Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
250–25K
3425–50K
3150–75K
1875–100K
14100–150K
13150K+
135 reports with mileage · 122 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Air Bags. Review the 43 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Suspension. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
9 crash reports3 fire reports12 injury reports
What owners actually said
257 reports
Mileage unknown · Feb 28, 2025
Exterior Lighting
There is no incident, however I would like to report a manufacturer problem. Many manufacturers put vehicles on the market with front headlights that are too bright and not aimed properly. See [XXX] There are regulations for the lumens of headlights and system of reflectors, but I assume manufacturers are not be watched for…
Read full complaint
There is no incident, however I would like to report a manufacturer problem. Many manufacturers put vehicles on the market with front headlights that are too bright and not aimed properly. See [XXX] There are regulations for the lumens of headlights and system of reflectors, but I assume manufacturers are not be watched for violations. Where I live, in Sarasota, FL, I am blinded by all the vehicle lights at night because lights appear to be on bright when they aren't. Something is very wrong. I don't think everyone is having aftermarket LED lights installed. I think they are coming from the manufacturers that way. Can you help? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11645503
Mileage unknown · May 26, 2023
Exterior Lighting
.
NHTSA ODI #11524026
213,000 miles · Jun 14, 2019
Fuel/propulsion SystemSteeringWheels
I NEED TO KNOW IT MY VEHICLE HAS ANY RECALLS I'M HAVING SOME MAJOR SAFETY CONCERNS ABOUT IT.
NHTSA ODI #11220203
44,900 miles · Apr 28, 2018
Vehicle Speed Control
AFTER THE ENGINE WARMS UP AND AT SPEEDS AROUND 45-50 THE ACCELERATION STICKS AS IF THE CRUISE CONTROL IS ON. THE ONLY WAY TO STOP IT IS TO PUT THE CAR IN NEUTRAL THEN DRIVE,OR SHUT THE ENGINE OFF. I DISCONNECTED THE SERVO TO THE CRUISE CONTROL TO ELIMINATE THE CRUISE AS THE CAUSE. THE PROBLEM IS INTERMITTENT BUT OCCURS OFTEN.
NHTSA ODI #11090763
200,000 miles · Apr 5, 2018
Fuel/propulsion System
FUEL RAIL IS LEAKING GASOLINE. THERE IS A PRESSURE DAMPER THAT IS ON THE RAIL THAT IS NON SERVICEABLE AND IT IS LEAKING FUEL ONTO RAIL THAT IS CAUSING THE SMELL TO ENTER THE CABIN. DEALER SAYS FUEL RAIL NEEDS TO BE REPLACED TO EFFECT PROPER REPAIR. FUEL LEAKS ANY TIME ENGINE IS RUNNING.
NHTSA ODI #11083356
102,000 miles · Jun 19, 2017
SteeringInjury
TL* THE CONTACT OWNS A 2001 DODGE CARAVAN SPORT. WHILE ATTEMPTING TO MAKE A LEFT TURN, THE STEERING WHEEL SUDDENLY LOCKED AND CAUSING THE STEERING WHEEL TO MAKE A POPPING NOISE. THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE CONTACT HAD TO USE EXCESSIVE FORCE TO MOVE THE STEERING WHEEL. SUDDENLY, THE STEERING WHEEL DID A HARD …
Read full complaint
TL* THE CONTACT OWNS A 2001 DODGE CARAVAN SPORT. WHILE ATTEMPTING TO MAKE A LEFT TURN, THE STEERING WHEEL SUDDENLY LOCKED AND CAUSING THE STEERING WHEEL TO MAKE A POPPING NOISE. THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE CONTACT HAD TO USE EXCESSIVE FORCE TO MOVE THE STEERING WHEEL. SUDDENLY, THE STEERING WHEEL DID A HARD RELEASE AND RETURNED TO NORMAL. THE HARD RELEASE CAUSED THE CONTACT TO RECEIVE INJURIES TO THE HAND, WRIST, AND ARM. MEDICAL ATTENTION WAS NEEDED. THE FAILURE RECURRED. THE CONTACT DID NOT TAKE THE VEHICLE TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE THERE WAS NO RECALL FOR THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 102,000.
NHTSA ODI #11000002
Mileage unknown · Jun 18, 2017
Unknown Or Other
I WAS ROLLING MY DRIVER'S SIDE WINDOW UP (ELECTRIC WINDOW), IT GOT HALF WAY UP AND IT SHATTERED ALL OVER ME. I WAS LITERALLY PICKING GLASS OUT OF MY LEGS FROM THIS WINDOW
NHTSA ODI #10995790
2,500 miles · Feb 1, 2017
SuspensionUnknown Or Other
THE REAR AXELS BEND AROUND BACK WHEELS ALSO FRONT MAKES A NOISE WHEN YOU HIT A BUMP
NHTSA ODI #10948896
Mileage unknown · Sep 29, 2016
Seat BeltsCrashInjury
TL* THE CONTACT OWNED A 2001 DODGE CARAVAN. WHILE DRIVING 70 MPH, THE VEHICLE VEERED OFF THE ROAD AND CRASHED INTO A TREE. THE AIR BAGS DEPLOYED. THE SECOND ROW DRIVER'S SIDE SEAT BELT FRACTURED. THE CONTACT SUSTAINED INJURIES TO THE HEAD, CHEST, AND ANKLE. THE FRONT PASSENGER RECEIVED A SPRAINED ANKLE AND THE OTHER OCCUPANT REC…
Read full complaint
TL* THE CONTACT OWNED A 2001 DODGE CARAVAN. WHILE DRIVING 70 MPH, THE VEHICLE VEERED OFF THE ROAD AND CRASHED INTO A TREE. THE AIR BAGS DEPLOYED. THE SECOND ROW DRIVER'S SIDE SEAT BELT FRACTURED. THE CONTACT SUSTAINED INJURIES TO THE HEAD, CHEST, AND ANKLE. THE FRONT PASSENGER RECEIVED A SPRAINED ANKLE AND THE OTHER OCCUPANT RECEIVED A BROKEN WRIST, BROKEN STERNUM, AND A CRACKED PELVIS/HIP. MEDICAL ATTENTION WAS REQUIRED. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED AND TOWED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE VIN AND FAILURE MILEAGE WERE UNKNOWN.
NHTSA ODI #10910658
Mileage unknown · Dec 4, 2015
Steering
STEERING WHEEL BECOMES SO TIGHT AND CANT EVEN MOVE WHEN EVER THE OUTSIDE TEMPERATURES FALL BELOW 50DEGREES. IT TAKES AT LEAST 15 MIN TO BECOME NORMAL. FUEL LEVELS ARE NORMAL IN MY VAN.
ON CERTAIN MINI VANS, CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DROP THROUGH VENT HOLES IN THE TOP OF THE RADIO AND RESULT IN A SHORT CIRCUIT THAT SUBSEQUENTLY SENDS DIRECT CURRENT TO THE REAR SPEAKERS.
Consequence & remedy
Consequence: THIS COULD RESULT IN A SPEAKER FIRE.
Remedy: DEALERS WILL ADD A SPECIAL TAPE TO THE TOP OF THE RADIO TO PREVENT THE POTENTIAL OF WATER INTRUSION. THE RECALL BEGAN ON JANUARY 31, 2005. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
Consequence & remedy
Consequence: THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
VEHICLE DESCRIPTION: MINIVANS. THE LOWER CONTROL ARM PIVOT BOLT COULD FRACTURE.
Consequence & remedy
Consequence: IF THE BOLT FRACTURES, THE LOWER CONTROL ARM COULD SEPARATE FROM THE CROSSMEMBER, CAUSING A LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL REPLACE THE LEFT AND RIGHT LOWER CONTROL ARM BOLTS AND NUTS. OWNER NOTIFICATION BEGAN APRIL 30, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Additional source detail variants (3)
Electrical System
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
2001 Dodge Caravan Problems, Complaints & Recalls | Skip That Year
Illustration