NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
31 reportsClear category filter94,925 miles · Jul 23, 2012
Electrical SystemEngine And Engine Cooling
DRIVING VEHICLE AT APPROPRIATE SPEED IN TRAFFIC, NOTICED A/C WAS BLOWING WARM AIR, SMELL OF SOMETHING BURNING AND SMOKE UNDER HOOD FROM PASSENGER SIDE. IMMEDIATELY TURNED OFF AIR AND STOPPED VEHICLE AS SOON AS IT WAS SAFE TO DO SO. UPON OPENING THE HOOD FOUND SMOKE COMING FROM RIGHT FRONT ENGINE BAY AREA AROUND ALTERNATOR AND A/…
Read full complaint
DRIVING VEHICLE AT APPROPRIATE SPEED IN TRAFFIC, NOTICED A/C WAS BLOWING WARM AIR, SMELL OF SOMETHING BURNING AND SMOKE UNDER HOOD FROM PASSENGER SIDE. IMMEDIATELY TURNED OFF AIR AND STOPPED VEHICLE AS SOON AS IT WAS SAFE TO DO SO. UPON OPENING THE HOOD FOUND SMOKE COMING FROM RIGHT FRONT ENGINE BAY AREA AROUND ALTERNATOR AND A/C COMPRESSOR. ALLOWED ENGINE TO VENTILATE AND COOL, RESTARTED VEHICLE BUT WITH HVAC SYSTEM OFF AND DROVE TO THE NEAREST REPAIR SHOP WHERE THE MECHANIC CHECKED THE VEHICLE. MECHANIC CHANGED THE ENGINE OIL AND RECOMMENDED TO CHARGE THE A/C SYSTEM WITH REFRIGERANT. OTHER MECHANICS SUGGESTED TAKING VEHICLE TO A/C REPAIR SHOP. INFORMED THAT T&C VEHICLES PRONE TO HAVE A/C COMPRESSOR ISSUES AND KNOWN DEFECT. NEVER RECEIVED RECALL NOTICE OR OFFER BY CHRYSLER TO HAVE KNOWN DEFECT CORRECTED. *TR
NHTSA ODI #10467158
68,000 miles · Jul 6, 2011
Electrical SystemEngine And Engine CoolingPower Train
TL* THE CONTACT OWNS A 2002 CHRYSLER TOWN AND COUNTRY. WHILE THE CONTACT WAS AT DRIVING VARIOUS SPEEDS THE ENGINE STALLED WITHOUT PRIOR WARNING. THE ENGINE RESTARTED AND THE CONTACT RESUMED NORMALLY. THE FAILURE RECURRED SPORADICALLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THEY WERE UNABLE TO LOCATE THE PROBLEM. TH…
Read full complaint
TL* THE CONTACT OWNS A 2002 CHRYSLER TOWN AND COUNTRY. WHILE THE CONTACT WAS AT DRIVING VARIOUS SPEEDS THE ENGINE STALLED WITHOUT PRIOR WARNING. THE ENGINE RESTARTED AND THE CONTACT RESUMED NORMALLY. THE FAILURE RECURRED SPORADICALLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THEY WERE UNABLE TO LOCATE THE PROBLEM. THE MANUFACTURER WAS MADE AWARE OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 68,000. UPDATED 8/29/11 *CN THE CONSUMER ALSO STATED THE VEHICLE HAD ELECTRICAL PROBLEMS AND THE PCM FAILED. UPDATED 10/05/11
NHTSA ODI #10410735
75,600 miles · Mar 2, 2011
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2002 CHRYSLER TOWN AND COUNTRY. THE CONTACT WAS DRIVING APPROXIMATELY 25 MPH WHEN THE POWER STEERING FAILED WITHOUT WARNING. HE THEN PULLED OVER TO INSPECT THE VEHICLE AND DISCOVERED THAT THE TIMING CHAIN ATTACHMENT WAS FRACTURED AND HAD CAUSED THE FAILURE. THE VEHICLE WAS THEN TOWED TO A DEALER WHERE THEY…
Read full complaint
TL* THE CONTACT OWNS A 2002 CHRYSLER TOWN AND COUNTRY. THE CONTACT WAS DRIVING APPROXIMATELY 25 MPH WHEN THE POWER STEERING FAILED WITHOUT WARNING. HE THEN PULLED OVER TO INSPECT THE VEHICLE AND DISCOVERED THAT THE TIMING CHAIN ATTACHMENT WAS FRACTURED AND HAD CAUSED THE FAILURE. THE VEHICLE WAS THEN TOWED TO A DEALER WHERE THEY ADVISED HIM THAT A BOLT WAS NEVER ATTACHED TO THE TIMING CHAIN AND BECAUSE OF THE STRESS ON THE COMPONENT, THE TIMING CHAIN FRACTURED. THE DEALER REPAIRED THE TIMING CHAIN CASKET AND GASKETS. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 75,600.
NHTSA ODI #10386212
57,000 miles · Jul 9, 2009
Engine And Engine Cooling
I HAD THE SAME PROBLEM WITH THE ENGINE LIGHT COMING ON. I WAS ALSO TOLD THAT BATTERY ACID WAS LEAKING ON THE WIRING HARNESS THAT CAUSE THE PROBLEM. ALSO CHRYSLER WAS AWARE OF THIS PROBLEM AND DID NOT HAVE A RECALL OR LET OWNERS KNOW.. THEY JUST REDESIGNED NEWER MODEL TO CORRECT THIS PROBLEM AT THE MERCY OF THEIR DEALERS TO CHA…
Read full complaint
I HAD THE SAME PROBLEM WITH THE ENGINE LIGHT COMING ON. I WAS ALSO TOLD THAT BATTERY ACID WAS LEAKING ON THE WIRING HARNESS THAT CAUSE THE PROBLEM. ALSO CHRYSLER WAS AWARE OF THIS PROBLEM AND DID NOT HAVE A RECALL OR LET OWNERS KNOW.. THEY JUST REDESIGNED NEWER MODEL TO CORRECT THIS PROBLEM AT THE MERCY OF THEIR DEALERS TO CHARGE THOUSANDS OF DOLLARS TO MAKE REPAIRS. *TR
NHTSA ODI #10276220
91,774 miles · Jun 3, 2009
Engine And Engine Cooling
EXHAUST MANIFOLD LEAK BETWEEN MANIFOLD AND HEAD ON THE FRONT OF THE ENGINE. COST:$140.15. *TR
NHTSA ODI #10272806
65,000 miles · Mar 20, 2009
Electrical SystemEngine And Engine Cooling
TL*THE CONTACT OWNS A 2002 CHRYSLER TOWN AND COUNTRY. THE CONTACT HAS EXPERIENCED SEVERAL ISSUES WITH THE ELECTRICAL COMPONENTS IN HIS VEHICLE. THE VEHICLE WOULD JUMP WHEN THE ACCELERATOR PEDAL WAS DEPRESSED OR ACCELERATING AT ANY SPEED. THE DEALER REPLACED ALL THE WIRES, WIRING HARNESS, SPARK PLUGS, AND THE BATTERY; HOWEVER,…
Read full complaint
TL*THE CONTACT OWNS A 2002 CHRYSLER TOWN AND COUNTRY. THE CONTACT HAS EXPERIENCED SEVERAL ISSUES WITH THE ELECTRICAL COMPONENTS IN HIS VEHICLE. THE VEHICLE WOULD JUMP WHEN THE ACCELERATOR PEDAL WAS DEPRESSED OR ACCELERATING AT ANY SPEED. THE DEALER REPLACED ALL THE WIRES, WIRING HARNESS, SPARK PLUGS, AND THE BATTERY; HOWEVER, THE FAILURE CONTINUED. THE AUTOMATIC DOORS ALSO BECAME INOPERABLE. THE VEHICLE WAS TAKEN TO A DIFFERENT DEALER AND THEY STATED THAT A NEW OXYGEN SYSTEM WAS NEEDED. THE COMPUTER SYSTEM AND SPARK PLUGS WIRES WERE REPLACED, BUT THE FAILURE CONTINUED. THE MANUFACTURER WAS NOTIFIED AND A CASE WAS FILED. THEY STATED THAT THE VEHICLE COULD BE REPAIRED UNDER WARRANTY. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 65,000 AND CURRENT MILEAGE WAS OVER 100,000.
NHTSA ODI #10262556
45,000 miles · Sep 19, 2008
Engine And Engine Cooling
2002 CHRYSLER TOWN&COUNTRY - 45,000 MILE. WHILE TRAVELING, SUDDENLY HEATER BEGAN BLOWING COLD AIR AND WITHIN 1 MINUTE CAR WENT FROM NORMAL TEMPERATURE RANGE TO EXTREME OVERHEAT AND ALARMS. STRANDED IN THE MIDDLE OF NOWHERE HAD TO HAVE CAR TOWED OVER 30 MILES TO NEAREST SERVICE STATION. TOLD REAR HEATER LINE RUSTED THROUGH AND DU…
Read full complaint
2002 CHRYSLER TOWN&COUNTRY - 45,000 MILE. WHILE TRAVELING, SUDDENLY HEATER BEGAN BLOWING COLD AIR AND WITHIN 1 MINUTE CAR WENT FROM NORMAL TEMPERATURE RANGE TO EXTREME OVERHEAT AND ALARMS. STRANDED IN THE MIDDLE OF NOWHERE HAD TO HAVE CAR TOWED OVER 30 MILES TO NEAREST SERVICE STATION. TOLD REAR HEATER LINE RUSTED THROUGH AND DUMPED ALL OF THE ENGINE COOLANT. ALSO TOLD THIS IS A COMMON PROBLEM IN MICHIGAN (THIS SERVICE STATION HAS REPLACED AT LEAST 3 OF THESE SINCE SPRING OF THIS YEAR) APPARENTLY CHRYSLER HAS RECOGNIZED THIS PROBLEM AND REPLACEMENT PART ($255) HAS BEEN REDESIGNED AND IS NOW ALUMINUM RATHER THAN STEEL. LUCKILY, NO ENGINE DAMAGE FOUND AFTER FAILURE WAS REPAIRED. *TR
NHTSA ODI #10242910
85,000 miles · Jun 3, 2008
Engine And Engine Cooling
TL*THE CONTACT OWNS A 2002 CHRYSLER TOWN AND COUNTRY. WHENEVER THE CONTACT ATTEMPTS TO START THE VEHICLE, IT WILL REMAIN RUNNING FOR A VERY SHORT TIME BEFORE SHUTTING OFF. THE CONTACT HAS TO TURN THE VEHICLE ON AND OFF THREE TIMES BEFORE IT WILL COMPLETELY STOP WORKING. THE CONTACT DID NOT NOTICE ANY DIFFERENCES IN THE VEHICL…
Read full complaint
TL*THE CONTACT OWNS A 2002 CHRYSLER TOWN AND COUNTRY. WHENEVER THE CONTACT ATTEMPTS TO START THE VEHICLE, IT WILL REMAIN RUNNING FOR A VERY SHORT TIME BEFORE SHUTTING OFF. THE CONTACT HAS TO TURN THE VEHICLE ON AND OFF THREE TIMES BEFORE IT WILL COMPLETELY STOP WORKING. THE CONTACT DID NOT NOTICE ANY DIFFERENCES IN THE VEHICLE PRIOR TO THE FAILURE, WHICH OCCURS ONCE EVERY THREE DAYS. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. THE CURRENT AND FAILURE MILEAGES WERE 85,000.
NHTSA ODI #10229710
Mileage unknown · Dec 15, 2007
Engine And Engine CoolingEquipmentSteering
THERE WAS A RECALL FOR CHRYSLER POWER STEERING HOSES AND MINE WAS FIXED TWO YEARS AGO & THEY REFUSE TO FIX IT AGAIN SAYING WEAR & TEAR. ALSO, THEY PUT OUT A NOTICE (BUT NOT TO OWNERS) THAT THE OIL PLATE ON THESE VEHICLES ARE LEAKING & THERE IS NO RECALL FOR THAT PROBLEM WHICH I'VE ALREADY CONSULTED 50 PEOPLE WITH THE SAME VAN A…
Read full complaint
THERE WAS A RECALL FOR CHRYSLER POWER STEERING HOSES AND MINE WAS FIXED TWO YEARS AGO & THEY REFUSE TO FIX IT AGAIN SAYING WEAR & TEAR. ALSO, THEY PUT OUT A NOTICE (BUT NOT TO OWNERS) THAT THE OIL PLATE ON THESE VEHICLES ARE LEAKING & THERE IS NO RECALL FOR THAT PROBLEM WHICH I'VE ALREADY CONSULTED 50 PEOPLE WITH THE SAME VAN AND SAME PROBLEM. *TR
NHTSA ODI #10211993
50,000 miles · Oct 30, 2007
Electrical SystemEngine And Engine CoolingFire
TL*THE CONTACT OWNS A 2002 CHRYSLER TOWN AND COUNTRY. WHILE DRIVING 55 MPH, THE VEHICLE OVERHEATED. THE VEHICLE MADE A CLACKING NOISE AND SMOKE BEGAN TO RISE FROM THE ENGINE. THE CHECK ENGINE LIGHT DID NOT ILLUMINATE UNTIL THE VEHICLE BEGAN SMOKING. THE CONTACT PULLED TO THE SIDE OF THE ROAD. THE ENGINE SHUT OFF AND THE CON…
Read full complaint
TL*THE CONTACT OWNS A 2002 CHRYSLER TOWN AND COUNTRY. WHILE DRIVING 55 MPH, THE VEHICLE OVERHEATED. THE VEHICLE MADE A CLACKING NOISE AND SMOKE BEGAN TO RISE FROM THE ENGINE. THE CHECK ENGINE LIGHT DID NOT ILLUMINATE UNTIL THE VEHICLE BEGAN SMOKING. THE CONTACT PULLED TO THE SIDE OF THE ROAD. THE ENGINE SHUT OFF AND THE CONTACT ALLOWED THE VEHICLE TO COOL DOWN. HE ADDED WATER TO THE RADIATOR AND DROVE TO HIS RESIDENCE. THE VEHICLE WAS THEN TOWED TO THE DEALER AND THEY STATED THAT THE COMPUTERS FAILED AND NEEDED TO BE REPLACED. THE CONTACT DISAGREED AND STATED THAT THE VEHICLE OVERHEATED BECAUSE THE FAN AND COOLING SYSTEM WERE INADEQUATE IN SIZE. THE DEALER DID NOT REPAIR THE VEHICLE. THE CURRENT MILEAGE WAS 71,421 AND FAILURE MILEAGE WAS 50,000.
NHTSA ODI #10207441
NHTSA investigations
6EA05009 · Headlight Malfunction
Opened Jun 1, 2005 · Closed May 2, 2006
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Additional source detail variants (3)
Electrical System
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
Exterior Lighting:headlights:switch
OWNER REPORTS INDICATE ALLEGATIONS OF IMPROPER HEADLIGHT OPERATION OF ONE OR BOTH HEADLIGHTS.SOME REPORT INTERMITTENT OUTAGE OR DIMMING.MANY REPORT THAT THE CONDITION IS RANDOM; IT SOMETIMES DOES NOT REPEAT AND LASTS FOR A VERY SHORT DURATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE SUMMARY REPORT FOR ADDITIONAL INFORMATION.
PE05004 · Headlight Malfunction
Opened Feb 2, 2005 · Closed Jun 1, 2005
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
Exterior Lighting:headlights:switch
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS INVESTIGATION AFTER RECEIVING REPORTS FROM CONSUMERS THAT THEIR HEADLIGHTS WOULD MALFUNCTION IN VARIOUS WAYS FROM FLICKERING TO COMPLETE NON-ILLUMINATION.HEADLIGHT OPERATION IS MONITORED BY THE VEHICLE'S BODY CONTROL MODULE (BCM) AND FRONT CONTROL MODULE (FCM).ODI IS UPGRADING THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA05-009) TO FURTHER EXAMINE THE ISSUE.
EA04031 · Power Liftgate Latch
Opened Nov 22, 2004 · Closed Apr 7, 2005
Status: closed (inferred from source dates) · Latches/locks/linkages; Latches/locks/linkages:tailgate:latch
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
Additional source detail variants (2)
Latches/locks/linkages
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
Latches/locks/linkages:tailgate:latch
THIS INVESTIGATION WAS OPENED AS PE04-054 REGARDING REPORTS OF ALLEGED POWER LIFTGATE (PLG) OPENING WHILE DRIVING.THE INVESTIGATION WAS UPGRADED ON NOVEMBER 22, 2004 BASED ON INFORMATION PROVIDED BY DAIMLERCHRYSLER CORPORATION (DCC) IN ITS SEPTEMBER 17, 2004 RESPONSE TO PE04-054. BY LETTER OF APRIL 5, 2005, DCC HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 70,235 MODEL YEAR (MY) 2003 CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN VEHICLES EQUIPPED WITH THE PLG OPTION.DCC HAS IDENTIFIED A PROBLEM IN EARLY PRODUCTION MY 2003 PLG CONTROL MODULES THAT CAN PREVENT THE PLG DOOR FROM LATCHING CLOSED IN A POWER OPEN/CLOSE CYCLE.IN THIS CONDITION THE PLG CAN RISE (NOT POWER OPEN) DURING VEHICLE OPERATION.DEALERS WILL INSTALL A REVISED PLG CONTROL MODULE TO REMEDY THE AFFECTED VEHICLES.SEE SAFETY RECALL 05V134 FOR DETAILS.
PE04049 · Speaker Fire In The Rear Of The Vehicle
Opened Jul 7, 2004 · Closed Nov 5, 2004
Status: closed (inferred from source dates) · Electrical System:wiring: Rear Compartment/trunk; Equipment:electrical:radio/tape Deck/cd Etc.
ON JULY 7, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING AN INTERIOR VEHICLE FIRE STARTING IN THE AREA OF THE DRIVER SIDE REAR SPEAKER.DAIMLERCHRYSLER CORPORATION (DCC) INFORMED ODI THAT CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DRIP ONTO THE RADIO AND INTO VENT HOLES ON TOP OF THE RADIO.THIS CAN RESULT IN A SHORT CIRCUIT SENDING DIRECT CURRENT TO THE REAR SPEAKERS AND CAUSE A SPEAKER FIRE.THE CONDITION IS PRESENT ONLY ON SUBJECT VEHICLES EQUIPPED WITH THE BASE RADIO.SUBJECT VEHICLES WITH OTHER OPTION RADIOS CONTAIN CIRCUIT PROTECTION THAT PREVENTS SENDING DIRECT CURRENT TO THE SPEAKERS AND ARE NOT AFFECTED.ALL NINE COMPLAINTS PERTAIN TO VEHICLES WITH THE BASE RADIO.BY LETTER DATED NOVEMBER 1, 2004, DCC NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA# 04V531) COVERING MODEL YEAR 2001-2002 DODGE CARAVAN, GRAND CARAVAN, CHRYSLER VOYAGER, AND TOWN & COUNTRY MODELS WITH BASE RADIO ONLY (EST. 238,000 VEHICLES).DCC DEALERS WILL INSTALL A PROTECTIVE TAPE TO THE TOP OF THE RADIO ASSEMBLY TO PREVENT WATER INTRUSION.THE ACTION TAKEN BY DCC IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Electrical System:wiring: Rear Compartment/trunk
ON JULY 7, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING AN INTERIOR VEHICLE FIRE STARTING IN THE AREA OF THE DRIVER SIDE REAR SPEAKER.DAIMLERCHRYSLER CORPORATION (DCC) INFORMED ODI THAT CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DRIP ONTO THE RADIO AND INTO VENT HOLES ON TOP OF THE RADIO.THIS CAN RESULT IN A SHORT CIRCUIT SENDING DIRECT CURRENT TO THE REAR SPEAKERS AND CAUSE A SPEAKER FIRE.THE CONDITION IS PRESENT ONLY ON SUBJECT VEHICLES EQUIPPED WITH THE BASE RADIO.SUBJECT VEHICLES WITH OTHER OPTION RADIOS CONTAIN CIRCUIT PROTECTION THAT PREVENTS SENDING DIRECT CURRENT TO THE SPEAKERS AND ARE NOT AFFECTED.ALL NINE COMPLAINTS PERTAIN TO VEHICLES WITH THE BASE RADIO.BY LETTER DATED NOVEMBER 1, 2004, DCC NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA# 04V531) COVERING MODEL YEAR 2001-2002 DODGE CARAVAN, GRAND CARAVAN, CHRYSLER VOYAGER, AND TOWN & COUNTRY MODELS WITH BASE RADIO ONLY (EST. 238,000 VEHICLES).DCC DEALERS WILL INSTALL A PROTECTIVE TAPE TO THE TOP OF THE RADIO ASSEMBLY TO PREVENT WATER INTRUSION.THE ACTION TAKEN BY DCC IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Equipment:electrical:radio/tape Deck/cd Etc.
ON JULY 7, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING AN INTERIOR VEHICLE FIRE STARTING IN THE AREA OF THE DRIVER SIDE REAR SPEAKER.DAIMLERCHRYSLER CORPORATION (DCC) INFORMED ODI THAT CONDENSATION FROM THE INSTRUMENT PANEL AIR CONDITIONING DUCTS MAY DRIP ONTO THE RADIO AND INTO VENT HOLES ON TOP OF THE RADIO.THIS CAN RESULT IN A SHORT CIRCUIT SENDING DIRECT CURRENT TO THE REAR SPEAKERS AND CAUSE A SPEAKER FIRE.THE CONDITION IS PRESENT ONLY ON SUBJECT VEHICLES EQUIPPED WITH THE BASE RADIO.SUBJECT VEHICLES WITH OTHER OPTION RADIOS CONTAIN CIRCUIT PROTECTION THAT PREVENTS SENDING DIRECT CURRENT TO THE SPEAKERS AND ARE NOT AFFECTED.ALL NINE COMPLAINTS PERTAIN TO VEHICLES WITH THE BASE RADIO.BY LETTER DATED NOVEMBER 1, 2004, DCC NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA# 04V531) COVERING MODEL YEAR 2001-2002 DODGE CARAVAN, GRAND CARAVAN, CHRYSLER VOYAGER, AND TOWN & COUNTRY MODELS WITH BASE RADIO ONLY (EST. 238,000 VEHICLES).DCC DEALERS WILL INSTALL A PROTECTIVE TAPE TO THE TOP OF THE RADIO ASSEMBLY TO PREVENT WATER INTRUSION.THE ACTION TAKEN BY DCC IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE03012 · Power Steering Hose Failure
Opened Apr 9, 2003 · Closed May 29, 2003
Status: closed (inferred from source dates) · Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:power Steering Fluid; Steering:hydraulic Power Assist:pump; Steering:linkages:drag:power Assist System
PLEASE SEE ATTACHED REPORT.
Additional source detail variants (5)
Steering:hydraulic Power Assist:hose, Piping, And Connections
PLEASE SEE ATTACHED REPORT.
Steering:hydraulic Power Assist:power Steering Fluid
PLEASE SEE ATTACHED REPORT.
Steering:hydraulic Power Assist:pump
PLEASE SEE ATTACHED REPORT.
Steering:hydraulic Power Assist System
PLEASE SEE ATTACHED REPORT.
Steering:linkages:drag:power Assist System
PLEASE SEE ATTACHED REPORT.
PE02068 · Fuel Tank Leak
Opened Sep 24, 2002 · Closed Oct 9, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
No summary supplied.
Illustration