Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
670–25K
9625–50K
6950–75K
4575–100K
51100–150K
23150K+
351 reports with mileage · 160 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 97 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Structure. Review the 67 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Exterior Lighting. Review the 55 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
40 crash reports34 fire reports43 injury reports
What owners actually said
511 reports
Mileage unknown · Oct 30, 2002
Seats
DRIVER'S OUTBOARD HEATED SEAT SWITCH HAZARDOUS TO DRIVE WITH. LEFT LEG COMPRESSES OUTBOARD SEAT OVER HEATED SEAT SWITCH WHEN SEATED. MUST TAKE LEFT HAND OFF OF STEERING WHEEL TO PUSH SEAT INBOARD TO SEE SWITCH. ALSO MUST TAKE EYES OFF OF ROAD TO LOOK DOWN AT THE UNCOVERED SWITCH. WHEN DRIVING HEATED SEAT SWITCH COMES ON & O…
Read full complaint
DRIVER'S OUTBOARD HEATED SEAT SWITCH HAZARDOUS TO DRIVE WITH. LEFT LEG COMPRESSES OUTBOARD SEAT OVER HEATED SEAT SWITCH WHEN SEATED. MUST TAKE LEFT HAND OFF OF STEERING WHEEL TO PUSH SEAT INBOARD TO SEE SWITCH. ALSO MUST TAKE EYES OFF OF ROAD TO LOOK DOWN AT THE UNCOVERED SWITCH. WHEN DRIVING HEATED SEAT SWITCH COMES ON & OFF WHEN MOVING BUTTON OR THIGH TO LEFT. WHEN TEMPERATURE IS 90 DEG. & AIR CONDITIONING IS ON, VERY UNCOMFORTABLE FIGHTING TO TURN OFF THE HEATED SEAT SWITCH. TIME TO LOOK DOWN & MOVE OUTBOARD SEAT INWARD CONTRIBUTES TO AN ACCIDENT. FRONT PASSENGER HEATED SEAT SWITCH COMES ON WHEN PASSENGER GETS IN OR OUT , WITH IGNITION SWITCH ON/AND OR ENGINE RUNNING. MUST STOP CAR IN TRAFFIC? DT
NHTSA ODI #769092
Mileage unknown · Oct 28, 2002
Service Brakes, Hydraulic
CONSUMER STATES, THAT THE ABS SYSTEM ON THE VEHICLE IS NOT WORKING PROPERLY, THAT WHEN APPLYING THE BRAKES, WILL SQUEALING AND MOANING. DEALER HAS BEEN NOTIFIED. PLEASE PROVIDE FURTHER INFORMATION. TS
NHTSA ODI #8021747
Mileage unknown · Oct 16, 2002
Seats
CONSUMER STATES THAT ON 2 OCCASIONS AN OBJECT FROM THE BACK WAS ABLE TO ROLLED FROM TO THE FRONT AND GO UNDER THE BRAKE PEDAL ALMOST CAUSING AN ACCIDENT. DUE TO THE FACT THEIR IS NOTHING BLOCKING IT'S PASSAGE UNDERNEATH THE DRIVER'S SEAT. MR *NLM *DT
NHTSA ODI #8020941
Mileage unknown · Oct 16, 2002
Seats
THE DRIVER'S SEAT HAS NOTHING UNDER IT TO PREVENT ITEMS ON THE REAR FLOOR AREA FROM ROLLING UNDER THE DRIVER'S FEET AND/OR THE PEDALS. TWICE, SODA BOTTLES THE KIDS HAVE DROPPED HAVE ROLLED UNDER MY BRAKE PEDAL. I CANNOT SEEM TO OBTAIN ANY ASSISTANCE FROM CHRYSLER REGARDING THIS ISSUE, AND ON MY LAST CALL TO THEM WAS TOLD IT WA…
Read full complaint
THE DRIVER'S SEAT HAS NOTHING UNDER IT TO PREVENT ITEMS ON THE REAR FLOOR AREA FROM ROLLING UNDER THE DRIVER'S FEET AND/OR THE PEDALS. TWICE, SODA BOTTLES THE KIDS HAVE DROPPED HAVE ROLLED UNDER MY BRAKE PEDAL. I CANNOT SEEM TO OBTAIN ANY ASSISTANCE FROM CHRYSLER REGARDING THIS ISSUE, AND ON MY LAST CALL TO THEM WAS TOLD IT WASN'T A SAFETY ISSUE, AND THEY WOULD MAKE A NOTE OF IT ON MY FILE (WHERE NO ONE WOULD READ IT UNLESS I CALL IN). MR
NHTSA ODI #768523
Mileage unknown · Oct 3, 2002
Fuel System, Gasoline
NO PARTS AVAILABLE RECALL#02V215000FUEL PUMP MODULE-MOUNTING FLANGE. LITCHFIELD CHRYSLER LITCHFIELD, IL 217-324-3909. NLM
NHTSA ODI #8020106
Mileage unknown · Sep 18, 2002
Seat Belts
THE CONSUMER IS CONCERNED WITH THE POSITION OF THE SEATBELTS AND BUCKLES LOCATED IN THE REAR OF THE VEHICLE. WHEN PRESENTING THIS PROBLEM TO THE DEALER, IT WAS SAID THEY WOULD PRESENT THE HAZARD TO THE COMPANY AND GET BACK TO CONSUMER. NO ONE HAS REPLIED AS OF YET. *JG *SCC
NHTSA ODI #567520
Mileage unknown · Sep 11, 2002
Vehicle Speed ControlCrashInjury
WHEN STOPPING AND PUTTING CAR INTO PARK IT SURGES FORWARD, WHICH CAUSED AN ACCIDENT/ INJURIES.*AKTHE ENGINE WAS ALSO REVING AT AN EXTREMELY HIGH SPEED AND SURGING FORWARD WHILE IN THE PARK POSITION. CONSUMER HAD TO CUT THE ENGINE TO STOP THE FORWARD MOTION OF THE VEHICLE. BECAUSE CHYRSLER COULD NOT DUPLICATE THE PROBLEM, THEY …
Read full complaint
WHEN STOPPING AND PUTTING CAR INTO PARK IT SURGES FORWARD, WHICH CAUSED AN ACCIDENT/ INJURIES.*AKTHE ENGINE WAS ALSO REVING AT AN EXTREMELY HIGH SPEED AND SURGING FORWARD WHILE IN THE PARK POSITION. CONSUMER HAD TO CUT THE ENGINE TO STOP THE FORWARD MOTION OF THE VEHICLE. BECAUSE CHYRSLER COULD NOT DUPLICATE THE PROBLEM, THEY WOULD NOT FIX OR REPLACE THE VEHICLE. *JG
NHTSA ODI #8018455
Mileage unknown · Sep 11, 2002
Fuel System, Gasoline
PARTS FOR RECALL 02V215000 HAVE NOT BEEN AVAILABLE FOR 3 WEEKS, AND THEY DIDN'T KNOW WHEN THEY WILL BE AVAILABLE.*AK
NHTSA ODI #8018426
Mileage unknown · Aug 30, 2002
Air BagsVisibility
A WHITE POWDER SUBSTANCE IS LEAKING FROM AIR BAG. DEALER REPLACED AIRBAG AND DASHBOARD. THE SUBSTANCE STARTED LEAKING AGAIN. THE MANUFACTURER STATED IT WAS A REACTION FROM PAINT ON THE PLASTIC. THE CONSUMER GETS ILL FROM RIDING IN VEHICLE. CONSUMER EXPERIENCES NAUSEA/HEADACHES, AND SORE THROAT WHEN RIDING IN THE VEHICLE. T…
Read full complaint
A WHITE POWDER SUBSTANCE IS LEAKING FROM AIR BAG. DEALER REPLACED AIRBAG AND DASHBOARD. THE SUBSTANCE STARTED LEAKING AGAIN. THE MANUFACTURER STATED IT WAS A REACTION FROM PAINT ON THE PLASTIC. THE CONSUMER GETS ILL FROM RIDING IN VEHICLE. CONSUMER EXPERIENCES NAUSEA/HEADACHES, AND SORE THROAT WHEN RIDING IN THE VEHICLE. THE MANUFACTURER WILL NOT TELL THE CONSUMER WHAT THE POWDER WAS-REPLACE AIR BAG ASSEMBLY. THE CONSUMER STATES THAT THE WINDOWS SLIP DOWN IN THE TRACK BY THEMSELVES AND MAKES A SQUEAKY/CREAKING NOISES WHEN USED-MAY STILL EXIST PER INVOICE, AND REINSTALL 2 RUBBER BUMPERS IN GLOVE BOX-HAD TO ORDER A NEW AIR BAG MODULE-SECOND TIME. *SCC
NHTSA ODI #8017669
Mileage unknown · Aug 29, 2002
Seat BeltsCrash
WHILE TRAVELING ON HIGHWAY ANOTHER VEHICLE VEERED INTO CONSUMER'S VEHICLE, AND DRIVER'S SIDE SEATBELT DIDN'T HOLD. DEALERSHIP IS AWARE OF PROBLEM.*AK
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.4L NON-TURBOCHARGED ENGINES AND AUTOMATIC TRANSAXLES, THE POWER STEERING PRESSURE HOSE MAY CONTACT THE AUTOMATIC TRANSAXLE DIFFERENTIAL COVER, POTENTIALLY DAMAGING THE HOSE.
Consequence & remedy
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSPECT AND RELOCATE, OR REPLACE AS NECESSARY, THE POWER STEERING HOSE AND CONFIRM TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END. THE RECALL BEGAN ON SEPTEMBER 20, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN PASSENGER VEHICLES, THE FUEL PUMP MODULE MOUNTING FLANGE COULD LEAK FUEL IF THE VEHICLE IS INVOLVED IN A ROLLOVER CRASH.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SECONDARY SEAL OVER THE FUEL PUMP MODULE. OWNER NOTIFICATION BEGAN AUGUST 12, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES ARE BEING RECALLED FOR A SOFTWARE ERROR IN THE INSTRUMENT CLUSTER MICROPROCESSOR. UNDER CERTAIN CONDITIONS, THE CLUSTER, WITH THE MAJORITY OF ITS GAUGES, ILLUMINATION, AND WARNING LAMPS, COULD BECOME INOPERATIVE.
Consequence & remedy
Consequence: DRIVING THE VEHICLE WITH AN INOPERATIVE CLUSTER COULD CAUSE A DISTRACTION, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL RE-FLASH THE CLUSTER SOFTWARE TO CORRECT THE CONDITION. OWNER NOTIFICATION BEGAN OCTOBER 8, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
PE04028 · Engine Compartment Fires
Opened Mar 15, 2004 · Closed Jun 18, 2004
Status: closed (inferred from source dates) · Steering; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Additional source detail variants (4)
Steering
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:hose, Piping, And Connections
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist System
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.
2002 Chrysler Pt Cruiser Problems, Complaints & Recalls | Skip That Year
Illustration