2018 Ford Edge

My 2018 Ford Edge Titanium experienced a catastrophic engine failure due to a known manufacturing defect involving coolant intrusion into the cylinders. The defect caused the vehicle to become inoperable and required a complete replacement of the 2.0L EcoBoost engine (Service Engine Assembly Part # J2GZ6006E) at 110,821 miles. The total out-of-pocket repair cost was $7,712.78. This sudden loss of engine power poses a severe safety risk on the road.

I had two incidents when I suddenly lost forward power. One was in town and lost power and was almost rear ended by another vehicle. Another incident was when I was on the interstate and lost forward power and had to get off the road because of the traffic until I could get forward movement again. I felt that this loss of power did put myself and others at risk. I also noticed rough idling and took it to the dealer. The first time, they could not get it to act up. Then I had an check engine light come on. I took it into the dealer and they replaced wires to different cylinder (cylinder 2 was affected). Less than a month later, I noticed surging while driving and then the engine light came on again. I took it back to the dealer and they notified me that it was coolant intrusion and needed a new engine at 52,000 miles. I felt unsafe in the vehicle with the surging and loss of power. Not only to myself but also to the other drivers on the road. I have since parked the vehicle out of concern.

On September 11, 2026, my 2018 Ford Edge with approximately 126,000 miles began shaking and the check-engine light came on. There were no earlier warnings. I am concerned the engine could lose power while driving. I took it to a Ford dealership, where the advisor verbally confirmed coolant inside an engine cylinder and reported codes P0302 and P0316. The repair was quoted at $8,600 before taxes, and repair assistance was denied. The only other recent inspection was a registration inspection a few months earlier.

Engine light came on, shuttering, white smoke. Had spark plugs replaced-didn’t help. Googled to see what might be wrong and found the coolant leak issue. Took it to a private garage to have a coolant pressure test, it failed, did a bore scope and showed significant damage to #2 cylinder. Took it to a Ford dealership to file for a goodwill assist and was turned down because “the car is too old and too many miles”. I am a veteran, on a fixed income, and cannot afford to pay for a new motor. I bought this car for myself on my 78th birthday, trading in my 2006 F-150, with almost 200,000 miles, for my dream car. Now I’ve spent $11,500 and have nothing.

Ford admits "known manufacturing defect" on Eco-Boost 2.0 engine. Coolant intrusion into engine. Coolant getting into combustion chamber, at only 28K miles on my own Ford Edge. Complaints all over the internet & "[XXX]" about this. Known to cause engine fires. Requires EXPENSIVE "long block assembly replacement". Page after page of complaints about this on your own NTSB website. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

On the dash board, it displayed a severe warning regarding "engine over temprature" that caused due to the engine coolant intrusion in to the cylinder 2 and caused it to misfire and the engine light to be displayed. After time and money consuming rigorous effort, each and individual parts of the engine checked based on the codes displayed. And, I realized that the engine itself was actually causing the such internal critical issue. Finally, I brought it to the Ford dealership and they told me that the engine has design defect that actually causes the coolant intrusion into the cylinder that shouldn't happen in the first place. And I was told the engine must be replaced. Detailed analysis of the issue discloses that Ford models between 2015-2018 have the same critical issues. However, Ford Motor Company never issues a recall safety issue for such potential engine issue that affected millions of Americans who have these models. I can't afford to pay $10k to replace a long block engine according to the dealer final solution to fix the internal engine problem. The car is disabled and parked out side for almost close to two years now. I am seeking justice. Help.me please!

Engine developed a bad skip, dealer service originally said it was a faulty spark plug or coil on cylinder 2so they replaced those for a cost of $414 on 6/4/26. This did not fix the problem. The second diagnosis identified the engine defect that was causing the skip. They recommended an engine replacement and contacted Ford to request assistance since it's a know manufacturing defect. This request was declined. Campbell Auto Repair replaced the engine on 8/19/2026 at a cost of $6,601.68. We feel that Ford should bear the cost of these repairs.