2018 Ford Escape

Check Engine Light appeared, and car seemed to sputter and had an odd chemical smell. Brought to mechanic who scanned PCM and found 3 misfire codes (P0300, O0301, P0316). They removed 1 spark plug and inspected cylinder and found it to be wet. Block test was performed, and fluid was found to be coolant. Engine head gasket requires replacement as well as repair or replacement of cylinder. Mechanic suggested seeking support from dealership to have the issue fixed because this is a known issue. A simple internet search confirmed that this make and model (2018 Ford Escape 4 Cyl Ecoboost) has this issue and it is well known and documented. Ford coolant intrusion is a known problem and design flaw. The service manager at the Flood Ford in Narraganset said that since there are no recalls and the warranty on the car has expired there is nothing that they can do as far as monetary support or compensation. They quoted a $9000 repair price. The manager then suggested speaking to Ford Customer Service directly. I spoke to a service rep followed by a supervisor (Reggie) at Ford Customer Service who both told me that there was nothing they could do because there were no active recalls or active customer service programs. The rep at Ford did tell me that CSP 19B37 was done on the vehicle in 2020, prior to my purchase. I was not told of this upon purchase or made aware in any way of a coolant issue. This issue causes major damage to the vehicle and is a safety risk.

CEL is on -- hard time getting vehicle to start up after getting gas - once is running has a "shake to it" for a few seconds then stables Would this be a potential cover? March 30, 2018 NHTSA CAMPAIGN NUMBER: 10137114 COMPONENT: FUEL SYSTEM, GASOLINE NHTSA ID Number: 10137114 Manufacturer Communication Number: SSM 47203 Components: FUEL SYSTEM, GASOLINE

It started with engine light coming on, engine was starting to run rough when started. I noticed the car was using more coolant than usual also. when scanned and pressure tested it was found to be misfiring in cylinder 2 and coolant was leaking into engine. by this point the vehicle is smoking also. It was decided the car should not be driven at this point.

My 2018 Ford escape has the 1.5 liter ecoboost engine which is well documented to have a coolant intrusion issue into the cylinders resulting in the vehicle needing a new engine. The check engine light came on last week and started to run roughly. I brought the vehicle to my local Ford dealership in Belleview Fl today 11/03/25. I payed for a diagnostic test which found 2 codes po302 and po316 and found coolant in cylinder #2. The result: will need to replace engine. My vehicle has 144k miles and therefore the original manufactured warranty has expired. Ford quoted me approximately $14,000 for a new engine/labor.

They KNOW the headgasket will eventually bust and they don’t tell you, it needs to be recalled because now I don’t have a vehicle when it was built to blow. The headgasket doesn’t have enough space or something and it causes coolant leaks, they have a whole procedure on replacing it because they know they messed up but only if you’re less than 84k miles!

Have had to have many sparks plug replaced, coolant needs replaced frequently, hesitating, hard start, blue smoke from exhaust, chugging, stalling, check engine light on. Two different mechanics have told me that coolant is leaking into cylinders causing engine failure. I purchased this vehicle new, and only owner. Have had to have transmission replaced as well. Costs estimate about 10k to replace motor. This has been happening since 100k miles.

Engine light came on. It came up as misfire cylinder 3 needing spark plugs/Ignition coil so I made an appointment to get that fixed. On my way to my appointment today, the “engine overheating stop vehicle” warning came on. Turns out this is the known coolant intrusion into the engine block problem that has caused the engine to crack and now needs replaced. Called Ford customer service and just like what they are telling everyone else, there is nothing they can do to help. Yes it’s a known problem by Ford but they will not fix it because my car does not meet mileage criteria. It has 130,000 miles.

Experience misfire + engine issues that resulted in white smoke coming out from my exhaust. When brining it into the shop it is apparently a common known issue with Ford Escapes from 2017-2019 where coolant leaks into the motor from a while in the short block. The short block requires $9000 to be replaced. When doing my research Ford released a customer survey back in 2022 that I did not receive where they acknowledged the issue and offered to replace. But since I did not receive this letter I did not get the opportunity to and now am out a car that I still owe money on. Why is this not legally required to be a recall?