IllustrationSymptoms similar to recall 07V349000. Smell of fuel accompanied by liquid on the ground. Inspection by mechanic indicates failure of fuel filler neck and accompanying inlet of the fuel tank itself. Unable to secure fuel filler neck replacement that fits, nor replacement fuel tank.
2001 Chevrolet Venture
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2001 Chevrolet Venture do not stand out strongly from the model-year median of 220.
About this comparison →How this year compares
Owner complaints by model year
Compare all Venture years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
150–25K
4025–50K
2950–75K
1975–100K
13100–150K
14150K+
130 reports with mileage · 92 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 44 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 30 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 25 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
17 crash reports3 fire reports23 injury reports
What owners actually said
222 reportsI HAVE A LEAKING FUEL TANK. IT IS DESCRIBED PERFECTLY IN RECALL: 07V349000, GM RECALL # 06230. WHEN I TOOK IT TO THE DEALER, THEY TOLD ME BECAUSE OF HIGHER MILEAGE, IT IS NOT COVERED. I THEN CALLED GM AND THEY TOLD ME THE SAME THING. HOW CAN YOU SELL A VEHICLE WITH A DEFECTIVE PART, PUT IT ON RECALL AND THEN NOT FIX IT? I A…
Read full complaint
I HAVE A LEAKING FUEL TANK. IT IS DESCRIBED PERFECTLY IN RECALL: 07V349000, GM RECALL # 06230. WHEN I TOOK IT TO THE DEALER, THEY TOLD ME BECAUSE OF HIGHER MILEAGE, IT IS NOT COVERED. I THEN CALLED GM AND THEY TOLD ME THE SAME THING. HOW CAN YOU SELL A VEHICLE WITH A DEFECTIVE PART, PUT IT ON RECALL AND THEN NOT FIX IT? I AM GLAD I FOUND IT BEFORE MY VEHICLE CAUGHT ON FIRE!
TL* THE CONTACT OWNS A 2001 CHEVROLET VENTURE. THE CONTACT STATED THAT WHILE OPERATING THE VEHICLE, AN ODOR OF FUEL WAS PRESENT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FUEL TANK WAS CRACKED CAUSING FUEL TO LEAK OUT. THE FUEL TANK WAS REPLACED AND THE FAILURE WAS REMEDIED. THE MANUFACTURER WAS NO…
Read full complaint
TL* THE CONTACT OWNS A 2001 CHEVROLET VENTURE. THE CONTACT STATED THAT WHILE OPERATING THE VEHICLE, AN ODOR OF FUEL WAS PRESENT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FUEL TANK WAS CRACKED CAUSING FUEL TO LEAK OUT. THE FUEL TANK WAS REPLACED AND THE FAILURE WAS REMEDIED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 117,000.
I WAS TOLD IT HAD INTERMITTENT REAR LIGHTING PROBLEM (DRIVER SIDE REAR LIGHTS WOULD GO IN AND OUT) WHEN PURCHASING VEHICLE USED IN 2012 WITH160,000 MILES, 90% HIGHWAY. HAD REPAIRED IMMEDIATELY FOR SAFETY, LEGAL AND STATE REQUIRED ANNUAL INSPECTIONS (OR SO I THOUGHT). WITHIN 3 MONTHS/75 MILES LATER, IT STARTED AGAIN. ENTIRE WI…
Read full complaint
I WAS TOLD IT HAD INTERMITTENT REAR LIGHTING PROBLEM (DRIVER SIDE REAR LIGHTS WOULD GO IN AND OUT) WHEN PURCHASING VEHICLE USED IN 2012 WITH160,000 MILES, 90% HIGHWAY. HAD REPAIRED IMMEDIATELY FOR SAFETY, LEGAL AND STATE REQUIRED ANNUAL INSPECTIONS (OR SO I THOUGHT). WITHIN 3 MONTHS/75 MILES LATER, IT STARTED AGAIN. ENTIRE WIRING HARNESS AND LIGHT ASSEMBLY WAS REPLACED, TO NO AVAIL. BEFORE I COULD TAKE IT IN AGAIN, BOTH REAR LIGHTS INTERMITTENTLY STOPPED WORKING. PASSENGER SIDE WIRING HARNESS AND LIGHT ASSEMBLY REPLACED. IT WASN'T FIXED.AND BEFORE I COULD GET IT BACK IN THE SHOP, THE FRONT PASSENGER SIDE LIGHTS STARTED THE SAME THING. NEW MECHANIC ASSURES ME, " DON'T WORRY, THERE ARE MANY THINGS I CAN TRY!" LITTLE CONSOLATION FOR THE DRIVERS BEHIND ME OR FOR ME FROM BEING PULLED OVER BY & TICKETED OR WHEN I NEED THE VA STATE MANDATORY "ANNUAL INSPECTION" STICKER. THEY ARE ABLE TO GET THEM TO WORK LONG ENOUGH BUT AGAIN, AT WHAT COST? MEANWHILE, THE INTERMITTENT PROBLEM MOVED TO THE PASSENGER FRONT LIGHTS, WHEN HITTING BRAKES I SEE THAT FLASHERS START TO WORK. ALL OF THE MECHANICS ARE "PUTTING A BAND-AID ON A BROKEN ARM". & II'M PAYING DEARLY EACH AND EVERY TIME. THEY NOW WANT TO REPLACE THINGS IN THE STEERING WHEEL BUT I WANT CHEVROLET TO CORRECT THE PROBLEM THIS TIME OR TELL THE MECHANICS WHAT TO DO. THIS IS A MINI-VAN THAT I DRIVE BACK AND FORTH TO THE GROCERY AND SCHOOL, .5 MILES - 5 MILES A WAY 3-4 TIMES A WEEK.
THE FUEL TANK LEAKS AT THE FUEL TANK, LEAK AT THE FUEL TANK FILLER TUBE ATTACHMENT POINT TO THE TANK. THERE IS A RUBBER GROMMET ON THE TANK THAT THE TUBE ATTACHES TO THE TANK WHERE THE LEAK IS. DEFIANTLY A FIRE HAZARD. LEAKS WHEN TANK IS MORE THAN 1/2 FULL. THIS TUBE IS METAL AND THE FUEL TANK FILLER TUBE ATTACHES TO WITH A RUBB…
Read full complaint
THE FUEL TANK LEAKS AT THE FUEL TANK, LEAK AT THE FUEL TANK FILLER TUBE ATTACHMENT POINT TO THE TANK. THERE IS A RUBBER GROMMET ON THE TANK THAT THE TUBE ATTACHES TO THE TANK WHERE THE LEAK IS. DEFIANTLY A FIRE HAZARD. LEAKS WHEN TANK IS MORE THAN 1/2 FULL. THIS TUBE IS METAL AND THE FUEL TANK FILLER TUBE ATTACHES TO WITH A RUBBER HOSE AND CLAMP. THE CHEVROLET DEALER SAYS THE VIN WAS EXCLUDE FROM NHTSA CAMPAIGN ID NUMBER 07V349000 (FUEL SYSTEM, GASOLINE:STORAGE), ALTHOUGH THE FAILURES WERE IDENTICAL. THE DEALER STATED HAVE TO REPLACE THE FUEL TANK WHICH NOT COVERED.
TL* THE CONTACT OWNS A 2001 CHEVROLET VENTURE. WHILE DRIVING APPROXIMATELY 50 MPH IN THE RAIN, THE WINDSHIELD WIPERS FAILED TO OPERATE PROPERLY. AFTER ACTIVATING THE WIPERS, THEY BECAME JAMMED TOGETHER. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE WIPER TRANSMISSION WAS FAULTY. THE TRANSMISSION WAS REP…
Read full complaint
TL* THE CONTACT OWNS A 2001 CHEVROLET VENTURE. WHILE DRIVING APPROXIMATELY 50 MPH IN THE RAIN, THE WINDSHIELD WIPERS FAILED TO OPERATE PROPERLY. AFTER ACTIVATING THE WIPERS, THEY BECAME JAMMED TOGETHER. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE WIPER TRANSMISSION WAS FAULTY. THE TRANSMISSION WAS REPLACED, BUT THE CONTACT CONTINUED TO EXPERIENCE THE FAILURES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 15,000.
FUEL LEAKING IN THE GROUND AROUND THE DRIVERS SIDE REAR TIRE.
THE COOLING SYSTEM OVERHEATS ALOT AND IVE BOUGHT ALOT OF COOLANT BECAUSE OF THIS PROBLEM AND IVE GOTTEN STRANDED A COUPLE OF TIMES AND ITS CRAZY IVE DID SOME RESEARCH AND IT COULD BE MULTIPLE THINGS BUT FOR SURE ITS GOING TO COST ALOT FOR THIS I CANT LAY FOR THESE EXSPENSIVE REPAIRS IM STILL GOING AND PAYING FOR SCHOOL ID JUST W…
Read full complaint
THE COOLING SYSTEM OVERHEATS ALOT AND IVE BOUGHT ALOT OF COOLANT BECAUSE OF THIS PROBLEM AND IVE GOTTEN STRANDED A COUPLE OF TIMES AND ITS CRAZY IVE DID SOME RESEARCH AND IT COULD BE MULTIPLE THINGS BUT FOR SURE ITS GOING TO COST ALOT FOR THIS I CANT LAY FOR THESE EXSPENSIVE REPAIRS IM STILL GOING AND PAYING FOR SCHOOL ID JUST WOULD LIKE SOME HELP TO GET THESE EXSPENSIVE REPAIRS FIXED BECAUSE THIS VAN IS MY OWNLY TRANSPORTATION.
TL* THE CONTACT OWNS A 2001 CHEVROLET VENTURE. WHILE DRIVING APPROXIMATELY 65 MPH, A LOUD NOISE WAS COMING FROM THE ENGINE. IN ADDITION, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. AND THE VEHICLE FAILED TO CHANGE GEARS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE OXYGEN SENSOR NEEDED TO BE REPLACED.…
Read full complaint
TL* THE CONTACT OWNS A 2001 CHEVROLET VENTURE. WHILE DRIVING APPROXIMATELY 65 MPH, A LOUD NOISE WAS COMING FROM THE ENGINE. IN ADDITION, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. AND THE VEHICLE FAILED TO CHANGE GEARS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE OXYGEN SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 162,000.
THE DRIVER'S SEATBELT WILL ONLY LATCH INTO THE BRACKET ABOUT HALF THE TIME. SOMETIMES IT TAKES UP TO 5 MINUTES TO GET IT TO CLICK IN. OTHERWISE IT JUST WILL NOT CLICK. I HAVE HAD TO STRETCH IT ACROSS TO HOOK IT INTO THE PASSENGER'S SIDE SEATBELT. LUCKILY FOR ME I DIDN'T HAVE A PASSENGER SO I COULD DO THIS BUT I AM WORRIED THA…
Read full complaint
THE DRIVER'S SEATBELT WILL ONLY LATCH INTO THE BRACKET ABOUT HALF THE TIME. SOMETIMES IT TAKES UP TO 5 MINUTES TO GET IT TO CLICK IN. OTHERWISE IT JUST WILL NOT CLICK. I HAVE HAD TO STRETCH IT ACROSS TO HOOK IT INTO THE PASSENGER'S SIDE SEATBELT. LUCKILY FOR ME I DIDN'T HAVE A PASSENGER SO I COULD DO THIS BUT I AM WORRIED THAT IN ATTACHING IT INTO THE PASSENGER'S SIDE THAT IT WILL NOT PERFORM SHOULD I NEED IT TO. *TR
Official recalls
907V349000 · Fuel System, Gasoline:storage
Aug 8, 2007
ON CERTAIN VEHICLES, VARIATIONS IN THE MANUFACTURING PROCESS OR EXPOSURE TO HIGH AMBIENT TEMPERATURES MAY LEAD TO FRACTURE OF THE FUEL TANK INLET CHECK VALVE (ICV).
Consequence & remedy
Consequence: A FRACTURE MAY ALLOW FUEL VAPORS TO PASS THROUGH AND ALLOW DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL TANK. THE RECALL WILL BE MAILED IN TWO PHASES WITH THE FIRST PHASE BEGINNING ON DECEMBER 4, 2007. THE SECOND PHASE WILL BE MAILED ON DECEMBER 13, 2007. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OR PONTIAC AT 1-800-620-7668. THE VEHICLE POPULATION INCLUDES BUICK RENDEZVOUS AND PONTIAC AZTEK VEHICLE BUILT IN MAY 2003; CHEVROLET VENTURE AND PONTIAC MONTANA VEHICLES BUILT FROM JUNE THROUGH AUGUST 2002; AND ALL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO, AND HAWAII.
04V597000 · Latches/locks/linkages:doors:latch
Dec 22, 2004
ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.
Consequence & remedy
Consequence: IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.
Remedy: DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.
03V250000 · Equipment:other:owners/service/other Manual
Jul 15, 2003
CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
02V329000 · Air Bags:frontal
Dec 9, 2002
ON CERTAIN PASSENGER, SPORT UTILITY VEHICLES AND MINI VANS, SOME OF THESE VEHICLES HAVE A PASSENGER AIR BAG THAT WAS MANUFACTURED WITHOUT A CHECK VALVE PIN. AN AIR BAG WITHOUT THE CHECK VALVE PIN COULD PRODUCE INCREASED PRESSURE AT THE ONSET OF THE AIR BAG DEPLOYMENT AND REDUCED PRESSURE AFTERWARD.
Consequence & remedy
Consequence: THIS COULD INCREASE THE SEVERITY OF INJURY TO A PERSON WHO WAS NOT PROPERLY RESTRAINED AND WHO WAS CLOSE TO THE PASSENGER AIR BAG AT THE TIME OF DEPLOYMENT. IT COULD ALSO REDUCE THE AB8ILITY OF THE AIR BAG TO PROTECT A RESTRAINED FRONT SEAT PASSENGER.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE PASSENGER AIR BAG. OWNER NOTIFICATION BEGAN DECEMBER 16, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OLDSMOBILE AT 1-800-442-6537, OR SATURN AT 1-800-553-6000, PROMPT #3.
01V383000 · Seats:front Assembly:recliner
Dec 13, 2001
VEHICLE DESCRIPTION: CERTAIN MINI VANS BUILT WITH SECOND ROW 50/50 SPLIT BENCH SEATS OR CAPTAIN'S CHAIRS, FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE SEAT LATCH ANCHOR WIRE DIAMETER IS GREATER THAN 6.1 MM.
Consequence & remedy
Consequence: IF THE CONNECTOR FOR A LATCH-TYPE CHILD RESTRAINT IS NOT ATTACHED CORRECTLY TO THE ANCHORAGE POINTS, THE RESTRAINT WILL NOT PROPERLY PROTECT A CHILD IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSPECT THE LATCH ANCHOR WIRES AND REPAIR THOSE WITH AN IMPROPER DIAMETER. OWNER NOTIFICATION BEGAN APRIL 10, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
01V264000 · Latches/locks/linkages:doors:latch
Aug 21, 2001
VEHICLE DESCRIPTION: 1997-2001 CHEVROLET VENTURE, PONTIAC MONTANA/TRANSPORT, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS THAT WERE SERVICED IN CAMPAIGN 01013 (01V-067) FROM APRIL TO AUGUST 2001. ALSO 2001 CHEVROLET VENTURE, PONTIAC MONTANA, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS ASSEMBLED IN JANUARY THROUGH APRIL 2001. THESE VEHICLES HAVE INADEQUATE FRONT WELDS. IF A FRONT WELD FAILS, THE ACTUATOR CAN JAM IN THE UNLATCHED POSITION AND, WHEN THE SLIDING DOOR CLOSES, IT WILL NOT BE LATCHED.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE. AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Remedy: DEALERS WILL INSPECT AND, IF REQUIRED, INSTALL A NEW POWER SLIDING DOOR UNLATCH ACTUATOR ASSEMBLY. OWNER NOTIFICATION BEGAN ON OCTOBER 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
01V067000 · Latches/locks/linkages:doors:latch
Mar 8, 2001
VEHICLE DESCRIPTION: MINIVANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS. THE DOOR CLOSES BUT MAY NOT BE LATCHED. IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE.
Consequence & remedy
Consequence: AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Remedy: DEALERS WILL INSTALL A NEW UN-LATCH ACTUATOR ASSEMBLY TO THE POWER SLIDING DOOR. THIS RECALL HAS BEEN CONTINUED UNDER SAFETY RECALL 01V-264. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
01V026000 · Air Bags:frontal
Feb 1, 2001
VEHICLE DESCRIPTION: PASSENGER, SPORT UTILITY VEHICLES AND MINIVANS. THE PASSENGER AIR BAG INFLATOR MODULES WERE BUILT WITHOUT THE CORRECT AMOUNT OF GENERANT, WHICH PRODUCES THE GAS THAT FILLS THE AIR BAG. SOME WERE BUILT WITH A DOUBLE LOAD OF GENERANT AND SOME WERE BUILT WITHOUT GENERANT.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH THAT WOULD TRIGGER A PASSENGER AIR BAG DEPLOYMENT, A DOUBLE LOAD OF GENERANT CAN CAUSE THE INFLATOR MODULE TO EXPLODE. IF THE AIR BAG MODULE EXPLODES, METAL AND PLASTIC DEBRIS COULD CAUSE SEVERE INJURY TO VEHICLE OCCUPANT. A MODULE WITH NO GENERANT WOULD NOT INFLATE THE AIR BAG, AND THE OCCUPANTS COULD RECEIVE MORE SEVERE INJURIES.
Remedy: DEALERS WILL REPLACE THE PASSENGER AIR BAG MODULE. TELEPHONE CALLS WERE MADE TO OWNERS ON JANUARY 29, 2001. FOLLOW UP OWNER MAILING BEGAN ON APRIL 17, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR SATURN AT 1-800-553-6000.
00V228003 · Seat Belts
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE04064 · POWER-SLIDING Door
Opened Sep 17, 2004 · Closed Dec 22, 2004
Status: closed (inferred from source dates) · Structure:body:door
SUBJECT VEHICLES ARE AVAILABLE WITH AN OPTIONAL POWER SLIDING DOOR.THE INTERIOR HANDLE IS ORIENTED IN THE VERTICAL POSITION IN THE DOOR PANEL AND LINES UP AT THE ELBOW LEVEL WHEN THE OCCUPANT IS SEATED IN THE 2ND-ROW OUTBOARD POSITION.IF THE OCCUPANT HOLDS THE INTERIOR HANDLE IN THE THUMB UP POSITION DURING POWER-ASSISTED OPENING, THE ARM/WRIST CAN BE PUSH BACK WITH FORCE AGAINST THE 2ND-ROW BUCKET SEAT OR CAPTAIN'S CHAIR SEAT BACK CREATING A RISK OF INJURY (OTHER SEATING CONFIGURATIONS HAVE AMPLE SEAT TO DOOR CLEARANCE TO AVOID ENTRAPMENT OF THE LOWER ARM).AMONG THE 103 TOTAL REPORTS, THERE WERE 102 ALLEGED INJURIES INCLUDING ARM/WRIST, THUMB AND SHOULDER INJURIES.A COUNT OF INJURIES REVEALS THAT 76 INJURIES WERE A FRACTURED OR A BROKEN ARM/WRIST REQUIRING AN IMMOBILIZING CAST FOR FOUR-TO-SIX WEEKS.ALL INJURIES INVOLVE THE RIGHT SIDE POWER SLIDING DOOR.THE LEFT SIDE POWER SLIDING DOOR IS ON FAR FEWER VEHICLES, BUT MORE IMPORTANTLY, IT PRODUCES LESS FORCE.GM NOTIFIED THE AGENCY BY LETTER DATED DECEMBER 21, 2004, THAT IT WILL RECALL MODEL YEAR 1997 THOUGH EARLY 2005 GM U-VAN VEHICLES EQUIPPED WITH A RIGHT SIDE POWER SLIDING DOOR AND WITH 2ND-ROW BUCKET SEATS OR CAPTAIN CHAIRS (NHTSA RECALL #04V597).AS PART OF THE RECALL REMEDY, GM WILL REPLACE THE DOOR HANDLE WITH A FLUSH MOUNTED HANDLE THAT WILL PREVENT AN OCCUPANT FROM GRASPING THE HANDLE WITH THE PALM BETWEEN THE HANDLE AND DOOR PANEL (THUMB UP ORIENTATION) AND THUS ELIMINATE THE POTENTIAL FOR ARM/WRIST ENTRAPMENT.THIS INVESTIGATION IS CLOSED.