WINDOW ON PASSENGER SIDE FAILS TO WORK. PRESSING THE WINDOW OPENED BUTTON LOWERED THE WINDOW, BUT THEN IT WOULDN'T RAISE IT. AFTER SOME TIME, THE BUTTON BEGAN WORKING AGAIN AND WE WERE ABLE TO RAISE IT. A FEW DAYS LATER WE LOWERED IT AGAIN AND IT AGAIN GOT STUCK. AFTER GETTING IT RAISED, WE DON'T LOWER THE WINDOW ANYMORE O…
Read full complaint
WINDOW ON PASSENGER SIDE FAILS TO WORK. PRESSING THE WINDOW OPENED BUTTON LOWERED THE WINDOW, BUT THEN IT WOULDN'T RAISE IT. AFTER SOME TIME, THE BUTTON BEGAN WORKING AGAIN AND WE WERE ABLE TO RAISE IT. A FEW DAYS LATER WE LOWERED IT AGAIN AND IT AGAIN GOT STUCK. AFTER GETTING IT RAISED, WE DON'T LOWER THE WINDOW ANYMORE OUT OF CONCERN THAT IT'LL GET STUCK IN THE LOWERED POSITION. *TR
NHTSA ODI #10282231
80,000 miles · Jul 24, 2009
Visibility
MY 2002 DODGE CARAVAN DRIVERS SIDE WINDOW BROKE AT 70K MILES, (NEW MOTOR) I HAD IT REPLACED AND NOW PASSENGER SIDE WINDOW IS BROKE 130K MILES. THIS IS A DEFECT IN THE MOTOR... MY SISTER HAS THE SAME VAN AND HERS IS BROKE TOO.I WOULD LIKE THIS RECALLED SO THAT I CAN OPEN THE WINDOW. *TR
NHTSA ODI #10278251
50,000 miles · Dec 31, 2005
Air BagsVisibility
AIR BAG LIGHT REMAINED ON ALL THE TIME. BROUGHT VAN TO DEALER KNOWING THAT THEIR HAD BEEN LARGE RECALLS OF VANS WITH AIRBAG PROBLEMS IN THE PAST. THE CLOCKSPRING NEEDED TO BE REPLACED. COMPANY CLAIMED THAT THERE WAS NO RECALL FOR 2002 MODELS. THIS SEEMS TO BE AN ONGOING PROBLEM FOR DODGE AND SHOULD BE COVERED BY THEM. ALSO …
Read full complaint
AIR BAG LIGHT REMAINED ON ALL THE TIME. BROUGHT VAN TO DEALER KNOWING THAT THEIR HAD BEEN LARGE RECALLS OF VANS WITH AIRBAG PROBLEMS IN THE PAST. THE CLOCKSPRING NEEDED TO BE REPLACED. COMPANY CLAIMED THAT THERE WAS NO RECALL FOR 2002 MODELS. THIS SEEMS TO BE AN ONGOING PROBLEM FOR DODGE AND SHOULD BE COVERED BY THEM. ALSO NOT COVERED UNDER THE WARRANTY. ALSO PROBLEMS WITH THE REAR WINDSHIELD WIPER MOTOR BREAKING. *JB
NHTSA ODI #10146622
Mileage unknown · Mar 15, 2005
Service Brakes, HydraulicVisibility
WHILE APPLYING THE BRAKE PEDAL VEHICLE STALLED. DRIVER WAS ABLE TO RESTART THE VEHICLE. WHILE DRIVING IN INCLEMENT WEATHER WINDSHIELD WIPERS FAILED . THIS CAUSED POOR VISIBILITY TO THE DRIVER. VEHICLE WAS TAKEN TO DEALER FOR INSPECTION, BUT MECHANIC COULD NOT DUPLICATE THE PROBLEM. *AK
NHTSA ODI #10115184
120 miles · Oct 12, 2004
Air BagsElectrical SystemEngine And Engine CoolingCrashInjury
I HAD PURCHASED A 2002 DODGE CARAVAN SE AND IMMEDIATELY AFTER IT WAS BACK IN THE SHOP FOR REPAIRS. I HEARD A NOISE IN THE WINDOW AND THE DODGE PLACE TOLD ME IT WAS NOTHING NOT TO WORRY ABOUT IT. ALSO I HAVE MADE SEVERAL TRIPS TO THE DODGE PLACE FOR THE BRAKES (REPLACED 6 TIMES ) , SLIDING DOOR DOESN'T STAY LATCHED AND ALWAYS S…
Read full complaint
I HAD PURCHASED A 2002 DODGE CARAVAN SE AND IMMEDIATELY AFTER IT WAS BACK IN THE SHOP FOR REPAIRS. I HEARD A NOISE IN THE WINDOW AND THE DODGE PLACE TOLD ME IT WAS NOTHING NOT TO WORRY ABOUT IT. ALSO I HAVE MADE SEVERAL TRIPS TO THE DODGE PLACE FOR THE BRAKES (REPLACED 6 TIMES ) , SLIDING DOOR DOESN'T STAY LATCHED AND ALWAYS SLIDES AND HITS MY CHILDREN WHILE GETTING IN OR OUT OF THE VEHICLE, THE DRIVERS SIDE SEAT BELT COMES UNDONE FOR NO REASON (IT WONT STAY LATCHED), I HAD A FLAT AND THE TIRE JACK BROKE WHILE JACKING UP THE VAN, I WAS STOPPED AT A RED LIGHT AND ALL OF A SUDDEN MY VAN JUST PROCEEDED TO GO AND I NO CONTROL OTHER THAN RUNNING IN A DITCH TO STOP, THE VAN ALWAYS DRIFTS TO THE RIGHT WHEN DRIVING AND DEALER SAID IT NOT FAULTY THAT'S HOW ITS MADE TO DO, I HAD 7 SETS OF TIRES AND THE DEALERSHIP SAID THEY COULDN'T FIND ANYTHING WRONG WITH THIS VEHICLE , I HAD AN ALIGNMENT DONE 4 TIMES BECAUSE OF THE DRIFTING AND TIRES WEARING OUT SO OFTEN, I HAVE HAD THE BALL BEARINGS REPLACED 2 TIMES, I HAD THE AC RECHARGED WITH FREON 2 TIMES IT JUST WOULDN'T KEEP COOL, THE BACK DEFROSTER SOMETIMES DOESN'T DEFROST MAKING IT IMPOSSIBLE TO SEE WHILE DRIVING, BAD SMELL COMING FROM VAN IT SMELLS LIKE A SKUNK AND IT MAKES IT HARD TO BREATHE. *NM
NHTSA ODI #10095637
Mileage unknown · Jan 15, 2004
EquipmentUnknown Or OtherVisibility
THE FIRST FAILURE WAS THE AIRBAG LIGHT STAYING ON CONTINUELY. I HAD IT REPAIRED A FEW MONTHS AFTER BUYING THE VEHICLE NEW. LESS THAN SIX MONTHS LATER, THE LIGHT STAYED ON AGAIN. WE HAD MOVED TO ASHLAND AND IT WAS REPAIRED THERE. WITHIN A WEEK OF HAVING IT REPAIRED, I TRIED TO USE MY HORN AND IT DID NOT WORK. THEY COULDN'T FIX IT…
Read full complaint
THE FIRST FAILURE WAS THE AIRBAG LIGHT STAYING ON CONTINUELY. I HAD IT REPAIRED A FEW MONTHS AFTER BUYING THE VEHICLE NEW. LESS THAN SIX MONTHS LATER, THE LIGHT STAYED ON AGAIN. WE HAD MOVED TO ASHLAND AND IT WAS REPAIRED THERE. WITHIN A WEEK OF HAVING IT REPAIRED, I TRIED TO USE MY HORN AND IT DID NOT WORK. THEY COULDN'T FIX IT AT MY CONVIENCE, SO I HAD TO WAIT A FEW WEEKS TO GET IT REPAIRS. NOW, MY WINDOWS SOMETIMES GO UP AND DOWN AND SOMETIMES THEY DO NOT. MY VAN IS LESS THAN 2 YEARS OLD AND ALREADY, I HAVE HAD TO BORROW SOMEONES CAR BECAUSE MINE WAS IN THE SHOP. THIS SHOULD NOT HAPPEN WITH A NEW VAN WITH LESS THAN 25,000 MILES ON IT. DEBBIE WAGGONER REDWAG@ALLTEL.NET
NHTSA ODI #10069411
36,202 miles · Nov 18, 2003
Visibility
WHILE DRIVING ON A DIRT ROADS DIRT AND ROCKS SEEPED THROUGH THE VENTILATION SYSTEM INTO THE VEHICLE. *AK
NHTSA ODI #10048121
Mileage unknown · Jul 26, 2002
Visibility
WHILE DRIVING THE REAR SIDE VENT WINDOW EXPLORED IN AN INWARD POISTION .*AK
ON CERTAIN MINI VANS, CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DROP THROUGH VENT HOLES IN THE TOP OF THE RADIO AND RESULT IN A SHORT CIRCUIT THAT SUBSEQUENTLY SENDS DIRECT CURRENT TO THE REAR SPEAKERS.
Consequence & remedy
Consequence: THIS COULD RESULT IN A SPEAKER FIRE.
Remedy: DEALERS WILL ADD A SPECIAL TAPE TO THE TOP OF THE RADIO TO PREVENT THE POTENTIAL OF WATER INTRUSION. THE RECALL BEGAN ON JANUARY 31, 2005. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN MINIVANS EQUIPPED WITH 3.3 OR 3.8L V-6 ENGINE, THE UPPER POWER STEERING COOLER HOSE MAY SPLIT AND CAUSE A FLUID LEAK.
Consequence & remedy
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDER HOOD FIRE.
Remedy: DEALERS WILL REPLACE THE UPPER POWER STEERING COOLER HOSE. THIS RECALL BEGAN ON SEPTEMBER 27, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
Consequence & remedy
Consequence: THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
VEHICLE DESCRIPTION: CERTAIN MINI VANS FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE OWNER MANUALS SUPPLIED WITH THESE VEHICLES DO NOT INDICATE WHICH SEATING POSITIONS ARE EQUIPPED WITH TETHER ANCHORAGES AND CHILD RESTRAINT ANCHORAGE SYSTEMS AS REQUIRED BY THE STANDARD.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
Remedy: OWNERS WILL BE PROVIDED WITH THE NECESSARY CHILD RESTRAINT SYSTEM INFORMATION. OWNER NOTIFICATION IS EXPECTED TO BEGIN OCTOBER 8, 2001. OWNERS WHO DO NOT RECEIVE THE FREE INFORMATION WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Additional source detail variants (3)
Electrical System
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
PE04049 · Speaker Fire In The Rear Of The Vehicle
Opened Jul 7, 2004 · Closed Nov 5, 2004
Status: closed (inferred from source dates) · Electrical System:wiring: Rear Compartment/trunk; Equipment:electrical:radio/tape Deck/cd Etc.
ON JULY 7, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING AN INTERIOR VEHICLE FIRE STARTING IN THE AREA OF THE DRIVER SIDE REAR SPEAKER.DAIMLERCHRYSLER CORPORATION (DCC) INFORMED ODI THAT CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DRIP ONTO THE RADIO AND INTO VENT HOLES ON TOP OF THE RADIO.THIS CAN RESULT IN A SHORT CIRCUIT SENDING DIRECT CURRENT TO THE REAR SPEAKERS AND CAUSE A SPEAKER FIRE.THE CONDITION IS PRESENT ONLY ON SUBJECT VEHICLES EQUIPPED WITH THE BASE RADIO.SUBJECT VEHICLES WITH OTHER OPTION RADIOS CONTAIN CIRCUIT PROTECTION THAT PREVENTS SENDING DIRECT CURRENT TO THE SPEAKERS AND ARE NOT AFFECTED.ALL NINE COMPLAINTS PERTAIN TO VEHICLES WITH THE BASE RADIO.BY LETTER DATED NOVEMBER 1, 2004, DCC NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA# 04V531) COVERING MODEL YEAR 2001-2002 DODGE CARAVAN, GRAND CARAVAN, CHRYSLER VOYAGER, AND TOWN & COUNTRY MODELS WITH BASE RADIO ONLY (EST. 238,000 VEHICLES).DCC DEALERS WILL INSTALL A PROTECTIVE TAPE TO THE TOP OF THE RADIO ASSEMBLY TO PREVENT WATER INTRUSION.THE ACTION TAKEN BY DCC IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Electrical System:wiring: Rear Compartment/trunk
ON JULY 7, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING AN INTERIOR VEHICLE FIRE STARTING IN THE AREA OF THE DRIVER SIDE REAR SPEAKER.DAIMLERCHRYSLER CORPORATION (DCC) INFORMED ODI THAT CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DRIP ONTO THE RADIO AND INTO VENT HOLES ON TOP OF THE RADIO.THIS CAN RESULT IN A SHORT CIRCUIT SENDING DIRECT CURRENT TO THE REAR SPEAKERS AND CAUSE A SPEAKER FIRE.THE CONDITION IS PRESENT ONLY ON SUBJECT VEHICLES EQUIPPED WITH THE BASE RADIO.SUBJECT VEHICLES WITH OTHER OPTION RADIOS CONTAIN CIRCUIT PROTECTION THAT PREVENTS SENDING DIRECT CURRENT TO THE SPEAKERS AND ARE NOT AFFECTED.ALL NINE COMPLAINTS PERTAIN TO VEHICLES WITH THE BASE RADIO.BY LETTER DATED NOVEMBER 1, 2004, DCC NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA# 04V531) COVERING MODEL YEAR 2001-2002 DODGE CARAVAN, GRAND CARAVAN, CHRYSLER VOYAGER, AND TOWN & COUNTRY MODELS WITH BASE RADIO ONLY (EST. 238,000 VEHICLES).DCC DEALERS WILL INSTALL A PROTECTIVE TAPE TO THE TOP OF THE RADIO ASSEMBLY TO PREVENT WATER INTRUSION.THE ACTION TAKEN BY DCC IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Equipment:electrical:radio/tape Deck/cd Etc.
ON JULY 7, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING AN INTERIOR VEHICLE FIRE STARTING IN THE AREA OF THE DRIVER SIDE REAR SPEAKER.DAIMLERCHRYSLER CORPORATION (DCC) INFORMED ODI THAT CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DRIP ONTO THE RADIO AND INTO VENT HOLES ON TOP OF THE RADIO.THIS CAN RESULT IN A SHORT CIRCUIT SENDING DIRECT CURRENT TO THE REAR SPEAKERS AND CAUSE A SPEAKER FIRE.THE CONDITION IS PRESENT ONLY ON SUBJECT VEHICLES EQUIPPED WITH THE BASE RADIO.SUBJECT VEHICLES WITH OTHER OPTION RADIOS CONTAIN CIRCUIT PROTECTION THAT PREVENTS SENDING DIRECT CURRENT TO THE SPEAKERS AND ARE NOT AFFECTED.ALL NINE COMPLAINTS PERTAIN TO VEHICLES WITH THE BASE RADIO.BY LETTER DATED NOVEMBER 1, 2004, DCC NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA# 04V531) COVERING MODEL YEAR 2001-2002 DODGE CARAVAN, GRAND CARAVAN, CHRYSLER VOYAGER, AND TOWN & COUNTRY MODELS WITH BASE RADIO ONLY (EST. 238,000 VEHICLES).DCC DEALERS WILL INSTALL A PROTECTIVE TAPE TO THE TOP OF THE RADIO ASSEMBLY TO PREVENT WATER INTRUSION.THE ACTION TAKEN BY DCC IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE03012 · Power Steering Hose Failure
Opened Apr 9, 2003 · Closed May 29, 2003
Status: closed (inferred from source dates) · Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:power Steering Fluid; Steering:hydraulic Power Assist:pump; Steering:linkages:drag:power Assist System
PLEASE SEE ATTACHED REPORT.
Additional source detail variants (5)
Steering:hydraulic Power Assist:hose, Piping, And Connections
PLEASE SEE ATTACHED REPORT.
Steering:hydraulic Power Assist:power Steering Fluid
PLEASE SEE ATTACHED REPORT.
Steering:hydraulic Power Assist:pump
PLEASE SEE ATTACHED REPORT.
Steering:hydraulic Power Assist System
PLEASE SEE ATTACHED REPORT.
Steering:linkages:drag:power Assist System
PLEASE SEE ATTACHED REPORT.
PE02068 · Fuel Tank Leak
Opened Sep 24, 2002 · Closed Oct 9, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.
2002 Dodge Caravan Problems, Complaints & Recalls | Skip That Year
Illustration