Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
920–25K
5125–50K
5550–75K
4475–100K
40100–150K
6150K+
288 reports with mileage · 440 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Structure. Review the 287 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 95 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 58 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
16 crash reports7 fire reports13 injury reports
What owners actually said
728 reports
55,000 miles · Mar 16, 2023
Structure
The contact owns a 2018 Ford Explorer. The contact stated that while his wife was driving approximately 70 MPH, the exterior rubber molding from the front passenger’s side windshield trim detached from the vehicle and struck a second vehicle. The contact stated that 3 of the 4 windshield trim panels had become loosened and were …
Read full complaint
The contact owns a 2018 Ford Explorer. The contact stated that while his wife was driving approximately 70 MPH, the exterior rubber molding from the front passenger’s side windshield trim detached from the vehicle and struck a second vehicle. The contact stated that 3 of the 4 windshield trim panels had become loosened and were not properly secured to the vehicle. The cause of the failure was not yet determined. The manufacturer and local dealer were notified of the failure. The contact referenced the NHTSA Investigation: PE23001 and stated that the vehicle had experience the failure. The failure mileage was 55,000.
Around 4:45 , was unable to access cruise control the message rapidly flashed., loss of headlights and all lighting for a few seconds. Was going 70 mph. I exited the interstate to turn around and go to my work on southbound the wrench light came on and I lost power steering, power, acceleration in my turn on the on ramp and proc…
Read full complaint
Around 4:45 , was unable to access cruise control the message rapidly flashed., loss of headlights and all lighting for a few seconds. Was going 70 mph. I exited the interstate to turn around and go to my work on southbound the wrench light came on and I lost power steering, power, acceleration in my turn on the on ramp and proceeded off the road onto the incline somehow avoiding a rollover and teetering sideways. Meanwhile no power to open my window etc. at an angle where I couldn’t open the door, took a minute to get out of the seatbelt. Suddenly got my window able to open and crawled out. The cops, and tow truck couldn’t believe I didn’t roll. The car was at a dealership the previous week for loss of power and terai. System problems/ no power steering and they replaced the throttle body 3 days before this happened. I’ve had multiple electrical/exhaust/power failures. I am terrified to drive this vehicle. It’s been to different dealerships and the ford ones and ford don’t care (only the dealership I purchased it at tries) it is at a fifth one now. We have forscan reports of the failures also. Multiple images at scene also. Car wouldn’t drive correctly and terrain management fault, unloaded itself from trailer too.
NHTSA ODI #11511692
Mileage unknown · Mar 13, 2023
Structure
On a trip from South Carolina to New York, both A-pillar trims blew off on the highway. I am attributing this to both the fluctuations in temperature in the prior 12 hours (over 30 degrees) and a known issue with this vehicle. It was also very windy out.
NHTSA ODI #11511496
Mileage unknown · Mar 10, 2023
EngineUnknown Or Other
Water pump leaking
NHTSA ODI #11511158
Mileage unknown · Mar 7, 2023
Forward Collision AvoidanceService BrakesCrash
I have had three incidents of total brake failure on this vehicle. First, about 3 months ago I could not stop while parking in my garage and hit a work bench. I chalked it up to just a weird low speed incident as the brakes worked fine the next time I drove it. Second, I was traveling on wet roads and 27 degree weather and co…
Read full complaint
I have had three incidents of total brake failure on this vehicle. First, about 3 months ago I could not stop while parking in my garage and hit a work bench. I chalked it up to just a weird low speed incident as the brakes worked fine the next time I drove it. Second, I was traveling on wet roads and 27 degree weather and could not stop for a yellow light. At the time I attributed it to an icey skid because, again, the brakes worked fine the next time I needed them. But in retrospect, I do not recall any feeling that the brakes were working. Lastly, today I rear ended a car in front of me when the brakes and the supposed forward collision system both failed dramatically. I was probably going 25 MPH coming to a red light and started to apply my brakes several hundred feet before the intersection. Nothing happened and I, panicked, began pumping the pedal relentlessly. Finally the dashboard crash warning light started flashing and still no drop in speed. I tried to get into low gear, but by that time it was too late and I crashed into a van in front of me. It totaled my car and pretty well wiped out the rear doors and windows of the van. Fortunately, no one was injured. I was not cited because an EMT nurse was in the lane beside me and witnessed my brake pumping, steering wheel grabbing actions and could tell what was going on. The police are going to investigate the brake problem as well as my insurance company, USAA. There have been no brake recalls issued for my vehicle and any other recalls are up to date. There are approximately 50000 miles on it and it has had meticulous care and regular maintenance and brake shoes are still listed as good condition on my last visit for an oil change.
NHTSA ODI #11510604
89,000 miles · Mar 2, 2023
Back Over PreventionElectrical System
The contact owns a 2018 Ford Explorer. The contact stated that while driving at an undisclosed speed, the infotainment screen was inoperable. No warning lights were illuminated. The vehicle was taken to a local dealer, where it was diagnosed that the application programming interface module (APIM) needed to be replaced; however,…
Read full complaint
The contact owns a 2018 Ford Explorer. The contact stated that while driving at an undisclosed speed, the infotainment screen was inoperable. No warning lights were illuminated. The vehicle was taken to a local dealer, where it was diagnosed that the application programming interface module (APIM) needed to be replaced; however, the part for the repair was on backorder. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 89,000.
NHTSA ODI #11509819
Mileage unknown · Feb 26, 2023
Structure
roof rail cover flew off on interstate
NHTSA ODI #11509201
Mileage unknown · Feb 25, 2023
Structure
The passenger side front windshield A pillar outer trim flew off the car when we were driving on CA freeway 15 on Saturday, February 25, 2023. The entire molding flew off and we don’t know if it hit any cars behind us since we were going at least 70 mph.
NHTSA ODI #11509124
Mileage unknown · Feb 15, 2023
Back Over Prevention
I have a 2018 Ford Explorer. My SYNC 3 is showing a black screen due to a failed APIM. I do not have my rear camera, GPS, or hands-free capability which impedes driving safely. Ford has recalled multiple other years of my vehicle for this same reason, but not the 2018. Ford has also extended it's warranty up to 7 years/100,000 …
Read full complaint
I have a 2018 Ford Explorer. My SYNC 3 is showing a black screen due to a failed APIM. I do not have my rear camera, GPS, or hands-free capability which impedes driving safely. Ford has recalled multiple other years of my vehicle for this same reason, but not the 2018. Ford has also extended it's warranty up to 7 years/100,000 miles on some years of my vehicle, for the same reason, but not the 2018. I am reading that there are numerous other owners who a have the same problem with only an expensive resolution. The Ford dealer confirmed the need to replace the APIM today at a cost of $1,417. This is unacceptable due to the safety factor and that they know this is a problem in their vehicles. I reported it to Ford and their response was my warranty is expired and there is no recall, so I have to pay.
NHTSA ODI #11507492
40,000 miles · Feb 15, 2023
Back Over Prevention
The contact owns a 2018 Ford Explorer. The contact stated the rearview camera screen was blue and inoperable. The contact stated the “Camera not Available” warning light was illuminated. The contact took the vehicle to the local dealer, where it was diagnosed with needing the rearview camera to be replaced. The vehicle was not r…
Read full complaint
The contact owns a 2018 Ford Explorer. The contact stated the rearview camera screen was blue and inoperable. The contact stated the “Camera not Available” warning light was illuminated. The contact took the vehicle to the local dealer, where it was diagnosed with needing the rearview camera to be replaced. The vehicle was not repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 40,000.
Ford Motor Company (Ford) is recalling certain 2016-2019 Explorer vehicles. The roof rail covers may come loose and detach from the vehicle.
Consequence & remedy
Consequence: A detached roof rail cover can create a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect the roof rail covers and as necessary, repair or replace the push-pins, rail clips, or roof rail covers, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 28, 2026. Additional letters will be sent once the remedy is available, anticipated in January 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S54. This recall expands previous NHTSA recall number 21V316. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 16, 2026.
Ford Motor Company (Ford) is recalling certain 2017-2019 Explorer vehicles. The rear suspension toe links may fracture.
Consequence & remedy
Consequence: A rear toe link fracture can result in a loss of steering control, increasing the risk of a crash.
Remedy: Dealers will replace the toe links, free of charge. Owner notification letters were mailed on March 16, 2026. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 26S08. This recall is an expansion of previous NHTSA recall number 21V537. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning February 25, 2026.
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
Consequence & remedy
Consequence: An electrical short circuit can increase the risk of a fire.
Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
Ford Motor Company (Ford) is recalling certain 2011-2019 Explorer vehicles. The A-pillar trim retention clips may not be properly engaged, allowing the trim to detach.
Consequence & remedy
Consequence: A detached trim piece can fall off the vehicle, becoming a road hazard and increasing the risk of a crash.
Remedy: Dealers will inspect and replace the A-pillar trim as necessary, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model years. Owner notification letters were mailed between July 18, 2024 and December 16, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S02.
Ford Motor Company (Ford) is recalling certain 2016-2019 Explorer vehicles. The retention pins could loosen and allow the roof rail covers to detach from the vehicle.
Consequence & remedy
Consequence: A detached roof rail cover can create a road hazard, increasing the risk of a crash.
Remedy: Dealers will install push-pins and replace any damaged rail clips and roof rail covers, as necessary, free of charge. The interim owner notification letter was mailed on June 22, 2021. Owner notification letters (remedy available) were mailed on October 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S22.
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence & remedy
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Additional source detail variants (2)
Seats:mid/rear Assembly
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Seats:front Assembly:recliner
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Ford Motor Company (Ford) is recalling certain 2018 Ford Explorer vehicles equipped with 2.3L or 3.5L GTDI engine. Due to an assembly error, the fuel pressure sensor may leak fuel.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Ford will notify owners, and dealers will replace the fuel line assembly, free of charge. The recall began December 7, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S35.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
PE23001 · Windshield Trim Molding Item Detachment
Opened Jan 27, 2023 · Closed Feb 8, 2024
Status: closed (inferred from source dates) · Structure:body:roof And Pillars
On January 27, 2023, the Office of Defects Investigation (ODI) opened PE23-001 to investigate allegations of A-pillar trim panel detachment on model year (MY) 2011-2019 Ford Explorer vehicles. At the time of opening, the office had received 164 Vehicle Owner Questionnaires (VOQs) reporting this failure. ODI has received 671 VOQs regarding this failure, including 1 alleged crash and 2 alleged injuries. Some consumers have reported that the failure occurred while they were driving at highway speeds, with the detached trim panel entering the path of travel of the vehicle behind them, requiring the driver of the following vehicle to take evasive action. It is noteworthy that motorists who experience this type of road hazard are less likely to accurately identify the subject vehicle the item detached from and report the event to the NHTSA. In its April 17, 2023 response to ODI’s information request, Ford provided 175 consumer complaints (including field reports) and 14,162 warranty claims related to A-pillar trim panel detachment. Ford relayed that the subject vehicles utilize a plastic A-pillar bracket, which is bolted to the vehicle structure during assembly. The A-pillar trim panel is attached to the bracket utilizing 7 plastic clips. Contributory factors which have been identified by Ford as leading to the subject defect include incomplete installation at the assembly plant, inadequate part stack up, damage to fasteners during installation, and failure to follow proper repair procedure during windshield replacements or other services. On January 19, 2024, Ford filed safety recall 24V-031 for MY 2011-2019 Ford Explorer vehicles to address the subject defect. In the Part 573 Safety Recall Report, Ford identified that a detached A-pillar trim panel can create a road hazard for other road users, increasing the risk of a crash. The recall remedy includes an inspection of the existing A-pillar trim panel and, if necessary, the replacement of the component. The remedy A-pillar trim panels will be installed with an additional adhesive for robustness and utilize an inspection procedure to ensure full engagement of all the retention clips during installation. In view of the recall action being taken by Ford, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
AQ22003 · Hertz/vehicles Rented With Open Recalls
Opened Dec 16, 2022 · No close date supplied
Status: open (inferred from source dates) · Latches/locks/linkages:hood:latch
NHTSA is opening this audit query to investigate whether The Hertz Corporation (Hertz) has complied with the requirements of the National Traffic and Motor Vehicle Safety Act (Safety Act). The Safety Act requires, among other things, that a rental company shall not rent a vehicle subject to a safety recall unless the recall remedy has been performed. 49 U.S.C. § 30120(i).NHTSA is in receipt of information that indicates Hertz rented vehicles to customers without having performed required recall repairs. Accordingly, we are opening this audit query to seek additional information concerning this issue.
Illustration