NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
185 reportsClear category filterMileage unknown · Sep 15, 2026
Electrical SystemForward Collision AvoidancePower Train
I own a 2020 Ford Explorer XLT AWD, VIN 1FMSK8DH6LGA35229. While driving, my vehicle displayed “4WD Fault – Service Required” along with the powertrain wrench warning. I then became unable to select/change drive modes. Pre-Collision Assist became unavailable, I experienced Lane Keeping/Lane Assist problems, and additional stabil…
Read full complaint
I own a 2020 Ford Explorer XLT AWD, VIN 1FMSK8DH6LGA35229. While driving, my vehicle displayed “4WD Fault – Service Required” along with the powertrain wrench warning. I then became unable to select/change drive modes. Pre-Collision Assist became unavailable, I experienced Lane Keeping/Lane Assist problems, and additional stability/traction warnings appeared. A professional diagnostic scan found AWD codes C0631:7E-68 and C0631:7F-6C related to the front axle disconnect actuator. The ABS module also stored U0102 (Lost Communication With Transfer Case Control Module) and U0155 (Lost Communication With Instrument Panel Cluster). My mechanic diagnosed failure of the front axle disconnect actuator/intermediate-shaft system. The repair requires removal of the original disconnect system and installation of Ford’s revised intermediate shaft/axle components, replacement of the vent/breather hose, and AWD programming. I was quoted approximately $1,337. The mechanic will then determine whether the transfer case/AWD control module also requires replacement, which would cost approximately $828 additional. Ford has issued TSB 25-2373, superseding TSB 23-2174, for certain 2020-2021 Explorer AWD vehicles. The bulletin specifically identifies C0631 and/or C00A6 and the front axle disconnect actuator/intermediate shaft and directs replacement with a revised intermediate shaft. I am concerned this is a safety defect because the failure resulted in AWD/drive-mode malfunction while multiple driver-assistance systems became unavailable. I request that NHTSA investigate this known failure and determine whether a safety recall is warranted.
NHTSA ODI #11764430
Mileage unknown · Aug 15, 2026
Electrical SystemStructureInjury
On August 14, 2026, the power liftgate on my 2020 Forde Explorer unexpectedly began closing while I was loading my dog into a kennel in the rear cargo area. I did not press the liftgate close button and no one else activated a liftgate control. My key fob was inside my purse on the front seat of the vehicle. The liftgate came d…
Read full complaint
On August 14, 2026, the power liftgate on my 2020 Forde Explorer unexpectedly began closing while I was loading my dog into a kennel in the rear cargo area. I did not press the liftgate close button and no one else activated a liftgate control. My key fob was inside my purse on the front seat of the vehicle. The liftgate came down while I was underneath it and struck me directly on the head. The impact knocked me to the ground. I saw stars and was confused immediately afterward and sustained a scalp laceration with significant bleeding. I did not lose consciousness and did not require stitches. One person directly witnessed the incident and was also struck by the closing liftgate. Because the liftgate struck my head first, its force was reduced before it contacted the other person, who was not injured. Other people arrived immediately afterward and can confirm my condition following the impact and that the key was in my purse on the front seat. This was not the first time this has happened. It has occurred on multiple occasions while loading without intentionally activating. I have been hit in the head before but not enough to cause bleeding. The incident occurred Friday evening on 8/14/2026. Vehicle has not yet been inspected because the service department is closed for the weekend. I plan to contact Ford once open on Monday. I am reporting this because I am concerned there may be a defect involving unintended activation of the power/hands-free liftgate and/or its safety obstacle-detection system. The unexpected closure has now caused an injury and also struck a second person.
NHTSA ODI #11757115
100,000 miles · Aug 5, 2026
Electrical SystemParking Brake
The contact owns a 2020 Ford Explorer. The contact stated that the vehicle experienced intermittent starting failures, and upon starting the vehicle and shifting into gear, the vehicle shut off. No warning light illuminated. Additionally, the electronic parking brake was unintendely engaged. The contact replaced the battery; how…
Read full complaint
The contact owns a 2020 Ford Explorer. The contact stated that the vehicle experienced intermittent starting failures, and upon starting the vehicle and shifting into gear, the vehicle shut off. No warning light illuminated. Additionally, the electronic parking brake was unintendely engaged. The contact replaced the battery; however, the failure persisted. The vehicle was not diagnosed or repaired by a dealer or an independent mechanic. The manufacturer was not notified of the failure. The failure mileage was approximately 100,000.
NHTSA ODI #11754954
Mileage unknown · Jul 27, 2026
Electrical System
My wife was driving and the horn started blowing and the rear wiper started ejecting all the wiper fluid. When I showed up to assist, it smelled super hot and I had to pull the fuse and negative lead to make the wiper pump and horn stop. It was towed to a Ford dealer, who found the main engine harness had MELTED going into the e…
Read full complaint
My wife was driving and the horn started blowing and the rear wiper started ejecting all the wiper fluid. When I showed up to assist, it smelled super hot and I had to pull the fuse and negative lead to make the wiper pump and horn stop. It was towed to a Ford dealer, who found the main engine harness had MELTED going into the engine compartment fuse box. The horn and wiper fluid pump also had to be replaced. It's fortunate this did not result in a fire. Ford dealer had the vehicle for TWO MONTHS to repair (and we had to take it back for the horn and washer pump). The Ford dealer said they could not give any reason for why this happened. The entire main harness and fuse panel had to be replaced. No check engine or warning lights appeared when this happened. My wife had to pull over on the side of the road.
NHTSA ODI #11753061
Mileage unknown · Jul 2, 2026
Electrical SystemStructureWheels
My driver window won’t stay up once it gets to the top it goes back down. The underbody is starting to detach. It is shifting hard and makes a loud noise. Worse at low speeds and applying brakes . The tire pressure sensors all went out at one time
NHTSA ODI #11747989
Mileage unknown · Jun 30, 2026
Electrical SystemSeats
With people in the backseat, the seats decided to fold out of nowhere from the previous recall where the seat released buttons on the second row get stuck. Even though it’s very clear that these buttons need to be replaced and I took it to a Ford dealership they said that they were fine even though the buttons literally are stuc…
Read full complaint
With people in the backseat, the seats decided to fold out of nowhere from the previous recall where the seat released buttons on the second row get stuck. Even though it’s very clear that these buttons need to be replaced and I took it to a Ford dealership they said that they were fine even though the buttons literally are stuck in no matter what and ever so slightly touching them causes the seats to fold. The passengers in the second row were not injured, but very easily could’ve been.
NHTSA ODI #11747334
Mileage unknown · Jun 26, 2026
Electrical SystemFuel/propulsion System
First the fuel pump control module went out and now for the 3rd time the electrical to the fuel pump control module has faulted
NHTSA ODI #11746795
Mileage unknown · Jun 20, 2026
Electrical SystemVisibility/wiper
The front windshield wiper on my vehicle,may become inoperative. The Ford Motors says that they don't have the part to replace,and when they have it I have to pay for the repair.
NHTSA ODI #11745393
Mileage unknown · May 27, 2026
Electrical SystemPower Train
I am filing a complaint regarding a recurring safety-related electrical and AWD defect in my 2020 Ford Explorer. My vehicle repeatedly displays the following warnings while driving: “4WD Fault Service Required” “Service AdvanceTrac” “Pre-Collision Assist Not Available” “Hill Start Assist Not Available” The issue began about a…
Read full complaint
I am filing a complaint regarding a recurring safety-related electrical and AWD defect in my 2020 Ford Explorer. My vehicle repeatedly displays the following warnings while driving: “4WD Fault Service Required” “Service AdvanceTrac” “Pre-Collision Assist Not Available” “Hill Start Assist Not Available” The issue began about a year ago occurring intermittently every few weeks and disappearing after restarting the vehicle. It has progressively worsened and now appears almost immediately after driving only a few feet. The defect affects multiple critical safety systems including AWD/4WD, traction/stability control, hill assist, and collision avoidance systems. I have contacted Ford multiple times. Ford only opens customer service cases but has not provided a permanent repair. Ford is aware this is a common issue with 2020 Explorers specifically, and later model years appear to have been corrected. Numerous owners report the exact same failures online. Ford has issued service information involving software reprogramming, module communication faults, and wiring harness issues, but only Ford dealerships can perform the required programming. This appears to be a widespread manufacturing or engineering defect and creates a serious safety concern while driving. Vehicle Information: 2020 Ford Explorer Mileage: Under 55,000 miles I respectfully request that NHTSA investigate this issue for a potential recall or mandatory corrective action.
NHTSA ODI #11740378
Mileage unknown · May 21, 2026
Electrical SystemExterior LightingVisibility/wiper
Both my passenger and driver headlights have failed. I have paid to have them replaced. The drivers side has failed twice. The passenger side has failed 3 times. I have taken it to the dealership and they “fixed” the issue but it keeps coming back months or weeks later. The low beams are what is failing. The message on the das…
Read full complaint
Both my passenger and driver headlights have failed. I have paid to have them replaced. The drivers side has failed twice. The passenger side has failed 3 times. I have taken it to the dealership and they “fixed” the issue but it keeps coming back months or weeks later. The low beams are what is failing. The message on the dash says “check headlight assembly see manual” This is a safety risk to me and other people on the road. They have failed while driving. If I am driving early in the morning or late at night I can not see if there are no street lights. People also can’t see me coming. This is a major safety risk. I bought the car in August 2024. Headlights have failed 5 times since then. The dealership helped me with my first four failures. On this last failure, they said it is not covered under warranty and that I need to pay $3000 for the headlight. Five failures of headlights seems like a manufacturer issue and not something. I am doing on my end.
NHTSA ODI #11739255
Official recalls
33Jul 14, 2026
Ford Motor Company (Ford) is recalling certain 2020-2027 Aviator and 2020-2026 Explorer vehicles. The switch for the easy-entry second-row outer seats may bind or stick, resulting in the seats unlatching, tipping, or sliding unexpectedly.
Consequence & remedy
Consequence: A seat that moves unexpectedly may not properly restrain an occupant during a crash, increasing the risk of injury.
Remedy: Dealers will inspect and replace the bezel around the switch as necessary, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model and model years. Interim letters explaining the safety risk were mailed August 19, 2026. Additional letters will be sent once the remedy is available, anticipated in January 2027. Lincoln Aviator owner notification letters were mailed August 21, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S52. This recall expands Recall 25V393. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 16, 2026.
Jun 24, 2026
Ford Motor Company (Ford) is recalling certain 2018-2021 Navigator, Expedition, 2020-2021 Explorer, Lincoln Aviator, and 2021 F-150 vehicles. The transmission park pawl may engage while the vehicle is in motion, resulting in park system damage.
Consequence & remedy
Consequence: Park system damage may result in a vehicle rollaway, increasing the risk of a crash.
Remedy: Dealers will update the powertrain control module software, and inspect and replace any damaged transmission components as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed July 10, 2026. Additional letters will be sent once the remedy is available, anticipated in April 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S48. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on June 26, 2026.
Mar 17, 2026
Ford Motor Company (Ford) is recalling certain 2020-2026 Explorer and Lincoln Aviator vehicles. The seat belt anchor bolts at the second-row outer seating positions may be improperly secured.
Consequence & remedy
Consequence: A loose seat belt buckle may not properly restrain an occupant during a crash, increasing the risk of injury.
Remedy: Dealers will inspect the second-row outer seat belt lower anchor bolts and replace or repair them as necessary, free of charge. Owner notification letters were mailed March 30, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C18. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 19, 2026.
Mar 3, 2026
Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer, Escape, Lincoln Aviator, and Lincoln Corsair vehicles. The windshield wiper motor may fail and prevent the windshield wipers from operating properly.
Consequence & remedy
Consequence: Windshield wipers that fail to operate properly can reduce visibility, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the front wiper motors as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed April 2, 2026. Additional letters will be sent once the final remedy is available, anticipated in October 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S14. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 4, 2026.
Mar 3, 2026
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape, Lincoln Corsair, 2020-2024 Lincoln Aviator, and Explorer vehicles. The image on the center display may flip or invert, resulting in an incorrectly displayed rearview image when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: An incorrectly displayed rearview image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will update the accessory protocol interface module (APIM) software, free of charge. Owner notification letters were mailed June 23, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C11. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 5, 2026.
Oct 10, 2025
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
Consequence & remedy
Consequence: An electrical short circuit can increase the risk of a fire.
Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
Jun 27, 2025
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
Consequence & remedy
Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
Jun 13, 2025
Ford Motor Company (Ford) is recalling certain 2020-2025 Aviator, and Explorer vehicles. The switch for the easy-entry second-row outer seats may bind or stick, resulting in the seats unlatching, folding, or sliding unexpectedly while driving.
Consequence & remedy
Consequence: A seat that moves unexpectedly may not properly restrain an occupant during a crash, increasing their risk of injury.
Remedy: Dealers will inspect the second-row seat switch, and replace the bezel around the switch as necessary, free of charge. Owner notification letters were mailed August 7, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S67.
Mar 14, 2025
Ford Motor Company (Ford) is recalling certain 2020-2023 Explorer, Lincoln Aviator, and 2020-2022 Lincoln Corsair vehicles previously repaired incorrectly under recall number 23V-342. The video output may fail, preventing the rearview camera image from displaying.
Consequence & remedy
Consequence: Loss of the rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will update the Image Processing Module software, free of charge. Owner notification letters were mailed April 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S27.
Mar 14, 2025
Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles previously repaired incorrectly under recall numbers 23V-199 or 22V-255. The rear axle horizontal mounting bolt may fracture and cause the driveshaft to disconnect.
Consequence & remedy
Consequence: A disconnected driveshaft can result in vehicle rollaway when the vehicle is placed in park without the parking brake applied. A disconnected driveshaft can also result in a loss of drive power. Either of these scenarios can increase the risk of a crash.
Remedy: Dealers will update the powertrain control module (PCM) software, free of charge. Owner notification letters were mailed April 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S22.
Feb 14, 2025
Ford Motor Company (Ford) is recalling certain 2020-2021 Explorer and Aviator vehicles. The seat belt buckle anchor bolts at one or more seating positions may be improperly secured. Additionally, vehicles may have an improperly secured seat belt retractor anchor bolt and/or seat belt anchor bolt at the second-row center seating position, if equipped.
Consequence & remedy
Consequence: A loose seat belt or seat belt buckle may not properly restrain an occupant during a crash, increasing the risk of injury.
Remedy: Dealers will inspect seat belt buckle anchor bolts in all seating positions. Additionally, dealers will inspect the seat belt retractor anchor bolt and seat belt anchor bolt at the second-row center seating position, if equipped. If loose anchor bolts are found, the affected seat components will be replaced. Repairs will be performed free of charge. Owner notification letters were mailed on June 5, 2025. Owners may contact Ford customer service at 866-436-7332. Ford's number for this recall is 25S09.
Nov 8, 2024
Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.
Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.
Aug 9, 2024
Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles equipped with the Police Interceptor Utility Package. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.
Consequence & remedy
Consequence: An engine compartment fire increases the risk of injury.
Remedy: Owners are advised to park and shut off the engine as promptly as possible upon hearing unexpected engine noises, or after experiencing an unexpected engine power reduction, or seeing smoke from the engine compartment. Dealers will update the Powertrain Control Module (PCM) software. In addition, dealers will inspect for connecting rod bearing failure and if necessary, replace the engine long block. All inspections and repairs will be performed free of charge. Owner notification letters were mailed August 15, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S52.
Mar 8, 2024
Ford Motor Company (Ford) is recalling certain 2020 Explorer vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: A rearview camera that displays a blank or distorted image can reduce the drivers view of what is behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed April 4, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C19. This recall is an expansion of NHTSA recall numbers 20V-575 and 22V-252.
Oct 6, 2023
Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles. The rear axle horizontal mounting bolt may fracture and cause the driveshaft to disconnect.
Consequence & remedy
Consequence: A disconnected driveshaft can result in a loss of drive power or a vehicle rollaway if the parking brake is not applied. Either of these scenarios can increase the risk of a crash.
Remedy: Dealers will replace the subframe bushing and rear axle bolt. They will also inspect the rear axle cover for damage near the bolt hole location and replace with a new cover if any damage is found. Repairs will be performed free of charge. Owner notification letters were mailed January 19, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S55.
Sep 8, 2023
Ford Motor Company (Ford) is recalling certain 2020-2022 Lincoln Aviator and Ford Explorer vehicles equipped with 3.0L PHEV engines. A manufacturing defect in one or more of the high voltage battery cells may result in an internal short circuit and battery failure.
Consequence & remedy
Consequence: Battery failure can cause a loss of drive power, increasing the risk of a crash. Battery failure can also increase the risk of a fire.
Remedy: Dealers will perform a Battery Energy Control Module (BECM) diagnostic test and replace the high voltage battery pack, as necessary, free of charge. Owner notification letters were mailed on April 8, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford Motor Company's number for this recall is 23S53.
May 12, 2023
Ford Motor Company (Ford) is recalling certain 2020-2023 Explorer, Lincoln Aviator, and 2020-2022 Lincoln Corsair vehicles equipped with a 360-degree camera. The video output may fail, preventing the rearview camera image from displaying.
Consequence & remedy
Consequence: Loss of the rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will replace the 360-degree camera, free of charge. Owner notification letters were mailed November 10, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S23. This recall expands and replaces NHTSA recall number 23V-022. Vehicles previously repaired under 23V-022 will need to have the new remedy performed.
Apr 28, 2023
Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer Police Interceptor Utility vehicles equipped with a 12.1-inch Integrated Computer Screen (ICS). When the Display On/Off Button is used to turn the display to "Off" prior to placing the vehicle in reverse, the backup camera rearview image will not appear on the display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: A rearview camera that does not display an image can reduce the driver's rear view, increasing the risk of a crash or injury.
Remedy: Dealers will update the ICS software, free of charge. Owner notification letters were mailed July 27, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C14.
Mar 24, 2023
Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles equipped with a 2.3L RWD, 3.3L GAS, 3.3L FHEV, or 3.0L ST powertrain. The previous powertrain control module (PCM) update completed under recall 22V-255 did not include the automatic electronic parking brake feature when the vehicle is shifted to park, as intended. In addition, the rear axle horizontal mounting bolt may fracture and cause the driveshaft to disconnect.
Consequence & remedy
Consequence: Without the electronic parking brake applied, the vehicle could rollaway if the driveshaft disconnects. A disconnected driveshaft can also result in a loss of drive power. Either of these scenarios can increase the risk of a crash.
Remedy: Dealers will update the PCM software, free of charge. Owner notification letters were mailed on May 31, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S16.
Additional source detail variants (2)
Parking Brake:electrical
Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles equipped with a 2.3L RWD, 3.3L GAS, 3.3L FHEV, or 3.0L ST powertrain. The previous powertrain control module (PCM) update completed under recall 22V-255 did not include the automatic electronic parking brake feature when the vehicle is shifted to park, as intended. In addition, the rear axle horizontal mounting bolt may fracture and cause the driveshaft to disconnect.
Consequence: Without the electronic parking brake applied, the vehicle could rollaway if the driveshaft disconnects. A disconnected driveshaft can also result in a loss of drive power. Either of these scenarios can increase the risk of a crash.
Remedy: Dealers will update the PCM software, free of charge. Owner notification letters were mailed on May 31, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S16.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles equipped with a 2.3L RWD, 3.3L GAS, 3.3L FHEV, or 3.0L ST powertrain. The previous powertrain control module (PCM) update completed under recall 22V-255 did not include the automatic electronic parking brake feature when the vehicle is shifted to park, as intended. In addition, the rear axle horizontal mounting bolt may fracture and cause the driveshaft to disconnect.
Consequence: Without the electronic parking brake applied, the vehicle could rollaway if the driveshaft disconnects. A disconnected driveshaft can also result in a loss of drive power. Either of these scenarios can increase the risk of a crash.
Remedy: Dealers will update the PCM software, free of charge. Owner notification letters were mailed on May 31, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S16.
Feb 10, 2023
Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles equipped with a 2.3L engine and 10R60 automatic transmission. An unintentional powertrain control module (PCM) reset may occur while the vehicle is in motion and result in park system damage.
Consequence & remedy
Consequence: A park system that is damaged may not shift into "PARK," resulting in a vehicle rollaway and increasing the risk of injury or crash.
Remedy: Dealers will inspect the park system for damage and repair as necessary, free of charge. Owner notification letters were mailed March 28, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S05.
Jan 23, 2023
Ford Motor Company (Ford) is recalling certain 2020-2023 Explorer, Lincoln Aviator, and 2020-2022 Lincoln Corsair vehicles equipped with a 360-degree camera. The video output may fail, preventing the rearview camera image from displaying.
Consequence & remedy
Consequence: Loss of the rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will update the image processing module (IPMB) software, free of charge. Interim owner notification letters informing owners of the safety risk were mailed April 25, 2023. Owner notification letters were mailed February 13, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S02. This recall expands and replaces NHTSA recall number 21V-735. Vehicles previously repaired under 21V-735 will need to have the new remedy performed.
Sep 22, 2021
Ford Motor Company (Ford) is recalling certain 2020-2021 Explorer, Lincoln Corsair, and Lincoln Aviator vehicles equipped with 360-degree cameras. The video output may fail, preventing the rearview camera image from displaying.
Consequence & remedy
Consequence: A rearview camera that does not display an image reduces the driver's rear view, increasing the risk of a crash.
Remedy: Dealers will update the Image Processing Module (IPMB) software, free of charge. Owner notification letters were mailed November 16, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S44.
Additional source detail variants (2)
Back Over Prevention:software
Ford Motor Company (Ford) is recalling certain 2020-2021 Explorer, Lincoln Corsair, and Lincoln Aviator vehicles equipped with 360-degree cameras. The video output may fail, preventing the rearview camera image from displaying.
Consequence: A rearview camera that does not display an image reduces the driver's rear view, increasing the risk of a crash.
Remedy: Dealers will update the Image Processing Module (IPMB) software, free of charge. Owner notification letters were mailed November 16, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S44.
Back Over Prevention: Sensing System: Camera
Ford Motor Company (Ford) is recalling certain 2020-2021 Explorer, Lincoln Corsair, and Lincoln Aviator vehicles equipped with 360-degree cameras. The video output may fail, preventing the rearview camera image from displaying.
Consequence: A rearview camera that does not display an image reduces the driver's rear view, increasing the risk of a crash.
Remedy: Dealers will update the Image Processing Module (IPMB) software, free of charge. Owner notification letters were mailed November 16, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S44.
Mar 10, 2021
Ford Motor Company (Ford) is recalling certain 2020 Lincoln Aviator and Ford Explorer vehicles. The rear lower control arm (RLCA) bolts that attach the rear lower control arms to the wheel knuckles may not have been heat-treated, which could cause them to break.
Consequence & remedy
Consequence: Broken RLCA bolts can cause a loss of steering control, and increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace both RLCA bolts, free of charge. The recall began on April 2, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S11.
Dec 17, 2020
Ford Motor Company (Ford) is recalling certain 2020-2021 Explorer and Lincoln Aviator vehicles. The right hand motor mount fasteners may have been incorrectly tightened, and may loosen over time.
Consequence & remedy
Consequence: With a loose motor mount, motor vibration may cause the axle to disconnect from the engine and could result in loss of power, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will remove and replace the right hand motor mount fasteners, free of charge. The recall began February 3, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S72.
Nov 24, 2020
Ford Motor Company (Ford) is recalling certain 2020 Explorer vehicles equipped with 2.3L engines and 19 gallon fuel tanks. The fuel tank inlet check valve may not be fully welded to the fuel tank shell.
Consequence & remedy
Consequence: An incomplete weld securing the inlet check valve to the fuel tank shell could result in a substantial fuel leak during a crash, increasing the risk of fire.
Remedy: Ford will notify owners, and dealers will replace the fuel tank shell, free of charge. The recall began December 8, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S68.
Nov 10, 2020
Ford Motor Company (Ford) is recalling certain 2020 Explorer and Lincoln Aviator vehicles equipped with a 2.0L or 3.3L engine and a 10 Speed Automatic Transmission with the All Wheel Drive package. The drive shaft may fracture along the weld seam.
Consequence & remedy
Consequence: Defective drive shafts may fail and cause a loss of connection between the transfer case and rear axle, possibly resulting in a vehicle rollaway when in Park or a loss of drive. Either condition can increase the risk of a crash. The drive shafts can also deform and separate from the driveline and potentially contact the fuel tank, increasing the risk of fuel leaks and/or fire.
Remedy: Ford will notify owners, and dealers will inspect the drive shaft label inspected and replace it as necessary, free of charge. The recall began December 11, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S65.
Sep 23, 2020
Ford Motor Company (Ford) is recalling certain 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence & remedy
Consequence: Reduced rearward visibility can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the rearview camera, free of charge. The recall began November 17, 2020. Remedy became available on February 1, 2021. Owner notification letters were mailed on February 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C19.
Sep 10, 2020
Ford Motor Company (Ford) is recalling certain 2020 Explorer vehicles. The affected vehicles are equipped with second row center seat belt buckles that may not be properly secured to the seat.
Consequence & remedy
Consequence: Vehicles with seat belt buckles that are not properly secured may fail to restrain an occupant during a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and dealers will replace the second row center seat assembly, free of charge. The recall began November 6, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S50.
Aug 21, 2020
Ford Motor Company (Ford) is recalling certain 2020 Explorer and 2020 Lincoln Aviator vehicles. The side air bag and/or seat back module attachments may not have been properly tightened in the front seat backs.
Consequence & remedy
Consequence: If the side air bag or seat back fasteners were not properly tightened, the side air bag deployment could be affected, increasing the risk of injury during a crash.
Remedy: Ford will notify owners, and dealers will remove front seat back panels from one or both front seats (VIN-specific) and verify that the fasteners have been properly tightened, free of charge. The recall began September 10, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S48.
Additional source detail variants (3)
Air Bags:critical Fasteners
Ford Motor Company (Ford) is recalling certain 2020 Explorer and 2020 Lincoln Aviator vehicles. The side air bag and/or seat back module attachments may not have been properly tightened in the front seat backs.
Consequence: If the side air bag or seat back fasteners were not properly tightened, the side air bag deployment could be affected, increasing the risk of injury during a crash.
Remedy: Ford will notify owners, and dealers will remove front seat back panels from one or both front seats (VIN-specific) and verify that the fasteners have been properly tightened, free of charge. The recall began September 10, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S48.
Seats
Ford Motor Company (Ford) is recalling certain 2020 Explorer and 2020 Lincoln Aviator vehicles. The side air bag and/or seat back module attachments may not have been properly tightened in the front seat backs.
Consequence: If the side air bag or seat back fasteners were not properly tightened, the side air bag deployment could be affected, increasing the risk of injury during a crash.
Remedy: Ford will notify owners, and dealers will remove front seat back panels from one or both front seats (VIN-specific) and verify that the fasteners have been properly tightened, free of charge. The recall began September 10, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S48.
Air Bags:side/window
Ford Motor Company (Ford) is recalling certain 2020 Explorer and 2020 Lincoln Aviator vehicles. The side air bag and/or seat back module attachments may not have been properly tightened in the front seat backs.
Consequence: If the side air bag or seat back fasteners were not properly tightened, the side air bag deployment could be affected, increasing the risk of injury during a crash.
Remedy: Ford will notify owners, and dealers will remove front seat back panels from one or both front seats (VIN-specific) and verify that the fasteners have been properly tightened, free of charge. The recall began September 10, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S48.
Dec 4, 2019
Ford Motor Company (Ford) is recalling certain 2020 Explorer and Lincoln Aviator vehicles. Over time, the protective sleeve on the vapor fuel line may chafe through the plastic liquid fuel line and cause a fuel leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Ford will notify owners, and dealers will install a longer protective sleeve on the liquid fuel line, as necessary, free of charge. Ford issued owners and interim notification on January 29, 2020. Recall began March 23, 2020. A second notice will be sent once parts are available, expected to be late in the first quarter of 2020. A renotification letter was sent on July 10, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S49.
Sep 30, 2019
Ford Motor Company (Ford) is recalling certain 2020 Ford Explorer vehicles equipped with 2.3L or 3.3L engines. The wiring harness may not have been properly secured and may contact the air conditioner compressor (A/C) pulley, potentially damaging the harness or the A/C belt.
Consequence & remedy
Consequence: The A/C pulley may rub through the wiring harness insulation and contact the unfused battery positive wire, resulting in a short circuit, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will install a tie strap to the wiring harness at the hand shock tower clip, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S32.
Aug 28, 2019
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence & remedy
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Additional source detail variants (2)
Seats:mid/rear Assembly
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Seats:front Assembly:recliner
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Aug 5, 2019
Ford Motor Company (Ford) is recalling certain 2020 Explorer and Lincoln Aviator vehicles. The Manual Park Release (MPR) cover may not be installed. In addition, the vehicles may be in Factory Mode, which disables warning alerts and does not display the transmission gear selected. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 114, "Theft Prevention" and 102, "Trans Shift Lever Seq/Starter Interlock/Trans Braking Effect."
Consequence & remedy
Consequence: Without the cover, the MPR lever may be unintentionally moved, allowing the vehicle to roll away. Being in Factory Mode, the vehicle will not display warnings and/or gear selection on the instrument cluster. Both conditions increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect and, if necessary, install a MPR cover. Dealers will verify the instrument cluster is not in Factory Mode and clear any fault codes, free of charge. The recall began August 23, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C06.
Additional source detail variants (3)
Parking Brake
Ford Motor Company (Ford) is recalling certain 2020 Explorer and Lincoln Aviator vehicles. The Manual Park Release (MPR) cover may not be installed. In addition, the vehicles may be in Factory Mode, which disables warning alerts and does not display the transmission gear selected. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 114, "Theft Prevention" and 102, "Trans Shift Lever Seq/Starter Interlock/Trans Braking Effect."
Consequence: Without the cover, the MPR lever may be unintentionally moved, allowing the vehicle to roll away. Being in Factory Mode, the vehicle will not display warnings and/or gear selection on the instrument cluster. Both conditions increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect and, if necessary, install a MPR cover. Dealers will verify the instrument cluster is not in Factory Mode and clear any fault codes, free of charge. The recall began August 23, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C06.
Electrical System: Instrument Cluster/panel
Ford Motor Company (Ford) is recalling certain 2020 Explorer and Lincoln Aviator vehicles. The Manual Park Release (MPR) cover may not be installed. In addition, the vehicles may be in Factory Mode, which disables warning alerts and does not display the transmission gear selected. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 114, "Theft Prevention" and 102, "Trans Shift Lever Seq/Starter Interlock/Trans Braking Effect."
Consequence: Without the cover, the MPR lever may be unintentionally moved, allowing the vehicle to roll away. Being in Factory Mode, the vehicle will not display warnings and/or gear selection on the instrument cluster. Both conditions increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect and, if necessary, install a MPR cover. Dealers will verify the instrument cluster is not in Factory Mode and clear any fault codes, free of charge. The recall began August 23, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C06.
Power Train:automatic Transmission:gear Position Indication (prndl)
Ford Motor Company (Ford) is recalling certain 2020 Explorer and Lincoln Aviator vehicles. The Manual Park Release (MPR) cover may not be installed. In addition, the vehicles may be in Factory Mode, which disables warning alerts and does not display the transmission gear selected. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 114, "Theft Prevention" and 102, "Trans Shift Lever Seq/Starter Interlock/Trans Braking Effect."
Consequence: Without the cover, the MPR lever may be unintentionally moved, allowing the vehicle to roll away. Being in Factory Mode, the vehicle will not display warnings and/or gear selection on the instrument cluster. Both conditions increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect and, if necessary, install a MPR cover. Dealers will verify the instrument cluster is not in Factory Mode and clear any fault codes, free of charge. The recall began August 23, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C06.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3DP25001 · Underbody Shields Detachment
Opened Sep 5, 2025 · Closed Apr 9, 2026
Status: closed (inferred from source dates) · Structure:frame And Members:underbody Shields
The Office of Defects Investigation (ODI) received a petition on August 22, 2025, requesting a defect investigation into an alleged defect of the “underbody shields” on model year (MY) 2020 Ford Explorer vehicles. The petition alleges premature degradation and detachment of the plastic underbody shields, potentially leading to road debris. The petition itself can be reviewed at NHTSA.gov under ODI number 11682326. A search of the subject vehicle population was undertaken using complaints submitted to ODI. No related complaints were found in NHTSA’s database for the subject vehicle population. Subsequently, ODI conducted a broader search for related complaints and field reports involving MY 2020-2025 Ford Explorer and Lincoln Aviator models, as these vehicles utilize substantially similar underbody shields. No complaints or reports were found citing any allegations pertaining to any of the underbody shields. ODI also reviewed manufacturer information and data and did not identify a trend related to the Petitioner’s allegations. Based on the absence of consumer complaints and reports, ODI has not identified a material risk of a complete detachment or a projectile hazard related to this condition. The petitioner's description of detectable symptoms - including noise and vibration that progressively worsen and visible sagging of the shields underneath the vehicle - indicates a failure mode that provides drivers with ample notice to seek service before a potential detachment. In view of the insufficient evidence of a vehicle-based defect pertaining to the underbody shields of the subject vehicle, ODI is denying this Defect Petition. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The Agency reserves the right to take additional action if warranted by future circumstances. To review the report cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ23002 · Rear Axle Bolt Failure
Opened Jun 20, 2023 · Closed Feb 15, 2024
Status: closed (inferred from source dates) · Power Train:axle Assembly; Power Train:driveline:differential Unit
On July 17, 2023, the Office of Defect Investigation (ODI) opened this Recall Query (RQ) after receiving 2 consumer complaints alleging loss of vehicle forward power and/or loss of transmission torque of the rear wheels in model year (MY) 2020-2022 Ford Explorer vehicles (subject vehicles). The RQ was opened to focus on the effectiveness of the remedies of Recalls 22V-255 and 23V-199 related to the alleged problem. Recall 22V-255 involved replacing the bushing and axle cover in the following subject vehicles: 3.3L FHEV Police built before October 14, 2020, and 3.3L Gas Police vehicle built before January 31, 2021. For 2.3L RWD, 3.0L PHEV, 3.3LFHEV, and 3.0LST retail (non-police) vehicles, the recall provided an PCM software update to engage the Electronic Park Brake (EPB) when Park is commanded. The recall addressed a breakage of the rear axle bolt that can cause the driveshaft/half shafts to disconnect, resulting in a loss of transmission torque to the rear wheels necessary to hold park. If the parking brake is not applied, the loss of the primary park torque will allow the vehicle to roll in park increasing the risk of crash and injury. Recall 23V-199 addressed 674 of the subject vehicles produced from February 2, 2019 to April 4, 2022, which received an incorrect remedy under Recall 22V-255. The affected vehicles had received a previous Powertrain Control Module (PCM) update which did not include an automatic EPB engagement when vehicle is shifted to park. On October 17, 2023, Ford filed a new safety recall (Recall 23V-675) covering 238,364 MY 2020-2022 Explorer vehicles with the following powertrains: 3.3L FHEV Police, 3.3L Gas Police, 3.0L Gas Police, 2.3L RWD, 3.0L PHEV, 3.3L FHEV, 3.0L RWD and 3.0L AWD, produced from October 22, 2018 to July 6, 2022, equipped with a 3-point mounted axle design. Ford stated that the cause of the bolt fracture is due to joint design not robust to peak axle input torques and manufacturing variability. The primary contributor is insufficient bearings for maximum joint loads. This can result in bearing deformation, increasing bending stress on the bolt, which may lead to fatigue failure. On January 19, 2023, Ford amended Recall 23V-675 to add 1,942 MY 2020-2022 Explorer vehicles with the following powertrain: 3.0L RWD Platinum and King Ranch variant, produced from October 22, 2018 to July 6, 2022, equipped with a 3-point mounted axle design. In addition to the safety recall, Ford will conduct a customer satisfaction program for the following MY 2020-2022 Explorer vehicles with the following powertrains: 2.3L AWD, 3.3L Gas Retail, 3.0L Gas AWD Platinum and King Ranch, produced from October 22, 2018 to July 6, 2022. Ford stated that the Explorer powerpack variants not covered under Recalled 23V-675 do not present an unreasonable risk to motor vehicle safety due to the combination of lower peak torque levels and torque management strategies to share inputs between front and rear axles, reducing occurrence of higher torque. According to Ford, this is also evidenced by the lower current and projected failure rates. In view of the recall action being taken by Ford, ODI is closing this RQ. NHTSA will continue to monitor complaints from the customer satisfaction program vehicles and reopen this issue, if necessary. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Power Train:axle Assembly
On July 17, 2023, the Office of Defect Investigation (ODI) opened this Recall Query (RQ) after receiving 2 consumer complaints alleging loss of vehicle forward power and/or loss of transmission torque of the rear wheels in model year (MY) 2020-2022 Ford Explorer vehicles (subject vehicles). The RQ was opened to focus on the effectiveness of the remedies of Recalls 22V-255 and 23V-199 related to the alleged problem. Recall 22V-255 involved replacing the bushing and axle cover in the following subject vehicles: 3.3L FHEV Police built before October 14, 2020, and 3.3L Gas Police vehicle built before January 31, 2021. For 2.3L RWD, 3.0L PHEV, 3.3LFHEV, and 3.0LST retail (non-police) vehicles, the recall provided an PCM software update to engage the Electronic Park Brake (EPB) when Park is commanded. The recall addressed a breakage of the rear axle bolt that can cause the driveshaft/half shafts to disconnect, resulting in a loss of transmission torque to the rear wheels necessary to hold park. If the parking brake is not applied, the loss of the primary park torque will allow the vehicle to roll in park increasing the risk of crash and injury. Recall 23V-199 addressed 674 of the subject vehicles produced from February 2, 2019 to April 4, 2022, which received an incorrect remedy under Recall 22V-255. The affected vehicles had received a previous Powertrain Control Module (PCM) update which did not include an automatic EPB engagement when vehicle is shifted to park. On October 17, 2023, Ford filed a new safety recall (Recall 23V-675) covering 238,364 MY 2020-2022 Explorer vehicles with the following powertrains: 3.3L FHEV Police, 3.3L Gas Police, 3.0L Gas Police, 2.3L RWD, 3.0L PHEV, 3.3L FHEV, 3.0L RWD and 3.0L AWD, produced from October 22, 2018 to July 6, 2022, equipped with a 3-point mounted axle design. Ford stated that the cause of the bolt fracture is due to joint design not robust to peak axle input torques and manufacturing variability. The primary contributor is insufficient bearings for maximum joint loads. This can result in bearing deformation, increasing bending stress on the bolt, which may lead to fatigue failure. On January 19, 2023, Ford amended Recall 23V-675 to add 1,942 MY 2020-2022 Explorer vehicles with the following powertrain: 3.0L RWD Platinum and King Ranch variant, produced from October 22, 2018 to July 6, 2022, equipped with a 3-point mounted axle design. In addition to the safety recall, Ford will conduct a customer satisfaction program for the following MY 2020-2022 Explorer vehicles with the following powertrains: 2.3L AWD, 3.3L Gas Retail, 3.0L Gas AWD Platinum and King Ranch, produced from October 22, 2018 to July 6, 2022. Ford stated that the Explorer powerpack variants not covered under Recalled 23V-675 do not present an unreasonable risk to motor vehicle safety due to the combination of lower peak torque levels and torque management strategies to share inputs between front and rear axles, reducing occurrence of higher torque. According to Ford, this is also evidenced by the lower current and projected failure rates. In view of the recall action being taken by Ford, ODI is closing this RQ. NHTSA will continue to monitor complaints from the customer satisfaction program vehicles and reopen this issue, if necessary. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Power Train:driveline:differential Unit
On July 17, 2023, the Office of Defect Investigation (ODI) opened this Recall Query (RQ) after receiving 2 consumer complaints alleging loss of vehicle forward power and/or loss of transmission torque of the rear wheels in model year (MY) 2020-2022 Ford Explorer vehicles (subject vehicles). The RQ was opened to focus on the effectiveness of the remedies of Recalls 22V-255 and 23V-199 related to the alleged problem. Recall 22V-255 involved replacing the bushing and axle cover in the following subject vehicles: 3.3L FHEV Police built before October 14, 2020, and 3.3L Gas Police vehicle built before January 31, 2021. For 2.3L RWD, 3.0L PHEV, 3.3LFHEV, and 3.0LST retail (non-police) vehicles, the recall provided an PCM software update to engage the Electronic Park Brake (EPB) when Park is commanded. The recall addressed a breakage of the rear axle bolt that can cause the driveshaft/half shafts to disconnect, resulting in a loss of transmission torque to the rear wheels necessary to hold park. If the parking brake is not applied, the loss of the primary park torque will allow the vehicle to roll in park increasing the risk of crash and injury. Recall 23V-199 addressed 674 of the subject vehicles produced from February 2, 2019 to April 4, 2022, which received an incorrect remedy under Recall 22V-255. The affected vehicles had received a previous Powertrain Control Module (PCM) update which did not include an automatic EPB engagement when vehicle is shifted to park. On October 17, 2023, Ford filed a new safety recall (Recall 23V-675) covering 238,364 MY 2020-2022 Explorer vehicles with the following powertrains: 3.3L FHEV Police, 3.3L Gas Police, 3.0L Gas Police, 2.3L RWD, 3.0L PHEV, 3.3L FHEV, 3.0L RWD and 3.0L AWD, produced from October 22, 2018 to July 6, 2022, equipped with a 3-point mounted axle design. Ford stated that the cause of the bolt fracture is due to joint design not robust to peak axle input torques and manufacturing variability. The primary contributor is insufficient bearings for maximum joint loads. This can result in bearing deformation, increasing bending stress on the bolt, which may lead to fatigue failure. On January 19, 2023, Ford amended Recall 23V-675 to add 1,942 MY 2020-2022 Explorer vehicles with the following powertrain: 3.0L RWD Platinum and King Ranch variant, produced from October 22, 2018 to July 6, 2022, equipped with a 3-point mounted axle design. In addition to the safety recall, Ford will conduct a customer satisfaction program for the following MY 2020-2022 Explorer vehicles with the following powertrains: 2.3L AWD, 3.3L Gas Retail, 3.0L Gas AWD Platinum and King Ranch, produced from October 22, 2018 to July 6, 2022. Ford stated that the Explorer powerpack variants not covered under Recalled 23V-675 do not present an unreasonable risk to motor vehicle safety due to the combination of lower peak torque levels and torque management strategies to share inputs between front and rear axles, reducing occurrence of higher torque. According to Ford, this is also evidenced by the lower current and projected failure rates. In view of the recall action being taken by Ford, ODI is closing this RQ. NHTSA will continue to monitor complaints from the customer satisfaction program vehicles and reopen this issue, if necessary. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ21002 · Rearview Camera Fmvss 111 Noncompliance
Opened Aug 3, 2021 · No close date supplied
Status: open (inferred from source dates) · Back Over Prevention: Sensing System: Camera
On September 23, 2020, Ford Motor Company (Ford) filed a noncompliance recall report under 49 CFR Part 573 (NHTSA Recall No. 20V-575), recalling 620,246 Model Year (MY) 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles for a noncompliance with Federal Motor Vehicle Safety Standard (FMVSS) 111, Rear Visibility. Ford's recall described the noncompliance as insufficient electrical conductivity within the printed circuit board (PCB) internal to the camera leading to intermittent rearview camera operation. The supplier of the cameras was Magna Electronics.According to Ford's chronology in the Part 573, during the period February-April 2020, Ford identified and monitored warranty claims pertaining to intermittent or inoperative rearview cameras. Ford reviewed supplier product changes, focusing on changes introduced by the supplier in the October-November 2019 time frame. The Part 573 stated that the issue was brought to Ford's Critical Concerns Review Group (CCRG) for review on May 12, 2020.On July 7, 2020, NHTSA's Vehicle Research and Testing Center (VRTC) informed the Office of Defects Investigation (ODI) of a trend of MY 2020 Escape vehicles with rearview camera malfunctions. ODI contacted Ford the next day, providing five Vehicle Owner Questionnaires (VOQs) alleging inoperative rearview cameras. On July 15, 2020, Ford met with NHTSA to discuss the rearview camera issue. In a subsequent August 24, 2020 meeting, ODI and NHTSA's Office of Vehicle Safety Compliance (OVSC) met with Ford to discuss the recall status and additional VOQs. Ford presented rate and scope data for many of its MY 2020 products during the August 2020 meeting indicating high failure rates for certain models.This RQ is being opened to investigate both the timeliness and scope of Ford's rearview camera recall (20V-575), and Ford's compliance with reporting requirements.The subject reports referenced in the opening resume are identified by the following ODI reference numbers which can be reviewed at NHTSA.gov: 11349813, 11344126, 11342696, 11341486, 11340254, 11337274, 11331444, 11330875, 11329235, 11316960, 11343521, 11341884, 11337226, 11344018, and 11339573.
Illustration