IllustrationWHILE DRIVING AT 60 MPH THERE WAS A VIBRATION THROUGHOUT THE VEHICLE. DEALER INFORMED CONSUMER THAT VIBRATION WAS NORMAL. DEALER SHOWED CONSUMER DOCKET ID# 1381844, STATING THAT CHEVROLET WAS AWARE OF THE PROBLEM, AND AN ATTEMPT TO REPAIR WAS UNNECESSARY.*AK
2000 Chevrolet Blazer
Owner reports · Recalls · Investigations
More warning signs than most Blazer years
Owner complaints for the 2000 Chevrolet Blazer are substantially higher than the model-year median of 32.
About this comparison →How this year compares
Owner complaints by model year
Compare all Blazer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
150–25K
6325–50K
8550–75K
4175–100K
51100–150K
15150K+
270 reports with mileage · 319 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Suspension. Review the 100 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 84 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 79 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
46 crash reports7 fire reports25 injury reports
What owners actually said
589 reportsI HAVE A 2000 BLAZER LT 4WD WITH 44,000 MILES ON IT. I RECENTLY STARTED EXPERIENCING VIBRATIONS AT HIGHWAY SPEEDS. MY DEALER VERIFIED THE PROBLEM. ACCORDING TO A GM DOCUMENT, THERE IS NO FIX TO THIS PROBLEM. ACCORDING TO GM DOCUMENT ID# 1381844. THE DOCUMENT IS ENTITLED "VIBRATION AT HIGHWAY SPEEDS-SUSPENSION WHEEL #PI01273…
Read full complaint
I HAVE A 2000 BLAZER LT 4WD WITH 44,000 MILES ON IT. I RECENTLY STARTED EXPERIENCING VIBRATIONS AT HIGHWAY SPEEDS. MY DEALER VERIFIED THE PROBLEM. ACCORDING TO A GM DOCUMENT, THERE IS NO FIX TO THIS PROBLEM. ACCORDING TO GM DOCUMENT ID# 1381844. THE DOCUMENT IS ENTITLED "VIBRATION AT HIGHWAY SPEEDS-SUSPENSION WHEEL #PI01273B - (09/15/2003). THE DOCUMENT EXPLAINS THE PROBLEM & SYMPTOMS EXACTLY AS DESCRIBED IN MANY OF THESE DISCUSSIONS. THERE IS A LINE IN THIS DOCUMENT THAT READS: THIS VIBRATION IS CONSIDERED A NORMAL CHARACTERISTIC FOR THESE VEHICLES AND NO REPAIR ATTEMPTS SHOULD BE MADE." THIS DOCUMENT COVERS 2 & 4WD DRIVE GM VEHICLES WITH THE SAME BODY TYPES (I.E. BLAZERS, JIMMY, BRAVADA, S-10, ENVOY) AND COVERS YEARS 00 - 03. THIS VEHICLE IS UNSAFE FOR USE ON THE HIGHWAY!! IF THIS WAS "NORMAL" WHY DIDN'T THE VEHICLE DO THIS WHEN IT WAS NEW? I CALLED CHEVY'S CUSTOMER SERVICE LINE AND THEY VERIFIED THE DOCUMENT. THEY TOLD ME TO TAKE IT TO ANOTHER DEALER FOR A SECOND OPINION AFTER THAT I GUESS I'M OUT OF LUCK. MY DEALER FOUND THE DOCUMENT AT THE FOLLOWING URL: HTTP://SERVICE.GM.COM/SERVLETS/BLOBSHTML?SHTMLFILE=1381844. *LA
REPLACEMENT OF BOTH FRONT WHEEL BEARINGS AT 60,000 MILES. LOTS OF ROAD NOISE AND "HUM" VIBRATION COMING FROM FRONT END FOR SEVERAL THOUSAND MILES, THEN IT GOT REAL BAD WHEN TURN STEERING WHEEL TO LEFT. SMALL TIME MECHANIC HAS REPLACED BEARINGS ON 12 BLAZERS OVER THE COURSE OF 6 MONTHS. ONE DEALER ACKNOWLEDGED THAT MANY BLAZER…
Read full complaint
REPLACEMENT OF BOTH FRONT WHEEL BEARINGS AT 60,000 MILES. LOTS OF ROAD NOISE AND "HUM" VIBRATION COMING FROM FRONT END FOR SEVERAL THOUSAND MILES, THEN IT GOT REAL BAD WHEN TURN STEERING WHEEL TO LEFT. SMALL TIME MECHANIC HAS REPLACED BEARINGS ON 12 BLAZERS OVER THE COURSE OF 6 MONTHS. ONE DEALER ACKNOWLEDGED THAT MANY BLAZERS HAVE BEEN IN TO REPLACE FRONT WHEEL BEARINGS ANYWHERE FROM 30-80000 MILE. MECHANIC THINKS IT'S CAUSED BY LACK OF ADEQUATE GROUNDING FOR THE ABS BRAKING SYSTEM. *LA
6/12/03, 2000 BLAZER 4X4 TRANSMISSION SUDDENLY LOST ABILITY TO OBTAIN ALL GEARS. AFTER PARKING, THE VEHICLE LOST ABILITY TO SHIFT INTO REVERSE AS WELL. NOISE TRANSMITTED FROM TRANSMISSION CONTAINED METALLIC MATERIAL GRINDING AND MOVING WITHIN. AT THE TIME, THE VEHICLE WAS STILL LESS THAN 3 YEARS OLD WITH THE MAJORITY OF ITS U…
Read full complaint
6/12/03, 2000 BLAZER 4X4 TRANSMISSION SUDDENLY LOST ABILITY TO OBTAIN ALL GEARS. AFTER PARKING, THE VEHICLE LOST ABILITY TO SHIFT INTO REVERSE AS WELL. NOISE TRANSMITTED FROM TRANSMISSION CONTAINED METALLIC MATERIAL GRINDING AND MOVING WITHIN. AT THE TIME, THE VEHICLE WAS STILL LESS THAN 3 YEARS OLD WITH THE MAJORITY OF ITS USE COMING FROM WORK TRANSPORTATION. THE CHEVY DEALER WOULD NOT QUOTE WITHOUT DISASSEMBLING THE TRANSMISSION, WHICH WOULD BE THE MAJORITY OF THE LABOR INVOLVED IN A FULL REPAIR. THEY STATED THAT THEY GENERALLY PREFER TO REPLACE THE TRANSMISSION, $3200. A LOCAL TRANSMISSION SHOP DIAGNOSED THE ISSUE WITHIN 10 MINUTES. THE OWNER HAS SEEN THIS ISSUE ON SEVERAL OCCASIONS AND LITERALLY DESCRIBED THE SYMPTOMS AS SOON AS I TOLD HIM I HAD A BLAZER WITH TRANSMISSION ISSUES. THE COMPLETE REBUILD, DUE TO A SUN-SHELL GEAR FAILURE, COST $2097.78. THE TECHNICIAN STATED THAT THE NON-ROBUST JOINING OF TWO CYLINDERS (NO FILLET) AS WELL AS THE THICKNESS AND MATERIAL USED ALLOWS THE PART TO FAIL QUITE FREQUENTLY. HE HAD COMPLETED MULTIPLE JOBS FOR THIS AT HIS SHOP ALONE. IN FACT, AN ACQUAINTANCE OF MINE, HAD THE IDENTICAL SITUATION HAPPEN WITH HIS BLAZER THE WEEK OF 10/26/03. AT THE TIME OF THE INCIDENT I HAD CALLED THE CHEVY CUSTOMER SERVICE LINE WITH NO HELP COMING FROM THEM. THIS HAS BEEN THE PINNACLE OF SEVERAL FAILURES ON THIS VEHICLE INCLUDING BOTH FRONT WHEEL BEARING ASSEMBLIES (38,000MI AND 55,000MI), A POWER SEAT THAT QUIT WORKING, A POWER WINDOW THAT QUIT WORKING, AND SEVERAL PAINT ISSUES. REFERENCE CHEVY TECHNICAL SERVICE BULLETIN 010730038.*AK
HEADLIGHTS FLICKER - FASTER THAN YOU CAN BLINK AN EYE--WILL THE LIGHTS STAY OFF SOMETIME? A DISASTER AT NIGHT.*AK
THE ADJUSTABLE PEDESTAL ON THE SEAT BASE OCCASIONALLY COLLAPSES WHEN IT IS SUBJECTED TO HIGH TEMPERATURES. *MR INCLUDING THE INTERIOR OF THE VEHICLE IN THE SUMMERTIME. THE PLASTIC WOULD BECOME VERY PLIABLE ALSO WHEN PRESSING THE BASE INTO THE SEAT DURING INSTALLATION, THE ADJUSTMENT NOTCHES SLIPPED. *SCC
SEAT ADJUSTMENT HANDLE BROKE OFF DRIVER'S SEAT. THIS IS A VERY EXPENSIVE REPAIR, AND HAVE FOUND OUT THAT THERE A ALOT OF THESE BREAKING. I THINK CHEVROLET SHOULD MAKE THIS INTO A RECALL SO THEIR CUSTOMERS DO NOT HAVE TO PAY FOR THEIR MISTAKES. NONE IS PERFECT, BUT AT LEAST THEY COULD MAKE THE EFFORT TO FIX THEM, AND NOT MAKE…
Read full complaint
SEAT ADJUSTMENT HANDLE BROKE OFF DRIVER'S SEAT. THIS IS A VERY EXPENSIVE REPAIR, AND HAVE FOUND OUT THAT THERE A ALOT OF THESE BREAKING. I THINK CHEVROLET SHOULD MAKE THIS INTO A RECALL SO THEIR CUSTOMERS DO NOT HAVE TO PAY FOR THEIR MISTAKES. NONE IS PERFECT, BUT AT LEAST THEY COULD MAKE THE EFFORT TO FIX THEM, AND NOT MAKE THE CUSTOMER DO SO.*AK
AUTOMATIC TRANSMISSION WAS LEAKING OIL. DEALER DETERMINED THAT THE LEAK WAS UNUSUAL, AND HAD TO TAKE TRANSMISSION APART TO FIND THE CAUSE OF THE LEAK. *AK
THE PASSENGER SIDE SEAT WILL NOT LOCK INTO PLACE, CAUSING THE SEAT TO SLIDE FORWARD WHILE THE VEHICLE IS IN OPERATION. THE PASSENGER SEAT LEVER ALSO BROKE OFF WHILE ATTEMPTING TO ADJUST THE RECLINE POSITION OF THE SEAT BACK. DEALER IS REPAIRING BOTH PROBLEMS WITH A COST OF OVER $600.00. *LA
PROBLEMS WITH 2000 CHEVROLET BLAZER SUV. *LA
Official recalls
408V231000 · Exterior Lighting:brake Lights:switch
May 21, 2008
GENERAL MOTORS IS RECALLING 5,862 MY 2000-2002 CHEVROLET BLAZER, MY 2000-2001 GMC JIMMY, AND MY 2000 OLDSMOBILE BRAVADA SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. THE RECALL BEGAN ON JUNE 17, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR OLDSMOBILE AT 1-800-630-6537, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> . NOTE: THIS CAMPAIGN IS AN EXPANSION OF A PREVIOUS RECALL (PLEASE SEE 01V364).
01V364000 · Exterior Lighting:brake Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:switch
Dec 3, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Exterior Lighting:brake Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
00V228003 · Seat Belts
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
99V220000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
Aug 11, 1999
VEHICLE DESCRIPTION: S -TRUCKS EQUIPPED WITH 2 WHEEL DRIVE. THESE VEHICLES MAY HAVE HAD THE RIGHT-HAND ANTILOCK BRAKE SYSTEM (ABS) MODULE FEED PIPE AND/OR BRAKE CROSSOVER PIPE TUBE NUTS TIGHTENED WITHOUT SEATING THE PIPE-FLARED-ENDS ENOUGH TO WITHSTAND NORMAL ASSEMBLY AND VEHICLE INPUTS WITHOUT PARTIALLY UNSEATING. THIS DOES NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC SERVICE BRAKE NORMAL, EMERGENCY, AND PARK BRAKING PERFORMANCE."
Consequence & remedy
Consequence: IF THIS OCCURRED, THE SEATING SEAL COULD BE BROKEN DURING VEHICLE ASSEMBLY, OR FROM EARLY ROAD INPUTS OR BRAKE FLUID CYCLING, AND A LEAK COULD OCCUR INCREASING THE BRAKE STOPPING DISTANCE.
Remedy: DEALERS WILL INSPECT THE BRAKE PIPE UNION FOR SIGNS OF BRAKE FLUID, AND IF NECESSARY, INSTALL A NEW BRAKE PIPE UNION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3RQ08001 · Hazard Light Switch Failure
Opened Feb 28, 2008 · Closed Jul 9, 2008
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
RQ02012 · Front Control Arm Ball Joints
Opened Sep 10, 2002 · Closed Mar 7, 2003
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
SEE ATTACHED PAGE.
Additional source detail variants (7)
Suspension:front:control Arm
SEE ATTACHED PAGE.
Suspension:front:control Arm:lower Arm
SEE ATTACHED PAGE.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED PAGE.
Suspension:front:control Arm:upper Arm
SEE ATTACHED PAGE.
Suspension:front:control Arm:upper Ball Joint
SEE ATTACHED PAGE.
Suspension:front
SEE ATTACHED PAGE.
Suspension
SEE ATTACHED PAGE.
PE01032 · Loss Of Stop Lamp Illumination
Opened Sep 6, 2001 · Closed Dec 20, 2001
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.