IllustrationWHILE DRIVING, THE ALIGNMENT IS OFF CAUSING THE VEHICLE TO SWERVE. NOTIFIED THE DEALER 5 TIMES , DEALER SAID THE TIRE IS DEFECTIVE. CONTACTED THE TIRE MANUFACTURE, THEY SAID IT'S NOT THE TIRE. PH *JG
2002 Chrysler Pt Cruiser
Owner reports · Recalls · Investigations
More warning signs than most Pt Cruiser years
Owner complaints for the 2002 Chrysler Pt Cruiser are substantially higher than the model-year median of 202.
About this comparison →How this year compares
Owner complaints by model year
Compare all Pt Cruiser years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
670–25K
9625–50K
6950–75K
4575–100K
51100–150K
23150K+
351 reports with mileage · 160 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 97 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 67 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 55 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
40 crash reports34 fire reports43 injury reports
What owners actually said
511 reportsVEHICLE HAS BEEN TO TWO SEPARATE DEALERS FOR POOR FUEL MILEAGE. VEHICLE IS GETTING LESS THAN 15 MILES PER GALLON, WHEN THE ADVERTISED MPG IS BETWEEN 19 AND 27. VEHICLE HAS A FOUL ODOR. BOTH DEALERS CLAIMED THAT THE COMPUTER DID NOT STORE ANY CODES AND THAT IT WAS RUNNING WITHIN SPECIFICATIONS.
SINCE DAY ONE HAVE HAD A "WOBBLE" IN FRONT END. STEERING WHEEL MOVES BACK AND FORTH. FEEL VIBRATION THROUGH FLOOR BOARD. THIS AT 35-40 MPH. NO "WOBBLE" OR VIBRATIONS AT HIGHER SPEEDS. TIRES ROTATED AND FRONT END BALANCED THREE TIMES. NO HELP. DODGE DEALER NO HELP. THEY SAID IT WAS THE GOODYEAR TIRES AND TO REPLACE THEM WITH MICH…
Read full complaint
SINCE DAY ONE HAVE HAD A "WOBBLE" IN FRONT END. STEERING WHEEL MOVES BACK AND FORTH. FEEL VIBRATION THROUGH FLOOR BOARD. THIS AT 35-40 MPH. NO "WOBBLE" OR VIBRATIONS AT HIGHER SPEEDS. TIRES ROTATED AND FRONT END BALANCED THREE TIMES. NO HELP. DODGE DEALER NO HELP. THEY SAID IT WAS THE GOODYEAR TIRES AND TO REPLACE THEM WITH MICHELIN. WILL BE LOOKING INTO FRONT AXLE OR DRIVELINE PROBLEMS NEXT.
SHORTLY AFTER THE ODOMETER REACHED 500 MILES, THE ENGINE BEGAN IDLING ROUGHLY AND MISSING. CONCERN ABOUT ENGINE FAILURE CAUSING ACCIDENT. RETURNED TO 2 SEPARATE DEALERS. BOTH STATED THE COMPUTER SHOWED NO PROBLEM, BUT SERVICE REPS ADMITTED HAVING OTHER COMPLAINTS. BOTH NOTED CHRYSLER REFUSED TO ACKNOWLEDGE ANY PROBLEM.
ON MY 2002 CHRYSLER PT CRUISER IT APPEARS THE GREASE FITTING ON BOTH LEFT AND RIGHT FRONT BALL JOINTS HAVE BEEN BROKEN OFF. I AM CONCERNED THAT A BROKEN GREASE FITTING CAN ACT AS A PATH FOR WATER AND OTHER CONTAMINANTS TO ENTER THE BALL JOINT AND CAUSE IT TO PREMATURELY WEAR OUT AND FAIL, POTENTIALLY CAUSING VEHICLE HANDLING PR…
Read full complaint
ON MY 2002 CHRYSLER PT CRUISER IT APPEARS THE GREASE FITTING ON BOTH LEFT AND RIGHT FRONT BALL JOINTS HAVE BEEN BROKEN OFF. I AM CONCERNED THAT A BROKEN GREASE FITTING CAN ACT AS A PATH FOR WATER AND OTHER CONTAMINANTS TO ENTER THE BALL JOINT AND CAUSE IT TO PREMATURELY WEAR OUT AND FAIL, POTENTIALLY CAUSING VEHICLE HANDLING PROBLEMS. I HEARD RUMORS THAT THE GREASE FITTINGS ARE PURPOSELY BEING BROKEN OFF AT THE CHRYSLER ASSEMBLY PLANT.
CONSUMER CALLED COMPLAINING ABOUT HAVING A PROBLEM WITH THE TIRES. ALSO STATED THAT THE FIRST WEEK THAT SHE BOUGHT THE VEHICLE SHE HAD TO TAKE IT BACK FOR SERVICE BECAUSE HER LEFT FRONT TIRE WAS LOW AND AT THE DEALER THEY PLUG THE TIRE AND NOW SHE IS HAVING THE SAME PROBLEM AGAIN. DEALER WAS CONTACTED AND DEALER AND THEY ADD A …
Read full complaint
CONSUMER CALLED COMPLAINING ABOUT HAVING A PROBLEM WITH THE TIRES. ALSO STATED THAT THE FIRST WEEK THAT SHE BOUGHT THE VEHICLE SHE HAD TO TAKE IT BACK FOR SERVICE BECAUSE HER LEFT FRONT TIRE WAS LOW AND AT THE DEALER THEY PLUG THE TIRE AND NOW SHE IS HAVING THE SAME PROBLEM AGAIN. DEALER WAS CONTACTED AND DEALER AND THEY ADD A PLUG INTO IT AND CONSUMER HAS NOT TAKING THE VEHICLE AGAIN. VEHICLE CARRIERS ORIGINAL EQUIPMENT. PLEASE ADD MANUFACTURE NAME, MODEL AND TIRE SIZE. TS
WHEN AIR CONDITIONER IS USED A BAD ODOR IS NOTICED, DEALER CAN NOT FIND A PROBLEM. TS
CONSUMER ADVISED THE ENGINE IS CONSUMING EXCESSIVE AMOUNTS OF OIL DURING NORMAL OPERATION. WITHIN 1K MILES CONSUMED 1.5 QUARTS AND WITHIN 3K MILES CONSUMED 2.5-3 QUARTS. CONSUMER IS CONCERNED THAT ENGINE MAY SEIZE WHILE DRIVING DUE TO EXCESSIVE CONSUMPTION. DEALER ADVISED CONSUMER VEHICLE HAS NO OIL LEAKS AND THAT CONSUMPTION…
Read full complaint
CONSUMER ADVISED THE ENGINE IS CONSUMING EXCESSIVE AMOUNTS OF OIL DURING NORMAL OPERATION. WITHIN 1K MILES CONSUMED 1.5 QUARTS AND WITHIN 3K MILES CONSUMED 2.5-3 QUARTS. CONSUMER IS CONCERNED THAT ENGINE MAY SEIZE WHILE DRIVING DUE TO EXCESSIVE CONSUMPTION. DEALER ADVISED CONSUMER VEHICLE HAS NO OIL LEAKS AND THAT CONSUMPTION IS NORMAL. TS *JG
CONSUMER IS COMPLAINING OF THE HEATED SEAT SWITCH WHICH IS MOUNTED ON THE OUT BOARD SIDE OF THE DRIVERS SEAT. THIS SWITCH CANNOT BE SEEN WHEN SITTING IN THE SEAT. CONSUMER FEELS THE SWITHCH IS IMPROPERLY POSITIONED. ALSO, WHEN MOVING IN BOTH THE PASSENGER AND THE DRIVERS SEAT THE SWITCH IS EASILY AGITATED AND WILL COME ON WHE…
Read full complaint
CONSUMER IS COMPLAINING OF THE HEATED SEAT SWITCH WHICH IS MOUNTED ON THE OUT BOARD SIDE OF THE DRIVERS SEAT. THIS SWITCH CANNOT BE SEEN WHEN SITTING IN THE SEAT. CONSUMER FEELS THE SWITHCH IS IMPROPERLY POSITIONED. ALSO, WHEN MOVING IN BOTH THE PASSENGER AND THE DRIVERS SEAT THE SWITCH IS EASILY AGITATED AND WILL COME ON WHEN IT IS NOT NEEDED. *JG
CONSUMER STATE THAT THE SHIFTER LEVER BUTTON DOES NOT HAVE TO BE DEPRESS TO CHANGE BETWEEN REVERSE, NEUTRAL OR DRIVE. WHILE DRIVING THE LEVER WAS "TAPPED" INTO REVERSE. CONSUMER IS VERY CONCERNED ABOUT SAFETY REGARDING ISSUE. MR
Official recalls
304V268000 · Steering:hydraulic Power Assist:hose, Piping, And Connections
Jun 3, 2004
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.4L NON-TURBOCHARGED ENGINES AND AUTOMATIC TRANSAXLES, THE POWER STEERING PRESSURE HOSE MAY CONTACT THE AUTOMATIC TRANSAXLE DIFFERENTIAL COVER, POTENTIALLY DAMAGING THE HOSE.
Consequence & remedy
Consequence: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSPECT AND RELOCATE, OR REPLACE AS NECESSARY, THE POWER STEERING HOSE AND CONFIRM TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END. THE RECALL BEGAN ON SEPTEMBER 20, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
02V215000 · Fuel System, Gasoline:delivery
Aug 8, 2002
ON CERTAIN PASSENGER VEHICLES, THE FUEL PUMP MODULE MOUNTING FLANGE COULD LEAK FUEL IF THE VEHICLE IS INVOLVED IN A ROLLOVER CRASH.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SECONDARY SEAL OVER THE FUEL PUMP MODULE. OWNER NOTIFICATION BEGAN AUGUST 12, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
01V288000 · Electrical System:wiring:interior/under Dash
Sep 10, 2001
VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES ARE BEING RECALLED FOR A SOFTWARE ERROR IN THE INSTRUMENT CLUSTER MICROPROCESSOR. UNDER CERTAIN CONDITIONS, THE CLUSTER, WITH THE MAJORITY OF ITS GAUGES, ILLUMINATION, AND WARNING LAMPS, COULD BECOME INOPERATIVE.
Consequence & remedy
Consequence: DRIVING THE VEHICLE WITH AN INOPERATIVE CLUSTER COULD CAUSE A DISTRACTION, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL RE-FLASH THE CLUSTER SOFTWARE TO CORRECT THE CONDITION. OWNER NOTIFICATION BEGAN OCTOBER 8, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE04028 · Engine Compartment Fires
Opened Mar 15, 2004 · Closed Jun 18, 2004
Status: closed (inferred from source dates) · Steering; Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Additional source detail variants (4)
Steering
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:hose, Piping, And Connections
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist:power Steering Fluid
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
Steering:hydraulic Power Assist System
PE04-028 WAS OPENED TO INVESTIGATE SEVEN COMPLAINTS ALLEGING THAT THE ENGINE COMPARTMENT CAUGHT FIRE ON MY 2002 PT CRUISER VEHICLES.ON JUNE 3, 2004, DAIMLERCHRYSLER (DCC) NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2001-2005 PT CRUISER VEHICLES EQUIPPED WITH NATURALLY ASPIRATED 2.4L ENGINES AND AUTOMATIC TRANSAXLES (RECALL 04V-268).THE NOTIFICATION IDENTIFIED VARIATION OF THE HIGH PRESSURE POWER STEERING HOSE ROUTING, WHICH ALLOWED THE HOSE TO CONTACT THE TRANSAXLE DIFFERENTIAL COVER, AS THE FACTOR CONTRIBUTING TO THIS DEFECT.CONTACT BETWEEN THE POWER STEERING HOSE AND THE TRANSAXLE DIFFERENTIAL COVER CAN CAUSE HOSE DAMAGE AND POWER STEERING FLUID LEAKAGE, WHICH CAN POTENTIALLY RESULT IN A FIRE. (NOTE: THE FAILURE DATA IN THIS RESUME IS LIMITED TO MY 2001-2003 VEHICLES PER DCC'S PE04-028 INFORMATION RESPONSES.)THIS CONDITION WAS LIMITED TO VEHICLES WITH AUTOMATIC TRANSAXLES AS VEHICLES WITH MANUAL TRANSMISSIONS HAVE SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND THE POWER STEERING HOSE DUE TO A SMALLER TRANSAXLE DESIGN.THIS CONDITION ALSO DOES NOT ADVERSELY AFFECT VEHICLES WITH TURBO ENGINES, WHICH HAVE A DIFFERENT POWER STEERING HOSE ROUTING THAT PROVIDES SUBSTANTIAL CLEARANCE BETWEEN THE TRANSAXLE DIFFERENTIAL COVER AND HOSE.DAIMLERCHRYSLER WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE POWER STEERING HOSE ASSEMBLY INSPECTED AND RELOCATED, OR REPLACED, AS NECESSARY, AND TO CONFIRM THE TORQUE OF THE HOSE FASTENER AT THE STEERING GEAR END.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.