NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
609 reportsMileage unknown · Dec 20, 2021
Service BrakesCrash
The component that malfunctioned was the abs sensor. It is not available for inspection. I was driving going around 45 in traffic and the drivers side rear brake locked up and spun me out of control and caused me to collide with another vehicle. I only lightly pressed the brakes and it happened suddenly and unexpectedly. It was …
Read full complaint
The component that malfunctioned was the abs sensor. It is not available for inspection. I was driving going around 45 in traffic and the drivers side rear brake locked up and spun me out of control and caused me to collide with another vehicle. I only lightly pressed the brakes and it happened suddenly and unexpectedly. It was not inspected before it was towed after the accident. There were no warning lamps.
NHTSA ODI #11444373
91,000 miles · May 7, 2015
Seat Belts
TL* THE CONTACT OWNS A 1991 FORD EXPLORER. WHILE DRIVING 15 MPH WITH ANOTHER PASSENGER, THE SEAT BELTS DISENGAGED AND CAUSED THE PASSENGER SEAT TO OVERTURN BETWEEN THE SEATS. THE PASSENGER WAS NOT INJURED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE…
Read full complaint
TL* THE CONTACT OWNS A 1991 FORD EXPLORER. WHILE DRIVING 15 MPH WITH ANOTHER PASSENGER, THE SEAT BELTS DISENGAGED AND CAUSED THE PASSENGER SEAT TO OVERTURN BETWEEN THE SEATS. THE PASSENGER WAS NOT INJURED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 91,000.
NHTSA ODI #10715094
15,000 miles · Jul 5, 2013
Fuel/propulsion SystemFire
ON JUNE 4TH MY DAUGHTER AND I WERE DRIVING EAST BOUND ON 62ND AND OVER-HILL IN LOS ANGELES CA. SHORTLY AFTER 12:00PM. WHEN SUDDENLY THE FORD EXPLORER WAS ENGULFED IN FLAMES. MY DAUGHTER AND I WERE ORDERED TO EXIT THE VEHICLE. I WAS NEVER NOTIFIED OF A RECALL. DUE TO INVESTIGATION ON MY OWN I HAVE RECEIVED A RECALL NUMBER. I…
Read full complaint
ON JUNE 4TH MY DAUGHTER AND I WERE DRIVING EAST BOUND ON 62ND AND OVER-HILL IN LOS ANGELES CA. SHORTLY AFTER 12:00PM. WHEN SUDDENLY THE FORD EXPLORER WAS ENGULFED IN FLAMES. MY DAUGHTER AND I WERE ORDERED TO EXIT THE VEHICLE. I WAS NEVER NOTIFIED OF A RECALL. DUE TO INVESTIGATION ON MY OWN I HAVE RECEIVED A RECALL NUMBER. IT IS 96S35. I HAVE ATTEMPTED TO RESOLVE THIS MATTER WITH FORD HOWEVER I JUST RECEIVED A LETTER FROM THEM REFUSING TO ASSIST ME. MY DAUGHTER AND I COULD HAVE BEEN BURNED ALIVE. I WOULD LIKE TO KNOW IF YOU COULD ASSIST ME. THE VEHICLE HAS SINCE BEEN DESTROYED. I ONLY HAVE IN MY POSSESSION THE PICTURE, AND A FIRE REPORT. *TR
NHTSA ODI #10523299
Mileage unknown · Oct 21, 2011
Tires
I PURCHASED TWO MICHELIN LTX MS2 235/75R15 TIRES FROM TIRE RACK.COM, E732381. THEY WERE DELIVERED SEPTEMBER 15, 2011 WITH AN INCORRECTLY COMPLETED OMB CONTROL NO. 2127-0050 TIRE REGISTRATION CARD. THE CARD LISTED THE BRAND AS BF GOODRICH AND THE TIRE IDENTIFICATION NUMBERS AS BETJMX912711. THE TIRES I RECEIVED ARE MICHE…
Read full complaint
I PURCHASED TWO MICHELIN LTX MS2 235/75R15 TIRES FROM TIRE RACK.COM, E732381. THEY WERE DELIVERED SEPTEMBER 15, 2011 WITH AN INCORRECTLY COMPLETED OMB CONTROL NO. 2127-0050 TIRE REGISTRATION CARD. THE CARD LISTED THE BRAND AS BF GOODRICH AND THE TIRE IDENTIFICATION NUMBERS AS BETJMX912711. THE TIRES I RECEIVED ARE MICHELIN B3DDDVOX2511 ACCORDING TO THE TIRE SIDEWALLS. I CONTACTED TIRE RACK'S CUSTOMER SERVICE DEPARTMENT. THEY ADVISED THAT THERE SYSTEM SHOWED THAT I WAS SENT MICHELIN B3DDDVOX2511 TIRES AND THAT IT WAS NOT THEIR RESPONSIBILITY TO CORRECTLY COMPLETE THE TIRE REGISTRATION CARD. DOES THIS COMPLY WITH DOT REGULATIONS REGARDING TIRE RETAILER'S CONDUCT REGARDING TIRE RECALL REGISTRATION? *TR
NHTSA ODI #10432381
2,000 miles · Oct 25, 2009
Tires
UNIROYAL TIRE SIDE WALL CRACKS LT 235 75R15 - NO FAILURE - JUST CRACK. ALL 4 OF MY TIRES HAD A SIDE WALL CRACK THE ENTIRE DIAMETER OF THE TIRE ABOUT 3 INCHES DOWN ON THE SIDE WALL . I NOTICED THE CRACK ON THE INSIDE AS WELL SO IT APPEARS THE TIRES HAD SOME ISSUE. I HAD NEVER APPLIED TIRE FOAM CLEANER(ARMOR ALL TIREFOAM P…
Read full complaint
UNIROYAL TIRE SIDE WALL CRACKS LT 235 75R15 - NO FAILURE - JUST CRACK. ALL 4 OF MY TIRES HAD A SIDE WALL CRACK THE ENTIRE DIAMETER OF THE TIRE ABOUT 3 INCHES DOWN ON THE SIDE WALL . I NOTICED THE CRACK ON THE INSIDE AS WELL SO IT APPEARS THE TIRES HAD SOME ISSUE. I HAD NEVER APPLIED TIRE FOAM CLEANER(ARMOR ALL TIREFOAM PRIOR ) BUT ONE TIME THIS LAST WEEK I DID APPLY SOME AND FOUND THE CRACK. LOOKING UNDER THE 1991 FORD EXPLORER 4X4 I DID SEE THE SAME ISSUE ON THE INSIDE OF A FRONT TIRE AS WELL...I NEVER APPLIED ANY ARMOR ALL TYPE CLEANER ON THE INSIDE EITHER. UNIROYAL FACTORY PHONE SUPPORT BLAMED ME OF APPLYING TIRE CLEANER WHICH RUINS TIRES AND SO DID THE WALMART TIRE STORE STAFF . I NEVER APPLIED ANYTHING AS THIS IS AN OLDER VEHICLE WHICH AND NO PR OR SHOW APPEAL. WALMART REPLACED ALL 4 TIRES ON 10-25-09 BUT THE TIRE PRESSURE WAS NOT 35 PSI ITS WAS AROUND 43 ACCORDING TO MY GAGE..THE TIRES ARE RATED FOR 50PSI. WALMART CHARGED THE PROBLEM TO MY WARRANTY AND THEN WANTED TO CHARGE AGAIN FOR A NEW WARRANTY. THIS WAS A TIRE FACTORY PROBLEM AS BOTH SIDE OF THE TIRES HAD A CRACK NOT A FIELD ROAD HAZARD ISSUE. KINGMAN AZ HAS TEMP RANGES FROM 110 IN JULY TO 9 DEGREES IN WINTER...THIS MAY BE FACTOR. *TR
NHTSA ODI #10289739
Mileage unknown · Apr 30, 2009
Engine And Engine CoolingFireInjury
TL*THE CONTACT OWNS A 1991 FORD EXPLORER. WHILE DRIVING 5 MPH ON A DRIVEWAY INCLINE, THE ENGINE IDLED EXCESSIVELY HIGH AND THE VEHICLE STALLED UNEXPECTEDLY. THE ENGINE RESTARTED AND RESUMED NORMAL OPERATION. THE CONTACT DETECTED SMOKE INSIDE AND OUTSIDE OF THE VEHICLE AND IMMEDIATELY TURNED OFF THE ENGINE. THE VEHICLE WAS IN…
Read full complaint
TL*THE CONTACT OWNS A 1991 FORD EXPLORER. WHILE DRIVING 5 MPH ON A DRIVEWAY INCLINE, THE ENGINE IDLED EXCESSIVELY HIGH AND THE VEHICLE STALLED UNEXPECTEDLY. THE ENGINE RESTARTED AND RESUMED NORMAL OPERATION. THE CONTACT DETECTED SMOKE INSIDE AND OUTSIDE OF THE VEHICLE AND IMMEDIATELY TURNED OFF THE ENGINE. THE VEHICLE WAS INSPECTED UNDERNEATH THE HOOD AND MASSIVE FLAMES ERUPTED FROM THE ENGINE COMPARTMENT. THE FIRE DEPARTMENT WAS CALLED TO THE SCENE. THE VEHICLE WAS COMPLETELY DESTROYED AND HAS NOT BEEN TOWED AWAY FROM THE SCENE. THE CONTACT SUSTAINED MINOR INJURIES TO HER HANDS. THE INSURANCE COMPANY WAS NOTIFIED OF THE FAILURE. THE FAILURE AND CURRENT MILEAGES WERE UNAVAILABLE.
NHTSA ODI #10267328
100,000 miles · Sep 8, 2008
Electrical SystemFire
TL*THE CONTACT OWNED A 1991 FORD EXPLORER. WHILE DRIVING 40 MPH, THE CONTACT NOTICED SMOKE COMING FROM THE INSTRUMENT PANEL. THE VEHICLE FAILED TO RESTART. SHE MANAGED TO MANEUVER THE VEHICLE TO THE SHOULDER AND LEFT TO CALL FOR HELP. UPON RETURNING TO THE VEHICLE, IT WAS CONSUMED IN FLAMES. THE VEHICLE WAS DESTROYED AND A …
Read full complaint
TL*THE CONTACT OWNED A 1991 FORD EXPLORER. WHILE DRIVING 40 MPH, THE CONTACT NOTICED SMOKE COMING FROM THE INSTRUMENT PANEL. THE VEHICLE FAILED TO RESTART. SHE MANAGED TO MANEUVER THE VEHICLE TO THE SHOULDER AND LEFT TO CALL FOR HELP. UPON RETURNING TO THE VEHICLE, IT WAS CONSUMED IN FLAMES. THE VEHICLE WAS DESTROYED AND A POLICE REPORT WAS FILED. THE FAILURE AND CURRENT MILEAGES WERE OVER 100,000.
NHTSA ODI #10241375
Mileage unknown · Mar 27, 2008
Vehicle Speed Control
TL*THE CONTACT OWNS A 1991 FORD EXPLORER. AFTER RECEIVING THE RECALL NOTICE FOR THE VEHICLE SPEED CONTROL: CRUISE CONTROL, THE CONTACT CALLED THE DEALER. THE DEALER STATED THAT THEY DID NOT HAVE THE PART FOR THE REPAIR; HOWEVER, THE RECALL STATED THAT THEY WERE AVAILABLE. THEY DID NOT KNOW WHEN THE PARTS WOULD ARRIVE. THERE …
Read full complaint
TL*THE CONTACT OWNS A 1991 FORD EXPLORER. AFTER RECEIVING THE RECALL NOTICE FOR THE VEHICLE SPEED CONTROL: CRUISE CONTROL, THE CONTACT CALLED THE DEALER. THE DEALER STATED THAT THEY DID NOT HAVE THE PART FOR THE REPAIR; HOWEVER, THE RECALL STATED THAT THEY WERE AVAILABLE. THEY DID NOT KNOW WHEN THE PARTS WOULD ARRIVE. THERE HAD BEEN NO FAILURE TO DATE. THE RECALL NUMBER WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 81,000.
NHTSA ODI #10222473
100,000 miles · Feb 26, 2008
Power TrainVehicle Speed Control
TL*THE CONTACT OWNS A 1991 FORD EXPLORER. THE CONTACT EXPERIENCED AUTOMATIC TRANSMISSION FAILURE. HE TOOK THE VEHICLE TO A MECHANIC AND THEY CLAIMED TO REPAIR IT, BUT ACTUALLY DID NOT. THE VEHICLE FAILED AND WAS TOWED TO A FORD DEALER AND THEY REPLACED THE CRUISE CONTROL SWITCH. THE AUTOMATIC TRANSMISSION WAS NOT REPAIRED. …
Read full complaint
TL*THE CONTACT OWNS A 1991 FORD EXPLORER. THE CONTACT EXPERIENCED AUTOMATIC TRANSMISSION FAILURE. HE TOOK THE VEHICLE TO A MECHANIC AND THEY CLAIMED TO REPAIR IT, BUT ACTUALLY DID NOT. THE VEHICLE FAILED AND WAS TOWED TO A FORD DEALER AND THEY REPLACED THE CRUISE CONTROL SWITCH. THE AUTOMATIC TRANSMISSION WAS NOT REPAIRED. THE VEHICLE IS CURRENTLY IN THE POSSESSION OF ANOTHER MECHANIC. THE CURRENT AND FAILURE MILEAGES WERE GREATER THAN 100,000. UPDATED 03/11/08. *LJ
NHTSA ODI #10219189
161,000 miles · Nov 27, 2006
Structure
COPY OF LETTER TO FMC: I OWN A 1991 FORD EXPLORER 4WD XLT [XXX]. I PURCHASED THIS VEHICLE ON 11/9/96, FROM CROWN DODGE, VENTURA, CALIFORNIA. THE SELLING DEALER ASSURED ME AT THE TIME THAT NO RECALLS WERE OUTSTANDING ON THIS VEHICLE. ON NOVEMBER 11/22/06, AS I CLOSED THE HATCH ON THIS VEHICLE, THE BRACKET THAT ATTACHES …
Read full complaint
COPY OF LETTER TO FMC: I OWN A 1991 FORD EXPLORER 4WD XLT [XXX]. I PURCHASED THIS VEHICLE ON 11/9/96, FROM CROWN DODGE, VENTURA, CALIFORNIA. THE SELLING DEALER ASSURED ME AT THE TIME THAT NO RECALLS WERE OUTSTANDING ON THIS VEHICLE. ON NOVEMBER 11/22/06, AS I CLOSED THE HATCH ON THIS VEHICLE, THE BRACKET THAT ATTACHES THE RIGHT-SIDE LIFTGATE GAS ASSIST CYLINDER TO THE HATCH TORE AWAY FROM THE HATCH. I HAVE JUST LEARNED THAT A SAFETY IMPROVEMENT CAMPAIGN (NUMBER 95I007000) WAS ISSUED IN OCTOBER 1995 TO REINFORCE THIS BRACKET. THE CAMPAIGN STATED THAT "IF A BRACKET AND GAS ASSIST CYLINDER WERE TO DETACH COMPLETELY FROM THE LIFTGATE AND NO LONGER BEAR AGAINST THE LIFTGATE AS INTENDED, THE REMAINING CYLINDER WOULD NOT HOLD THE LIFTGATE IN AN OPEN POSITION. PERSONAL INJURY COULD OCCUR." THE CORRECTIVE ACTION WAS FOR FORD DEALERS TO REINFORCE THE BRACKET ATTACHMENTS. MY LOCAL FORD DEALER SERVICE REPRESENTATIVE STATED TODAY THEY COULD NOT HONOR THIS SAFETY IMPROVEMENT CAMPAIGN. REBECCA (#6048) AT THE FORD CUSTOMER SERVICE CALL CENTER TOLD ME THE CAMPAIGN HAD EXPIRED, AND COULDN'T OFFER ASSISTANCE. YOUR COMPANY'S RESPONSE TO DATE IS NOT ACCEPTABLE. THE BRACKET WAS ATTACHED TO THE HATCH BY ONLY TWO SMALL SPOT WELDS, AS IS THE LEFT-SIDE BRACKET. THE FAILURE STILL HAS THE POTENTIAL FOR CAUSING SERIOUS INJURY, ESPECIALLY IF THE LEFT-SIDE BRACKET WERE TO FAIL. THE VEHICLE WAS APPARENTLY NOT REPAIRED UNDER THIS SAFETY IMPROVEMENT CAMPAIGN. I WAS NOT NOTIFIED OF THE CAMPAIGN NOR OFFERED AN OPPORTUNITY TO HAVE THIS DEFECT REPAIRED. SINCE THE SAFETY HAZARD THAT THIS SAFETY IMPROVEMENT CAMPAIGN SOUGHT TO RESOLVE STILL EXISTS ON MY VEHICLE, I REQUEST THAT THE BROKEN BRACKET BE REPAIRED AND THE REMAINING BRACKET REINFORCED AT NO CHARGE TO ME, PER THE INTENT OF THE SAFETY IMPROVEMENT CAMPAIGN. THANK YOU FOR YOUR ASSISTANCE. [XXX] *NM UPDATED 07/12/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #10174414
Official recalls
8Dec 18, 1997
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES EQUIPPED WITH FACTORY INSTALLED SUNROOF. THE SUNROOF GLASS PANEL ASSEMBLY CAN SEPARATE WHILE THE VEHICLE IS MOVING DUE TO INCORRECT HINGE ENGAGEMENT. THIS WAS CAUSED BY IMPROPER SUNROOF INSTALLATION OF THE GLASS PANEL.
Consequence & remedy
Consequence: UNEXPECTED SEPARATION OF THE SUNROOF GLASS PANEL COULD POSSIBLY DISTRACT THE DRIVER INCREASING THE RISK OF A VEHICLE CRASH OR LOSS OF VEHICLE CONTROL.
Remedy: OWNERS WILL BE PROVIDED WITH AN INSTRUCTION BOOKLET WHICH THOROUGHLY OUTLINES, WITH ILLUSTRATIONS, THE PROPER PROCEDURES FOR THE REMOVAL, STORAGE, AND REINSTALLATION OF THE SUNROOF'S GLASS PANEL. A WARNING LABEL FOR ATTACHMENT TO THE SUNROOF'S LATCH KNOB WILL ALSO BE PROVIDED TO THE OWNERS.
Feb 5, 1996
THE STUDS WHICH ATTACH THE BRAKE MASTER CYLINDER TO THE POWER BRAKE VACUUM BOOSTER ASSEMBLY CAN DEVELOP STRESS CORROSION CRACKING AFTER BEING OPERATED FOR AN EXTENDED PERIOD OF TIME IN THE SOUTHERN CALIFORNIA LOCATION.
Consequence & remedy
Consequence: IF A CRACK OCCURS, IT COULD RESULT IN ONE OR BOTH STUDS FRACTURING. THE MASTER CYLINDER COULD THEN SEPARATE FROM THE VACUUM BOOSTER, WHEN THE BRAKES ARE APPLIED, PREVENTING THE SERVICE BRAKES FROM ACTIVATING INCREASING THE RISK OF A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE THE POWER BRAKE VACUUM BOOSTER ASSEMBLY.
Aug 17, 1992
THE RIGID MOUNTED SAFETY BELT BUCKLES ARE DEFECTIVE IN THREE WAYS. FIRST, A FASTENED SAFETY BELT BUCKLE WILL NOT UNLATCH WHEN THE RELEASE BUTTON IS DEPRESSED. THIS RESULTS FROM INTERFERENCE BETWEEN THE BUCKLE EJECTOR FINGER AND THE BUCKLE TONGUE WINDOW. THE SECOND DEFECT IS THE SAFETY BELT BUCKLE MAY NOT LATCH. THE THIRD POSSIBLE DEFECT IS THAT THE TONGUE MAY BE RETAINED BY THE BUCKLE, BUT IT MAY NOT BE LATCHED SUFFICIENTLY TO PROVIDE OCCUPANT PROTECTION.
Consequence & remedy
Consequence: AN INSUFFICIENTLY LATCHED OR UNLATCHED SAFETY BELTINCREASES THE RISK OF INJURY TO SEAT OCCUPANTS IN THE EVENT OF A SUDDEN STOP ORACCIDENT. IF THE SAFETY BELT BUCKLE WILL NOT UNLATCH, IT WILL NOT ALLOW THEOCCUPANT TO GET OUT OF THE VEHICLE IN AN EMERGENCY SITUATION.
Remedy: FORD WILL REPLACE THE RIGID MOUNTED SAFETY BELT BUCKLES WITH END RELEASE SAFETY BELT BUCKLES DESIGNED TO PREVENT LATCH PROBLEMS.
Nov 4, 1991
WHEN THE AUTOMATIC TRANSMISSION SHIFT LEVER IS PLACED IN THE PARK POSITION, THE PARK PAWL DOES NOT ALWAYS ABUT OR ENGAGE THE PARK GEAR.
Consequence & remedy
Consequence: DRIVER MAY BELIEVE THE VEHICLE IS SAFELY ENGAGED IN PARKWHEN THE GEAR IS NOT TRULY ENGAGED. THIS CAN LEAD TO THE VEHICLE JUMPING OUT OFGEAR UNINTENTIONALLY, VEHICLE ROLLAWAY WHEN PARKED ON A SLOPED SURFACE, ANDINADVERTENT MOTION WHEN THE VEHICLE IS STARTED. ALL OF THESE CONDITIONS CANRESULT IN A VEHICLE ACCIDENT.
Remedy: REPAIR THE TRANSMISSION WITH A NEW PARK PAWL.
Feb 12, 1991
REAR BUMPER REINFORCEMENT MAY BE SUBJECT TO FATIGUE CRACKING UNDER EXTENDED TRAILER TOW SERVICE WHEN USING A BUMPER-MOUNTED TRAILER HITCH BALL.
Consequence & remedy
Consequence: UNDER EXTREME CONDITIONS, BUMPER COULD SEPARATE FROM THEVEHICLE WHEN USING A BUMPER MOUNTED TRAILER HITCH BALL.
Remedy: INSTALL TWO BRACKETS TO REINFORCE THE BUMPER.
Feb 11, 1991
THE FRONT HEAT SHIELD MAY CONTACT THE FRONT OF THE PLASTIC FUEL TANK, CAUSING CUTS OR OTHER DAMAGE TO THE EXTENT OF PENETRATION.
Consequence & remedy
Consequence: THIS PENETRATION OF THE FUEL TANK CAUSES VAPORS TO ESCAPEAND POSSIBLY FUEL TO SPILL, WHICH COULD CATCH FIRE IN THE PRESENCE OF ANIGNITION SOURCE.
Remedy: RELOCATE THE HEAT SHIELD; INSPECT AND REPLACE DAMAGED FUEL FUEL TANKS.
Feb 11, 1991
THE HOT PLATE WELD WHICH ATTACHES THE VAPOR VENT VALVE CARRIER TO THE TOP OF THE PLASTIC FUEL TANK MAY PARTIALLY FRACTURE, ALLOWING VAPOR OF FUEL TO ESCAPE FROM THE TOP OF THE TANK.
Consequence & remedy
Consequence: THE ESCAPED VAPOR OR LEAKED FUEL COULD CAUSE A FIRE INTHE PRESENCE OF A SOURCE OF IGNITION.
Remedy: FUEL TANK WILL BE REMOVED AND INSPECTED FOR WELD INTEGRITY. FUEL TANKS WITH INADEQUATE WELDS WILL BE REPLACED.
May 21, 1990
IF SUNROOF GLASS IS REMOVED AND REINSTALLED BY VEHICLE OPERATOR, HINGE ASSEMBLIES CAN BE ACCIDENTALLY IMPROPERLY MATED.
Consequence & remedy
Consequence: SUNROOF COULD DETACH FROM THE VEHICLE WHILE BEING DRIVEN,CREATING A RISK TO FOLLOWING VEHICLES OR PEOPLE IN THE VICINITY, OR TO VEHICLEOCCUPANTS IF THE GLASS SHOULD FALL INTO THE CABIN.
Remedy: INSTALL REVISED SUNROOF HINGES THAT WILL ADEQUATELY RETAIN SUNROOF ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
17EA00012 · Spare Tire Winch Cable
Opened Apr 14, 2000 · Closed Oct 20, 2000
Status: closed (inferred from source dates) · Structure
There is no summary currently available
PE99072 · Spare Tire Winch Cable
Opened Nov 30, 1999 · Closed Apr 14, 2000
Status: closed (inferred from source dates) · Structure
FROM THE BEGINNING OF THE 1991 MODEL YEAR PRODUCTION UNTIL THE MIDDLE OF THE 1994 MODEL YEAR PRODUCTION, FORD USED A GALVANIZED STEEL CABLE TO LIFT AND HOLD IN STORED POSITION, THE EXPLORER SPARE TIRE.ON MAY 19, 1994, BASED ON THE RESULTS OF FORD DURABILITY TESTING , FORD CHANGED TO A 4.00MM STAINLESS STEEL CABLE.THERE HAVE BEEN OVER 100 INCIDENTS IN WHICH THE ORIGINAL GALVANIZED STEEL CABLE FAILED ALLOWING THE SPARE TIRE TO DROP FROM ITS REAR STORAGE WELL.ONE OF THESE INCIDENTS CAUSED A FOLLOWING VEHICLE TO BE INVOLVED IN A COLLISION AND ON SIX OTHER OCCASIONS THE WHEEL MADE CONTACT WITH FOLLOWING VEHICLES, RESULTING IN PROPERTY DAMAGE.
RQ99016 · Liftgate Support Bracket Failure
Opened Jul 29, 1999 · No close date supplied
Status: open (inferred from source dates) · Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
Additional source detail variants (2)
Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
DP98001 · Heavy Lateral Vibration
Opened Jan 6, 1998 · Closed Feb 4, 1998
Status: closed (inferred from source dates) · Structure
NHTSA WAS PETITIONED TO COMMENCE A DEFECT INVESTIGATION OF THE SUBJECT VEHICLES ON JANUARY 6, 1998.THE PETITION ALLEGES THAT EARLY MODEL FORD EXPLORER SPORT UTILITY VEHICLES DEVELOP HEAVY LATERAL VIBRATIONS AT SPEEDS ABOVE 55 MPH AND WHEN ENCOUNTERING BUMPS AT LOW SPEEDS.THE PETITION FURTHER ALLEGES THAT THESE VIBRATIONS COULD POSSIBLY CAUSE LOSS OF VEHICLE CONTROL.THE ANALYSIS OF THE PETITION IS PRESENTED IN THE ATTACHED NOTICE WHICH IS PUBLISHED IN THE FEDERAL REGISTER.
RQ97015 · Parking Pawl
Opened Oct 29, 1997 · Closed Apr 1, 1999
Status: closed (inferred from source dates) · Power Train:automatic Transmission
WHEN THE AUTOMATIC SHIFT LEVER IS PLACED IN THE PARK POSITION, THE PARKING PAWL DOES NOT ALWAYS ENGAGE THE PARK GEAR.THIS CAN LEAD TO THE VEHICLE JUMPING OUT OF GEAR UNINTENTIONALLY AND CAUSE THE VEHICLE TO START ROLLING INADVERTENTLY
EA97011 · Sunroof Shattering And Separation
Opened May 23, 1997 · Closed Jan 20, 1998
Status: closed (inferred from source dates) · Structure
There is no summary currently available
Additional source detail variants (2)
Structure
There is no summary currently available
Structure
There is no summary currently available
EA95018 · Separation Of Master Cylinder
Opened Jun 19, 1995 · Closed Apr 2, 1996
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
Additional source detail variants (2)
Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
PE95001 · Brake Master Cylinder/booster Separation
Opened Jan 3, 1995 · Closed Jun 19, 1995
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE94044 · Engine Cooling Fan Cracks
Opened Jun 10, 1994 · Closed Aug 31, 1994
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA93003 · Throttle Sticking
Opened Jan 15, 1993 · Closed Jan 6, 1994
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE92084 · Front Seat Track Failure
Opened Oct 23, 1992 · Closed Feb 26, 1993
Status: closed (inferred from source dates) · Seats
There is no summary currently available
PE92029 · Whl Separation/torque Loss
Opened Mar 16, 1992 · Closed Aug 31, 1992
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
EA91040 · Vacuum Boostr Valve Fails
Opened Oct 3, 1991 · Closed Aug 17, 1992
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE91127 · Park Pawl Bending
Opened Sep 16, 1991 · Closed Nov 8, 1991
Status: closed (inferred from source dates) · Power Train:automatic Transmission
There is no summary currently available
Additional source detail variants (2)
Power Train:automatic Transmission
There is no summary currently available
Power Train:automatic Transmission
There is no summary currently available
EA91034 · Throttle Release Failure
Opened Jul 17, 1991 · Closed Apr 10, 1992
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE91084 · Vacuum Boostr Valve Fails
Opened Jun 10, 1991 · Closed Oct 3, 1991
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE91058 · Throttle Release Failure
Opened Mar 6, 1991 · Closed Jul 22, 1991
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
Illustration