The contact owns a 2002 Chrysler PT Cruiser. The contact stated that the rear quarter glass fasteners on both sides of the vehicle had started to separate from the vehicle. The contact stated that the windows were violently shaking while driving at various speeds. The contact was concerned that the windows might fall out while d…
Read full complaint
The contact owns a 2002 Chrysler PT Cruiser. The contact stated that the rear quarter glass fasteners on both sides of the vehicle had started to separate from the vehicle. The contact stated that the windows were violently shaking while driving at various speeds. The contact was concerned that the windows might fall out while driving and cause injury to a pedestrian. Neither the dealer nor the manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 70,000.
NHTSA ODI #11595572
170,311 miles · Jun 16, 2017
Structure
TAKARA RECALL. WHILE CHANGING UPPER AND LOWER MOTOR MOUNT I NOTICED SUB FRAME ON THE PASSENGER'S SIDE WAS ROTTED AND AFTER I PUT MOUNTS IN THE CAR PULLS WHEN ACCELERATING
NHTSA ODI #10995582
294,000 miles · Oct 30, 2016
EngineStructure
ENGINE CRADLE, OR FRONT SUBFRAME, IS RUSTED TO THE POINT I'VE STOPPED DRIVING THE CAR. I'M IN THE PROCESS OF FINDING A REPLACEMENT BUT CHRYSLER NO LONGER MAKES THE PART! NOTHING HAS HAPPENED TO THIS POINT BECAUSE OF MY CAUTION BUT THE FRONT END WAS STARTING TO MAKE POPPING NOISES WHEN I STARTED OUT FROM A DEAD STOP. THE PROBL…
Read full complaint
ENGINE CRADLE, OR FRONT SUBFRAME, IS RUSTED TO THE POINT I'VE STOPPED DRIVING THE CAR. I'M IN THE PROCESS OF FINDING A REPLACEMENT BUT CHRYSLER NO LONGER MAKES THE PART! NOTHING HAS HAPPENED TO THIS POINT BECAUSE OF MY CAUTION BUT THE FRONT END WAS STARTING TO MAKE POPPING NOISES WHEN I STARTED OUT FROM A DEAD STOP. THE PROBLEM IS ON THE FRONT PASSENGER SIDE. I UNDERSTAND FROM READING ARTICLES, MANY OTHER PTS HAVE THIS SAME PROBLEM. FOR YEARS, I HAVE TRIED TO PRIME AND SPRAY OIL ON THE PART TO EXTEND IT'S LIFE. TIME HAS COME.... *TR
NHTSA ODI #10920082
84,000 miles · Dec 2, 2015
StructureSuspension
TL* THE CONTACT OWNS A 2002 CHRYSLER PT CRUISER. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 5 MPH AND MAKING A RIGHT TURN, THE VEHICLE CAME TO AN ABRUPT STOP. THE CONTACT EXIT THE VEHICLE AND DISCOVERED THAT THE FRONT PASSENGER SIDE SUB FRAME HAD EXCESSIVE RUST AND FRACTURED. THE VEHICLE WAS TOWED TO AN INDEPENDENT M…
Read full complaint
TL* THE CONTACT OWNS A 2002 CHRYSLER PT CRUISER. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 5 MPH AND MAKING A RIGHT TURN, THE VEHICLE CAME TO AN ABRUPT STOP. THE CONTACT EXIT THE VEHICLE AND DISCOVERED THAT THE FRONT PASSENGER SIDE SUB FRAME HAD EXCESSIVE RUST AND FRACTURED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC AND WAS DIAGNOSED THAT THE FRONT PASSENGER FRAME, THE CV AXLES AND THE LOWER CONTROL ARMS WITH BALL JOINT AND THE STABILIZER LINK HAD FRACTURED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 84,000.
NHTSA ODI #10808040
136,616 miles · Oct 27, 2015
StructureSuspension
TL* THE CONTACT OWNS A 2002 CHRYSLER PT CRUISER. WHEN THE VEHICLE APPROACHED AN ABRUPT STOP AND ACCELERATED, THERE WAS AN ABNORMAL NOISE COMING FROM THE FRONT OF THE VEHICLE. IN ADDITION, THE CONTACT STATED THAT THE VEHICLE VEERED TO THE RIGHT INDEPENDENTLY WITHOUT WARNING WHILE DRIVING 40 MPH. THE CONTACT DISCOVERED THAT THE FR…
Read full complaint
TL* THE CONTACT OWNS A 2002 CHRYSLER PT CRUISER. WHEN THE VEHICLE APPROACHED AN ABRUPT STOP AND ACCELERATED, THERE WAS AN ABNORMAL NOISE COMING FROM THE FRONT OF THE VEHICLE. IN ADDITION, THE CONTACT STATED THAT THE VEHICLE VEERED TO THE RIGHT INDEPENDENTLY WITHOUT WARNING WHILE DRIVING 40 MPH. THE CONTACT DISCOVERED THAT THE FRONT PASSENGER SIDE CROSS MEMBER WAS FRACTURED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 136,616.
NHTSA ODI #10786444
95,000 miles · Jan 31, 2015
Structure
NOTE: THIS IS NOT A SAFETY ISSUE (AS FAR AS I KNOW) BUT I WANT IT TO GO ON RECORD FROM WHAT ALL PT CRUISER OWNERS HAVE BEEN GOING THROUGH. DASHBOARD CRACKED AND VENT GRIDS CRUMBLED WHEN DOING A REGULAR CLEANING (DUSTING WITH CLOTH). I JUST WANT TO BE NOTED THAT I FOUND OUT THAT THE GREAT MAJORITY OF PT CRUISERS HAVE THIS ISSUE…
Read full complaint
NOTE: THIS IS NOT A SAFETY ISSUE (AS FAR AS I KNOW) BUT I WANT IT TO GO ON RECORD FROM WHAT ALL PT CRUISER OWNERS HAVE BEEN GOING THROUGH. DASHBOARD CRACKED AND VENT GRIDS CRUMBLED WHEN DOING A REGULAR CLEANING (DUSTING WITH CLOTH). I JUST WANT TO BE NOTED THAT I FOUND OUT THAT THE GREAT MAJORITY OF PT CRUISERS HAVE THIS ISSUE. I DO NOT THINK IT IS FAIR TO CUSTOMERS TO HAVE NO PROTECTION FROM SUCH POOR QUALITY MATERIALS. MANUFACTURE SHOULD BE MADE LIABLE FOR SUCH THINGS. *TR
NHTSA ODI #10680103
84,000 miles · Jun 30, 2014
Air BagsEngineStructureCrash
VEHICLE PULLED OUT OF BUSINESS COMPLEX TURN IN LEFT ABOUT A CAR LENGTHS AWAY FROM ME WHEN HE PULLED OUT..ATTEMPTED TO STOP BUT VEHICLE WAS TOO CLOSE. NO AIR BAGS DEPLOYED. *TR
NHTSA ODI #10606984
151,232 miles · Aug 22, 2013
StructureSuspension
I WAS TRAVELING DOWN THE HIGHWAY WITH MY TWO CHILDREN IN THE CAR. I SLOWED AT AN INTERSECTION AND THE VEHICLE ABRUPTLY PULLED TO THE RIGHT. I ALMOST LOST CONTROL OF THE VEHICLE AND ENDED UP IN THE DITCH, BUT I WAS ABLE TO STOP IN TIME. I PROCEEDED TO HAVE THE VEHICLE TOWED HOME AND WAS TOLD BY A MECHANIC THAT THE SUBFRAME OF MY …
Read full complaint
I WAS TRAVELING DOWN THE HIGHWAY WITH MY TWO CHILDREN IN THE CAR. I SLOWED AT AN INTERSECTION AND THE VEHICLE ABRUPTLY PULLED TO THE RIGHT. I ALMOST LOST CONTROL OF THE VEHICLE AND ENDED UP IN THE DITCH, BUT I WAS ABLE TO STOP IN TIME. I PROCEEDED TO HAVE THE VEHICLE TOWED HOME AND WAS TOLD BY A MECHANIC THAT THE SUBFRAME OF MY VEHICLE HAD RUSTED THROUGH. THIS IS A MAJOR CONCERN WITH THE SAFETY OF MY FAMILY AND OTHERS THAT I COULD HAVE GOTTEN INTO AN ACCIDENT WITH. I FEEL THAT CHRYSLER SHOULD BE RESPONSIBLE FOR THE REPAIRS OF MY VEHICLE, OTHER THEN THE SUBFRAME I NEEDED TO HAVE MY CAR LAST MORE THEN 10 YEARS. *TR
NHTSA ODI #10536825
35,585 miles · Jul 9, 2012
Structure
LOUD CRACKING SOUNDS WHILE DRIVING THEN THE DASH STARTED OPENING UP IN TWO PLACES, ONE THROUGH THE VENT FAN ALL THE WAY TO THE INSTRUMENT PANEL AND THE OTHER FROM THE VENT TOWARD THE GLOVE BOX. CHRYSLER AND MY DEALER CLAIM THEY HAVE NEVER HEARD OF THIS PROBLEM ALTHOUGH MANY COMPLAINTS ON THE WEB AND THIS SITE? ALSO MANY ON THIS …
Read full complaint
LOUD CRACKING SOUNDS WHILE DRIVING THEN THE DASH STARTED OPENING UP IN TWO PLACES, ONE THROUGH THE VENT FAN ALL THE WAY TO THE INSTRUMENT PANEL AND THE OTHER FROM THE VENT TOWARD THE GLOVE BOX. CHRYSLER AND MY DEALER CLAIM THEY HAVE NEVER HEARD OF THIS PROBLEM ALTHOUGH MANY COMPLAINTS ON THE WEB AND THIS SITE? ALSO MANY ON THIS SITE SAID THEY CONTACTED CHRYSLER. HAVE MADE APPOINTMENT TO REPLACE AT MY COST SINCE IT DOESN'T SEEM SAFE TO DRIVE A CAR THAT'S SPLITTING DOWN THE MIDDLE, AND CHRYSLER AND THE DEALER CLAIM NO RESPONSIBILITY. MY CAR HAS BEEN WELL MAINTAINED, USED SUN SHADES AND ONLY HAS 35,585 MILES, LIVING ON THE CENTRAL CALIFORNIA COAST WHERE THE WEATHER IS MILD ALL YEAR AROUND. SEEMS LIKE THIS IS DEFECTIVE MATERIAL THAT CHRYSLER SHOULD REPLACE. *TR
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.4L NON-TURBOCHARGED ENGINES AND AUTOMATIC TRANSAXLES, THE POWER STEERING PRESSURE HOSE MAY CONTACT THE AUTOMATIC TRANSAXLE DIFFERENTIAL COVER, POTENTIALLY DAMAGING THE HOSE.
Consequence & remedy
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSPECT AND RELOCATE, OR REPLACE AS NECESSARY, THE POWER STEERING HOSE AND CONFIRM TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END. THE RECALL BEGAN ON SEPTEMBER 20, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN PASSENGER VEHICLES, THE FUEL PUMP MODULE MOUNTING FLANGE COULD LEAK FUEL IF THE VEHICLE IS INVOLVED IN A ROLLOVER CRASH.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SECONDARY SEAL OVER THE FUEL PUMP MODULE. OWNER NOTIFICATION BEGAN AUGUST 12, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES ARE BEING RECALLED FOR A SOFTWARE ERROR IN THE INSTRUMENT CLUSTER MICROPROCESSOR. UNDER CERTAIN CONDITIONS, THE CLUSTER, WITH THE MAJORITY OF ITS GAUGES, ILLUMINATION, AND WARNING LAMPS, COULD BECOME INOPERATIVE.
Consequence & remedy
Consequence: DRIVING THE VEHICLE WITH AN INOPERATIVE CLUSTER COULD CAUSE A DISTRACTION, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL RE-FLASH THE CLUSTER SOFTWARE TO CORRECT THE CONDITION. OWNER NOTIFICATION BEGAN OCTOBER 8, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
PE04028 · Engine Compartment Fires
Opened Mar 15, 2004 · Closed Jun 18, 2004
Status: closed (inferred from source dates) · Steering; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Additional source detail variants (4)
Steering
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:hose, Piping, And Connections
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist System
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.
2002 Chrysler Pt Cruiser Problems, Complaints & Recalls | Skip That Year
Illustration