TL* THE CONTACT OWNS A 2002 DODGE CARAVAN. THE CONTACT STATED THAT THE RADIO WIRES WOULD SHORT CIRCUIT WHENEVER THE RADIO WAS ACTIVATED. THERE WAS A RECALL RELATED TO THE FAILURE UNDER NHTSA CAMPAIGN ID NUMBER 04V531000 (EQUIPMENT). THE VIN WAS NOT INCLUDED IN THE RECALL. IN ADDITION, THE DRIVER'S SIDE EXTERIOR AND INTERIOR SLID…
Read full complaint
TL* THE CONTACT OWNS A 2002 DODGE CARAVAN. THE CONTACT STATED THAT THE RADIO WIRES WOULD SHORT CIRCUIT WHENEVER THE RADIO WAS ACTIVATED. THERE WAS A RECALL RELATED TO THE FAILURE UNDER NHTSA CAMPAIGN ID NUMBER 04V531000 (EQUIPMENT). THE VIN WAS NOT INCLUDED IN THE RECALL. IN ADDITION, THE DRIVER'S SIDE EXTERIOR AND INTERIOR SLIDING DOORS WOULD NOT UNLOCK. THE VEHICLE WAS NOT REPAIRED. THE CONTACT ALSO MENTIONED THAT THE FUEL TANK HOSE WAS REPLACED PREVIOUSLY. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 80,000. *TR
NHTSA ODI #10568723
Mileage unknown · Aug 29, 2011
Equipment
THE RADIO JUST WENT OUT WHILE I WAS DRIVING, IT MADE A LITTLE POP SOUND AND NEVER CAME BACK ON. *TR
NHTSA ODI #10422397
Mileage unknown · Nov 29, 2007
Equipment
AFTER STARTING THE VEHICLE AND PUTTING IT INTO DRIVE, THE VEHICLE SUDDENLY ACCELERATED TO A SPEED OF 45-50 MPH WITHOUT MY HAVING PRESSED THE ACCELERATOR. THE RMP GAUGE WAS FLUCTUATING WILDLY AND THE ENGINE EMITTED A LOUD "REVVING" SOUND. I IMMEDIATELY APPLIED THE BRAKES WHICH REDUCED THE SPEED OF THE VEHICLE TO ONLY APPROX. 25…
Read full complaint
AFTER STARTING THE VEHICLE AND PUTTING IT INTO DRIVE, THE VEHICLE SUDDENLY ACCELERATED TO A SPEED OF 45-50 MPH WITHOUT MY HAVING PRESSED THE ACCELERATOR. THE RMP GAUGE WAS FLUCTUATING WILDLY AND THE ENGINE EMITTED A LOUD "REVVING" SOUND. I IMMEDIATELY APPLIED THE BRAKES WHICH REDUCED THE SPEED OF THE VEHICLE TO ONLY APPROX. 25-35 MPH. IN ORDER TO BRING THE CAR TO A COMPLETE STOP, I HAD TO "STAND" ON THE BRAKES (PRESSING EXTREMELY HARD). AT THIS POINT THE ENGINE STALLED. WHEN MY MECHANIC TEST DROVE THE VEHICLE TO DETERMINE THE PROBLEM, HE, TOO, INDICATED WHAT DIFFICULTY HE HAD "CONTROLLING" THE CAR AND WAS ALMOST IN AN ACCIDENT. THE CAR WAS ULTIMATELY TAKEN TO D'AMBROSIO DODGE IN DOWNINGTOWN, PA FOR REPAIR. THE MECHANIC TOLD ME HE WAS FAMILIAR WITH THIS TYPE OF PROBLEM, INDICATING TO ME I AM NOT THE FIRST PERSON TO HAVE THIS HAPPEN. THIS IS AN EXTREMELY DANGEROUS PROBLEM THAT OCCURRED WITH MY VEHICLE. DODGE SHOULD ISSUE A RECALL FOR THE 2002 CARAVAN SPORT TO ENSURE THAT NO ONE ELSE IS PUT IN DANGER. *TR
NHTSA ODI #10210297
Mileage unknown · Jul 20, 2007
EquipmentSeat Belts
THE REAR SEAT BELTS IN OUR 2002 DODGE CARAVAN HAVE STOPPED FUNCTIONING AGAIN. THEY WERE REPLACED IN FEBRUARY 2003, JANUARY 2007 AND ARE GOING IN TO BE REPLACE AGAIN TODAY JULY 2007. THEY DO NOT ENGAGE WHEN PULLED AND THEY DO NOT RETRACT AFTER USE. *TR
NHTSA ODI #10197020
66,799 miles · Sep 21, 2006
Equipment
DT*: THE CONTACT STATED THE VEHICLE EMITTED A FOGHORN-LIKE SOUND FROM THE AIR CONDITIONING SYSTEM. THIS ONLY OCCURRED WHILE THE AIR CONDITIONING SYSTEM WAS RUNNING ON LOW FAN SPEED. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, HOWEVER THE DEALER WAS UNABLE TO DETERMINE THE PROBLEM.
NHTSA ODI #10168887
129,233 miles · Oct 21, 2005
Equipment
DT: THE CONTACT HAD RECALL REPAIR WORK DONE ON AIR CONDITIONER DRAIN HOSE. AFTER THE DEALER FINISHED THE WORK, THE DEALER CHARGED THE CONTACT $91.00 FOR THE SERVICE. HE HAS BEEN IN CONTACT WITH THE DEALER SEVERAL TIMES IN THE PAST WEEK, AND THEY STATED THEY WOULD BE CALLING HIM BACK, BUT THEY NEVER DID. ALSO, THE DEALERSHIP…
Read full complaint
DT: THE CONTACT HAD RECALL REPAIR WORK DONE ON AIR CONDITIONER DRAIN HOSE. AFTER THE DEALER FINISHED THE WORK, THE DEALER CHARGED THE CONTACT $91.00 FOR THE SERVICE. HE HAS BEEN IN CONTACT WITH THE DEALER SEVERAL TIMES IN THE PAST WEEK, AND THEY STATED THEY WOULD BE CALLING HIM BACK, BUT THEY NEVER DID. ALSO, THE DEALERSHIP TOLD HIM THAT THE SERVICE MANAGER WAS NOT THEIR TO SPEAK WITH, AND THAT WHEN THE MANAGER WAS AVAILABLE HE WILL CALL HIM BACK.*AK
NHTSA ODI #10140441
69,000 miles · Jul 15, 2005
Equipment
DT: 2002 CHRYSLER DODGE MINIVANS ARE PRONE TO LEAKING WATER INTO THE PASSENGER SIDE FOOT WELL AREA WHEN THE AIR CONDITIONER IS OPERATING. THIS PROBLEM HAS HAPPENED FOR THE PAST THREE YEARS, AND HAS BEEN FIXED THREE TIMES BY THE DEALERSHIP. THE CONSUMER HAD TO PAY AFTER THE WARRANTY RAN OUT. THE AIR CONDITIONER COMPRESSOR FAI…
Read full complaint
DT: 2002 CHRYSLER DODGE MINIVANS ARE PRONE TO LEAKING WATER INTO THE PASSENGER SIDE FOOT WELL AREA WHEN THE AIR CONDITIONER IS OPERATING. THIS PROBLEM HAS HAPPENED FOR THE PAST THREE YEARS, AND HAS BEEN FIXED THREE TIMES BY THE DEALERSHIP. THE CONSUMER HAD TO PAY AFTER THE WARRANTY RAN OUT. THE AIR CONDITIONER COMPRESSOR FAILED PREMATURELY. THE CONSUMER HAS HAD THE COMPRESSOR REPLACED, THE WARRANTY PAID FOR THAT. THE COMPRESSOR FAILED IN JUNE OF 2005. THE VEHICLE HAS 69,000 MILES. THE LEAKING DEPENDED ON HOW MUCH THE AIR CONDITIONER WAS USED. *AK *SC *JB
NHTSA ODI #10126671
20,000 miles · Feb 24, 2005
Equipment
SAFETY RECALL-RADIO VENT SLOTS, D48 ON DODGE CARAVAN IS AN UNSATISFACTORY FIX. PLACING TAPE OVER THE RADIO VENTS WILL CAUSE THE RADIO TO OVERHEAT IN FLORIDA! A FIRE IS POSSIBLE. *NM
NHTSA ODI #10112110
Mileage unknown · Dec 3, 2004
EquipmentSteering
THE CONSUMER HEARD A SHUTTERING NOISE COMING FROM THE FRONT RIGHT TIRE WHEN TURNING THE STEERING WHEEL TO THE RIGHT. THE RACK AND PINION WAS REPLACED BUT THE PROBLEM STILL EXISTED. *TC THE CONSUMER WAS TOLD THE POWER STEERING WAS THE PROBLEM AND HAD ALREADY BEEN REPLACED. ALSO WHEN THE A/C WAS TURNED ON, IT MADE A LOUD NOIS…
Read full complaint
THE CONSUMER HEARD A SHUTTERING NOISE COMING FROM THE FRONT RIGHT TIRE WHEN TURNING THE STEERING WHEEL TO THE RIGHT. THE RACK AND PINION WAS REPLACED BUT THE PROBLEM STILL EXISTED. *TC THE CONSUMER WAS TOLD THE POWER STEERING WAS THE PROBLEM AND HAD ALREADY BEEN REPLACED. ALSO WHEN THE A/C WAS TURNED ON, IT MADE A LOUD NOISE. *SC *JB
NHTSA ODI #10103950
49,426 miles · May 18, 2004
Equipment
THE A/C UNIT LEAKED DOWN THE FIREWALL ON THE INSIDE PASSENGER SIDE OF MY CARAVAN AND RUINED THE CARPET. IT WAS REPAIRED IN FEB. 2003 UNDER WARRANTY. IN MARCH 2004 WE NOTICED MOLD ON THE FLOOR . THE SAME THING HAD HAPPENED AGAIN. CHRYSTLER KNOWS THAT THEY HAVE A PROBLEM WITH THIS BECAUSE THEY PUT OUT A TBS 24-008-02 TO FIX IT. PR…
Read full complaint
THE A/C UNIT LEAKED DOWN THE FIREWALL ON THE INSIDE PASSENGER SIDE OF MY CARAVAN AND RUINED THE CARPET. IT WAS REPAIRED IN FEB. 2003 UNDER WARRANTY. IN MARCH 2004 WE NOTICED MOLD ON THE FLOOR . THE SAME THING HAD HAPPENED AGAIN. CHRYSTLER KNOWS THAT THEY HAVE A PROBLEM WITH THIS BECAUSE THEY PUT OUT A TBS 24-008-02 TO FIX IT. PROBLEM IS IT DOESN'T ALWAYS WORK (ACCORDING TO SERVICE REPS.) WE ARE SUEING THEM TO FIX IT AGAIN. *AK
ON CERTAIN MINI VANS, CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DROP THROUGH VENT HOLES IN THE TOP OF THE RADIO AND RESULT IN A SHORT CIRCUIT THAT SUBSEQUENTLY SENDS DIRECT CURRENT TO THE REAR SPEAKERS.
Consequence & remedy
Consequence: THIS COULD RESULT IN A SPEAKER FIRE.
Remedy: DEALERS WILL ADD A SPECIAL TAPE TO THE TOP OF THE RADIO TO PREVENT THE POTENTIAL OF WATER INTRUSION. THE RECALL BEGAN ON JANUARY 31, 2005. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN MINIVANS EQUIPPED WITH 3.3 OR 3.8L V-6 ENGINE, THE UPPER POWER STEERING COOLER HOSE MAY SPLIT AND CAUSE A FLUID LEAK.
Consequence & remedy
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDER HOOD FIRE.
Remedy: DEALERS WILL REPLACE THE UPPER POWER STEERING COOLER HOSE. THIS RECALL BEGAN ON SEPTEMBER 27, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
Consequence & remedy
Consequence: THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
VEHICLE DESCRIPTION: CERTAIN MINI VANS FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE OWNER MANUALS SUPPLIED WITH THESE VEHICLES DO NOT INDICATE WHICH SEATING POSITIONS ARE EQUIPPED WITH TETHER ANCHORAGES AND CHILD RESTRAINT ANCHORAGE SYSTEMS AS REQUIRED BY THE STANDARD.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
Remedy: OWNERS WILL BE PROVIDED WITH THE NECESSARY CHILD RESTRAINT SYSTEM INFORMATION. OWNER NOTIFICATION IS EXPECTED TO BEGIN OCTOBER 8, 2001. OWNERS WHO DO NOT RECEIVE THE FREE INFORMATION WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Additional source detail variants (3)
Electrical System
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
PE04049 · Speaker Fire In The Rear Of The Vehicle
Opened Jul 7, 2004 · Closed Nov 5, 2004
Status: closed (inferred from source dates) · Electrical System:wiring: Rear Compartment/trunk; Equipment:electrical:radio/tape Deck/cd Etc.
ON JULY 7, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING AN INTERIOR VEHICLE FIRE STARTING IN THE AREA OF THE DRIVER SIDE REAR SPEAKER.DAIMLERCHRYSLER CORPORATION (DCC) INFORMED ODI THAT CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DRIP ONTO THE RADIO AND INTO VENT HOLES ON TOP OF THE RADIO.THIS CAN RESULT IN A SHORT CIRCUIT SENDING DIRECT CURRENT TO THE REAR SPEAKERS AND CAUSE A SPEAKER FIRE.THE CONDITION IS PRESENT ONLY ON SUBJECT VEHICLES EQUIPPED WITH THE BASE RADIO.SUBJECT VEHICLES WITH OTHER OPTION RADIOS CONTAIN CIRCUIT PROTECTION THAT PREVENTS SENDING DIRECT CURRENT TO THE SPEAKERS AND ARE NOT AFFECTED.ALL NINE COMPLAINTS PERTAIN TO VEHICLES WITH THE BASE RADIO.BY LETTER DATED NOVEMBER 1, 2004, DCC NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA# 04V531) COVERING MODEL YEAR 2001-2002 DODGE CARAVAN, GRAND CARAVAN, CHRYSLER VOYAGER, AND TOWN & COUNTRY MODELS WITH BASE RADIO ONLY (EST. 238,000 VEHICLES).DCC DEALERS WILL INSTALL A PROTECTIVE TAPE TO THE TOP OF THE RADIO ASSEMBLY TO PREVENT WATER INTRUSION.THE ACTION TAKEN BY DCC IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Electrical System:wiring: Rear Compartment/trunk
ON JULY 7, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING AN INTERIOR VEHICLE FIRE STARTING IN THE AREA OF THE DRIVER SIDE REAR SPEAKER.DAIMLERCHRYSLER CORPORATION (DCC) INFORMED ODI THAT CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DRIP ONTO THE RADIO AND INTO VENT HOLES ON TOP OF THE RADIO.THIS CAN RESULT IN A SHORT CIRCUIT SENDING DIRECT CURRENT TO THE REAR SPEAKERS AND CAUSE A SPEAKER FIRE.THE CONDITION IS PRESENT ONLY ON SUBJECT VEHICLES EQUIPPED WITH THE BASE RADIO.SUBJECT VEHICLES WITH OTHER OPTION RADIOS CONTAIN CIRCUIT PROTECTION THAT PREVENTS SENDING DIRECT CURRENT TO THE SPEAKERS AND ARE NOT AFFECTED.ALL NINE COMPLAINTS PERTAIN TO VEHICLES WITH THE BASE RADIO.BY LETTER DATED NOVEMBER 1, 2004, DCC NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA# 04V531) COVERING MODEL YEAR 2001-2002 DODGE CARAVAN, GRAND CARAVAN, CHRYSLER VOYAGER, AND TOWN & COUNTRY MODELS WITH BASE RADIO ONLY (EST. 238,000 VEHICLES).DCC DEALERS WILL INSTALL A PROTECTIVE TAPE TO THE TOP OF THE RADIO ASSEMBLY TO PREVENT WATER INTRUSION.THE ACTION TAKEN BY DCC IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Equipment:electrical:radio/tape Deck/cd Etc.
ON JULY 7, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING AN INTERIOR VEHICLE FIRE STARTING IN THE AREA OF THE DRIVER SIDE REAR SPEAKER.DAIMLERCHRYSLER CORPORATION (DCC) INFORMED ODI THAT CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DRIP ONTO THE RADIO AND INTO VENT HOLES ON TOP OF THE RADIO.THIS CAN RESULT IN A SHORT CIRCUIT SENDING DIRECT CURRENT TO THE REAR SPEAKERS AND CAUSE A SPEAKER FIRE.THE CONDITION IS PRESENT ONLY ON SUBJECT VEHICLES EQUIPPED WITH THE BASE RADIO.SUBJECT VEHICLES WITH OTHER OPTION RADIOS CONTAIN CIRCUIT PROTECTION THAT PREVENTS SENDING DIRECT CURRENT TO THE SPEAKERS AND ARE NOT AFFECTED.ALL NINE COMPLAINTS PERTAIN TO VEHICLES WITH THE BASE RADIO.BY LETTER DATED NOVEMBER 1, 2004, DCC NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA# 04V531) COVERING MODEL YEAR 2001-2002 DODGE CARAVAN, GRAND CARAVAN, CHRYSLER VOYAGER, AND TOWN & COUNTRY MODELS WITH BASE RADIO ONLY (EST. 238,000 VEHICLES).DCC DEALERS WILL INSTALL A PROTECTIVE TAPE TO THE TOP OF THE RADIO ASSEMBLY TO PREVENT WATER INTRUSION.THE ACTION TAKEN BY DCC IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE03012 · Power Steering Hose Failure
Opened Apr 9, 2003 · Closed May 29, 2003
Status: closed (inferred from source dates) · Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:power Steering Fluid; Steering:hydraulic Power Assist:pump; Steering:linkages:drag:power Assist System
PLEASE SEE ATTACHED REPORT.
Additional source detail variants (5)
Steering:hydraulic Power Assist:hose, Piping, And Connections
PLEASE SEE ATTACHED REPORT.
Steering:hydraulic Power Assist:power Steering Fluid
PLEASE SEE ATTACHED REPORT.
Steering:hydraulic Power Assist:pump
PLEASE SEE ATTACHED REPORT.
Steering:hydraulic Power Assist System
PLEASE SEE ATTACHED REPORT.
Steering:linkages:drag:power Assist System
PLEASE SEE ATTACHED REPORT.
PE02068 · Fuel Tank Leak
Opened Sep 24, 2002 · Closed Oct 9, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.
2002 Dodge Caravan Problems, Complaints & Recalls | Skip That Year
Illustration