2018 Ford Edge

The contact owns a 2018 Ford Edge. The contact stated that while driving at an undisclosed speed, the Coolant Level Low message displayed, and there was white smoke coming from the exhaust pipe. The vehicle experienced rough idling. The contact pulled over and turned off the vehicle to cool down the engine. The vehicle was able to restart after several attempts. The vehicle was taken to the dealer, where it was diagnosed with coolant intrusion into the cylinders, and it was determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The contact related the failure to Technical Service Bulletin: 19-2346 (Coolant in Cylinders, White Exhaust Smoke, And/or Illuminated MIL); however, the vehicle was not covered under the TSB. The failure mileage was approximately 130,000.

Ford Ecoboost 2.0 engine in my 2018 Ford Edge failed at 71,945 miles due to cooling leaking into cylinder #2. Engine started rough for about two weeks but leveled out after about 5 seconds. When the check engine light came on while my wife was leaving home, we stopped driving the car until I could get an appt with Conway Heaton Ford in Bardstown KY. There the engine was found to have coolant leaking into the #2 cylinder. Dealer said the car was unsafe to drive and the engine needed to be replaced. They would not return the keys to me due to the safety hazard the car had become. Engine was replaced on [XXX] at a cost of $6916.00. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

First indication of an issue was when the check engine light illuminated (2/1/2024). I took car to an independent repair shop who identified the codes as PO304 - misfire cylinder 4 and P0316 - misfire on start up. Borescope revealed coolant leaking thru #4 cylinder wall & cylinder #1 showing stream of coolant from cylinder head gasket. Ford TSB recommends long block engine replacement due to coolant intrusion in the engine. The car remained parked from 2/2/24 to 3/13/2024. 3/13/2024. On 3/13 I took the car to the local Ford dealership whose service department confirmed the original diagnosis. Safety issue - coolant intrusion into the combustion chamber could induce an engine fire or cause the engine to seize up while being driven. The car is still at the Ford dealership. The mileage when the CELcame on was 72944 miles. Current mileage approximately 72960. Toatal cost to repaired quoted at $ 9,110.01.

2018 Ford Edge purched certified pre-owned in Novemeber 2023. In February, engine light displayed after diagnostic was ran, we were told that there is a coolant intrusion and we would need to replace the entire engine, approximately $8k. Ford Autonation, Valencia and Ford customer service directed us to contact you so we can report the coolant issue which is a known recall for Ford Edge. The VIN number doesn't fall within the recalled models, but since our vehicle is having the same issue, Ford told us to report this issue to you so that the VIN or Factory can be included in the recall. Ford case # CXH01736957. Car is currently at the Ford Autonation, Valencia Service dept.

The contact owns a 2018 Ford Edge. The contact stated while starting the vehicle, the vehicle was idling abnormally rough. The contact stated that the vehicle shuddered, and an abnormal odor was detected, and white smoke was observed coming from the exhaust. The check engine warning light was illuminated. The vehicle was taken to the dealer where it was diagnosed as coolant intrusion with coolant leaking into cylinder #3. The vehicle was not repaired due to the cost. The contact was informed of Customer Satisfaction Program: 21N12. The manufacturer was made aware of the failure and advised the contact to report the failure to the NHTSA Hotline. The failure mileage was approximately 100,000.

The contact's wife owns a 2018 Ford Edge. The contact stated while his wife was driving 65 MPH, the message "Engine Hot" was displayed and the vehicle was overheating. The contact's wife pulled to the side of the road and allowed the engine to cool down. The contact stated that his wife turned on the hazard lights and drove to the nearby residence at slow speeds. The contact stated that the failure recurred while driving. The vehicle was taken to the dealer, where it was diagnosed that there was coolant intrusion in the engine. The dealer determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that they could not assist because the VIN was not included in a recall. The failure mileage was 70,642.

The heating in the car was not working. Then one morning the car started overheating and the check engine light came on. Taken to dealer to find the coolant was low and that it was leaking into cylinders 2 and 3 and now the engine needed to be replaced. This is an $8000 plus repair on a car I just bought for $20000 with under 75000 miles.

The contact owns a 2018 Ford Edge. The contact stated that while driving at an undisclosed speed, the vehicle began to idle abnormally rough, and the contact observed white smoke coming from the exhaust. After a visual inspection of the engine compartment, the contact observed that the coolant reservoir was abnormally low. The check warning light was illuminated. The vehicle was taken to the dealer, who determined that coolant intrusion into cylinder #3 had resulted in damage to the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 21N12. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 110,000.

The contact owns a 2018 Ford Edge. The contact stated while operating the vehicle, the check engine warning light remained illuminated, and the vehicle was vibrating abnormally. The vehicle was taken to the local dealer who diagnosed that coolant was discovered in cylinder #1, causing a crack in the engine long block. The contact was informed that the engine needed to be replaced. Additionally, the transmission pressure plate had failed causing the vehicle to vibrate. The vehicle was not repaired. The failure mileage was 98,000.