IllustrationSTEERING COLUMN HAD SMOKE COMING OUT OF IT A WEEK AGO. I'M CONSTANTLY HEARING THE BLINKERS EVEN WHEN THEY'RE NOT IN USE, FOR THE PAST FEW MONTHS NOW. THIS HAPPENS ANYTIME THE CAR IS RUNNING, WHETHER IT'S MOVING OR STOPPED. PROBLEM WITH CONSTANT BLINKER SOUND STARTED THE FIRST OF APRIL, AND HAS CONTINUED EVER SINCE. *TR
2000 Chevrolet Blazer
Owner reports · Recalls · Investigations
More warning signs than most Blazer years
Owner complaints for the 2000 Chevrolet Blazer are substantially higher than the model-year median of 32.
About this comparison →How this year compares
Owner complaints by model year
Compare all Blazer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
150–25K
6325–50K
8550–75K
4175–100K
51100–150K
15150K+
270 reports with mileage · 319 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Suspension. Review the 100 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 84 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 79 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
46 crash reports7 fire reports25 injury reports
Steering complaints
23 reportsFORTUNATELY, I HAD JUST GOTTEN OFF THE FREEWAY AND WAS LOOKING FOR AN ADDRESS AT A SLOW SPEED. ALL OF A SUDDEN THE CAR LURCHED; I HAD NO STEERING; I LOST ALL ELECTRICAL CONTROL; THE CAR GROUND TO A HALT; SMOKE CAME OUT FROM UNDER THE HOOD. I AND A FRIEND GOT OUT OF THE CAR. FORTUITOUSLY, FIRE TRUCKS APPEARED. IT TURNED OUT T…
Read full complaint
FORTUNATELY, I HAD JUST GOTTEN OFF THE FREEWAY AND WAS LOOKING FOR AN ADDRESS AT A SLOW SPEED. ALL OF A SUDDEN THE CAR LURCHED; I HAD NO STEERING; I LOST ALL ELECTRICAL CONTROL; THE CAR GROUND TO A HALT; SMOKE CAME OUT FROM UNDER THE HOOD. I AND A FRIEND GOT OUT OF THE CAR. FORTUITOUSLY, FIRE TRUCKS APPEARED. IT TURNED OUT THEY WERE RETURNING FROM ANOTHER INCIDENT AS I COULD NOT BELIEVE THE IMMEDIACY OF THEIR RESPONSE. THEY TOOK OVER PREVENTING FURTHER AGGRAVATION OF THIS SITUATION. THE BATTERY WAS BOILING. ALL THE ELECTRICAL WIRE HARNESSES WERE MELTED. THE UPPER SUSPENSION CONTROL ARM WAS BROKEN. THE FIREMEN'S OBSERVATION WAS, IF I HAD BEEN GOING ANY FASTER, THE CAR COULD HAVE FLIPPED. AFTER BEING TOWED TO A NEARBY MECHANIC, I LEARNED THE UPPER CONTROL ARM HAD BROKEN. IT IMPAILED THE STARTER WHICH SHORTED. THAT MELTED THE WIRING HARNESSES TO AND FROM THE BATTERY, AS WELL AS BEING THE CAUSE OF THE BATTERY BOILING. THE KEY ISSUE IS THAT GENERAL MOTORS WOULD BUILD A VEHICLE WHERE THE UPPER CONTROL ARM IS SO FLIMSY IT WOULD BREAK. I HAVE READ OTHER INCIDENTS OF THE SAME THING WITH THE CHEVROLET BLAZER WHERE, FOR EXAMPLE, A PERSON WAS GOING 30MPH, THE CAR FLIPPED, AND THE PERSON WAS KNOCKED UNCONSCIOUS. A REPEATED CORPORATE FAILURE OF THIS NATURE SHOULD HAVE CONSEQUENCES. *TR
FRONT END IS JUNK,THE SMELL OF RAW GAS WHEN FUELING UP AND REPLACED OIL LINE, STEERING PARTS, DOOR PIN, BACK LIGHT, RIGHT HUB, BEFORE SERVICE WARRANTY WAS UP. THEN OF COARSE THE, ROTORS WENT ALONG WITH THE LEFT HUB AND HEATER CORE WENT,.. THE BLAZER HAS BEEN A LEMON SINCE I BOUGHT IT NEW. CRIED ALOT.. I JUST TURNED THE 100,000 …
Read full complaint
FRONT END IS JUNK,THE SMELL OF RAW GAS WHEN FUELING UP AND REPLACED OIL LINE, STEERING PARTS, DOOR PIN, BACK LIGHT, RIGHT HUB, BEFORE SERVICE WARRANTY WAS UP. THEN OF COARSE THE, ROTORS WENT ALONG WITH THE LEFT HUB AND HEATER CORE WENT,.. THE BLAZER HAS BEEN A LEMON SINCE I BOUGHT IT NEW. CRIED ALOT.. I JUST TURNED THE 100,000 ON 7/15/10 COULDN'T GO ANYWHERE CAUSE IT WAS IN THE SHOP BEING FIXED... LEMON SO MUCH FOR BUYING NEW. *TR
TL*THE CONTACT OWNED A 2000 CHEVROLET BLAZER. WHILE DRIVING APPROXIMATELY 55 MPH THE STEERING WHEEL BECAME VERY STIFF. WHILE COMPENSATING FOR THE STIFF STEERING THE VEHICLE WAS INVOLVED IN A ROLLOVER CRASH IN WHICH THE AIR BAGS DID NOT DEPLOY. THE CONTACT WAS INJURED. A POLICE REPORT WAS FILED. SHE WAS TAKEN BY HELICOPTER TO TH…
Read full complaint
TL*THE CONTACT OWNED A 2000 CHEVROLET BLAZER. WHILE DRIVING APPROXIMATELY 55 MPH THE STEERING WHEEL BECAME VERY STIFF. WHILE COMPENSATING FOR THE STIFF STEERING THE VEHICLE WAS INVOLVED IN A ROLLOVER CRASH IN WHICH THE AIR BAGS DID NOT DEPLOY. THE CONTACT WAS INJURED. A POLICE REPORT WAS FILED. SHE WAS TAKEN BY HELICOPTER TO THE HOSPITAL. THE VEHICLE WAS TOWED AND WAS NEVER EXAMINED TO DETERMINE THE CAUSE OF FAILURE. THE FAILURE AND CURRENT MILEAGES WERE 120,000.
2000 CHEVY BLAZER...STEERING IS DANGEROUS...TO MUCH PLAY IN STEERING...THIS HAS ALWAYS BEEN THE CASE AFTER WARRANTY WENT OUT. I DO NOT FEEL SAFE ENOUGH IN THE VEHICLE TO DRIVE IT ON THE HIGHWAY NOR DO I TAKE VACATIONS IN IT. I HAVE LIMITED USE WITH THE VEHICLE DUE TO THIS CONCERN. *TR
BALL JOINTS THIS VEHICLE HAS FAILED MASSACHUSETTS YEARLY INSPECTION 2 YEARS IN A ROW DUE TO SLOPPY BALL JOINTS. IF THE VEHICLE WAS NOT INSPECTED THE RESULT COULD BE RATHER HAZARDOUS TO ME AND PEOPLE ON THE HIGHWAY. *TR
TL*THE CONTACT OWNS A 2000 CHEVROLET BLAZER. THE CONTACT STATED THAT THE TWO REAR BRAKE LIGHTS ABOVE THE HITCH FAIL TO ILLUMINATE WHEN THE BRAKE PEDAL IS DEPRESSED. THE DEALER STATED THAT THE BRAKE LIGHTS WERE ALREADY REPAIRED ACCORDING TO THE MECHANIC'S RECORDS. SHE STATED THAT HER VEHICLE IS UNDER RECALL NUMBER 01V364000 (E…
Read full complaint
TL*THE CONTACT OWNS A 2000 CHEVROLET BLAZER. THE CONTACT STATED THAT THE TWO REAR BRAKE LIGHTS ABOVE THE HITCH FAIL TO ILLUMINATE WHEN THE BRAKE PEDAL IS DEPRESSED. THE DEALER STATED THAT THE BRAKE LIGHTS WERE ALREADY REPAIRED ACCORDING TO THE MECHANIC'S RECORDS. SHE STATED THAT HER VEHICLE IS UNDER RECALL NUMBER 01V364000 (EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS:SWITCH), BUT THE DEALER WILL NOT REPAIR THE VEHICLE FOR FREE SINCE IT WAS ALREADY PERFORMED. THE CURRENT AND FAILURE MILEAGES WERE 134,000. UPDATED 02/01/08. *LJ THE DRIVE BELT AND POWER STEERING PUMP.
2000 BLAZER TRANSMISSION FAILED, COST $3000 TO REPAIR. LEFT BALL JOINT FAILED AND REPLACED ALL $500, PITMAN ARM, IDLER ARM, TIE RODS RIGHT AND LEFT NEEDED REPLACEMENT. LEFT FRONT WHEEL BEARING HUB FAILED AND WAS REPLACED, BOTH $800. OVERHEATING DUE TO DEXCOOL LEAK AT INTAKE NEEDED REPLACEMENT. I HAVE A $20,000 PIECE OF J…
Read full complaint
2000 BLAZER TRANSMISSION FAILED, COST $3000 TO REPAIR. LEFT BALL JOINT FAILED AND REPLACED ALL $500, PITMAN ARM, IDLER ARM, TIE RODS RIGHT AND LEFT NEEDED REPLACEMENT. LEFT FRONT WHEEL BEARING HUB FAILED AND WAS REPLACED, BOTH $800. OVERHEATING DUE TO DEXCOOL LEAK AT INTAKE NEEDED REPLACEMENT. I HAVE A $20,000 PIECE OF JUNK SITTING IN MY DRIVEWAY.THIS WAS ONGOING FROM EARLIER YEAR MODELS BUT NO RECALLS FOR THIS YEAR ,WHY NO BODY DIED ? FUEL GAUGE BOUNCED. *AK
RADLEY CHEVROLET DID NOT PROVIDE US WITH A RECALL NOTICE ON BRAKE LIGHTS NOT WORKING. WE HAVE HAD PROBLEMS WITH OUR 2000 CHEVROLET BLAZER FROM THE START. WE HAVE BEEN NOW TOLD THAT THE IDLER ARM ON THE CAR IS A SAFETY HAZARD. WE ALSO HAD THE FUEL GAUGE GO OUT. HOW OFTEN DO THESE COMPONENTS GO OUT. CAN YOU TELL ME ANYTHING A…
Read full complaint
RADLEY CHEVROLET DID NOT PROVIDE US WITH A RECALL NOTICE ON BRAKE LIGHTS NOT WORKING. WE HAVE HAD PROBLEMS WITH OUR 2000 CHEVROLET BLAZER FROM THE START. WE HAVE BEEN NOW TOLD THAT THE IDLER ARM ON THE CAR IS A SAFETY HAZARD. WE ALSO HAD THE FUEL GAUGE GO OUT. HOW OFTEN DO THESE COMPONENTS GO OUT. CAN YOU TELL ME ANYTHING ABOUT THE IDLER ARM AND IS THERE ANY RECALLS FOR THIS ITEM. *JB
PROBLEMS THAT ARE NOT SAFTEY ISSUES: AIR CONDITIONING DOESN'T WORK; DOOR HINGE PIN NEEDS TO BE REPLACED; DRIVER'S WINDOW SLIPS OFF TRACK TO THE OUTSIDE OF THE FRAME, RESULTING IN THE BACK SIDE OF THE WINDOW CRACKED AT LEAST A 1/4 OF AN INCH (WAS TOLD BY FRIENDLY CHEVROLET IN SPRINGFIELD IL THAT THIS IS A DESIGN PROBLEM AND CAN …
Read full complaint
PROBLEMS THAT ARE NOT SAFTEY ISSUES: AIR CONDITIONING DOESN'T WORK; DOOR HINGE PIN NEEDS TO BE REPLACED; DRIVER'S WINDOW SLIPS OFF TRACK TO THE OUTSIDE OF THE FRAME, RESULTING IN THE BACK SIDE OF THE WINDOW CRACKED AT LEAST A 1/4 OF AN INCH (WAS TOLD BY FRIENDLY CHEVROLET IN SPRINGFIELD IL THAT THIS IS A DESIGN PROBLEM AND CAN NOT BE FIXED; CALLED CHEVROLET AND WAS TOLD TO TAKE IT BACK TO DEALER AND PAY THEM TO REEVALUATE THE PROBLEM; ) SAFTY ISSUES: BALL JOINTS NEED TO BE REPLACED;GAS GAUGE SENDING UNIT DOESN'T WORK;;DIFFERENTIAL IS LEAKING AND PLUG CONNECTED TO THIS NEEDS TO BE DRILLED OUT AND RETHREADED TO FIND OUT HOW BAD THE LEAK IS; WINDSHIELD WIPER ON DRIVER'S SIDE LOOSE AND FLIPS OFF TO THE LEFT OF THE WINDSHIELD IN HEAVY RAIN AND SNOW; ELECTRICAL HARNASS NEEDS TO BE REPLACED; ENGINE INSOLATION PEALING OFF UNDER HOOD; ENGINE LIGHT ON CONTINUALLY; CAR STALLS INTERMITANTLY(FIRST TIME IT HAPPENED, WAS TOLD THE ENGINE HAD OVERHEATED); AT EVERY START UP, ENGINE STAYS IN NUETRAL (HAS NO EXCELLERATOR POWER)THEN CATCHES AFTER ABOUT THREE MINUTES); WORK DONE: THERMOSTAT HOSES REPLACED;DISTRIBUTOR REPLACED;SPARK PLUG WIRES AND SPARK PLUGS REPLACED; SEPENTINE BELT REPLACED; PART BETWEEN THE AXLE AND THE U JOINTS NEEDED TO BE REPLACED; OIL LEAK FIXED;FUEL INJECTOR REPLACED; I HAVE NO IDEA WHAT WILL GO WRONG WHEN; IT'S LIKE PLAYING RUSSIAN RULLETT WHILE DRIVING; HAVE RENTED VEHICLE TWICE; WILL ALSO NEED TO RENT VEHICLE FOR CROSS COUNTRY ROAD TRIP NEXT WEEK; WILL NOT RISK DRIVING THIS CAR; (INCIDENT DATE: FIRST INCIDENT-DAY ESTIMATED)
Official recalls
408V231000 · Exterior Lighting:brake Lights:switch
May 21, 2008
GENERAL MOTORS IS RECALLING 5,862 MY 2000-2002 CHEVROLET BLAZER, MY 2000-2001 GMC JIMMY, AND MY 2000 OLDSMOBILE BRAVADA SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. THE RECALL BEGAN ON JUNE 17, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR OLDSMOBILE AT 1-800-630-6537, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> . NOTE: THIS CAMPAIGN IS AN EXPANSION OF A PREVIOUS RECALL (PLEASE SEE 01V364).
01V364000 · Exterior Lighting:brake Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:switch
Dec 3, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Exterior Lighting:brake Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
00V228003 · Seat Belts
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
99V220000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
Aug 11, 1999
VEHICLE DESCRIPTION: S -TRUCKS EQUIPPED WITH 2 WHEEL DRIVE. THESE VEHICLES MAY HAVE HAD THE RIGHT-HAND ANTILOCK BRAKE SYSTEM (ABS) MODULE FEED PIPE AND/OR BRAKE CROSSOVER PIPE TUBE NUTS TIGHTENED WITHOUT SEATING THE PIPE-FLARED-ENDS ENOUGH TO WITHSTAND NORMAL ASSEMBLY AND VEHICLE INPUTS WITHOUT PARTIALLY UNSEATING. THIS DOES NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC SERVICE BRAKE NORMAL, EMERGENCY, AND PARK BRAKING PERFORMANCE."
Consequence & remedy
Consequence: IF THIS OCCURRED, THE SEATING SEAL COULD BE BROKEN DURING VEHICLE ASSEMBLY, OR FROM EARLY ROAD INPUTS OR BRAKE FLUID CYCLING, AND A LEAK COULD OCCUR INCREASING THE BRAKE STOPPING DISTANCE.
Remedy: DEALERS WILL INSPECT THE BRAKE PIPE UNION FOR SIGNS OF BRAKE FLUID, AND IF NECESSARY, INSTALL A NEW BRAKE PIPE UNION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3RQ08001 · Hazard Light Switch Failure
Opened Feb 28, 2008 · Closed Jul 9, 2008
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
RQ02012 · Front Control Arm Ball Joints
Opened Sep 10, 2002 · Closed Mar 7, 2003
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
SEE ATTACHED PAGE.
Additional source detail variants (7)
Suspension:front:control Arm
SEE ATTACHED PAGE.
Suspension:front:control Arm:lower Arm
SEE ATTACHED PAGE.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED PAGE.
Suspension:front:control Arm:upper Arm
SEE ATTACHED PAGE.
Suspension:front:control Arm:upper Ball Joint
SEE ATTACHED PAGE.
Suspension:front
SEE ATTACHED PAGE.
Suspension
SEE ATTACHED PAGE.
PE01032 · Loss Of Stop Lamp Illumination
Opened Sep 6, 2001 · Closed Dec 20, 2001
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.