2020 Ford Edge

On 10/22/2022 while driving on a highway at the posted speed limit, without warning the Panorama Sun Roof exploded showering shards of glass on Myself and My Wife. The glass sunroof was properly closed but the inside headliner panel was open to enjoy the sun. The moderate average temperature outside at this time was approximately 68 degrees. This vehicle currently has approximately 12,250 miles on it. When the sunroof suddenly exploded, my wife sustained cuts to her hand and both of us were covered in shredded glass, including tiny glass shards embedded in our scalps. The explosion was so sudden and loud I nearly lost control of the vehicle. Fortunately, there was minimal traffic on the road at the time of the explosion with no vehicles immediately in front of us. Research has revealed many incidents of exploding sunroofs on various Ford models, with an exceptionally high incident rate for the Ford Edge model. It was further discovered that this exploding sunroof issue in various Ford models has been ongoing since 2008 with the Ford Motor Company being made aware of this defect. Research has further indicated to date, Ford has failed to issue a recall for this serious and dangerous defect. If our grandchildren had been rear seat passengers (which is often the case), this incident could have been tragically much worse. Not only did the exploding sunroof cause a serious, dangerous and injurious safety threat to us as passengers, getting the vehicle off the road (with the interior headliner panel closed) caused a safety threat to any nearby drivers as we could hear and see the remaining shattered glass flying off the vehicle into the roadway.

We were driving my 2020 Ford Edge when my vehicle and another vehicle collided. The entire front end of my Ford was smashed in due to the force of the impact. We had to be extracted by the fire department, because we could not open the doors. My pre collusion alert system did not sound off; nor did the airbags deploy despite the rate of speed from the other car as we both entered the intersection. As a result of the airbags failing to deploy, my wife suffered injuries resulting in a trip to the ER. She is still treating with medical providers. Prior to this incident we had no indication of any safety features failing. No warning lights, messages or other symptoms. The manufacturer has been made aware of the incident but has not yet inspected the vehicle at the time of this report. It is currently being held at an auto repair shop.

I WAS DRIVING IN STOP AND GO TRAFFIC FOR SEVERAL MINUTES. WHEN WE WOULD MOVE FORWARD IT WOULD ONLY BE FOR 1 CAR LENGTH. I STOPPED, AND WHEN THE ENGINE TURNED BACK ON FROM THE AUTO START/STOP, THE CAR LURCHED FORWARD AND HIT THE CAR IN FRONT OF ME. I STILL HAD MY FOOT ON THE BREAK. AT FIRST I THOUGHT I HAD BEEN HIT FROM BEHIND, BECAUSE I HAD MY FOOT ON THE BREAK. I HAVE SEEN 2 OTHER COMPLAINTS SIMILAR TO MINE, HOWEVER, THEY DID NOT RESULT IN AN ACCIDENT.

I HAD JUST ENTERED MY CAR AND WAS GOING ABOUT 45 MPH AND HAD GONE ABOUT 2 MILES WHEN I HEARD A STRANGE NOISE ON THE TOP OF MY VEHICLE I IMMEDIATELY PULLED OVER AND GOT OUT TO LOOK AND NOTICED THE WHOLE MOON ROOF OF MY EDGE HAD BROKEN AND WAS FALLING INTO MY HEAD LINER. IT WASN'T LIKE THAT WHEN I LEFT HOME AND IT IS A NEW CAR WITH ONLY 8000 MILES ON IT. FORD REFUSES TO PAY FOR THE NEW MOON ROOF SAYING THEY DON'T COVER GLASS, BUT I SHOULDN'T HAVE TO PAY FOR AN OBVIOUS DEFECT. I GOT ONLINE AND NOTICED THAT THIS IS HAPPENING TO A LOT OF VEHICLES AND THE MANUFACTURERS DON'T WANT TO PAY FOR REPLACEMENT. IS THERE ANYTHING I CAN DO TO MAKE THEM PAY FOR THE REPLACEMENT?

ON JULY 4,2020 AT APPROX 10:15AM I WAS DRIVING ON PA 663 HIGHWAY. OUT OF NO WHERE, I HEAR THIS LOUD BOOM. CAR IN FRONT OF ME KEPT GOING, CAR IN BACK OF ME GETTING CLOSER AS I SLOW DOWN AND PULL OFF TO THE SIDE OF HIGHWAY. CAR BEHIND ME KEPT GOING. I GET OUT OF CAR AND FIND MY PANORAMIC SUNROOF SHATTERED. I HAD THE COVER CLOSED SO GLASS WAS CAUGHT INSIDE COVER. I LOOK INSIDE COVER AND FIND NOTHING BUT SHATTERED GLASS. I CALL FORD ROADSIDE ASSISTANCE. WHILE I WAIT FOR DRIVER, I TAKE PICTURES. DRIVER ARRIVES AND TOWS CAR TO NEAREST FORD DEALER WHICH IS 100 MILES FROM MY HOME. ON MONDAY, 7/6/20, I CALL DEALER SINCE I'VE ONLY HAD THIS CAR 26 DAYS. BRAND NEW, LEASED WITH 907 MILES. DEALER TELLS ME IT'S NOT UNDER THEIR WARRANTY. I'M TOLD SOMETHING MUST HAVE HIT THE ROOF BUT NO SIGN OR EVIDENCE OF ANYTHING. I CALL FORD CORPORATE AND THEY TELL ME THE SAME THING. SINCE I NEED A CAR, I FILE CLAIM WITH MY INSURANCE TO HAVE IT FIXED HAVING TO PAY A DEDUCTIBLE AND THE COST OF A RENTAL.

THERE IS AN EXHAUST ODOR IN THE VEHICLE ESPECIALLY AFTER A HARD ACCELERATION AS IN PASSING ANOTHER VEHICLE. I TOOK VEHICLE TO MY FORD DEALER WHO SAID THERE WERE KNOWN PROBLEMS REPORTED ON MY MODEL VEHICLE. I SINCE FOUND A FORD TSB 18-2057 THAT COVERS THE ISSUE, BUT FOR YEARS 2015-2018. IT APPEARS THE PROBLEM EXISTS ON THE 2020 MODEL YEAR VEHICLES, TOO. *TR