Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
920–25K
5125–50K
5550–75K
4475–100K
40100–150K
6150K+
288 reports with mileage · 440 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Structure. Review the 287 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 95 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 58 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
16 crash reports7 fire reports13 injury reports
What owners actually said
728 reports
Mileage unknown · Oct 27, 2025
Electrical System
Fault code B14E7:08-0A Right Front Enhanced Exterior Lighting System, passenger headlamp will not turn off until BCM disconnects after 20 minutes. Dealer diagnosis determined a possible headlamp control module FB5Z13C788D fault (replaced left module with right module and same headlamp stayed on so both headlamp control modules a…
Read full complaint
Fault code B14E7:08-0A Right Front Enhanced Exterior Lighting System, passenger headlamp will not turn off until BCM disconnects after 20 minutes. Dealer diagnosis determined a possible headlamp control module FB5Z13C788D fault (replaced left module with right module and same headlamp stayed on so both headlamp control modules are correctly functioning) this indicates a broken wire in right front enhanced exterior lighting system wiring harness. Problem remains unresolved.
NHTSA ODI #11695845
35,000 miles · Oct 27, 2025
Structure
The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving …
Read full complaint
The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the A-pillar trim detached, and the front windshield made an abnormal sound. The dealer was made aware of the failure but confirmed that parts were not yet available. The contact was informed that tape could be used as a temporary repair. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 35,000.
NHTSA ODI #11695814
99,700 miles · Oct 22, 2025
Structure
The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign number: 24V031000 (Structure). However, the part to do the recall repair was not yet available. The contact stated that while driving at 60 MPH, the driver's side A-pillar trim detached from the vehicle. The local dealer was contacted; how…
Read full complaint
The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign number: 24V031000 (Structure). However, the part to do the recall repair was not yet available. The contact stated that while driving at 60 MPH, the driver's side A-pillar trim detached from the vehicle. The local dealer was contacted; however, the vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 99,700.
NHTSA ODI #11695066
Mileage unknown · Oct 22, 2025
Unknown Or Other
Backup Camera does not work. This has been going on for two years. We have been to the dealer about this situation. There were intermittent messages saying that the camera didn't work, then it completely stopped. This started in 2023. We went to the dealer to find out about what it would cost to have it fixed and found out tha…
Read full complaint
Backup Camera does not work. This has been going on for two years. We have been to the dealer about this situation. There were intermittent messages saying that the camera didn't work, then it completely stopped. This started in 2023. We went to the dealer to find out about what it would cost to have it fixed and found out that all the years around the 2018 had been recalled for this problem. We wanted you to know that the 2018 has the same problem as these other vehicles with the backup camera.
NHTSA ODI #11695058
Mileage unknown · Oct 22, 2025
Engine
Another timing chain failure on highway with engine stopping on road. This should be a recall!!!!! Only 101,300 miles on engine. No warnings no check engine lights until after failure.
NHTSA ODI #11694943
Mileage unknown · Oct 21, 2025
SteeringSuspension
On Saturday 10/18/2025 the rear drivers side tow link of my 2018 Ford Explorer XLT snapped while driving 70 mph under normal driving conditions on a 4-lane section of i-75 in Detroit, MI. This caused a loss of steering, and my family and almost hit the median concrete wall when it sharply veered to the left completely unexpected…
Read full complaint
On Saturday 10/18/2025 the rear drivers side tow link of my 2018 Ford Explorer XLT snapped while driving 70 mph under normal driving conditions on a 4-lane section of i-75 in Detroit, MI. This caused a loss of steering, and my family and almost hit the median concrete wall when it sharply veered to the left completely unexpectedly. There were no warning sounds or symptoms and happened at random on a straight away. We then spun out doing multiple 360 spins on 2 wheels, almost flipping completely, and landing in the middle 2 lanes. We had a semi truck and another vehicle narrowly miss us. I was able to then move fast enough to the side of the road and avoid being hit by more oncoming traffic. We called 911 and AAA for towing to Suburban Ford of Troy who did an inspection and found the drivers side rear tow link has snapped due to a seized knuckle. There is a recall for the exact same known issue in the 2011-2017 Ford Explorers. My wife’s 2017 explorer has the same parts as my 2018 and has the recall for the tow links and ball joint due to this known issue, yet Ford is refusing to acknowledge the issue is still affecting later model years. My Explorer only had 74,000 miles on it and never any accidents or abnormal driving conditions/hard driving. My family and I are extremely lucky to be alive after such a catastrophic failure. This type of issue should never happen on any vehicle and is a totally unacceptable engineering failure. Ford needs to inspect this issue on the later models beyond 2017 as this will cost lives. This will kill people and we are actually in shock that we lived through this. Ford should take responsibility and pay for this repair, as well as the other side the same as they do the years the recalled.
NHTSA ODI #11694871
Mileage unknown · Oct 16, 2025
Unknown Or Other
Nothing has happened yet, but I want to make dure nothing does happen as a result of not taking care of this potential problem.
NHTSA ODI #11693744
Mileage unknown · Oct 14, 2025
Structure
The contact owns a 2018 Ford Explorer. The contact stated that while driving approximately 50 MPH, the front driver’s side A-pillar trim was suddenly ejected from the vehicle. The local dealer was notified of the failure. The vehicle was not repaired. The contact later received notification of NHTSA Campaign Number: 24V031000(ST…
Read full complaint
The contact owns a 2018 Ford Explorer. The contact stated that while driving approximately 50 MPH, the front driver’s side A-pillar trim was suddenly ejected from the vehicle. The local dealer was notified of the failure. The vehicle was not repaired. The contact later received notification of NHTSA Campaign Number: 24V031000(STRUCTURE), which was related to the failure, but parts needed to repair the vehicle were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that later the front passenger’s side A-pillar trim experienced the same failure. The manufacturer was not made aware of the failure. The failure mileage was unknown
NHTSA ODI #11693252
Mileage unknown · Oct 10, 2025
Unknown Or Other
The plastic covers on the roof rails are both loose and constantly pop out. I'm nervous that they are going to fly off when driving, causing an issue for other drivers.
NHTSA ODI #11692613
Mileage unknown · Oct 8, 2025
Electrical System
Traveling 50mph, noticed smoke rolling from under the dash. Got to the side of the road. The entire dash was engulfed in fire. I had to fight my way out of the car after the doors locked. After I got out of the vehicle I called 911. Fire department came. It has been ruled as electrical. I am not sure whom I need to reach out to…
Read full complaint
Traveling 50mph, noticed smoke rolling from under the dash. Got to the side of the road. The entire dash was engulfed in fire. I had to fight my way out of the car after the doors locked. After I got out of the vehicle I called 911. Fire department came. It has been ruled as electrical. I am not sure whom I need to reach out to yet in regards to this matter and a total loss.
Ford Motor Company (Ford) is recalling certain 2016-2019 Explorer vehicles. The roof rail covers may come loose and detach from the vehicle.
Consequence & remedy
Consequence: A detached roof rail cover can create a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect the roof rail covers and as necessary, repair or replace the push-pins, rail clips, or roof rail covers, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 28, 2026. Additional letters will be sent once the remedy is available, anticipated in January 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S54. This recall expands previous NHTSA recall number 21V316. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 16, 2026.
Ford Motor Company (Ford) is recalling certain 2017-2019 Explorer vehicles. The rear suspension toe links may fracture.
Consequence & remedy
Consequence: A rear toe link fracture can result in a loss of steering control, increasing the risk of a crash.
Remedy: Dealers will replace the toe links, free of charge. Owner notification letters were mailed on March 16, 2026. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 26S08. This recall is an expansion of previous NHTSA recall number 21V537. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning February 25, 2026.
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
Consequence & remedy
Consequence: An electrical short circuit can increase the risk of a fire.
Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
Ford Motor Company (Ford) is recalling certain 2011-2019 Explorer vehicles. The A-pillar trim retention clips may not be properly engaged, allowing the trim to detach.
Consequence & remedy
Consequence: A detached trim piece can fall off the vehicle, becoming a road hazard and increasing the risk of a crash.
Remedy: Dealers will inspect and replace the A-pillar trim as necessary, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model years. Owner notification letters were mailed between July 18, 2024 and December 16, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S02.
Ford Motor Company (Ford) is recalling certain 2016-2019 Explorer vehicles. The retention pins could loosen and allow the roof rail covers to detach from the vehicle.
Consequence & remedy
Consequence: A detached roof rail cover can create a road hazard, increasing the risk of a crash.
Remedy: Dealers will install push-pins and replace any damaged rail clips and roof rail covers, as necessary, free of charge. The interim owner notification letter was mailed on June 22, 2021. Owner notification letters (remedy available) were mailed on October 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S22.
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence & remedy
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Additional source detail variants (2)
Seats:mid/rear Assembly
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Seats:front Assembly:recliner
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Ford Motor Company (Ford) is recalling certain 2018 Ford Explorer vehicles equipped with 2.3L or 3.5L GTDI engine. Due to an assembly error, the fuel pressure sensor may leak fuel.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Ford will notify owners, and dealers will replace the fuel line assembly, free of charge. The recall began December 7, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S35.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
PE23001 · Windshield Trim Molding Item Detachment
Opened Jan 27, 2023 · Closed Feb 8, 2024
Status: closed (inferred from source dates) · Structure:body:roof And Pillars
On January 27, 2023, the Office of Defects Investigation (ODI) opened PE23-001 to investigate allegations of A-pillar trim panel detachment on model year (MY) 2011-2019 Ford Explorer vehicles. At the time of opening, the office had received 164 Vehicle Owner Questionnaires (VOQs) reporting this failure. ODI has received 671 VOQs regarding this failure, including 1 alleged crash and 2 alleged injuries. Some consumers have reported that the failure occurred while they were driving at highway speeds, with the detached trim panel entering the path of travel of the vehicle behind them, requiring the driver of the following vehicle to take evasive action. It is noteworthy that motorists who experience this type of road hazard are less likely to accurately identify the subject vehicle the item detached from and report the event to the NHTSA. In its April 17, 2023 response to ODI’s information request, Ford provided 175 consumer complaints (including field reports) and 14,162 warranty claims related to A-pillar trim panel detachment. Ford relayed that the subject vehicles utilize a plastic A-pillar bracket, which is bolted to the vehicle structure during assembly. The A-pillar trim panel is attached to the bracket utilizing 7 plastic clips. Contributory factors which have been identified by Ford as leading to the subject defect include incomplete installation at the assembly plant, inadequate part stack up, damage to fasteners during installation, and failure to follow proper repair procedure during windshield replacements or other services. On January 19, 2024, Ford filed safety recall 24V-031 for MY 2011-2019 Ford Explorer vehicles to address the subject defect. In the Part 573 Safety Recall Report, Ford identified that a detached A-pillar trim panel can create a road hazard for other road users, increasing the risk of a crash. The recall remedy includes an inspection of the existing A-pillar trim panel and, if necessary, the replacement of the component. The remedy A-pillar trim panels will be installed with an additional adhesive for robustness and utilize an inspection procedure to ensure full engagement of all the retention clips during installation. In view of the recall action being taken by Ford, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
AQ22003 · Hertz/vehicles Rented With Open Recalls
Opened Dec 16, 2022 · No close date supplied
Status: open (inferred from source dates) · Latches/locks/linkages:hood:latch
NHTSA is opening this audit query to investigate whether The Hertz Corporation (Hertz) has complied with the requirements of the National Traffic and Motor Vehicle Safety Act (Safety Act). The Safety Act requires, among other things, that a rental company shall not rent a vehicle subject to a safety recall unless the recall remedy has been performed. 49 U.S.C. § 30120(i).NHTSA is in receipt of information that indicates Hertz rented vehicles to customers without having performed required recall repairs. Accordingly, we are opening this audit query to seek additional information concerning this issue.
Illustration