IllustrationAIR BAG LIGHT INTERMITTENTLY COMES ON. *NM
2002 Dodge Caravan
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2002 Dodge Caravan do not stand out strongly from the model-year median of 182.
About this comparison →How this year compares
Owner complaints by model year
Compare all Caravan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
310–25K
4025–50K
4350–75K
1975–100K
16100–150K
6150K+
155 reports with mileage · 90 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 59 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 36 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 33 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
13 crash reports11 fire reports6 injury reports
Air Bags complaints
59 reportsDT*: THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS, THE AIRBAG LIGHT ILLUMINATED. THE VEHICLE WAS INSPECTED BY A DEALER, WHO DETERMINED THE AIRBAG HOUSING MECHANISMS NEEDED TO BE REPLACED. AFTERWARDS, THE PROBLEM PERSISTED. THE VEHICLE WAS RETURNED TO THE DEALER WHO DETERMINED THE FRONT AIRBAG CLOCK SPRINGS NEEDED TO BE REP…
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS, THE AIRBAG LIGHT ILLUMINATED. THE VEHICLE WAS INSPECTED BY A DEALER, WHO DETERMINED THE AIRBAG HOUSING MECHANISMS NEEDED TO BE REPLACED. AFTERWARDS, THE PROBLEM PERSISTED. THE VEHICLE WAS RETURNED TO THE DEALER WHO DETERMINED THE FRONT AIRBAG CLOCK SPRINGS NEEDED TO BE REPLACED. AFTER THE REPLACEMENT, THE AIRBAG LIGHT ILLUMINATED AGAIN. THE VEHICLE WAS INSPECTED BY A DEALER, WHO DETERMINED WHILE THE AIRBAG LIGHT WAS ILLUMINATED; THE AIRBAGS WERE INOPERATIVE, AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS ALERTED.
AIR BAG LIGHT TURNED ON. TOOK IT TO CHRYSLER/DODGE DEALER TO BE EXAMINED, THEY FOUND THE CLOCKSPRING ASSEMBLY NEEDED REPLACING. CLOCKSPRING ASSEMBLY WAS REPLACED FOR A COST OF $250.00. *NM
AIR BAG LIGHT STAYS ON. DEALER STATES CLOCK SPRING IS DEFECTIVE AND CHRYSLER DOES NOT DEEM THIS TO BE SAFETY HAZARD,WARRANTY OR RECALL ISSUE. THEREFORE WILL NOT PAY TO FIX PROBLEM. PARTS FOR FIX UNAVAILABLE AND REPAIR IS EXPENSIVE. *NM
AIR BAG LIGHT WOULD COME ON, GO OFF, COME ON, WHEN DRIVING. TOOK DODGE CARAVAN INTO DEALER SERVICE DEPT. THEY RAN A AIRBAG SYSTEM DIAGNOSIS AND DETERMINED AIR BAG WOULD NOT WORK, THEY SAID THEY HAD NEVER SEEN AN AIRBAG DEFECT. DEALER CALLED DODGE REPRESENTATIVE AND REPRESENTATIVE DENIED THE REQUEST TO CORRECT (PAY FOR) THIS PR…
Read full complaint
AIR BAG LIGHT WOULD COME ON, GO OFF, COME ON, WHEN DRIVING. TOOK DODGE CARAVAN INTO DEALER SERVICE DEPT. THEY RAN A AIRBAG SYSTEM DIAGNOSIS AND DETERMINED AIR BAG WOULD NOT WORK, THEY SAID THEY HAD NEVER SEEN AN AIRBAG DEFECT. DEALER CALLED DODGE REPRESENTATIVE AND REPRESENTATIVE DENIED THE REQUEST TO CORRECT (PAY FOR) THIS PROBLEM. THIS VEHICLE HAS NEVER BEEN IN AN ACCIDENT. THIS SHOULD BE CONSIDERED AS A SERIOUS DEFECT AS IF AN ACCIDENT WOULD HAVE OCCURRED THE AIRBAG WOULD NOT HAVE WORKED/INFLATED. *JB
DT*: THE CONTACT STATED WHILE DRIVING 50 MPH ON NORMAL ROAD CONDITIONS THE AIR BAG LIGHT ILLUMINATED AS AN ALERT THAT AIR BAGS SENSORS WERE NOT ACTIVATED. THE VEHICLE HAS BEEN TAKEN TO THE DEALERSHIP EIGHT TIMES. THE CONTACT EXPRESSED CONCERN THAT LEMON LAWS DO NOT APPLY WHEN THE PURCHASE TRANSACTION WAS MORE THAN TWO YEARS O…
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING 50 MPH ON NORMAL ROAD CONDITIONS THE AIR BAG LIGHT ILLUMINATED AS AN ALERT THAT AIR BAGS SENSORS WERE NOT ACTIVATED. THE VEHICLE HAS BEEN TAKEN TO THE DEALERSHIP EIGHT TIMES. THE CONTACT EXPRESSED CONCERN THAT LEMON LAWS DO NOT APPLY WHEN THE PURCHASE TRANSACTION WAS MORE THAN TWO YEARS OLD EVENTHOUGH THE VEHICLE HAS ONLY 50.000 MILES
DURING NORMAL DRIVING OPERATIONS THE AIRBAG WARNING LIGHT WOULD INTERMITTENTLY COME ON. NOW IT COMES ON AT THE START OF THE ENGINE, AND DOES NOT TURN OFF. IT APPEARS THAT THIS IS THE SAME CLOCKSPRING PROBLEM AS WAS RECALLED EARLIER. *NM
THE AIR BAG LIGHT ON MY 2002 DODGE CARAVAN WENT ON. THEN STEERING WHEEL STARTED TO MAKE CLICKING NOISE WHEN TURNING CORNERS. THEN DIRECTIONAL INDICATORS WOULD NOT TURN OFF AFTER MAKING A TURN. FINALLY, I ALMOST GOT INTO AN ACCIDENT BECAUSE MY STEERING WHEEL LOCKED AND I COULD NOT TURN A CORNER. I FORCED IT AND IT DID TURN. I WIL…
Read full complaint
THE AIR BAG LIGHT ON MY 2002 DODGE CARAVAN WENT ON. THEN STEERING WHEEL STARTED TO MAKE CLICKING NOISE WHEN TURNING CORNERS. THEN DIRECTIONAL INDICATORS WOULD NOT TURN OFF AFTER MAKING A TURN. FINALLY, I ALMOST GOT INTO AN ACCIDENT BECAUSE MY STEERING WHEEL LOCKED AND I COULD NOT TURN A CORNER. I FORCED IT AND IT DID TURN. I WILL NOT DRIVE THIS VEHICLE AGAIN. I CALLED A CHRYSLER DEALER AND THEY TOLD ME IT SOUNDS LIKE THE CLOCKSPRING. THE MILEAGE ON THIS VEHICLE IS ONLY 33,000 MILES. SINCE IT IS OUT OF WARRANTY I WOULD HAVE TO PAY FOR IT BECAUSE THERE HAVE NOT BEEN ANY RECALLS FOR THIS AS OF YET. THIS IS THE SECOND DODGE CARAVAN THAT I HAVE OWNED. THE FIRST ONE WAS RECALLED FOR THE CLOCKSPRING ALSO. I KNOW THAT CHRYSLER HAS A HISTORY OF BAD CLOCKSPRINGS. ARE THEY WAITING FOR ENOUGH ACCIDENTS TO HAPPEN? I WANT CHRYSLER TO FIX THIS PROBLEM FOR ME, FREE OF CHARGE. THIS IS NOT AN ABUSED VEHICLE. I TAKE CARE OF EVERYTHING I OWN. HOW CAN THEY MAKE SUCH POOR PARTS? *JB
I BOUGHT A DODGE CARAVAN 2002. OUT OF NOWHERE THE AIRBAG LIGHT COMES ON WHEN I TURN THE STEERING WHEEL. I TOOK IT TO A DODGE DEALERSHIP TO HAVE IT CHECKED BUT BECAUSE MY CARAVAN DIDN'T FALL INTO THE CATEGORY OF THAT RECALL IT WAS NOT TAKEN CARE OF. THE PERSON AT THE SERVICE DESK DID SAY THAT MANY CARAVANS HAVE HAD THAT PROBLEM…
Read full complaint
I BOUGHT A DODGE CARAVAN 2002. OUT OF NOWHERE THE AIRBAG LIGHT COMES ON WHEN I TURN THE STEERING WHEEL. I TOOK IT TO A DODGE DEALERSHIP TO HAVE IT CHECKED BUT BECAUSE MY CARAVAN DIDN'T FALL INTO THE CATEGORY OF THAT RECALL IT WAS NOT TAKEN CARE OF. THE PERSON AT THE SERVICE DESK DID SAY THAT MANY CARAVANS HAVE HAD THAT PROBLEM. SO I CALLED CHRYSLER CORPORATION AND THEY STATED THAT BECAUSE THE CAR HAS 80,000+ MILES ON IT THEY WILL NOT DO ANYTHING BECAUSE IT IS OUT OF WARRANTY. EVEN THOUGH THE DEFECT WAS THERE BEFORE. THIS ISN'T FAIR AND I THINK THAT IT SHOULD BE TAKEN CARE OF BY CHRYSLER BECAUSE THEY SOLD THE DEFECTIVE VAN TO BEGIN WITH. *JB
DT*: THE CONTACT STATED THE AIR BAG LIGHT CONTINUED TO ILLUMINATE WITHOUT PREVIOUS PROBLEMS WITH THE AIR BAGS. THE VEHICLE HAS NOT BEEN SEEN BY A DEALER OR REPAIR SHOP. *AK UPDATED 2/16/2006 - *NM
Official recalls
404V531000 · Equipment:electrical:radio/tape Deck/cd Etc.
Nov 2, 2004
ON CERTAIN MINI VANS, CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DROP THROUGH VENT HOLES IN THE TOP OF THE RADIO AND RESULT IN A SHORT CIRCUIT THAT SUBSEQUENTLY SENDS DIRECT CURRENT TO THE REAR SPEAKERS.
Consequence & remedy
Consequence: THIS COULD RESULT IN A SPEAKER FIRE.
Remedy: DEALERS WILL ADD A SPECIAL TAPE TO THE TOP OF THE RADIO TO PREVENT THE POTENTIAL OF WATER INTRUSION. THE RECALL BEGAN ON JANUARY 31, 2005. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
04V386000 · Steering:hydraulic Power Assist:hose, Piping, And Connections
Aug 5, 2004
ON CERTAIN MINIVANS EQUIPPED WITH 3.3 OR 3.8L V-6 ENGINE, THE UPPER POWER STEERING COOLER HOSE MAY SPLIT AND CAUSE A FLUID LEAK.
Consequence & remedy
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDER HOOD FIRE.
Remedy: DEALERS WILL REPLACE THE UPPER POWER STEERING COOLER HOSE. THIS RECALL BEGAN ON SEPTEMBER 27, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
03V094000 · Structure
Mar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
Consequence & remedy
Consequence: THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
01V310000 · Child Seat
Oct 4, 2001
VEHICLE DESCRIPTION: CERTAIN MINI VANS FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE OWNER MANUALS SUPPLIED WITH THESE VEHICLES DO NOT INDICATE WHICH SEATING POSITIONS ARE EQUIPPED WITH TETHER ANCHORAGES AND CHILD RESTRAINT ANCHORAGE SYSTEMS AS REQUIRED BY THE STANDARD.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
Remedy: OWNERS WILL BE PROVIDED WITH THE NECESSARY CHILD RESTRAINT SYSTEM INFORMATION. OWNER NOTIFICATION IS EXPECTED TO BEGIN OCTOBER 8, 2001. OWNERS WHO DO NOT RECEIVE THE FREE INFORMATION WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA05009 · Headlight Malfunction
Opened Jun 1, 2005 · Closed May 2, 2006
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Additional source detail variants (3)
Electrical System
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
PE05004 · Headlight Malfunction
Opened Feb 2, 2005 · Closed Jun 1, 2005
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
PE04049 · Speaker Fire In The Rear Of The Vehicle
Opened Jul 7, 2004 · Closed Nov 5, 2004
Status: closed (inferred from source dates) · Electrical System:wiring: Rear Compartment/trunk; Equipment:electrical:radio/tape Deck/cd Etc.
ON JULY 7, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING AN INTERIOR VEHICLE FIRE STARTING IN THE AREA OF THE DRIVER SIDE REAR SPEAKER.DAIMLERCHRYSLER CORPORATION (DCC) INFORMED ODI THAT CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DRIP ONTO THE RADIO AND INTO VENT HOLES ON TOP OF THE RADIO.THIS CAN RESULT IN A SHORT CIRCUIT SENDING DIRECT CURRENT TO THE REAR SPEAKERS AND CAUSE A SPEAKER FIRE.THE CONDITION IS PRESENT ONLY ON SUBJECT VEHICLES EQUIPPED WITH THE BASE RADIO.SUBJECT VEHICLES WITH OTHER OPTION RADIOS CONTAIN CIRCUIT PROTECTION THAT PREVENTS SENDING DIRECT CURRENT TO THE SPEAKERS AND ARE NOT AFFECTED.ALL NINE COMPLAINTS PERTAIN TO VEHICLES WITH THE BASE RADIO.BY LETTER DATED NOVEMBER 1, 2004, DCC NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA# 04V531) COVERING MODEL YEAR 2001-2002 DODGE CARAVAN, GRAND CARAVAN, CHRYSLER VOYAGER, AND TOWN & COUNTRY MODELS WITH BASE RADIO ONLY (EST. 238,000 VEHICLES).DCC DEALERS WILL INSTALL A PROTECTIVE TAPE TO THE TOP OF THE RADIO ASSEMBLY TO PREVENT WATER INTRUSION.THE ACTION TAKEN BY DCC IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Electrical System:wiring: Rear Compartment/trunk
ON JULY 7, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING AN INTERIOR VEHICLE FIRE STARTING IN THE AREA OF THE DRIVER SIDE REAR SPEAKER.DAIMLERCHRYSLER CORPORATION (DCC) INFORMED ODI THAT CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DRIP ONTO THE RADIO AND INTO VENT HOLES ON TOP OF THE RADIO.THIS CAN RESULT IN A SHORT CIRCUIT SENDING DIRECT CURRENT TO THE REAR SPEAKERS AND CAUSE A SPEAKER FIRE.THE CONDITION IS PRESENT ONLY ON SUBJECT VEHICLES EQUIPPED WITH THE BASE RADIO.SUBJECT VEHICLES WITH OTHER OPTION RADIOS CONTAIN CIRCUIT PROTECTION THAT PREVENTS SENDING DIRECT CURRENT TO THE SPEAKERS AND ARE NOT AFFECTED.ALL NINE COMPLAINTS PERTAIN TO VEHICLES WITH THE BASE RADIO.BY LETTER DATED NOVEMBER 1, 2004, DCC NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA# 04V531) COVERING MODEL YEAR 2001-2002 DODGE CARAVAN, GRAND CARAVAN, CHRYSLER VOYAGER, AND TOWN & COUNTRY MODELS WITH BASE RADIO ONLY (EST. 238,000 VEHICLES).DCC DEALERS WILL INSTALL A PROTECTIVE TAPE TO THE TOP OF THE RADIO ASSEMBLY TO PREVENT WATER INTRUSION.THE ACTION TAKEN BY DCC IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Equipment:electrical:radio/tape Deck/cd Etc.
ON JULY 7, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING AN INTERIOR VEHICLE FIRE STARTING IN THE AREA OF THE DRIVER SIDE REAR SPEAKER.DAIMLERCHRYSLER CORPORATION (DCC) INFORMED ODI THAT CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DRIP ONTO THE RADIO AND INTO VENT HOLES ON TOP OF THE RADIO.THIS CAN RESULT IN A SHORT CIRCUIT SENDING DIRECT CURRENT TO THE REAR SPEAKERS AND CAUSE A SPEAKER FIRE.THE CONDITION IS PRESENT ONLY ON SUBJECT VEHICLES EQUIPPED WITH THE BASE RADIO.SUBJECT VEHICLES WITH OTHER OPTION RADIOS CONTAIN CIRCUIT PROTECTION THAT PREVENTS SENDING DIRECT CURRENT TO THE SPEAKERS AND ARE NOT AFFECTED.ALL NINE COMPLAINTS PERTAIN TO VEHICLES WITH THE BASE RADIO.BY LETTER DATED NOVEMBER 1, 2004, DCC NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA# 04V531) COVERING MODEL YEAR 2001-2002 DODGE CARAVAN, GRAND CARAVAN, CHRYSLER VOYAGER, AND TOWN & COUNTRY MODELS WITH BASE RADIO ONLY (EST. 238,000 VEHICLES).DCC DEALERS WILL INSTALL A PROTECTIVE TAPE TO THE TOP OF THE RADIO ASSEMBLY TO PREVENT WATER INTRUSION.THE ACTION TAKEN BY DCC IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE03012 · Power Steering Hose Failure
Opened Apr 9, 2003 · Closed May 29, 2003
Status: closed (inferred from source dates) · Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:power Steering Fluid; Steering:hydraulic Power Assist:pump; Steering:linkages:drag:power Assist System
PLEASE SEE ATTACHED REPORT.
Additional source detail variants (5)
Steering:hydraulic Power Assist:hose, Piping, And Connections
PLEASE SEE ATTACHED REPORT.
Steering:hydraulic Power Assist:power Steering Fluid
PLEASE SEE ATTACHED REPORT.
Steering:hydraulic Power Assist:pump
PLEASE SEE ATTACHED REPORT.
Steering:hydraulic Power Assist System
PLEASE SEE ATTACHED REPORT.
Steering:linkages:drag:power Assist System
PLEASE SEE ATTACHED REPORT.
PE02068 · Fuel Tank Leak
Opened Sep 24, 2002 · Closed Oct 9, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.