TL* THE CONTACT OWNS A 2002 CHEVROLET VENTURE. WHILE DRIVING APPROXIMATELY 5 MPH, THE STEERING SNAPPED AND DISENGAGED. THE VEHICLE WAS COASTED TO THE SIDE OF THE ROAD AND WAS TOWED TO THE CONTACT'S RESIDENCE. BASED UPON THE CONTACT'S EXAMINATION, THE GEAR BOX WAS FRACTURED. THE FAILURE WAS NOT DIAGNOSED. THE MANUFACTURER WAS NOT…
Read full complaint
TL* THE CONTACT OWNS A 2002 CHEVROLET VENTURE. WHILE DRIVING APPROXIMATELY 5 MPH, THE STEERING SNAPPED AND DISENGAGED. THE VEHICLE WAS COASTED TO THE SIDE OF THE ROAD AND WAS TOWED TO THE CONTACT'S RESIDENCE. BASED UPON THE CONTACT'S EXAMINATION, THE GEAR BOX WAS FRACTURED. THE FAILURE WAS NOT DIAGNOSED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 145,000.
NHTSA ODI #10881493
145,740 miles · Jun 26, 2016
Steering
SOMETHING BROKE INSIDE STEERING COLUMN , RACK & PINON. 100% LOST CONTROL OF STEERING. VEHICLE WAS IN MOTION WHEN ATTEMPT TO TURN.
NHTSA ODI #10876635
123,000 miles · Jun 2, 2011
SteeringStructure
TL*THE CONTACT OWNS A 2002 CHEVROLET VENTURE. THE CONTACT STATED WHILE MAKING A TURN THE ENGINE FELL ON THE GROUND, THE STEERING COLUMN AND SUB FRAME BROKE. THE INSURANCE COMPANY TOWED THE VEHICLE TO AN AUTO BODY SHOP. THE VEHICLE WAS IN THE PROCESS REPAIRING THE VEHICLE. THE DEALER AND MANUFACTURER WERE CONTACTED. THE FAILURE …
Read full complaint
TL*THE CONTACT OWNS A 2002 CHEVROLET VENTURE. THE CONTACT STATED WHILE MAKING A TURN THE ENGINE FELL ON THE GROUND, THE STEERING COLUMN AND SUB FRAME BROKE. THE INSURANCE COMPANY TOWED THE VEHICLE TO AN AUTO BODY SHOP. THE VEHICLE WAS IN THE PROCESS REPAIRING THE VEHICLE. THE DEALER AND MANUFACTURER WERE CONTACTED. THE FAILURE AND CURRENT MILEAGE WAS 123,000.
NHTSA ODI #10404179
44,000 miles · May 17, 2009
Steering
I TOOK MY 2002 CHEVROLET VENTURE IN FOR A WHEEL ALIGNMENT, MY MECHANIC CALLED BACK AND SAID THE FRONT TIE RODS WERE IN IMMINENT DANGER OF FAILING. HE RECOMMENDED THAT THEY BE REPLACED, AND THEY WERE. ANOTHER EXAMPLE OF SHODDY, WE DON'T CARE WORKMANSHIP FROM GM. *TR
NHTSA ODI #10268961
45,000 miles · Apr 19, 2007
SteeringSuspension
TL* THE CONTACT OWNS A 2002 CHEVROLET VENTURE. WHILE DRIVING AT HIGHWAY SPEEDS OF 70 MILES PER HOUR, THE FRONT RIGHT TIRE ROD BROKE ALONG WITH THE FRONT RIGHT CONTROL ARM. THE DEALER (IN GRANTS PASS, OREGON) STATED THAT THEY ARE UNABLE TO ASSIST HIM WITH THE FAILURE SINCE IT WAS INVOLVED IN A CRASH; HOWEVER, THE CONTACT WAS NO…
Read full complaint
TL* THE CONTACT OWNS A 2002 CHEVROLET VENTURE. WHILE DRIVING AT HIGHWAY SPEEDS OF 70 MILES PER HOUR, THE FRONT RIGHT TIRE ROD BROKE ALONG WITH THE FRONT RIGHT CONTROL ARM. THE DEALER (IN GRANTS PASS, OREGON) STATED THAT THEY ARE UNABLE TO ASSIST HIM WITH THE FAILURE SINCE IT WAS INVOLVED IN A CRASH; HOWEVER, THE CONTACT WAS NOT INVOLVED A CRASH. THE FRONT TIRES WERE WORN AND THAT DOESNT OCCUR DURING AN ACCIDENT. THE CONTACT IS AWARE OF THE SAFETY RISK INVOLVED. THE FAILURE MILEAGE WAS 45,000 AND THE CURRENT MILEAGE WAS 57,2000.
NHTSA ODI #10188347
12,000 miles · Jan 6, 2005
Child SeatElectrical SystemExterior Lighting
CRANCKING EXTENSVLY, BRAKES FRONT AND REAR, UNEVEN WEAR AND TEAR, HYDROPLANING NOISE, VIBRATIONS, STEERING AND UNALIGNMENTS PROBLEMS, EMMISION REPAIRED AND TREATED, AS THE CREATED SULPHUR ODORS, AND STALLING. UNEVEN DRIVING, ABS LIGHT COMING ON AT SPEED EXCEEDING 60 MPH. *AK
NHTSA ODI #10105875
31,620 miles · Mar 5, 2004
Steering
CONSUMER HEARD A RUMBLING NOISE WHEN PULLING OUT OF PARKING SPACE. THIS NOISE WAS NOT HEARD WHEN VEHICLE WAS IN NORMAL DRIVING MOTION. VEHICLE HAD BEEN AT THE DEALER AT LEAST 4 TIMES. HOWEVER, DEALER WAS UNABLE TO DETERMINE THE CAUSE OF THE PROBLEM. *AK
NHTSA ODI #10061528
37,745 miles · Jan 19, 2004
Steering
BROKEN TIE ROD + RACK AND PINION FAILURE CAUSING TOTAL STEERING LOSS AND COSTLY REPAIRS! * CB
ON CERTAIN VEHICLES, VARIATIONS IN THE MANUFACTURING PROCESS OR EXPOSURE TO HIGH AMBIENT TEMPERATURES MAY LEAD TO FRACTURE OF THE FUEL TANK INLET CHECK VALVE (ICV).
Consequence & remedy
Consequence: A FRACTURE MAY ALLOW FUEL VAPORS TO PASS THROUGH AND ALLOW DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL TANK. THE RECALL WILL BE MAILED IN TWO PHASES WITH THE FIRST PHASE BEGINNING ON DECEMBER 4, 2007. THE SECOND PHASE WILL BE MAILED ON DECEMBER 13, 2007. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OR PONTIAC AT 1-800-620-7668. THE VEHICLE POPULATION INCLUDES BUICK RENDEZVOUS AND PONTIAC AZTEK VEHICLE BUILT IN MAY 2003; CHEVROLET VENTURE AND PONTIAC MONTANA VEHICLES BUILT FROM JUNE THROUGH AUGUST 2002; AND ALL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO, AND HAWAII.
ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.
Consequence & remedy
Consequence: IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.
Remedy: DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE04064 · POWER-SLIDING Door
Opened Sep 17, 2004 · Closed Dec 22, 2004
Status: closed (inferred from source dates) · Structure:body:door
SUBJECT VEHICLES ARE AVAILABLE WITH AN OPTIONAL POWER SLIDING DOOR.THE INTERIOR HANDLE IS ORIENTED IN THE VERTICAL POSITION IN THE DOOR PANEL AND LINES UP AT THE ELBOW LEVEL WHEN THE OCCUPANT IS SEATED IN THE 2ND-ROW OUTBOARD POSITION.IF THE OCCUPANT HOLDS THE INTERIOR HANDLE IN THE THUMB UP POSITION DURING POWER-ASSISTED OPENING, THE ARM/WRIST CAN BE PUSH BACK WITH FORCE AGAINST THE 2ND-ROW BUCKET SEAT OR CAPTAIN'S CHAIR SEAT BACK CREATING A RISK OF INJURY (OTHER SEATING CONFIGURATIONS HAVE AMPLE SEAT TO DOOR CLEARANCE TO AVOID ENTRAPMENT OF THE LOWER ARM).AMONG THE 103 TOTAL REPORTS, THERE WERE 102 ALLEGED INJURIES INCLUDING ARM/WRIST, THUMB AND SHOULDER INJURIES.A COUNT OF INJURIES REVEALS THAT 76 INJURIES WERE A FRACTURED OR A BROKEN ARM/WRIST REQUIRING AN IMMOBILIZING CAST FOR FOUR-TO-SIX WEEKS.ALL INJURIES INVOLVE THE RIGHT SIDE POWER SLIDING DOOR.THE LEFT SIDE POWER SLIDING DOOR IS ON FAR FEWER VEHICLES, BUT MORE IMPORTANTLY, IT PRODUCES LESS FORCE.GM NOTIFIED THE AGENCY BY LETTER DATED DECEMBER 21, 2004, THAT IT WILL RECALL MODEL YEAR 1997 THOUGH EARLY 2005 GM U-VAN VEHICLES EQUIPPED WITH A RIGHT SIDE POWER SLIDING DOOR AND WITH 2ND-ROW BUCKET SEATS OR CAPTAIN CHAIRS (NHTSA RECALL #04V597).AS PART OF THE RECALL REMEDY, GM WILL REPLACE THE DOOR HANDLE WITH A FLUSH MOUNTED HANDLE THAT WILL PREVENT AN OCCUPANT FROM GRASPING THE HANDLE WITH THE PALM BETWEEN THE HANDLE AND DOOR PANEL (THUMB UP ORIENTATION) AND THUS ELIMINATE THE POTENTIAL FOR ARM/WRIST ENTRAPMENT.THIS INVESTIGATION IS CLOSED.
2002 Chevrolet Venture Problems, Complaints & Recalls | Skip That Year
Illustration