2019 Ford Edge

The contact owns a 2019 Ford Edge. The contact stated while driving approximately 40 MPH, the vehicle shuddered. No warning light was illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 81,000.

The Transmision hesitates and jerks while shifting at speeds from 25-40 mph. This is unsafe while pulling into traffic, and causes unnecessary wear on the drivetrain!. I have read about many others who have the same issues, with little help from Ford. We have an appointment at our Ford dealership. No warning lights light up when it acts up.

Transmission problem. Vehicle shudders while accelerating and cruising at highway speeds. No codes found, torque converter is shuddering between 1-300 rpms while accelerating and while cruising at highway speeds. This could cause catastrophic failure at any second. Reproduced and Confirmed by Ford Dealership. Has not been inspected by anyone else. No warning lamps or messages. 2 weeks prior there was a slight vibration when it shifted while accelerating that happened 3 times. Drove 400+ miles up to Syracuse NY fine. Drove back home and experienced massive shuddering when I was almost home. Dropped off car at local dealership that was thankfully within a few miles.

The contact owns a 2019 Ford Edge. The contact stated that the vehicle jerked upon acceleration or deceleration. No warning lights were ever illuminated. The vehicle was taken to a local dealer where it was diagnosed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 86,000.

The contact owns a 2019 Ford Edge. The contact stated while driving 30-40 MPH and depressing the accelerator pedal, the vehicle jerked and lurched forward. There was no warning light illuminated. The contact stated that the failure had been recurring while driving. The vehicle was taken to the dealer, where it was diagnosed that the transmission had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was unknown.

The contact owns a 2019 Ford Edge. The contact stated that while driving at various speeds, the transmission was slipping, and the vehicle struggled to remain in the intended gear. Additionally, while driving at highway speeds, there was an abnormal knocking sound coming from the vehicle. There was no warning light illuminated. The vehicle was taken to the dealer and was diagnosed with transmission failure. The vehicle was not repaired. The contact stated that the failure persisted. The vehicle was taken to a certified mechanic who confirmed the transmission failure diagnoses. The transmission was replaced. The manufacturer was made aware of the failure and opened a case. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 104,000.

Purge flow valve had replaced by Ford Service on 10/5/24. Car wouldn’t start after getting gas. Check engine light came on. Code was Po496. Currently, upon acceleration @15-20 mph car starts jerking, buck, slipping, very hard to go hill. Took to Ford Service for diagnostic on 10/15/24. Told torque converter shuddering on PIDS. Recommend replacing torque converter @ a cost of $5200. Per, reviewing many complaints on this same model & yr many haven’t had success with just replacing torque converter. It doesn’t fix issue. Transmission had to be replaced. Ford does have a TSB 21-2389 that supersedes TSB 21-2081 out. It states cars with 8F35 transmission may have this issue due to the software in the power train control module. Instructing, to reprogram the PCM & the transmission solenoid strategy. After reviewing all complaints on this issue, this solution does not correct problem. I was also told by Ford service; this wouldn’t fix the issue. From what I’ve read the way this transmission is engineered will likely cause it to always do this. Because Ford Frankensteined the 6F35 (previous models) by inserting 2 gears in between existing ones, the transition from 1-2-3 will never be as fluid as 3-4, 4-5, and so on. Basically what is 1-3 on mine (8F35) is 1-2 on a 6F35. This quite frankly is a terrible transmission & only a matter of time before transmission goes completely out & someone gets killed. This year & model has numerous issues not listed here. Seems like as soon as warranty expires problems start popping up. Some issues pop up before warranty expires. This is getting dangerous & very expensive!

We purchased our 2019 Ford Edge Titanium in March of 2022 with 71K miles on it from a local used car dealer. The vehicle was jerky in the lower speeds (up to 40 mph) - best described as if the transmission did not know what gears to go in, so it would jump back and forth, causing uncontrollable hesitations and accelerations - jumping back and forth between gears. The dealer said this was normal for the newer 10 speed transmissions and that it had to learn each new driver. At that time, there weren't reported issues online about these transmissions, so I accepted the dealers explanation as normal. The jerking and jumping between gears got worse and at 91K miles, the vehicle even stopped going in reverse, which made it even more dangerous. We replaced the transmission with another used transmission (believe 18K miles on it) and that one was even worse with the jerkiness and jumping back and forth, so we replaced it with another used transmission (believe 45K miles on it) which is now having the exact same issues. We have 95K miles on our vehicle and are now needing a 3rd transmission replacement. No safety warning lights came up. While it's a big inconvenience with the vehicle being constantly in repair, the bigger issue is the incredible safety issue with the hesitations and jumping in and out of gears, reverse not working, etc. that can put multiple people's lives in danger when the vehicle is not reacting and performing without hesitation. We have had close calls on crashes due to the transmission hesitations and jerky gear shifting and it distracts us from paying attention to the road, other vehicles, and pedestrians. We encourage anyone from NHTSA to contact us to talk through it, inspect the vehicle, and/or talk with our repair shop about these now common faulty transmissions. If bodily injury occurs due to known faulty transmissions, I would file a significant product liability lawsuit against Ford and the transmission manufacturer for their negligence.

The contact owns a 2019 Ford Edge. The contact stated that while driving approximately 65 MPH with cruise control activated and his two kids in the vehicle, the cruise control inadvertently deactivated and the transmission seemed to have fallen out of gear, and the vehicle started bucking and jerking and then lost motive power and started to decelerate. The contact pulled over off the highway and restarted the vehicle. The contact stated that the failure was an ongoing failure with the transmission. Additionally, the contact stated that the transmission was shifting roughly while changing gears. There was no warning light illuminated. The vehicle was taken to a local dealer where the vehicle was diagnosed, and the contact was informed that the torque converter needed to be replaced. The vehicle was also taken to an independent mechanic and the contact was informed that the transmission needed to be replaced. The contact was advised that a temporary fix would be to flush and refill the transmission fluid. The vehicle was not repaired. The contact referenced TSB 21-2081 as probable cause for the failure. The manufacturer was notified of the failure. The approximate failure mileage was 60,000.