2018 Ford Explorer

My 2018 Ford Explorer XLT 3.5L that we bought brand new from Bob Bell Ford/Glen Burnie Maryland had a water pump failure at only 72,344 miles, this was a safety concern when driving down the road that put us & others at risk. The only indication was dashboard warning that said (Engine coolant over temperature)This failure happened while taking daughter to college on 8/21/26 We had to get towed to independent service center 175 miles away & repaired at the cost of $2900.00.

This vehicle was inspected by a certified Ford dealership (Premier Ford, Service Advisor: Harry). Ford Motor Company’s Consumer Affairs Department subsequently reviewed the case under Complaint ID: XXX. In their official written response, Ford explicitly admitted the root cause, stating: "the vehicle experienced a failure to the harness for the alternator which melted due to heat from the exhaust." INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While driving at highway speed on a 2-lane highway with three children under the age of [XXX] in the vehicle, my 2018 Ford Explorer experienced sudden complete engine failure with no prior warning. No warning lights, no temperature gauge change, no unusual sounds. The vehicle went from operating normally to catastrophic failure instantaneously, forcing me to sharply cross active traffic to exit the roadway. The vehicle came to rest near a train track. The root cause was internal water pump failure. Ford's design places the water pump inside the engine, causing coolant to leak internally with no external indicators and no dashboard warning until catastrophic damage has already occurred. Ford did not install a coolant level sensor in the reservoir, and the only coolant warning available is an overheating alert, which never triggered. I had taken every reasonable precaution. Two thousand miles prior, an oil change showed no coolant contamination. One week prior, I physically checked the coolant level and it was within safe range. Ford's design gave me zero opportunity to detect or prevent this failure. This is a known recurring issue. Over 86 engine complaints have been filed with NHTSA for this model year alone and Ford has been aware of this defect since at least 2007. Despite class action litigation in both Canada and the United States, Ford has not issued a U.S. recall. Repair costs exceed $9,000. I am requesting NHTSA open a formal investigation and compel Ford to issue a U.S. recall. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My vehicles transmission has been replaced 2 times already (3 years apart)- now it is overheating. Absolutely no warning lights have came on at any time in regards to any of my situations - My vehicle is available for inspection at any time. When the transmission went in my vehicle, I was traveling on an interstate with my child. The dealer has confirmed replaced the transmission as it was still under the 5 year warranty - my vehicle is set to go back into the shop today to be inspected as to why it is overheating.

At 89k miles, my engine has failed, due to coolant intrusion, according to Ken Garff Ford Dealership in St. George, UT. I started having issues with rough start and timing miss and engine light came on. I immediately took it to Dealership and they did two repairs (tune-up) and subsequent gasket change because they said oil was getting into my spark plugs. It did not resolve the issue, took it straight back and now they're telling me I need a new engine. This comes 2 years after I had to pay $7k for a new transmission at only 60k miles. This is wrong and not OK that I am having to deal with this. I don't have $12k laying around for a new engine on a vehicle that shouldn't be having all these issues!

I PURCHASED A 2018 FORD EXPLORER WITH THE 2.3L 4 CYLINDER ENGINGE IN 2023. WITHIHN A YEAR OF MY ENGINE STARTED TO HAVE ISSUES HESITATING WHEN ACCELERATING. THEN IT OVERHEATED AND I REALIZED MY COOLANT WAS DISAPPEARING BUT WASNT POOLING ANYWHERE.. IT WAS EVAPORATING BECAUSE IT WAS LEAKING INTO MY SPARK PLUGS. WHEN I CHANGED PLUGS I NOTICED OIL OR COOLANT ON TWO OF THEM I CALLED FORD ABOUT IT BECAUSE MY ENGINE HAS A PENDING LAWSUIT FOR THIS PROBLEM IT KEPT GETTING WORSE . I DONT HAVE THE MONEY FOR THE REPAIRS AND I ASKED THEM IF THEY COULD DO A GOOD FAITH REPAIR AND I WAS DENIED. AS OF 4/16/2026 MY ENGINE FAILED AND MY COOLANT IS FILLED WITH OIL BECAUSE OF THE DEFECTIVE ENGINE THAT THEY KNEW ABOUT SINCE 2010

Upon startup rough idle and check engine light came on. Mechanic confirmed cylinder head thinning causing fluid leak into first cylinder. A mechanical note verifies but Ford won't issue a recall. Apparently Ford has know this for years with Ecoboost engines. I don't want to become a victim of vehicle dying in the middle of traffic. Have seen several complaints from Ford owners with no fixes by Ford.

The contact owns a 2018 Ford Explorer. The contact stated that after the vehicle was idling at a traffic stop, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The check engine warning light illuminated. The contact pulled over to the side of the road and turned off the vehicle. The vehicle was restarted; however, the vehicle stalled after driving several minutes. The vehicle was towed to an independent mechanic who diagnosed the vehicle with engine failure and determined that the engine needed to be replaced. The vehicle was not repaired due to the cost. The vehicle remained with the independent mechanic unrepaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 162,000.

- I have experienced a sudden loss of engine power and speed on 5 occasions. Very scary and dangerous to completely lose power on the highway with cars behind you. Had to pull off onto the shoulder(s) in dangerous conditions, with two young kids in the backseat. Hazards, turn off the car, restart the car, etc. - When the power loss happens, the vehicle's dashboard lights turn on, including the engine and wrench icons along with the words "See Manual." - Based on my research, I believe it may be due to a defective throttle body and/or software, related to the "terrain management system." - Problem was not reproduced or confirmed by a dealer or independent service center - No inspections by the manufacturer, police, insurance representatives or others - No warning message is provided prior to the failure, which is another issue