NHTSA owner reports · September 18, 2026 snapshot.
Equipment complaints
42 reportsClear category filter131,000 miles · Jul 26, 2004
Air BagsElectrical SystemEngine And Engine Cooling
WHILE DRIVING THE TRANSMISSION FAILED AND THE VEHICLE WAS UNABLE TO SHIFT GEARS. TRANSMISSION WAS REPLACED TWICE, HOWEVER THE PROBLEM RECURRED. *AK THE HORN AIRBAG AND CRUISE CONTROL HAVE BEEN REPLACED. THE VEHICLE HAD BRAKE PROBLEMS. THE DEALER DETERMINED THAT THE FRONT BRAKES WERE AT 45% BUT THE REAR BRAKES WERE AT 70%. T…
Read full complaint
WHILE DRIVING THE TRANSMISSION FAILED AND THE VEHICLE WAS UNABLE TO SHIFT GEARS. TRANSMISSION WAS REPLACED TWICE, HOWEVER THE PROBLEM RECURRED. *AK THE HORN AIRBAG AND CRUISE CONTROL HAVE BEEN REPLACED. THE VEHICLE HAD BRAKE PROBLEMS. THE DEALER DETERMINED THAT THE FRONT BRAKES WERE AT 45% BUT THE REAR BRAKES WERE AT 70%. THE DEALER CLEANED AND ADJUSTED THE BRAKES. THE A/C FAILED, THE DEALER REPLACED THE FAN MODULE. THE POWER DOOR LOCKS FAILED. THE CD PLAYER DOESN'T WORK. THE LOW BEAM HEAD LIGHTS DO NOT PROVIDE ENOUGH LIGHT THEREFORE THE CONSUMER HAS TO LEAVE THE HIGH BEAMS ON TO SEE. THIS PROBLEM HAS BEEN CHECKED THREE TIMES BUT THE DEALER SAID THEY SEEM CORRECT. THE PASSENGER SEAT BROKE. THE STARTER FAILED AND AS A RESULT THE VEHICLE WOULD NOT START. THE STEERING PUMP FAILED AND AS A RESULT THE STEERING WHEEL BECAME TIGHT WHEN MAKING TURNS. THE REAR HEATER LINES WERE LEAKING. THE WATER PUMP LEAKED. *NM
NHTSA ODI #10079478
114,000 miles · Jan 15, 2004
EquipmentPower Train
INTERMITTENT LOSS OF SPEED. TRANSMISSION STUCKS AT LOWER GEAR. VEHICLE RUNS FINE FOR A WHILE AND SUDDENLY JUMPS TO LOWER GEAR, BRINGING THE VAN TO A SUDDEN LOW SPEED. LUCKLY ESCAPED FROM A MAJOR ACCIDENT WHILE OVERTAKING A TRUCK ON HIGHWAY AT THE SPEED OF 70MILES/HR. SHOWED THE VEHICLE TO CHRYSLER DEALER. THEY JUST KEPT THE VAN…
Read full complaint
INTERMITTENT LOSS OF SPEED. TRANSMISSION STUCKS AT LOWER GEAR. VEHICLE RUNS FINE FOR A WHILE AND SUDDENLY JUMPS TO LOWER GEAR, BRINGING THE VAN TO A SUDDEN LOW SPEED. LUCKLY ESCAPED FROM A MAJOR ACCIDENT WHILE OVERTAKING A TRUCK ON HIGHWAY AT THE SPEED OF 70MILES/HR. SHOWED THE VEHICLE TO CHRYSLER DEALER. THEY JUST KEPT THE VAN FOR LONG TIME AND REPLACE A PIECE OF WIRE AND SAID ITS GOOD TO GO. BUT PROBLEM CAME BACK AGAIN AFTER A WEEK. NOW THEY SAY ALL WIRING HAS TO BE REPLACED WHICH COULD COST ME LIKE $1700 TO $1800. I'M THE SECOND OWNER AND I TAKE GOOD CARE OF THIS VAN, CHANGING FLUIDS, FILTERS & STUFF. IF THIS IS ENGINEERING MISTAKE BY CHRYSLER WITH THEIR TRANSMISSON, THEN SHOULDN\\'T THEY TAKE CARE OF THIS ISSUE. I SPOKE TO CHRYSLER CUSTOMER SERVICE AND THEY SAID SINCE THIS VAN IS OUT OF THE WARRANTY THEY ARE NOT RESPONSIBLE. THANKS.
NHTSA ODI #10070120
63,400 miles · Aug 23, 2003
Engine And Engine CoolingEquipmentPower Train
THE AIRCONDITIONER CONTINUES TO MALFUNCTION AFTER SEVERAL ATTEMPTS TO FIX IT BY MY MECHANIC. AFTER THE SECOND SETTING THE VAN BEGINS TO OVERHEAT.THE CLUTCH IN THE TRANSMISSION FAILED AFTER 63,500 MILES.*AK
NHTSA ODI #10033376
Mileage unknown · May 29, 2003
Air BagsEquipment
CLOCKSPRING REPLACEMENT. *MR AFTER THE CONSUMER PAID FOR THE REPAIRS, HE RECEIVED A RECALL LETTER IN THE MAIL REGARDING THE CLOCK SPRING AND IS NOW REQUESTING REIMBURSEMENT. THE RADIO WAS INOPERATIVE. *JB
NHTSA ODI #10022281
36,000 miles · Feb 17, 2003
EquipmentInterior Lighting
RADIO DOES NOT RECEIVE FM STATIONS, INTERIOR LIGHTS INTERMITTENTLY CAME ON WITH DOOR OPENING
NHTSA ODI #10007622
Mileage unknown · Mar 3, 2002
Equipment
NO SUMMARY LISTED FOR ABOV EVEHICLE. *AK
NHTSA ODI #758868
Mileage unknown · Dec 11, 2001
EquipmentFuel System, Gasoline
FUEL RAIL - NHTSA CAMPAIGN ID # 00V268000. DEALER DOES NOT SHOW RECORD OF THIS RECALL, NOR DOES DIAMLER CHRYSLER RECALL LINE (800) 853-1403. FUEL IS LEAKING ONTO THE ENGINE BLOCK FROM CRACK(S) IN THE FUEL RAIL. DEALER WILL NOT REPAIR FREE OF CHARGE, WILL CHARGE FULL REPAIR COSTS. JACK EXTENSION - THE JACK THAT COMES WITH THE…
Read full complaint
FUEL RAIL - NHTSA CAMPAIGN ID # 00V268000. DEALER DOES NOT SHOW RECORD OF THIS RECALL, NOR DOES DIAMLER CHRYSLER RECALL LINE (800) 853-1403. FUEL IS LEAKING ONTO THE ENGINE BLOCK FROM CRACK(S) IN THE FUEL RAIL. DEALER WILL NOT REPAIR FREE OF CHARGE, WILL CHARGE FULL REPAIR COSTS. JACK EXTENSION - THE JACK THAT COMES WITH THE MINIVAN HAS A SMALL "EXTENDOR" PIECE THAT FITS INTO THE JACK THEN INTO THE DESIGNATED PLACE ON THE FRAME IN ORDER TO JACK THE CAR UP. WHEN I JACKED UP THE VAN USING THESE PIECES, THE VAN SLIPPED OFF THE JACK/EXTENSION PIECE, DAMAGING THE RUNNING BOARD (AND NARROWLY MISSING MY HEAD!). IT APPEARS THERE IS SUPPOSED TO BE A COTTER PIN TO HOLD THE EXTENSION PIECE ONTO THE JACK, BUT THIS WAS NOT INCLUDED.
NHTSA ODI #755528
Mileage unknown · Oct 31, 2001
Air BagsElectrical SystemEquipment
ABS LIGHT STAYS ON, AND HORN/ CRUISE CONTROL DO NOT WORK. REAR A/C UNIT FOR THE PASSENGERS ONLY WORK ON HIGH SPEED. CONSUMER SPOKE WITH SERVICE TECHNICIAN OVER THE PHONE, AND TECHNICIAN INDICATED IT COULD POSSIBLY BE THE CLOCK SPRING.*AK
NHTSA ODI #898541
Mileage unknown · Sep 20, 2001
EquipmentSteering
WHILE TRAVELING OVER A PUDDLE OF WATER CONSUMER LOST POWER STEERING, DEALER HAS BEEN NOTIFIED. *AK THE LOSS OF STEERING OCCURED TWICE AND THE DEALER INDICATED THE STEERING PROBLEM WAS DUE TO THE A/C BELT FAILURE AND FAILURE TO INSTALL SPECIAL BRACKET BY THE MANUFACTURER. *YH
NHTSA ODI #896568
Mileage unknown · Sep 20, 2001
Air BagsElectrical SystemEngine And Engine Cooling
HORN FAILS TO WORK ALONG WITH AN AIR BAG WARNING LIGHT THAT DOESN'T TURN OFF; TRANSMISSION OF THE CAR HAD TO REPLACED IN LESS THAN FOUR YEARS; ELECTRICAL SYSTEMS IN THE CAR ACTS RATHER SPORADIC, RADIO TURNS OFF AND ON BY IT SELF; AIR CONDITIONING NO LONGER WORKS/ HOSE FAILED RADIATOR , AND WATER PUMP HAD TO BE REPLACED
NHTSA ODI #752419
NHTSA investigations
14EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE00032 · Air Bag Clockspring
Opened Aug 8, 2000 · Closed Feb 21, 2001
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available
EA97002 · Fuel Tank Leaks
Opened Jan 31, 1997 · Closed Feb 10, 1998
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THIS ENGINEERING ANALYSIS WAS OPENED ON JANUARY 31, 1997 BASED ON INFORMATION GATHERED DURING PRELIMINARY EVALUATION (PE), PE96-051. THE PE WAS OPENED ON AUGUST 19, 1996, TO INVESTIGATE ALLEGATIONS OF FUEL LEAKAGE FROM THE AREA WHERE THE FUEL PUMP/SENDING UNIT JOINS THE FUEL TANK.FOR BREVIDY, THIS AREA WILL BE REFERRED TO AS THE PUMP/TANK INTERFACE.THESE ALLEGATIONS WERE FIRST RECEIVED BY ODI ON AUGUST 2, 1996 WHILE INVESTIGATING ALLEGATIONS OF CHRYSLER MINIVAN THROTTLE SHAFT HAND-UP, AND UNCONTROLLED ENGINE SPEED, IN PE96-036.WHILE DISCUSSING THAT ISSUE WITH A FLEET, IT WAS ALLEGED THAT AT LEAST 10(OUT OF 40) 1996 EARLY PRODUCTION CHRYSLER MINIVANS LEAKED FUEL FROM THE PUMP/TANK INTERFACE.ANALYSIS OF THE COMPLAINT AND WARRANTY DATA INDICATE FUEL TANK LEAKAGE INCIDENTS IN THE SUBJECT VEHICLES PREDOMINATLY AFFECTED EARLY PRODUCTION VEHICLES.THE DATA INVOLVING CONFIRMED INCIDENTS OF TANK/PUMP INTERFACE LEAKS SUGGEST THAT THOSE FAILURES HAVE BEEN DECLINING SINCE JULY 1996.ODI HAS RECEIVED NO REPORTS OF THE SUBJECT CONDITION INVOLVING ORIGINAL EQUIPMENT PUMPS AND TANKS SINCE SEPTEMBER, 1997.CURRENTLY THIS ISSSUE DOES NOT REQRESENT A CONTINUING FIELD CONCERN.ODI WILL CONTINUE TO MONITOR THE SUBJECT VEHICLES FOR FUEL LEAKS OF ANY TYPE.A SAFETY RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURED DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA97003 · Integrated Child Seat Belt Lockup
Opened Jan 31, 1997 · Closed Aug 19, 1998
Status: closed (inferred from source dates) · Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Additional source detail variants (2)
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
DP96014 · Defective Air Bag Crash Sensor
Opened Nov 14, 1996 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:sensor/control MODULE-INACTIVE
CFAS SENT A FOLLOW-UP LETTER ON DECEMBER 12, 1996, TO CHANGE THE INTENT OF THE PETITION TO AIRBAG AGGRESSIVITY AND DEPLOYMENT VARIABILITY.NHTSA RECEIVED THE LETTER ON 12/12/96; ACCORDINGLY, THE PETITION DUE DAY WAS CHANGED TO APRIL 12, 1997.CFAS PETITIONED THE AGENCY TO CONDUCT AN INVESTIGATION TO DETERMINE WHETHER THE AIRBAG CRASH SENSOR AND/OR DEPLOYMENT SYSTEMS FOR THE 1991-92 CHEVROLET CORSICA/BERETTA, 1990-92 FORD TAURUS, AND 1994-96 CHRYSLER MINIVANS ARE DEFECTIVE.CFAS ALLEGE THAT INFORMATION ON LOW SPEED CRASHES HERE OCCUPANTS HAVE SUFFERED FATAL INJURIES SUGGESTS [THAT THE ABOVE VEHICLES] HAVE DEFECTIVE AIRBAG CRASH SENSOR AND/OR DEPLOYMENT SYSTEMS.
EA96025 · Sliding Door Latch Failure
Opened Oct 15, 1996 · Closed Jul 30, 1998
Status: closed (inferred from source dates) · Structure
ANALYSIS OF KNOWN INCIDENTS INDICATES A DECLINING TREND OVER THE LAST FIVE CALENDAR QUARTERS.EXTENSIVE TESTING OF INCIDENT VEHICLES HAS FAILED TO REPRODUCE OCCURRENCES OF FULL LATCH DISENGAGEMENT.NO FAILURE MODE WHICH COULD CAUSE A PROPERLY LATCHED DOOR TO LOSE FULL LATCH ENGAGEMENT WHILE DRIVING HAS BEEN VERIFIED AS A CAUSAL FACTOR IN ANY OF THE KNOWN INCIDENT VEHICLES DURING THIS INVESTIGATION.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.HOWEVER, ODI WILL CONTINUE TO MONITOR COMPLAINT INPUT FOR THE NEXY YEAR AND WILL REQUEST UPDATED REPORTS FROM CHRYSLER DURING THAT PROCESS.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
SQ96016 · Integrated Child Seat Belt Lockup
Opened Sep 18, 1996 · Closed Feb 4, 1997
Status: closed (inferred from source dates) · Seat Belts:integrated Child Seat
ODI CONTINUES TO RECEIVE COMPLAINTS ALLEGING LATCHING/RETRACTOR MECHANISM PROBLEMS.CHRYSLER'S ASSESSMENT OF THE PROBLEM INDICATES THAT OWNERS OF THE VEHICLES ARE NOT ADHERING TO THE CLEANING REQUIREMENTS FOR THE SEAT.THE SEAT APPEARS TO MALFUNCTION IF CRUMBS OF FOOD OR BEVERAGE RESIDUE ACCUMULATES ON THE LATCHING TONGUE IN THEWELL LOCATED BETWEEN THE CHILD'S LEGS.ODI HAS 19 COMPLAINTS OF RETRACT LOCKUP.SEVEN OF THESE COMPLAINTS REPORT CUTTING THE STRAPS TO REMOVE THE CHILD.TWO OF THE SEVEN CONSUMERS ALLEGE THE CHILD WAS CHOKING.CHRYSLER REPORTS 60 OWNER/FIELD REPORTS WHICH INDICATED 19 HARNESSES WERE CUT TO REMOVE THE CHILDREN.ADDITIONAL INFORMATION IS NEEDED TO FULLY ASSESS THE SAFETY CONSEQUENCE OF THE ALLEGED DEFECT AND TO EVALUATE THE CHRYSLER CORPORATION'S RATIONAL FOR NOT CONDUCTING A SAFETY RECALL CAMPAIGN.
PE96051 · Fuel Leaks From The Gas Tank
Opened Aug 19, 1996 · Closed Jan 31, 1997
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
ANALYSIS TO DATE INDICATES THAT SOME OF THE SUBJECT VEHICLESCONTINUE TO EXPERIENCE FUEL LEAKS FROM THE FUEL TANK AT THE SENDING UNIT INTERFACE.MOST OFTEN THE LEAK INVOLVES THE O-RING SEAL.
PE96038 · Sliding Door Latch Failure
Opened May 16, 1996 · Closed Oct 15, 1996
Status: closed (inferred from source dates) · Structure
CHRYSLER MAINTAINS THAT THE COMMON FACTOR CONTRIBUTING TO KNOWN SLIDING DOOR OPENING INCIDENTS IS PRIOR INCORRECT DEALER LATCH ADJUSTMENT.CHRYSLER ATTRIBUTES THIS PROBLEM TO AN INACCURATE SERVICE MANUAL PROCEDURE - SLIDING DOOR LATCH/LOCK CONTROL, REMOVAL AND INSTALLATION.CHRYSLER FURNISHED INFORMATION SHOWING THAT SIX OF ITS COMPLAINTS, AND TWO OF ODI'S, INVOLVED VEHICLES THAT HAD UNDERGONE PRIOR REPAIRS TO THE AFFECTED SLIDING DOOR.CHRYSLER HAS ADDRESSED THE PROBLEM BY ISSUING TWO TECHNICAL SERVICE BULLETINS.TSB 26-06-96, SERVICE MANUAL REVISIONS, WAS ISSUED IN JUNE 1996 AND INCLUDES A SERVICE REVISION (#81-370-6105A) CORRECTING SERVICE MANUAL SLIDING DOOR REPAIR PROCEDURES.TSB 23-39-96, SLIDING DOOR(S) DIFFICULT TO OPEN FROM THE OUTSIDE AND/OR INSIDE, WAS ISSUED JUNE 28, 1996.CHRYSLER IDENTIFIED THREE DESIGN CHANGES INVOLVING THE SUBJECT COMPONENTS: (1)SLIDING DOOR LATCH PAWL SPRING FORCE INCREASED FROM 5.4 NEWTONS TO 8.0 NEWTONS IN SEPTEMBER 1995 TO ENHANCE PAWL ROTATION RETURN TO NEUTRAL POSITION; (2)ADJUSTABLE SLIDING DOOR HINGE IMPLEMENTED IN NOVEMBER 1995 TO REDUCE VARIATION IN SLIDING DOOR FIT; AND(3)SLIDING DOOR STRIKER ATTACHMENT HOLES REVISED IN JANUARY 1996 TO ELIMINATE UP/DOWN ADJUSTMENT OF STRIKER TO IMPROVE INSTALLATION PROCESS AND REDUCE VARIABILITY OF ALIGNMENT BETWEEN LATCH AND STRIKER.AT PRESENT, ODI IS NOT AWARE OF ANY INCIDENTS INVOLVING VEHICLES BUILT IN OR AFTER JANUARY 1996.ODI HAS CONTINUED TO RECEIVE COMPLAINTS OF SLIDING DOORS OPENING WHILE THE VEHICLES ARE IN MOTION, INCLUDING VEHICLES WITH NO PRIOR SERVICE HISTORY TO THE AFFECTED SLIDING DOOR ASSEMBLY.OWNERS ALLEGE THAT THE DOORS OPEN ANYWHERE FROM A FEW INCHES TO FULLY OPEN, AT SPEEDS RANGING FROM 15 TO 60 MPH.ODI HAS ALSO RECEIVED NUMBEROUS COMPLAINTS ALLEGING DIFFICULTY IN LATCHING THE SUBJECT SLIDING DOORS AND/OR DIFFICULTY IN OPENING ONE OR BOTH SLIDING DOORS.
PE96008 · Safety Blt Latch Operation
Opened Jan 25, 1996 · Closed Jun 28, 1996
Status: closed (inferred from source dates) · Seat Belts
There is no summary currently available
PE95053 · Fuel Leakeage From Rollover Valve
Opened Oct 25, 1995 · Closed Dec 22, 1995
Status: closed (inferred from source dates) · Engine And Engine Cooling:exhaust System:emission Control
There is no summary currently available
Illustration