2020 Ford Edge

While driving the HVAC stops working, radio locks at current setting (cannot turn volume up or down, etc.), screen goes blank or locks, windows do not open or close. Their are multiple warnings about sensors not working. Malfunctioning driver assist jerks wheel when driving through a restaraunt drive-thru. Had the sensor replaced for the adaptive cruise control and it did not correct the cruise issue. The issue initially started with the monitor screen going blank randomly and then progressing to the above issues. This had been happening for the last 2 or 3 years before the above accured.

Complainant: [XXX] Vehicle: 2020 Ford Edge VIN: [XXX] Current Mileage: Approx. 152,000 miles Target of Complaint: Ford Motor Company / [Don Chalmers Ford] Subject: Request for Goodwill Financial Assistance Due to Documented, Inherent Transmission Manufacturing Defect I am filing this dispute to request financial assistance/cost-sharing from Ford Motor Company for a total transmission failure on my 2020 Ford Edge. While the vehicle is past its standard powertrain warranty, the failure is directly caused by an inherent manufacturing defect that Ford has internally acknowledged and documented. The dealership has quoted $9,000 for a full replacement, an unreasonable financial burden for a known, pre-existing mechanical flaw. The vehicle is experiencing severe shifting difficulties, specifically when attempting to transition the vehicle out of Park into any other gear. A formal diagnostic inspection conducted by the authorized Ford dealership confirmed a total transmission failure. Crucially, the dealership verified that the vehicle's symptoms and mechanical failures match Technical Service Bulletin (TSB) 857 / 20-2190 (tel:857%20/%2020-2190). This internal Ford bulletin specifically addresses harsh engagements, shifting faults, and component degradation within this vehicle's transmission model. The dealership initially denied financial assistance because this vehicle’s specific VIN is not included in safety recall Campaign 20S47. I wish to clarify that I am not arguing a violation of a safety recall. I understand that Campaign 20S47 is a narrow, VIN-specific safety mandate. Instead, my case rests on the fact that the dealership’s own diagnostics verified the exact mechanical failure described in Ford’s internal Technical Service Bulletins. A TSB proves that Ford is fully aware of a widespread, systemic manufacturing defect in these units. The exclusion of my VIN from a safety recall does not negate the fact that my vehicle suff INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552

Transmission Fluid Leak/Fire Risk (Recall 20S49): Certain 2020 Edge models have missing or loose bolts on the start/stop accumulator endcap, which can cause a leak and increase the risk of fire. Rearview Camera Failure (Recall 20V572000): A common issue where the rear camera may display a blank or distorted image, failing to comply with safety standards. Driveshaft Seizure (Recall 21S43): A potential lack of lubrication in the rear drive unit can cause it to seize, leading to loss of drive and vehicle control. Inoperable HVAC Blower Motor: A potential defect causing the blower motor to fail, which can hinder windshield defrosting. Power train alert not going into park break light issue

Safety Defects and Mechanical Failures My 2020 Ford Edge (VIN: [XXX] ) is plagued by systemic safety defects that render it unroadworthy under Pennsylvania law (37 Pa. Code § 301.2).[1, 2] The 8F35 transmission suffers from a documented "shudder" and loss of motive power (TSB 21-2389), creating a high risk of collisions in traffic.[3, 4, 5] Additionally, the vehicle is subject to critical federal recalls: Recall 21S02 (21V-011) regarding sudden rear axle seizure [6, 7, 8] and Recall 20S49 (20V-550) regarding a lethal fire hazard from leaking transmission fluid.[9, 10, 11] The engine also exhibits a design flaw known as "coolant intrusion" (TSB 19-2346), which leads to catastrophic engine failure and hydro-lock.[12, 13, 14] ​Deceptive Trade Practices and Lender Liability CarMax sold this vehicle as "Quality Certified" without fulfilling the disclosure requirements mandated by the 2022 Multistate Attorney General Settlement.[15, 16] Specifically, CarMax failed to provide the required standalone, signed disclosure form for open safety recalls prior to the sale.[17, 18, 15] Because this transaction was financed through Santander Consumer USA, the lender is derivatively liable for CarMax’s deceptive acts under the FTC Holder Rule (16 C.F.R. § 433).[19, 2] This federal rule allows me to assert all legal claims and defenses against Santander that I have against CarMax, including breach of the implied warranty of merchantability, which overrides any "As-Is" disclaimer when a vehicle is sold in a non-roadworthy condition INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Is cutting out when going, camera is failing, heated mirrors are not working, 10 codes are showing up on mechanics scan tool. Took to ford dealership they disregarded my concern and only changed differential fluid for a weird sound concern that is already on a recall but didn’t include this vin and didn’t check for any other diagnosis. Been to 3 shops nobody is figuring it out.

10/2022 2yrs owning and around 50,000 miles the all wheel drive went out due to a sensor thats not protected from the elements and of course not covered under the warranty and $900.00 dollars later they install a new one that wasn't updated in order to prevent this from happening again. 9/2/2025 3yrs later and 88,000 miles now the torque converter is going out which i was told by the ford technician that they have been seeing this alot. Of course my warranty is gone even the extended one that I purchased when I purchased this car new. So to fix this manufacturer's issue will now cost me $4,000 dollars to fix. But I was told the torque converter has been updated so I shouldn't have this issue again. So they know this is a problem which i assume is the reason for the updated converter so why isn't this a recall.

The contact owns a 2020 Ford Edge. The contact stated while driving at an undisclosed speed, the vehicle was jerking erratically. No warning lights were illuminated. The contact stated that it was a safety hazard while taking the kids to school and picking up the kids from school. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and a case was filed. The contact referenced a Technical Services Bulletin with a similar failure. The contact was advised to pay for a software update. The contact declined and stated that he should not have to pay to correct the issue. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 80,000.