2020 Ford Edge

Our 2020 Ford Edge SEL has experienced ongoing shuddering and hesitation while driving. The Ford dealership inspected the vehicle and diagnosed the torque converter as the likely cause, recommending approximately $4,500 in repairs. The torque converter has not been replaced and is available for inspection. We obtained a second opinion from an independent repair shop, which replaced the EGR sensors and updated them in an attempt to resolve the issue. The problem has created a safety concern because the vehicle does not always accelerate or operate normally while driving. The exact cause remains UNKNOWN, and the issue has not been inspected by police or insurance representatives.

XXX, I parked my Edge car around 11am. I always put the car into park mode before turning off vehicle! The road was flat, good weather and had no previous issues/warnings. I went into building. My gray Ford Edge 2020 ST with 105,000. miles is a wonderful vehicle! I came out of appointment about an hour later and my Edge had rolled backwards 6 to 8 feet! It almost hit another vehicle, parked behind my car! I immediately took my car to local Ford dealership service, Baugh Ford, [XXX]. I was told I needed to pay 1500 dollars for the vehicle to be taken apart to get an estimate of what needed to be fixed? I don’t have 1500 dollars to just give to ford service for them to look online and find what other years and other Ford models have had with this exactly same safety recall! This is a HUGE safety issue and FORD DOES NOT want to fix because this is a vehicle that I paid off in 7 years, have been only driver and never been in any accidents! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2020 Ford Edge. The contact stated that while driving at an undisclosed speed, the vehicle jerked roughly while turning right or left, with a grinding sound coming from the vehicle. The contact stated that the vehicle was driving sluggishly. The contact stated that the brakes had been recently serviced but might be the issue. The vehicle was taken to a dealer where it was diagnosed with a rear axle failure caused by inadequate lubrication in the rear axle. The contact associated the failure with NHTSA Campaign Number: 21V011000 (Power Train); however, the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 94,000.

While driving the HVAC stops working, radio locks at current setting (cannot turn volume up or down, etc.), screen goes blank or locks, windows do not open or close. Their are multiple warnings about sensors not working. Malfunctioning driver assist jerks wheel when driving through a restaraunt drive-thru. Had the sensor replaced for the adaptive cruise control and it did not correct the cruise issue. The issue initially started with the monitor screen going blank randomly and then progressing to the above issues. This had been happening for the last 2 or 3 years before the above accured.

The vehicle hesitates, jumps, and then surges into gear when accelerating from low speed, which I believe makes it difficult and hazardous merging into traffic and other driving situations. Due to the hesitation it is unable to get up to speed very easily or quickly on busy interstate roads. The hesitation, jumping, and surging has gotten progressively worse and occurs at higher speeds now. It seems like it now does this during each gear shift. I am a longtime Ford owner I previously drove a 2001 F150 with little to no problems, it reached around 280,000 miles before it's trade in. I now have a 2020 Edge SEL 2.0 AWD and have really enjoyed this car until this problem started. It was bought in March of 2024 with 62k miles and it now has 92k. The problem initially only surfaced after the car had bene on and moving for a while and it was very subtle. I could not tell if it was engine or tranny and it was only barely noticeable. But the issue has remained and now occurs at all periods of time when being driven. I have had this vehicle inspected by multiple service centers now, both of which confirm the problem being that when shifting gears the internal parts of the transmission slip causing wear and extra heat generation, leading to the slipping and jumping. The transmission needs to either be rebuilt or replaced due to its faulty initial construction. I have been told by these mechanics that they have had to do this exact replace on many of this exact same model of car, and similarly each time they've done it the models are typically around 80,000-90,000 miles not even making it to 100,000. There were no warning lights or messages and there still aren't any even after getting it looked at twice.

The transmission has been serviced regularly. It is starting to jerk at lower speeds. I have had two auto mechanics from different shops and locations inspect the transmission. Both have found shaved metal in the transmission fluid. After a call to two different Ford dealerships, the auto mechanics were informed that it is a problem with these transmissions, but Ford has not issued a recall. If I have to replace the transmission, I will be contacting an attorney for assistance. There have been no warning lights or alarms indicating that there are problems with the transmission. Because there are no warning lights on the dashboard, it has been hard to diagnose the actual problem. Of course, I am approximately 6000 miles over the extended warranty. At the time I took the car to the shop, the mileage was 79,465.

Recently had the torque converter replaced for shuddering/shifting weird. Although there is no more shuddering, the car still does not seem to be shifting correctly. It hesitates between shifting gears and will then accelerate quickly. It was seen at the shop again today and they could not find any issues with it although I was told it will likely do it again for me and to let them know. There have not been an indicator lights.