NHTSA owner reports · September 18, 2026 snapshot.
Equipment complaints
18 reportsClear category filter120,000 miles · May 14, 2007
Electrical SystemEngine And Engine CoolingEquipmentCrash
THE HANDLE THAT ALLOWS YOU TO RECLINE THE SEAT BROKE OFF FLUSHED WITH THE SEAT, THIS HAPPENED TO BOTH THE DRIVER AND PASSENGER SEATS IN JUNE 2005. THE HOOD WILL NOT POP UP WHEN THE LEVER WAS PULLED UNTIL ONE BANGED ON THE GRILL OR THE HOOD IN CERTAIN SPOTS, WHICH JUST STARTED IN MARCH OF 2007. THE GAS MILEAGE DROPPED FRO…
Read full complaint
THE HANDLE THAT ALLOWS YOU TO RECLINE THE SEAT BROKE OFF FLUSHED WITH THE SEAT, THIS HAPPENED TO BOTH THE DRIVER AND PASSENGER SEATS IN JUNE 2005. THE HOOD WILL NOT POP UP WHEN THE LEVER WAS PULLED UNTIL ONE BANGED ON THE GRILL OR THE HOOD IN CERTAIN SPOTS, WHICH JUST STARTED IN MARCH OF 2007. THE GAS MILEAGE DROPPED FROM 20 MPG TO 16 MPG WITHIN 6 MONTHS. THE BACK GLASS STUCK AND WAS HARD TO OPEN, STARTED IN 2006. WHEN TURNING ON THE AIR CONDITIONER (A/C ) THE CAR HAD NO POWER, I HAVE TO TURN IT OFF WHEN ACCELERATING ON THE INTERSTATE OR ON HILLS. IF THE CRUISE CONTROL WAS SET IT KICKED OFF WHEN THE A/C WAS ON. WHEN I NEEDED TO STOP QUICKLY THE BRAKES FAILED, AND FELT A GRINDING SENSATION THROUGH THE PEDAL, BUT THE MECHANIC CHANGED THE BRAKES AND CHECKED THE ROTORS, BUT HASN'T FOUND ANY PROBLEM. SUSPECTED A DEFECT SOMEWHERE IN THE BRAKE SYSTEM\ AS OF 2005. THE FAN KICKED ON ALL THE TIME, EVEN WHEN THE ENGINE WAS COLD, AND IN WINTER WHEN FIRST STARTING. ONE MECHANIC TOLD ME THAT IN MANY BLAZERS THE CATALYTIC CONVERTER BROKE OFF IN THE MUFFLER, WHICH HAD TO BE REPLACED. HAD BEEN TOLD THIS HAPPENED SO MUCH THAT MOST PEOPLE LEFT THEM OFF. TOO MANY OTHER PROBLEMS TO MENTIONED. ALSO, THE HORN WORKED ONLY WHEN IT WANTED TO, PROBLEM IN THE STEERING WHEEL. *AK
NHTSA ODI #10190669
Mileage unknown · Jan 27, 2005
EquipmentLatches/locks/linkages
FRONT DOOR HINGES ON 2000 S-10 BLAZER HAVE ROTTED. DRIVER HINGE IN 2002, NOW PASSENGER HINGE (BOTH FRONT DOORS) IN JANUARY OF 05. DOOR HINGES BOTH NEEDED REPLACEMENT WHICH SEEMS EXTREMELY ODD ON FAIRLY NEW VEHICLE. RESEARCH ON THE INTERNET SHOWS THAT MANY PEOPLE HAVE THE SAME PROBLEM AND PROBABLY JUST DON'T KNOW WHERE TO REPO…
Read full complaint
FRONT DOOR HINGES ON 2000 S-10 BLAZER HAVE ROTTED. DRIVER HINGE IN 2002, NOW PASSENGER HINGE (BOTH FRONT DOORS) IN JANUARY OF 05. DOOR HINGES BOTH NEEDED REPLACEMENT WHICH SEEMS EXTREMELY ODD ON FAIRLY NEW VEHICLE. RESEARCH ON THE INTERNET SHOWS THAT MANY PEOPLE HAVE THE SAME PROBLEM AND PROBABLY JUST DON'T KNOW WHERE TO REPORT IT SIMULATANEOUSLY. IT'S FAILURE RESULTS IN THE INABILITY TO CLOSE THE DOORS, WHICH, DEPENDING ON WHEN THEY BREAK (I.E. WHEN CLOSING DOOR, HITTING A BUMP IN ROAD - WHICH COULD CAUSE CLOSED DOOR TO UNLATCH FROM POST, FLINGING DOOR OPEN WHILE DRIVING). I REALLY STRONGLY SUGGEST THIS BE LOOKED AT. IT APPEARS THAT THE WHEEL WELLS ALLOW ROAD SPRAY AND MOISTURE TO BE THROWN DIRECTLY INTO THE DOOR PANEL WELL WHERE THE HINGE IS LOCATED AND IS CAUSING THE ROT. LOOKS LIKE A MAJOR MANUFACTURING DEFECT TO NOT SEAL THE DOOR HINGE AREA FROM THE WHEEL SPRAY AND DEBRIS THROW-BACK ZONE.*AK
NHTSA ODI #10107997
40,000 miles · Jan 15, 2004
EquipmentFuel System, GasolineService Brakes, Hydraulic
1. SECUNDAIRY AIRPUMP 2. MULTIFUNCTION SWITCH (INITIAL RECALL NEVER REC'D, ONLY REIMBURSED FOR $218)
NHTSA ODI #10069329
Mileage unknown · Jul 21, 2003
Equipment
CONSUMER STATES WHILE CHANGING A FLAT TIRE, THE JACK SNAPPED DOWN, AND DAMAGED THE RING. DEALER NOTIFIED. *AK
NHTSA ODI #10029734
43,000 miles · May 7, 2003
Air BagsEquipmentExterior Lighting
I WAS NOTIFIED BY ANOTHER DRIVER I HAD NO BRAKE LIGHTS, BROUGHT BACK TO DEALER AND INFORMED THAT IT WOULD COST $400 TO FIX. FOUND OUT THROUGH MY EMPLOYER THERE HAD BEEN A RECALL FOR THIS PROBLEM. WHY WAS IT NOT CORRECTED BEFORE I PURCHASED IT FROM THE CHEVY DEALER. ALSO INFORMED MY AIRBAG WARNING LIGHT WAS ON AND THE A MODULE…
Read full complaint
I WAS NOTIFIED BY ANOTHER DRIVER I HAD NO BRAKE LIGHTS, BROUGHT BACK TO DEALER AND INFORMED THAT IT WOULD COST $400 TO FIX. FOUND OUT THROUGH MY EMPLOYER THERE HAD BEEN A RECALL FOR THIS PROBLEM. WHY WAS IT NOT CORRECTED BEFORE I PURCHASED IT FROM THE CHEVY DEALER. ALSO INFORMED MY AIRBAG WARNING LIGHT WAS ON AND THE A MODULE WAS AT FAULT AND WOULD COST ANOTHER $550 TO FIX AND THAT IT MAY INFLATE AIRBAG WHILE DRIVING. THESE ARE TOTALLY UNREALISTIC PROBLEMS TO OCCUR IN A 2 YEAR OLD MODEL WITH LESS THEN 40,000 MI. *JB
NHTSA ODI #10018388
37,979 miles · Mar 17, 2003
EquipmentLatches/locks/linkagesSeats
SUSPENSION FRONT AND REAR-UPPER AND LOWER BALL JOINTS(FRONT)LEFT AND RIGHT SIDES IDLER ARM AND BOTH REAR LEAF SPRINGS NEEDED TO BE REPLACED. WARPED ROTORS LEFT AND RIGHT. LEFT DOOR LOCK CYLINDER FELL OFF. DEALER REPLACED RIGHT REAR SPEAKER UNDER WARRANTY. FRONT SEAT RECLINER LEVERS REPLACED RESULTING IN SPLIT COST WITH DEALER. …
Read full complaint
SUSPENSION FRONT AND REAR-UPPER AND LOWER BALL JOINTS(FRONT)LEFT AND RIGHT SIDES IDLER ARM AND BOTH REAR LEAF SPRINGS NEEDED TO BE REPLACED. WARPED ROTORS LEFT AND RIGHT. LEFT DOOR LOCK CYLINDER FELL OFF. DEALER REPLACED RIGHT REAR SPEAKER UNDER WARRANTY. FRONT SEAT RECLINER LEVERS REPLACED RESULTING IN SPLIT COST WITH DEALER. MANUFACTURER REP OFFERED LABOR/PARTS SPLIT FOR SUSPENSION WORK AND BRAKE WORK FOR $1400.00. REFUSED WORK ON DOOR LOCK IN EXCESS OF $300.00. *JB
NHTSA ODI #10010638
Mileage unknown · Jan 29, 2003
Equipment
LIGHTS ON THE CONSOLE AND EXTERIOR LIGHTS WILL FLICK ON AND OFF AT RANDOM LYWITH CAUSE DETERMINED AS THE AIR INJECTION REACTION PUMP. PH. *AK
NHTSA ODI #10004858
Mileage unknown · Jul 23, 2002
EquipmentWheels
THE CONSUMER RECEIVED RECALL REGARDING THE CERTIFICATION LABEL WHICH LOWERED THE PAYLOAD/ AXLE RATING, THE CONSUMER HAD ALREADY INSTALLED A LIGHTWEIGHT SNOWPLOW ON THE VEHICLE AFTER THE DEALER REFERRED HIM TO THE PAYLOAD LABEL ON THE INSIDE OF THE DOOR FRAME(CERTIFICATION LABEL). BOTH FRONT WHEEL BEARINGS HAVE GONE BAD AND CON…
Read full complaint
THE CONSUMER RECEIVED RECALL REGARDING THE CERTIFICATION LABEL WHICH LOWERED THE PAYLOAD/ AXLE RATING, THE CONSUMER HAD ALREADY INSTALLED A LIGHTWEIGHT SNOWPLOW ON THE VEHICLE AFTER THE DEALER REFERRED HIM TO THE PAYLOAD LABEL ON THE INSIDE OF THE DOOR FRAME(CERTIFICATION LABEL). BOTH FRONT WHEEL BEARINGS HAVE GONE BAD AND CONSUMER FEELS THIS COULD BE DUE TO OVERLOAD. THE CONSUMER HAS ASKED SEVERAL DEALERS IF HIS VEHICLE IS OVERLOADED AND COULD NOT GIVE HIM AN ANSWER. *SLC *SCC
NHTSA ODI #566818
Mileage unknown · Jul 17, 2002
EquipmentExterior LightingPower Train
SINCE PURCHASE OF VEHICLE OCT 2000 I HAVE BEEN IN THE SHOP 35 X FOR MANUFACTURING PROBLEMS. ONGOING PROBLEMS INCLUDE DIMMING OF HEADLIGHTS AT ANY GIVEN TIME AND FLICKERING OF CLOCK/RADIO DISPLAY AT ANY GIVEN TIME. SERVICE ATTEMPTED TO FIX THE DIMMING AND FLICKERING BY REPLACING THE ALTERNATOR, BUT IT DID NOT FIX THE PROBLEM. …
Read full complaint
SINCE PURCHASE OF VEHICLE OCT 2000 I HAVE BEEN IN THE SHOP 35 X FOR MANUFACTURING PROBLEMS. ONGOING PROBLEMS INCLUDE DIMMING OF HEADLIGHTS AT ANY GIVEN TIME AND FLICKERING OF CLOCK/RADIO DISPLAY AT ANY GIVEN TIME. SERVICE ATTEMPTED TO FIX THE DIMMING AND FLICKERING BY REPLACING THE ALTERNATOR, BUT IT DID NOT FIX THE PROBLEM. THEY ARE NOW UNABLE TO DUPLICATE THE PROBLEM. IT TOOK SERVICE 5 ATTEMPTS TO FIX TAILLIGHT WATER RETENTION PROBLEM (THEY SEALED THE ENTIRE ASSEMBLY). THE REAR DIFFERENTIAL FLUID WAS REPORTEDLY LOW FROM FACTORY CAUSING A GRINDING SOUND IN MY GEARS (IT TOOK 2 ATTEMPTS TO FIX THAT PROBLEM). SINCE THAT DIFFERENTIAL PROBLEM, I HAVE HAD A CLUNK BETWEEN 2ND & 3RD GEARS (SERVICE IS UNABLE TO DUPLICATE THE PROBLEM).
NHTSA ODI #764343
Mileage unknown · Jun 5, 2002
EquipmentExterior LightingFuel System, Other
CONSUMER STATES 4 WAY FLASHERS AND BRAKE LIGHTS FAILED 5 TIMES AND THE MULTIFUNCTION SWITCH WAS REPLACED 3 TIMES. HOWEVER, AFTER REPLACEMENT, CONSUMER RECEVIED RECALL NOTICE (01V364000) RELATING TO BRAKE LIGHT AND HAZARD FLASHING LIGHT FAILURE. CONSUMER IS REQUESTING REIMBURSEMENT FOR OUT OF POCKET EXPENSES. *TT …
Read full complaint
CONSUMER STATES 4 WAY FLASHERS AND BRAKE LIGHTS FAILED 5 TIMES AND THE MULTIFUNCTION SWITCH WAS REPLACED 3 TIMES. HOWEVER, AFTER REPLACEMENT, CONSUMER RECEVIED RECALL NOTICE (01V364000) RELATING TO BRAKE LIGHT AND HAZARD FLASHING LIGHT FAILURE. CONSUMER IS REQUESTING REIMBURSEMENT FOR OUT OF POCKET EXPENSES. *TT
NHTSA ODI #565988
Official recalls
4May 21, 2008
GENERAL MOTORS IS RECALLING 5,862 MY 2000-2002 CHEVROLET BLAZER, MY 2000-2001 GMC JIMMY, AND MY 2000 OLDSMOBILE BRAVADA SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. THE RECALL BEGAN ON JUNE 17, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR OLDSMOBILE AT 1-800-630-6537, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> . NOTE: THIS CAMPAIGN IS AN EXPANSION OF A PREVIOUS RECALL (PLEASE SEE 01V364).
Dec 3, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Exterior Lighting:brake Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Aug 11, 1999
VEHICLE DESCRIPTION: S -TRUCKS EQUIPPED WITH 2 WHEEL DRIVE. THESE VEHICLES MAY HAVE HAD THE RIGHT-HAND ANTILOCK BRAKE SYSTEM (ABS) MODULE FEED PIPE AND/OR BRAKE CROSSOVER PIPE TUBE NUTS TIGHTENED WITHOUT SEATING THE PIPE-FLARED-ENDS ENOUGH TO WITHSTAND NORMAL ASSEMBLY AND VEHICLE INPUTS WITHOUT PARTIALLY UNSEATING. THIS DOES NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC SERVICE BRAKE NORMAL, EMERGENCY, AND PARK BRAKING PERFORMANCE."
Consequence & remedy
Consequence: IF THIS OCCURRED, THE SEATING SEAL COULD BE BROKEN DURING VEHICLE ASSEMBLY, OR FROM EARLY ROAD INPUTS OR BRAKE FLUID CYCLING, AND A LEAK COULD OCCUR INCREASING THE BRAKE STOPPING DISTANCE.
Remedy: DEALERS WILL INSPECT THE BRAKE PIPE UNION FOR SIGNS OF BRAKE FLUID, AND IF NECESSARY, INSTALL A NEW BRAKE PIPE UNION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3RQ08001 · Hazard Light Switch Failure
Opened Feb 28, 2008 · Closed Jul 9, 2008
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
RQ02012 · Front Control Arm Ball Joints
Opened Sep 10, 2002 · Closed Mar 7, 2003
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
SEE ATTACHED PAGE.
Additional source detail variants (7)
Suspension:front:control Arm
SEE ATTACHED PAGE.
Suspension:front:control Arm:lower Arm
SEE ATTACHED PAGE.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED PAGE.
Suspension:front:control Arm:upper Arm
SEE ATTACHED PAGE.
Suspension:front:control Arm:upper Ball Joint
SEE ATTACHED PAGE.
Suspension:front
SEE ATTACHED PAGE.
Suspension
SEE ATTACHED PAGE.
PE01032 · Loss Of Stop Lamp Illumination
Opened Sep 6, 2001 · Closed Dec 20, 2001
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.
Illustration