IllustrationRELAY FOR 4 WAY FLASHERS IS CLICKING, ONLINE MY PROBLEM WITH FLASHER RELAY AND BRAKE LIGHTS IS LISTED UNDER RECALL 01073B. I HAVE NO IDEA IF THIS RECALL WAS DONE, DONE PROPERLY OR JUST TIMED OUT.
2000 Chevrolet Blazer
Owner reports · Recalls · Investigations
More warning signs than most Blazer years
Owner complaints for the 2000 Chevrolet Blazer are substantially higher than the model-year median of 32.
About this comparison →How this year compares
Owner complaints by model year
Compare all Blazer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
150–25K
6325–50K
8550–75K
4175–100K
51100–150K
15150K+
270 reports with mileage · 319 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Suspension. Review the 100 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 84 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 79 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
46 crash reports7 fire reports25 injury reports
What owners actually said
589 reportsWHEN BRAKING THE ABS BRAKE SYSTEM LOCKS. IT LOCKS UP INTO A LIMITED SLIP MODE WHILE BRAKING AT A NORMAL STOP. IT DOES NOT BRAKE CORRECTLY. IT PUMPS BADLY WHILE ATTEMPTING TO STOP. THIS HAPPENS MULTIPLE TIME A DAY WHEN DRIVING. HAVE TO BREAK WAY BEFORE NEEDING TO BECAUSE IT WILL SLIP. TYPICALLY HAPPENS IN PARKING LOTS AND REGULAR…
Read full complaint
WHEN BRAKING THE ABS BRAKE SYSTEM LOCKS. IT LOCKS UP INTO A LIMITED SLIP MODE WHILE BRAKING AT A NORMAL STOP. IT DOES NOT BRAKE CORRECTLY. IT PUMPS BADLY WHILE ATTEMPTING TO STOP. THIS HAPPENS MULTIPLE TIME A DAY WHEN DRIVING. HAVE TO BREAK WAY BEFORE NEEDING TO BECAUSE IT WILL SLIP. TYPICALLY HAPPENS IN PARKING LOTS AND REGULAR STREETS WHEN USING BREAKS. IN MOTION. THIS HAS BEEN HAPPENING SINCE MARCH 2020.
IT STARTED WITH MY GAUGES BOUNCING ALL OVER GOING ON AND OFF , THEN IT FELT LIKE THE BRAKES WERE ON AND I HAD TO GIVE IT ALOT OF GAS TO GET GOING.NOW THE DASH WILL WORK WHEN I TURN THE KEY ON BUT AS SOON AS IT STARTS IT GOES OUT WITH THE EXCEPTION OF THE OIL PRESSURE AND THE CHARGING GAUGE. THE TRANSMISSION ISNT WORKING RIGHT AT…
Read full complaint
IT STARTED WITH MY GAUGES BOUNCING ALL OVER GOING ON AND OFF , THEN IT FELT LIKE THE BRAKES WERE ON AND I HAD TO GIVE IT ALOT OF GAS TO GET GOING.NOW THE DASH WILL WORK WHEN I TURN THE KEY ON BUT AS SOON AS IT STARTS IT GOES OUT WITH THE EXCEPTION OF THE OIL PRESSURE AND THE CHARGING GAUGE. THE TRANSMISSION ISNT WORKING RIGHT AT ALL AND I DONT DARE DRIVE IT ANYWHERE. THE FUSE BOX UNDER THE HOOD DOES NOT TEST RIGHT, ONLY ABOUT HALF OF IT HAS POWER AND I AM AT A LOSS THERE! THERE HAS BEEN ELECTRICAL PROBNLEMS WITH IT EVER SINCE I BOUGHT IT.
I HAVE REPLACED THE HUB ASSEMBLY, IDLER ARM, & WHEEL BEARINGS ON BOTH DRIVER & PASSENGER SIDE OF MY VEHICLE. WHEN I DRIVE OVER 45 MPH MY CAR MAKES AN AWFUL SOUND & NO MATTER WHAT I CHANGE OR HAVE FIXED THE PARKING BRAKE/ABS LIGHTS STAY ON. I'VE HAD MANY MECHANICS LOOK AT & SAY THEY'VE FIXED THE ISSUE BUT NONE HAVE ACTUALLY FIXED…
Read full complaint
I HAVE REPLACED THE HUB ASSEMBLY, IDLER ARM, & WHEEL BEARINGS ON BOTH DRIVER & PASSENGER SIDE OF MY VEHICLE. WHEN I DRIVE OVER 45 MPH MY CAR MAKES AN AWFUL SOUND & NO MATTER WHAT I CHANGE OR HAVE FIXED THE PARKING BRAKE/ABS LIGHTS STAY ON. I'VE HAD MANY MECHANICS LOOK AT & SAY THEY'VE FIXED THE ISSUE BUT NONE HAVE ACTUALLY FIXED IT. I WAS DRIVING 70MPH ON THE HIGHWAY & MY BRAKES FELT AS IF THEY WERE LOCKING UP. *TR
STEERING COLUMN HAD SMOKE COMING OUT OF IT A WEEK AGO. I'M CONSTANTLY HEARING THE BLINKERS EVEN WHEN THEY'RE NOT IN USE, FOR THE PAST FEW MONTHS NOW. THIS HAPPENS ANYTIME THE CAR IS RUNNING, WHETHER IT'S MOVING OR STOPPED. PROBLEM WITH CONSTANT BLINKER SOUND STARTED THE FIRST OF APRIL, AND HAS CONTINUED EVER SINCE. *TR
DRIVER MAY HAVE SWERVED TO AVOID AN ANIMAL (DEER) ON DARK COUNTRY ROAD. VEHICLE ROLLED OVER EJECTING THE DRIVER. DEATH WAS INSTANT. THE DRIVERS DOOR CAME OFF HINGES AND LOCKS. SEE PHOTOS. AIRBAG DID NOT DEPLOY. NO OTHER VEHICLE INVOLVED.
FUEL SENSOR PROBLEM THAT'S BEEN GOING ON WITH A LOT OF 2000 CHEVY BLAZER ALSO TRAIL BLAZERS AND ALSO THE DISTRIBUTOR THERE IS NO SEAL UNDER THE DISTRIBUTOR CAP CAUSE IT TO HAVE MOISTURE AND CAUSE IT NOT TO RUN AND YOU HAVE TO REPLACE IT THIS IS TO THE COMPANY OR WHOEVER'S IN CHARGE NOW THE FUEL SYSTEM ITSELF IS CALLED A SPIDER …
Read full complaint
FUEL SENSOR PROBLEM THAT'S BEEN GOING ON WITH A LOT OF 2000 CHEVY BLAZER ALSO TRAIL BLAZERS AND ALSO THE DISTRIBUTOR THERE IS NO SEAL UNDER THE DISTRIBUTOR CAP CAUSE IT TO HAVE MOISTURE AND CAUSE IT NOT TO RUN AND YOU HAVE TO REPLACE IT THIS IS TO THE COMPANY OR WHOEVER'S IN CHARGE NOW THE FUEL SYSTEM ITSELF IS CALLED A SPIDER SENSE OR WHAT I CALL IT NOT TO RUN IT ALL THE TIME THEY MUST BE SOME TYPE OF FILTER BESIDES THE ONE ON SIDE OF THE VEHICLE ITSELF BECAUSE THEY GO OUT WITHIN A YEAR OR MAYBE TWO YEARS OR SO THIS MUST BE ADDRESSED SO HOPEFULLY I GET SOME INFORMATION TO HELP FIX THE VEHICLE THAT I DON'T THINK YOU I HOPE I COULD GET SOME INFORMATION ABOUT IT BECAUSE THE FULE SENSOR IS A BIG DEAL WEN THEY LAST FOR ABOUT A YEAR AND THEN TO BUY ONE FOR ABOUT 400 DOLLARS AND THEN PAY ANOTHER 1000 DOLLARS FOR LABOR I THINK THAT THE INJECTION FOR THE FULE SENSOR SHOULD BE ADDRESSED HOPEFULLY HAVE A RE CALL THANK YOU FOR TAKING THE TIME TO READ THIS AND HOPE YOU CAN HELP GOD BLESS
BOTH PASSENGER SIDE FRONT AND DRIVER'S SIDE FRONT SEATBELTS ARE TOREN OVER 3/4 THREW THE BELTTHAT CROSSES CHEST APPROXIMATELY AT BREAST HEIGHT( HALF WAY UP FROM BUCKLE) ALSO PRIOR SIGNS OF OTHER REPAIRS TO SEATBELT STRAPS. I PURCHASED IT THIS WAY, SO UNKNOWN CAUSE.
TL* THE CONTACT OWNS A 2000 CHEVROLET BLAZER. THE CONTACT STATED THAT THE VEHICLE MADE AN ABNORMAL CLICKING SOUND EVEN WHEN THE TURN SIGNAL SWITCH WAS NOT ACTIVATED. UPON INSPECTION, THE TURN SIGNAL INDICATORS DID NOT ILLUMINATE. THE VEHICLE WAS TAKEN TO THE INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FLASHERS WERE DEFE…
Read full complaint
TL* THE CONTACT OWNS A 2000 CHEVROLET BLAZER. THE CONTACT STATED THAT THE VEHICLE MADE AN ABNORMAL CLICKING SOUND EVEN WHEN THE TURN SIGNAL SWITCH WAS NOT ACTIVATED. UPON INSPECTION, THE TURN SIGNAL INDICATORS DID NOT ILLUMINATE. THE VEHICLE WAS TAKEN TO THE INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FLASHERS WERE DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 01V364000 (EXTERIOR LIGHTING). THE DEALER WAS NOT CONTACTED. ALTHOUGH THE MANUFACTURER ACKNOWLEDGED THE RECALL, THEY STATED THAT THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS APPROXIMATELY 167,000.
TRIED PUTTING GAS IN MY VEHICLE AND IT WOULDNT UMP MUCH RAN BACK INTO GAS STATION TO GET BACK THE MONEY I DIDNT PUMP AND WHEN I CAME BACK OUT MY GAS WAS ON THE GROUND. STATIONARY AT THE GAS PUMP
Official recalls
408V231000 · Exterior Lighting:brake Lights:switch
May 21, 2008
GENERAL MOTORS IS RECALLING 5,862 MY 2000-2002 CHEVROLET BLAZER, MY 2000-2001 GMC JIMMY, AND MY 2000 OLDSMOBILE BRAVADA SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. THE RECALL BEGAN ON JUNE 17, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR OLDSMOBILE AT 1-800-630-6537, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> . NOTE: THIS CAMPAIGN IS AN EXPANSION OF A PREVIOUS RECALL (PLEASE SEE 01V364).
01V364000 · Exterior Lighting:brake Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:switch
Dec 3, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Exterior Lighting:brake Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
00V228003 · Seat Belts
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
99V220000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
Aug 11, 1999
VEHICLE DESCRIPTION: S -TRUCKS EQUIPPED WITH 2 WHEEL DRIVE. THESE VEHICLES MAY HAVE HAD THE RIGHT-HAND ANTILOCK BRAKE SYSTEM (ABS) MODULE FEED PIPE AND/OR BRAKE CROSSOVER PIPE TUBE NUTS TIGHTENED WITHOUT SEATING THE PIPE-FLARED-ENDS ENOUGH TO WITHSTAND NORMAL ASSEMBLY AND VEHICLE INPUTS WITHOUT PARTIALLY UNSEATING. THIS DOES NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC SERVICE BRAKE NORMAL, EMERGENCY, AND PARK BRAKING PERFORMANCE."
Consequence & remedy
Consequence: IF THIS OCCURRED, THE SEATING SEAL COULD BE BROKEN DURING VEHICLE ASSEMBLY, OR FROM EARLY ROAD INPUTS OR BRAKE FLUID CYCLING, AND A LEAK COULD OCCUR INCREASING THE BRAKE STOPPING DISTANCE.
Remedy: DEALERS WILL INSPECT THE BRAKE PIPE UNION FOR SIGNS OF BRAKE FLUID, AND IF NECESSARY, INSTALL A NEW BRAKE PIPE UNION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3RQ08001 · Hazard Light Switch Failure
Opened Feb 28, 2008 · Closed Jul 9, 2008
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
RQ02012 · Front Control Arm Ball Joints
Opened Sep 10, 2002 · Closed Mar 7, 2003
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
SEE ATTACHED PAGE.
Additional source detail variants (7)
Suspension:front:control Arm
SEE ATTACHED PAGE.
Suspension:front:control Arm:lower Arm
SEE ATTACHED PAGE.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED PAGE.
Suspension:front:control Arm:upper Arm
SEE ATTACHED PAGE.
Suspension:front:control Arm:upper Ball Joint
SEE ATTACHED PAGE.
Suspension:front
SEE ATTACHED PAGE.
Suspension
SEE ATTACHED PAGE.
PE01032 · Loss Of Stop Lamp Illumination
Opened Sep 6, 2001 · Closed Dec 20, 2001
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.