAR INDICATOR READS PARK IT IS NOT FULLY ENGAGED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 39000 AND CURRENT MILEAGE WAS 44000.

NHTSA ODI #10266520

2004 model year · 8,804 miles · Apr 23, 2009

Power Train

Read full complaint

TL*THE CONTACT OWNS A 2004 FORD EXPLORER. AFTER STARTING THE ENGINE, THE GEAR SHIFTED FROM THE "PARK" POSITION TO "REVERSE". THERE WAS A FORCEFUL FORWARD SHIFTING MOTION WHEN THAT OCCURRED. IN ADDITION, WHEN THE GEAR SHIFT WAS PLACED IN THE "REVERSE POSITION" AND SHIFTING INTO THE "DRIVE" POSITION THERE WAS IMMEDIATE HESITATION. THERE WERE NO WARNING LIGHT INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION. THE TECHNICIAN STATED THE FAILURE WAS CONTRIBUTED TO THE SHIFT SOLENOID WHICH WAS REPLACED. AN AUTHORIZED DEALER PREVIOUSLY REPLACED THE SOLENOID FOR IDENTICAL FAILURE. THE CONTACT IS AWARE OF THE SAFETY RISK. THE FAILURE MILEAGE WAS 8,804 AND THE CURRENT MILEAGE WAS 55,000.

NHTSA ODI #10266482

2004 model year · 95,000 miles · Apr 23, 2009

Power TrainCrash

Read full complaint

TL*THE CONTACT OWNS A 2004 FORD EXPLORER. WHEN PLACING THE VEHICLE IN A PARKED POSITION THE VEHICLE IT ROLLED BACKWARDS EVEN WHEN IT WAS ON A LEVEL SURFACE. ON ONE OCCASION THE VEHICLE ROLLED BACKWARD AND CRASHED INTO ANOTHER VEHICLE. THERE WERE NO INJURIES. WHEN THE FAILURE OCCURRED SHE NOTICES THE OVER DRIVE LIGHT ILLUMINATED ON THE INSTRUMENT CONTROL PANEL. THE DEALER STATED THAT HER SECOND GEAR WAS MISSING; THEREFORE, SHE WOULD BE RESPONSIBLE FOR PAYING $3,700 TO REPLACE THE TRANSMISSION. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 95,000 AND THE CURRENT MILEAGE WAS 100,000.

NHTSA ODI #10266476

2004 model year · 10,000 miles · Apr 22, 2009

Power Train

TL*THE CONTACT OWNS A 2004 FORD EXPLORER. THE TRANSMISSION IN THE VEHICLE IS CONSTANTLY SLIPPING. THE VEHICLE HESITATED AFTER NUMEROUS ATTEMPTS TO ADJUST TO THE CORRECT GEAR. DUE TO THE FAILURE IT TAKES LONGER THAN IT SHOULD TO INCREASE SPEED. THE DEALER MADE AN ADJUSTMENT TO THE TRANSMISSION; HOWEVER, THE VEHICLE WAS NOT FULLY…

Read full complaint

NHTSA ODI #10266364

2008 model year · 4,000 miles · Apr 20, 2009

Power Train

Read full complaint

WE HAVE HAD TRANSMISSION PROBLEMS FROM THE START WITH THIS 2008 EXPLORER. WHEN SLOWING TO MAKE A TURN THE TRANSMISSION GETS HUNG BETWEEN GEARS, THEN THE ENGINE REVS UP, THEN THE TRANSMISSION WILL DROP INTO GEAR WITH NECK SNAPPING RESULT, LUNGING FORWARD QUICKLY. I'M AFRAID THAT THIS COULD CAUSE MY WIFE TO LOOSE CONTROL OF THE VEHICLE. ALSO THE LOCKING TORQUE CONVERTER DISENGAGES CONSTANTLY AT HIGHWAY SPEEDS, THEN RE-ENGAGES, THEN DISENGAGES. I WAS FINALLY ABLE TO GET A FORD ENGINEER NAMED DERRICK TO CHECK THE VEHICLE, BUT HE REFUSES TO ACKNOWLEDGE THE PROBLEM. ALL HE WANTS TO TALK ABOUT IS HOW SMOOTH THE VEHICLE RIDES ON THE HIGHWAY, JUST A LOT OF DOUBLE TALK TO DIVERT ATTENTION AWAY FROM THE PROBLEM. IT IS A CONSTANT PROBLEM, VERIFIED BY DAVID LAUGHLIN OF FORD MOTOR COMPANY, PAUL SANFORD OF COURTESY FORD, AND DAVE ADAMS OF COURTESY FORD. *TR

NHTSA ODI #10266077

2004 model year · 34,303 miles · Apr 20, 2009

Power Train

Read full complaint

SHIFTING INTO REVERSE, THE VEHICLE WILL NOT MOVE, WHEN YOU GIVE IT MORE GAS, THEN SUDDENLY SURGE. THIS LATEST INCIDENT, I ALMOST HIT A PEDESTRIAN. I THOUGHT THIS WAS A THROTTLE RESPONSE ISSUE, BUT NOW I THINK IT MAYBE A TRANSMISSION ISSUE. THIS HAS BEEN AN ISSUE SINCE THE DAY I BOUGHT IT....THE DEALER PUT SOME FLUID IN THE TRANSMISSION AND RE-CALIBRATED THE THROTTLE. DEALER SAID THIS IS THE FIRST YEAR FORD USED AN ELECTRONIC THROTTLE. (NO CABLE FROM GAS PEDAL TO THROTTLE BODY.) AFTER READING THE NEWSPAPER ARTICLE, SEEMS THAT MANY OWNERS HAVE HAD SIMILAR COMPLAINTS. *TR

NHTSA ODI #10266053

Related Official recalls

26V402000 · Power Train:automatic Transmission

Jun 24, 2026

Ford Motor Company (Ford) is recalling certain 2018-2021 Navigator, Expedition, 2020-2021 Explorer, Lincoln Aviator, and 2021 F-150 vehicles. The transmission park pawl may engage while the vehicle is in motion, resulting in park system damage.

Consequence & remedy

Consequence: Park system damage may result in a vehicle rollaway, increasing the risk of a crash.

Remedy: Dealers will update the powertrain control module software, and inspect and replace any damaged transmission components as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed July 10, 2026. Additional letters will be sent once the remedy is available, anticipated in April 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S48. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on June 26, 2026.

23V199000 · Parking Brake:electrical; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Mar 24, 2023

Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles equipped with a 2.3L RWD, 3.3L GAS, 3.3L FHEV, or 3.0L ST powertrain. The previous powertrain control module (PCM) update completed under recall 22V-255 did not include the automatic electronic parking brake feature when the vehicle is shifted to park, as intended. In addition, the rear axle horizontal mounting bolt may fracture and cause the driveshaft to disconnect.

Consequence & remedy

Consequence: Without the electronic parking brake applied, the vehicle could rollaway if the driveshaft disconnects. A disconnected driveshaft can also result in a loss of drive power. Either of these scenarios can increase the risk of a crash.

Remedy: Dealers will update the PCM software, free of charge. Owner notification letters were mailed on May 31, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S16.

Additional source detail variants (2)

Parking Brake:electrical

Consequence: Without the electronic parking brake applied, the vehicle could rollaway if the driveshaft disconnects. A disconnected driveshaft can also result in a loss of drive power. Either of these scenarios can increase the risk of a crash.

Remedy: Dealers will update the PCM software, free of charge. Owner notification letters were mailed on May 31, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S16.

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

23V069000 · Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Feb 10, 2023

Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles equipped with a 2.3L engine and 10R60 automatic transmission. An unintentional powertrain control module (PCM) reset may occur while the vehicle is in motion and result in park system damage.

Consequence & remedy

Consequence: A park system that is damaged may not shift into "PARK," resulting in a vehicle rollaway and increasing the risk of injury or crash.

Remedy: Dealers will inspect the park system for damage and repair as necessary, free of charge. Owner notification letters were mailed March 28, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S05.

23V070000 · Power Train:automatic Transmission

Feb 10, 2023

Ford Motor Company (Ford) is recalling certain 2022-2023 F-150, Mustang, Explorer, Bronco, and 2023 Lincoln Aviator vehicles equipped with automatic transmissions. The transmission may contain a loose bolt which could prevent the transmission from engaging the park gear, although the gear shifter position may indicate that the vehicle has been shifted to "PARK."

Consequence & remedy

Consequence: The inability to secure the vehicle in the park position can result in a rollaway, increasing the risk of a crash or injury.

Remedy: Dealers will inspect and, if necessary, replace the transmissions, free of charge. Owner notification letters were mailed April 25, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S06.

19V575000 · Electrical System: Instrument Cluster/panel; Parking Brake; Power Train:automatic Transmission:gear Position Indication (prndl)

Aug 5, 2019

Ford Motor Company (Ford) is recalling certain 2020 Explorer and Lincoln Aviator vehicles. The Manual Park Release (MPR) cover may not be installed. In addition, the vehicles may be in Factory Mode, which disables warning alerts and does not display the transmission gear selected. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 114, "Theft Prevention" and 102, "Trans Shift Lever Seq/Starter Interlock/Trans Braking Effect."

Consequence & remedy

Consequence: Without the cover, the MPR lever may be unintentionally moved, allowing the vehicle to roll away. Being in Factory Mode, the vehicle will not display warnings and/or gear selection on the instrument cluster. Both conditions increase the risk of a crash.

Remedy: Ford will notify owners, and dealers will inspect and, if necessary, install a MPR cover. Dealers will verify the instrument cluster is not in Factory Mode and clear any fault codes, free of charge. The recall began August 23, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C06.

Additional source detail variants (3)

Parking Brake

Consequence: Without the cover, the MPR lever may be unintentionally moved, allowing the vehicle to roll away. Being in Factory Mode, the vehicle will not display warnings and/or gear selection on the instrument cluster. Both conditions increase the risk of a crash.

Remedy: Ford will notify owners, and dealers will inspect and, if necessary, install a MPR cover. Dealers will verify the instrument cluster is not in Factory Mode and clear any fault codes, free of charge. The recall began August 23, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C06.

Electrical System: Instrument Cluster/panel

Power Train:automatic Transmission:gear Position Indication (prndl)

07V453000 · Power Train:automatic Transmission:cooling Unit And Lines

Sep 26, 2007

ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH THE 4.6L ENGINE AND 6R TRANSMISSION, THE BOLT SECURING THE TRANSMISSION OIL COOLER LINE FITTINGS AT THE TRANSMISSION MAY NOT HAVE BEEN SUFFICIENTLY TORQUED DURING VEHICLE ASSEMBLY. AS A RESULT, THE BOLT MAY LOOSEN AND THE TRANSMISSION OIL COOLER LINES MAY DISENGAGE FROM THE TRANSMISSION, CAUSING A TRANSMISSION FLUID LEAK.

Consequence & remedy

Consequence: IF LEAKING TRANSMISSION FLUID CONTACTS THE CATALYTIC CONVERTER, IT MAY POSE A RISK OF FIRE.

Remedy: DEALERS WILL INSPECT AND HAVE THE TRANSMISSION COOLER LINE ATTACHMENT BOLT TIGHTENED FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 30, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

00V395000 · Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Nov 28, 2000

VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES EQUIPPED WITH THE 3.27 OR 3.55 AXLE RATION. THE SUBJECT VEHICLES HAVE A POWERTRAIN CONTROL MODULE THAT COULD ALLOW THE VEHICLE TO EXCEED THE DESIGN INTENT TOP SPEED. AT THESE EXTREME SPEEDS, THE VEHICLE COULD BE CAPABLE OF EXCEEDING THE SPEED RATING OF THE TIRE.

Consequence & remedy

Consequence: OPERATING THE VEHICLE ABOVE THE MAXIMUM SPEED RATING COULD LEAD TO A TIRE FAILURE WHICH AT THESE SPEEDS COULD RESULT IN A CRASH.

Remedy: DEALERS WILL REPROGRAM THE POWERTRAIN CONTROL MODULE.

91V189000 · Power Train:automatic Transmission

Nov 4, 1991

WHEN THE AUTOMATIC TRANSMISSION SHIFT LEVER IS PLACED IN THE PARK POSITION, THE PARK PAWL DOES NOT ALWAYS ABUT OR ENGAGE THE PARK GEAR.

Consequence & remedy

Consequence: DRIVER MAY BELIEVE THE VEHICLE IS SAFELY ENGAGED IN PARKWHEN THE GEAR IS NOT TRULY ENGAGED. THIS CAN LEAD TO THE VEHICLE JUMPING OUT OFGEAR UNINTENTIONALLY, VEHICLE ROLLAWAY WHEN PARKED ON A SLOPED SURFACE, ANDINADVERTENT MOTION WHEN THE VEHICLE IS STARTED. ALL OF THESE CONDITIONS CANRESULT IN A VEHICLE ACCIDENT.

Remedy: REPAIR THE TRANSMISSION WITH A NEW PARK PAWL.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

Related NHTSA investigations

EA09013 · Vehicle Rollaway Allegations

Opened Aug 18, 2009 · Closed Feb 12, 2013

Status: closed (inferred from source dates) · Power Train:automatic Transmission:gear Position Indication (prndl); Power Train:automatic Transmission:lever And Linkage:column Shift; Steering; Steering:column; Steering:column LOCKING:ANTI-THEFT Device

This investigation is being closed based on several considerations.By the most inclusive counting of all alleged rollaway incidents (i.e., counting all alleged rollaway incidents and assuming a singular failure mechanism), the incident rate is low, however during EA09-013, ODI identified a number of different failure mechanisms in 180 incidents related to the alleged defect.The highest rate for any particular failure mechanism, the failure of the Automatic Transmission Parking System, was 4.4/100K.The next-highest failure rate was for the BSI System, at 3.4/100K.For all identified failure mechanisms there has been a drastically declining trend including very few incidents occurring in recent years.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.For additional information regarding this investigation, see the complete closing resume in the document file for EA09-013. The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10168454, 10279630, 10280078.

Additional source detail variants (5)

Power Train:automatic Transmission:gear Position Indication (prndl)

Power Train:automatic Transmission:lever And Linkage:column Shift

Steering:column

Steering:column LOCKING:ANTI-THEFT Device

Steering

RQ97015 · Parking Pawl

Opened Oct 29, 1997 · Closed Apr 1, 1999

Status: closed (inferred from source dates) · Power Train:automatic Transmission

WHEN THE AUTOMATIC SHIFT LEVER IS PLACED IN THE PARK POSITION, THE PARKING PAWL DOES NOT ALWAYS ENGAGE THE PARK GEAR.THIS CAN LEAD TO THE VEHICLE JUMPING OUT OF GEAR UNINTENTIONALLY AND CAUSE THE VEHICLE TO START ROLLING INADVERTENTLY

PE91127 · Park Pawl Bending

Opened Sep 16, 1991 · Closed Nov 8, 1991

Status: closed (inferred from source dates) · Power Train:automatic Transmission

There is no summary currently available

Additional source detail variants (2)

Power Train:automatic Transmission

There is no summary currently available

Power Train:automatic Transmission

There is no summary currently available