2019 Ford Edge

When obtaining a tire rotation at the Ford Dealership, I was told that I had swollen lug nuts and for safety reasons should be replaced. I never had a vehicle with this problem. To replace all the lug nuts, it was a cost to me of $259.20. This is a manufacturer defect that should have been covered under my extended warranty but was not. I was told that the lug nuts could seize and not be able to be removed if I needed to change my tire. This in my opinion is a safety concern and should be addressed.

The contact owns a 2019 Ford Edge. The contact stated that while driving at an undisclosed speed, the check engine and engine temperature warning lights illuminated; however, the contact immediately pulled over to the shoulder of the roadway and turned off the vehicle. The contact was able to restart the vehicle and safely drove to the location where the vehicle had received an oil change service two days before. The independent mechanic inspected the vehicle and checked the coolant level, which he had filled two days before, and informed the contact that he could smell coolant burning and that the coolant was leaking into the engine. The contact was advised to take the vehicle to the dealer for assistance. The contact safely drove the vehicle to her residence, contacted the dealer, and scheduled for the vehicle to be picked up by a tow truck service. The vehicle was towed to the dealer, where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced; however, the vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 89,000.

Vehicle had history of making clunking sound when moving from stopped position to moving. Intermittent issues with pausing/ hesitating acceleration. June 2023, progressed to bucking, shuddering, fluctuating RPM. No lights, codes Had serviced, tune up, etc. Dx'ed needing new transmission due to faulty torque converter. Vehicle parked until ordered transmission arrives ( has been on back order, was to be released 8/11/2023, waiting to be received).

Went to get brakes replaced and found out the lug nuts were jammed on and could not be removed, took it to the deal to find out they were swollen on and no one would have been able to remove them but them! They stated they see it all the time if I had a flat no one would have gotten them off it would have had to towed! To me this is a safety hazard that could leave me stranded. They said this was comment I called ford they would not acknowledge it

The contact owns a 2019 Ford Edge. The contact stated that while driving at an undisclosed speed, the low coolant warning light illuminated. The contact stopped, parked the vehicle, refilled the coolant, and drove the vehicle to her residence. The contact stated that the vehicle was started the following day and the low coolant warning light was illuminated. The contact checked the coolant level and became aware that the coolant reservoir was empty but there was no evidence of a coolant leak on the ground underneath the vehicle. The contact stated that the vehicle was taken to an independent mechanic for an oil change and the contact was informed that the head gasket was blown, and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 85,800.

The contact owns a 2019 Ford Edge. The contact stated while driving 30 MPH, the "AWD Fault - Contact Service Department" message was displayed. The vehicle was taken to the dealer and the contact was informed that the rear drive unit actuator motor, actuator bolts, fuel strap bolts, drive shaft bolts, rear wheel bearing bolts and rear axle nuts needed to be replaced. The vehicle was not repaired. The manufacturer was contacted but provided no assistance. The failure mileage was 12,500.

The contact owns a 2019 Ford Edge. The contact stated that while driving at an undisclosed speed and depressing the accelerator pedal, the vehicle shuddered and stalled. There was no warning light illuminated. The vehicle was taken to an independent mechanic, where the failure was related to Ford Technical Service Bulletin Number: 19-2208 (Coolant In Cylinders). The vehicle was not repaired. There was no further information provided. The manufacturer was made aware of the failure and informed the contact that the vehicle was not under warranty. The failure mileage was approximately 61,220.

The contact owns a 2019 Ford Edge. The contact stated that the vehicle was designed with the START/STOP feature; however, the feature was inoperable. Additionally, the contact stated while driving at various speeds, the vehicle sputtered. There was no warning light illuminated. The contact stated that the failure mainly occurred while changing gears below 50 MPH. The vehicle failed to shift into gear, and the RPMS revved up. The contact veered to the side of the road. The contact was able to continue driving however, the vehicle failed to exceed 20 MPH. The power train warning light was illuminated, and the message "Check Manual" was displayed. The contact stated that while driving from a complete stop, the vehicle would jerk and would hesitate to respond. Additionally, the contact stated that the vehicle would stop abruptly when coming to a complete stop. The vehicle was taken to several independent mechanics, where it was diagnosed that the failure was related to the transmission and to NHTSA Campaign Number: 20V550000 (Power Train). The vehicle was not repaired. The dealer was not notified of the failure. The manufacturer was notified of the failure and informed the contact that they could not assist because the VIN was not included in a recall. The failure mileage was approximately 81,500.

I was driving on a country road and had my cruise control set to 55. My car braked hard and de-accelerated to about 40 and then increased the speed without hitting the resume button. My 89 year old mother was my passenger in the car with me and both of us were jolted when the seat belts locked up. We both gasped as we were startled by this action. There were no animals, vehicles or blowing debris across the path of my car. No messages appeared on my dash. I have not reported this to my Ford dealer and the car is available to be checked. This was a one time event. If a police officer had been behind me I would have received a ticket for brake checking.