IllustrationBALL JOINTS THIS VEHICLE HAS FAILED MASSACHUSETTS YEARLY INSPECTION 2 YEARS IN A ROW DUE TO SLOPPY BALL JOINTS. IF THE VEHICLE WAS NOT INSPECTED THE RESULT COULD BE RATHER HAZARDOUS TO ME AND PEOPLE ON THE HIGHWAY. *TR
2000 Chevrolet Blazer
Owner reports · Recalls · Investigations
More warning signs than most Blazer years
Owner complaints for the 2000 Chevrolet Blazer are substantially higher than the model-year median of 32.
About this comparison →How this year compares
Owner complaints by model year
Compare all Blazer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
150–25K
6325–50K
8550–75K
4175–100K
51100–150K
15150K+
270 reports with mileage · 319 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Suspension. Review the 100 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 84 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 79 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
46 crash reports7 fire reports25 injury reports
What owners actually said
589 reportsTL*THE CONTACT OWNS A 2000 CHEVROLET BLAZER. WHILE DRIVING 40 MPH, THE CONTACT ATTEMPTED TO STOP THE VEHICLE AND THE ABS ENGAGED. THE CONTACT HAD TO APPLY MORE BRAKE PRESSURE IN ORDER TO STOP THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER AND THE CONTACT WAS INFORMED THAT THE FRONT HUB WHEEL SPEED SENSOR NEEDED TO BE REPLAC…
Read full complaint
TL*THE CONTACT OWNS A 2000 CHEVROLET BLAZER. WHILE DRIVING 40 MPH, THE CONTACT ATTEMPTED TO STOP THE VEHICLE AND THE ABS ENGAGED. THE CONTACT HAD TO APPLY MORE BRAKE PRESSURE IN ORDER TO STOP THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER AND THE CONTACT WAS INFORMED THAT THE FRONT HUB WHEEL SPEED SENSOR NEEDED TO BE REPLACED. THERE WERE NO PRIOR WARNINGS. THE CURRENT AND FAILURE MILEAGES WERE 73,640. UPDATED 12-04-08 *BF THE DEALER REPLACED THE WHEEL SPEED SENSORS. UPDATED 12/10/08. *JB
TOOK VEHICLE IN FOR OIL CHANGE, NEXT DAY CAR MADE NOISES AND LEAKED OIL. CONTACTED DEALER, TWO DAYS LATER CAR NEEDED TWO QTS OF OIL. CAR DEALER THEN TOWED CAR,HAD CAR FOR A WEEK AND SAID 'IT'S NOT THEIR FAULT'. EXTENDED WARRANTY EXPIRED. *TR
FUEL GAGE SWITCHES BETWEEN FULL TO EMPTY ALL THE TIME. WHEN THE CAR IS AT STOP AND RUNNING, TO DRIVING DOWN THE ROAD. YOU NEVER REALLY KNOW HOW MUCH GAS YOU REALLY HAVE. I HAVE TAKEN TO WRITING DOWN THE MILEAGE EVERY TIME I FILL UP. *TR
FUEL GAUGE FLUCTUATES WILDLY BETWEEN FULL AND EMPTY WHEN TANK IS LESS THAN HALF FULL. IF YOU LOOK IT UP THE GMC JIMMY WHICH USES THE SAME FUEL SYSTEM HAS THE SAME CUSTOMER COMPLAINTS. YOU NEVER KNOW HOW MUCH GAS YOU HAVE IN THE TANK. THIS CAUSED ME TO RUN OUT OF GAS ON A INTERSTATE HIGHWAY IN THE MIDDLE OF RUSH HOUR AND I WAS UN…
Read full complaint
FUEL GAUGE FLUCTUATES WILDLY BETWEEN FULL AND EMPTY WHEN TANK IS LESS THAN HALF FULL. IF YOU LOOK IT UP THE GMC JIMMY WHICH USES THE SAME FUEL SYSTEM HAS THE SAME CUSTOMER COMPLAINTS. YOU NEVER KNOW HOW MUCH GAS YOU HAVE IN THE TANK. THIS CAUSED ME TO RUN OUT OF GAS ON A INTERSTATE HIGHWAY IN THE MIDDLE OF RUSH HOUR AND I WAS UNABLE TO PULL OVER TO THE SIDE BECAUSE OF TRAFFIC. LUCKILY NO ONE RAN INTO ME, BUT IT DID CREATE A BAD TRAFFIC PROBLEM. GM REFUSES TO ADMIT THIS A PROBLEM BUT THE MECHANICS I'VE TALKED TO SAY THIS IS A PROBLEM THEY HAVE TO REPAIR ALL THE TIME. THIS VEHICLE SHOULD BE RECALLED BEFORE SOMEONE GETS INJURED OR KILLED. *TR
THE FUEL GAUGE DOES NOT WORK. IT GOES FROM EMPTY TO FULL ALL THE TIME NO MATTER HOW MUCH GAS YOU HAVE. *TR
VEHICLE IS EXHIBITING PROBLEMS WITH BRAKE LIGHTS AND HAZARD FLASHERS, CONSISTENT WITH RECALL 01073. THESE ISSUED HAVE BEEN INTERMITTENT, BUT IN THE PAST MONTH HAVE BECOME CONSTANT. CHEVROLET CUSTOMER SERVICE HAS STATED THAT THIS RECALL SERVICE WAS PERFORMED IN 2002. THIS ISSUE WITH LIGHTS HAS OCCURRED SINCE 2007, CONTACT WITH…
Read full complaint
VEHICLE IS EXHIBITING PROBLEMS WITH BRAKE LIGHTS AND HAZARD FLASHERS, CONSISTENT WITH RECALL 01073. THESE ISSUED HAVE BEEN INTERMITTENT, BUT IN THE PAST MONTH HAVE BECOME CONSTANT. CHEVROLET CUSTOMER SERVICE HAS STATED THAT THIS RECALL SERVICE WAS PERFORMED IN 2002. THIS ISSUE WITH LIGHTS HAS OCCURRED SINCE 2007, CONTACT WITH CHEVY HAS BEEN OFF AND ON SINCE THAT POINT. CONTACTED CHEVY TODAY 9/15/2008 BECAUSE MULTI-FUNCTION SWITCH HAS NOW STARTED TO SMOKE WHEN TURN SIGNALS ARE USED. THIS IS OBVIOUSLY COMING FROM THE MFC WHICH WAS SUPPOSEDLY REPAIRED IN 2002. CHEVY HAS STATED THAT RECALLS ARE A ONE-TIME FIX AND ANY FURTHER ISSUES AT ANY POINT IS THE LIABILITY OF THE CUSTOMER. THEY ARE UNWILLING TO PROVIDE ANY SUPPORT FOR A RESOLUTION OF A RECALL REPAIR WITH WAS PERFORMED ONLY 6 YEARS AGO. IF THIS ISSUE IS UNRELATED TO THE 01073 RECALL, I AM WILLING TO PAY FOR REPAIRS OUT OF MY POCKET, BUT I WANT CHEVY TO INITIATE THE DIAGNOSIS, INSTEAD THEY ARE TELLING ME THAT THEY WILL PROVIDE NO FINANCIAL SUPPORT WHATSOEVER TO EVEN DETERMINE THE CAUSE OF THIS ERROR. I HAVE STRESSED THE IMPORTANCE OF OPERATING A VEHICLE WITH ALL SAFETY FEATURES INTACT, AND IT IS OBVIOUS THAT THE SAME PROBLEM THAT 01073 ADDRESSED HAS RECURRED. I WOULD LIKE CHEVY TO BEAR THE COSTS OF DIAGNOSIS, AND COSTS OF PARTS AND LABOR FOR ALL REPAIRS REQUIRED TO REMEDY THE MALFUNCTIONS RELATING TO THE HAZARD SWITCH AND/OR MFC (MULTI-FUNCTION TURN SIGNAL SWITCH). *TR
I PURCHASED A 2000 2WD CHEVY BLAZER. WHEN IT RAINS ALOT. WHEN IT RAINS I GET A PUDDLE IN THE BACK FLOOR AND IT LEAKS ALL THE WAY TO THE FRONT OF THE VEHICLE. THERE SHOULD BE SOME TYPE OF RECALL FOR THIS. I HAVE TO USE THE WET VAC TO CLEAN THIS UP EVERY TIME. THE OTHER ITEM WHEN IT RAINS IS SOMETIMES THE BLAZER WILL NOT EVEN STAR…
Read full complaint
I PURCHASED A 2000 2WD CHEVY BLAZER. WHEN IT RAINS ALOT. WHEN IT RAINS I GET A PUDDLE IN THE BACK FLOOR AND IT LEAKS ALL THE WAY TO THE FRONT OF THE VEHICLE. THERE SHOULD BE SOME TYPE OF RECALL FOR THIS. I HAVE TO USE THE WET VAC TO CLEAN THIS UP EVERY TIME. THE OTHER ITEM WHEN IT RAINS IS SOMETIMES THE BLAZER WILL NOT EVEN START. IT IS LIKE IF THE CAR HAS TO DRY BEFORE IT CAN START AND STAY ON. *TR
FUEL GAUGE FLUCTUATES VIOLENTLY AND RAPIDLY REGARDLESS OF THE AMOUNT OF GAS IN TANK. PROBLEM HAS EXISTED FOR OVER TWO YEARS AND APPEARS TO BE A COMMON DEFECT WITH PART. ATTEMPT TO REPLACE HOWEVER OPTIONS ARE LIMITED DUE TO SENDING UNIT AND FUEL TOGETHER AS ONE UNIT. *TR
TL*THE CONTACT OWNS A 2000 CHEVROLET BLAZER. THE CONTACT TOOK HER VEHICLE TO AN AUTHORIZED DEALER AND THEY STATED THAT THE FRAME, CONTROL ARM, AND TORSION BAR HAD EXCESSIVE RUST. THE TECHNICIAN STATED THAT IN ORDER FOR THE VEHICLE TO BE CLASSIFIED AS SAFE, SHE WOULD HAVE TO REPLACE THE ENTIRE FRAME AND MEMBERS AT HER EXPENSE B…
Read full complaint
TL*THE CONTACT OWNS A 2000 CHEVROLET BLAZER. THE CONTACT TOOK HER VEHICLE TO AN AUTHORIZED DEALER AND THEY STATED THAT THE FRAME, CONTROL ARM, AND TORSION BAR HAD EXCESSIVE RUST. THE TECHNICIAN STATED THAT IN ORDER FOR THE VEHICLE TO BE CLASSIFIED AS SAFE, SHE WOULD HAVE TO REPLACE THE ENTIRE FRAME AND MEMBERS AT HER EXPENSE BECAUSE THE VEHICLE EXCEEDED ITS WARRANTY. THE VEHICLE HAS NOT BEEN REPAIRED. THE MANUFACTURER DID NOT ASSIST. THE FAILURE MILEAGE WAS 15,000 AND CURRENT MILEAGE WAS 24,000. UPDATED 10/14/08 *BF THE ROTORS HAD TO BE REPLACED DUE TO RUST BUILD-UP. THE DRIVER SIDE DOOR PINS, BUSHINGS AND RETAINER HAD TO BE REPLACED DUE TO RUST. UPDATED 10/15/08. *JB
Official recalls
408V231000 · Exterior Lighting:brake Lights:switch
May 21, 2008
GENERAL MOTORS IS RECALLING 5,862 MY 2000-2002 CHEVROLET BLAZER, MY 2000-2001 GMC JIMMY, AND MY 2000 OLDSMOBILE BRAVADA SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. THE RECALL BEGAN ON JUNE 17, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR OLDSMOBILE AT 1-800-630-6537, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> . NOTE: THIS CAMPAIGN IS AN EXPANSION OF A PREVIOUS RECALL (PLEASE SEE 01V364).
01V364000 · Exterior Lighting:brake Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:switch
Dec 3, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Exterior Lighting:brake Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
00V228003 · Seat Belts
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
99V220000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
Aug 11, 1999
VEHICLE DESCRIPTION: S -TRUCKS EQUIPPED WITH 2 WHEEL DRIVE. THESE VEHICLES MAY HAVE HAD THE RIGHT-HAND ANTILOCK BRAKE SYSTEM (ABS) MODULE FEED PIPE AND/OR BRAKE CROSSOVER PIPE TUBE NUTS TIGHTENED WITHOUT SEATING THE PIPE-FLARED-ENDS ENOUGH TO WITHSTAND NORMAL ASSEMBLY AND VEHICLE INPUTS WITHOUT PARTIALLY UNSEATING. THIS DOES NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC SERVICE BRAKE NORMAL, EMERGENCY, AND PARK BRAKING PERFORMANCE."
Consequence & remedy
Consequence: IF THIS OCCURRED, THE SEATING SEAL COULD BE BROKEN DURING VEHICLE ASSEMBLY, OR FROM EARLY ROAD INPUTS OR BRAKE FLUID CYCLING, AND A LEAK COULD OCCUR INCREASING THE BRAKE STOPPING DISTANCE.
Remedy: DEALERS WILL INSPECT THE BRAKE PIPE UNION FOR SIGNS OF BRAKE FLUID, AND IF NECESSARY, INSTALL A NEW BRAKE PIPE UNION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3RQ08001 · Hazard Light Switch Failure
Opened Feb 28, 2008 · Closed Jul 9, 2008
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
RQ02012 · Front Control Arm Ball Joints
Opened Sep 10, 2002 · Closed Mar 7, 2003
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
SEE ATTACHED PAGE.
Additional source detail variants (7)
Suspension:front:control Arm
SEE ATTACHED PAGE.
Suspension:front:control Arm:lower Arm
SEE ATTACHED PAGE.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED PAGE.
Suspension:front:control Arm:upper Arm
SEE ATTACHED PAGE.
Suspension:front:control Arm:upper Ball Joint
SEE ATTACHED PAGE.
Suspension:front
SEE ATTACHED PAGE.
Suspension
SEE ATTACHED PAGE.
PE01032 · Loss Of Stop Lamp Illumination
Opened Sep 6, 2001 · Closed Dec 20, 2001
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.