NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
54 reportsClear category filterMileage unknown · Jul 30, 2003
Service Brakes, AirService Brakes, Hydraulic
MY 2000 CHEVY BLAZER (88K MI.) HAD BOTH THE ABS SYSTEM LIGHT AND EMERGENCY BRAKE LIGHT COME ON. I HAVE ALSO EXPERIENCED STRANGE ABS ACTIVATION EVEN AT LOW SPEED AND LIGHT BRAKE APPLICATION. MY DEALER SAID THE ABS CONTROLLER IS FAULTY. I HAVE FOUND NUMEROUS DESCRIPTIONS OF THESE VERY SAME SYMTOMS FROM OTHER OWNERS AS WELL AS T…
Read full complaint
MY 2000 CHEVY BLAZER (88K MI.) HAD BOTH THE ABS SYSTEM LIGHT AND EMERGENCY BRAKE LIGHT COME ON. I HAVE ALSO EXPERIENCED STRANGE ABS ACTIVATION EVEN AT LOW SPEED AND LIGHT BRAKE APPLICATION. MY DEALER SAID THE ABS CONTROLLER IS FAULTY. I HAVE FOUND NUMEROUS DESCRIPTIONS OF THESE VERY SAME SYMTOMS FROM OTHER OWNERS AS WELL AS TSB REFERENCES TO THIS DEFECT. THIS LOOKS LIKE A TREND AND A DESIGN FLAW AND A SAFTEY ISSUE. THIS SHOULD BE INVESTIGATED AND THE ABS CONTROLLER SYSTEM SHOULD BE RECALLED.
NHTSA ODI #10030473
78,000 miles · May 17, 2003
Service Brakes, HydraulicCrash
WHILE TRAVELING AT SLOW SPEEDS, (LESS THAN 15 MPH) BRAKE PEDAL PULSES, AND GOES TOWARDS THE FLOOR. ABS THEN ACTIVATES, AND THE TRUCK DOES NOT STOP. THIS HAS HAPPENED 5-10 TIMES, TWICE CAUSING COLLISIONS WITH CURBS, AND PARKING BARRIERS. GARAGE THAT FIXED A BROKEN BRAKE LINE, CHECKED THE BRAKES, AND COULD FIND NO PROBLEMS. *JB
NHTSA ODI #10018840
41,699 miles · May 5, 2003
Power TrainSeatsService Brakes, Hydraulic
PURCHASED 2000 BLAZER 11/24/00. MANY PROBLEMS SINCE. TRANSMISSION COOLER LINE, WARRANTY REPAIR. OIL COOLER LINES, UPPER AND LOWER, WARRANTY REPAIR. WARRANTY EXPIRED AND THEY ARE LEAKING STILL. PROBLEM NEVER REALLY FIXED. IDLER ARM, WARRANTY REPAIR. DRIVER SIDE RECLINE HANDLE DRIVER SEAT FELL BACK WOULD NOT RETURN TO UPRIGHT POSI…
Read full complaint
PURCHASED 2000 BLAZER 11/24/00. MANY PROBLEMS SINCE. TRANSMISSION COOLER LINE, WARRANTY REPAIR. OIL COOLER LINES, UPPER AND LOWER, WARRANTY REPAIR. WARRANTY EXPIRED AND THEY ARE LEAKING STILL. PROBLEM NEVER REALLY FIXED. IDLER ARM, WARRANTY REPAIR. DRIVER SIDE RECLINE HANDLE DRIVER SEAT FELL BACK WOULD NOT RETURN TO UPRIGHT POSITION, WARRANTY REPAIR. BOTH FRONT WHEEL BEARINGS AND ROTORS, WARRANTY REPAIR. FROM DAY 1 NUMEROUS RATTLES AND SQUEAKS. DOOR PANELS RATTLE CONSTANTLY. PASSENGER SEAT RATTLES AND SQUEAKS. WINDSHIELD WIPER ENTIRE ARM CAME OFF, REPAIRED AT MY EXPENSE. OUT OF WARRANTY, AT 41,699 MILES BUT NOT EVEN (2) YEARS OLD, TRANSMISSION HAD TO BE REBUILT AT MY EXPENSE. CHEVY CUSTOMER SERVICE IS A JOKE! COST OF TRANSMISSION $2,442 AND THE COST OF A TWO WEEK CAR RENTAL. EVEN WHEN TRANSMISSION LINE HAD TO BE REPAIRED WE HAD TO RENT A CAR AT OUR EXPENSE BECAUSE LOCAL DEALER REFUSED TO SUPPLY A LOANER. AGAIN CHEVY CUSTOMER SERVICE A JOKE! CALLED CHEVY HOT LINE/HELP LINE AND WAS JUST GIVEN THE RUN AROUND. I WILL NEVER BUY CHEVY AMERICAN MADE AUTO AGAIN. WHY IS IT YOU CAN BUY ANY ITEM AT MOST DEPARTMENT STORES AND TAKE IT BACK AND RECEIVE SATISFACTION, BUT SPEND $25,000+ FOR A CHEVY PRODUCT AND YOU ARE SCREWED WHEN YOU SIMPLY WANT THE RELIABILITY AND SERVICE YOU WERE PROMISED. I TELL EVERY PERSON I MEET NOT TO BUY A CHEVY. SOLID LIKE A ROCK? WHAT A LIE! *JB
NHTSA ODI #10017055
37,979 miles · Mar 17, 2003
EquipmentLatches/locks/linkagesSeats
SUSPENSION FRONT AND REAR-UPPER AND LOWER BALL JOINTS(FRONT)LEFT AND RIGHT SIDES IDLER ARM AND BOTH REAR LEAF SPRINGS NEEDED TO BE REPLACED. WARPED ROTORS LEFT AND RIGHT. LEFT DOOR LOCK CYLINDER FELL OFF. DEALER REPLACED RIGHT REAR SPEAKER UNDER WARRANTY. FRONT SEAT RECLINER LEVERS REPLACED RESULTING IN SPLIT COST WITH DEALER. …
Read full complaint
SUSPENSION FRONT AND REAR-UPPER AND LOWER BALL JOINTS(FRONT)LEFT AND RIGHT SIDES IDLER ARM AND BOTH REAR LEAF SPRINGS NEEDED TO BE REPLACED. WARPED ROTORS LEFT AND RIGHT. LEFT DOOR LOCK CYLINDER FELL OFF. DEALER REPLACED RIGHT REAR SPEAKER UNDER WARRANTY. FRONT SEAT RECLINER LEVERS REPLACED RESULTING IN SPLIT COST WITH DEALER. MANUFACTURER REP OFFERED LABOR/PARTS SPLIT FOR SUSPENSION WORK AND BRAKE WORK FOR $1400.00. REFUSED WORK ON DOOR LOCK IN EXCESS OF $300.00. *JB
NHTSA ODI #10010638
Mileage unknown · Aug 13, 2002
Engine And Engine CoolingService Brakes, Hydraulic
WHILE DRIVING 60MPH ENGINE SHUT OFF, CAUSING LOSS OF POWER STEERING AND BRAKES.*AK CONSUMER STATES THE BRAKES ARE SENSITIVE AND GRAB QUICKLY, DEALER COULD NOT DUPLICATE CONCERN, ALSO THERE WAS AN OIL LEAK, THE DEALER REPLACED A CRACKED OIL PAN.*JB
NHTSA ODI #8016236
Mileage unknown · May 29, 2002
Service Brakes, Hydraulic
ROTORS: FRONT ROTORS FLAKING BADLY - REPLACED AT 22,000 MILES. BACK ROTORS FLAKING BADLY, HAD TO FIGHT TO GET REPLACED AT 34,000 MILES. DEALER SAID THIS PART IS NOT PART OF WARRANTY - IS A "WEAR" ITEM. DRIVER'S SEAT RECLINING LEVER BROKE ALMOST IMMEDIATELY. DEALER REPAIRED.*AK
NHTSA ODI #762422
Mileage unknown · Dec 17, 2001
EquipmentExterior LightingFuel System, Gasoline
ENGINE STALLED WHILE DRIVING, DEALER DETERMINED FUEL GAUGE WAS BROKEN, MASTERCARD WAS REPLACED.*AK CONSUMER STATED THE GAS GAUGE READ ? OF A TANK, DEALER FOUND BROKEN FUEL CARD AND REPLACED THE CARD, PARKING BRAKE HOSE BROKE OF AND DRUM WAS RUSTY CAUSING PARKING BRAKE TO HANG UP, DEALER REPLACED DAMAGED SHOES AND RUSTED DRUMS…
Read full complaint
ENGINE STALLED WHILE DRIVING, DEALER DETERMINED FUEL GAUGE WAS BROKEN, MASTERCARD WAS REPLACED.*AK CONSUMER STATED THE GAS GAUGE READ ? OF A TANK, DEALER FOUND BROKEN FUEL CARD AND REPLACED THE CARD, PARKING BRAKE HOSE BROKE OF AND DRUM WAS RUSTY CAUSING PARKING BRAKE TO HANG UP, DEALER REPLACED DAMAGED SHOES AND RUSTED DRUMS, BRAKE LIGHTS AND LIGHTS INTERMITTENTLY INOPERATIVE, WHILE BRAKING AND TURNING TO THE RIGHT VEHICLE IS MAKING GRINDING NOISE FROM FRONT, DEALER REPLACED LEFT HUB, WHILE DRIVING BRAKES MAKE NOISE, DEALER FOUND ROTORS OUT OF ROUND, WIPERS WILL INTERMITTENTLY NOT WORK, AND ALSO THERE WAS A BURNING SMELL COMING FROM FUSE AREA, DRIVER SIDE SEAT WOULD NOT LOCK INTO PLACE AND THE RECLINER BROKE, DRIVERS SIDE DOOR PANEL WAS LOOSE, DEALER REPLACED SIDE DOOR PANEL AND DRIVERS WINDOW WAS LOOSE AND RATTLING, MOLDING WAS ALSO RATTLING. *YD
NHTSA ODI #8000804
Mileage unknown · Nov 1, 2001
Exterior LightingService Brakes, Hydraulic
BRAKE LIGHTS DO NOT LIGHT UP WHEN STEPPING ON BRAKES. ALSO, EMERGENCY BRAKE LIGHTS DO NOT COME ON. CONTACTED DEALER, AND DEALER WAS NOT WILLING TO DO ANYTHING. *AK
NHTSA ODI #898633
Mileage unknown · Nov 1, 2001
Service Brakes, Hydraulic
EVERY PLACE I HAVE CONTACTED ABOUT THESE REPAIRS HAS STATED THEY ARE AWARE OF THESE TWO PRODUCT-WIDE PART DEFECTS. PER SCOTT AT DARRYL BURKE, THE MF SWITCH HAS BEEN GOING OUT ON MOST AFFECTED VEHICLES, WHICH HAS BEEN A PRODUCT-WIDE FAILURE, PRIOR TO THE 36OOO MILE WARRANTY LIMIT. PER JR AT ATLANTIC AVE. TIRE IN CARY, NC, 919 8…
Read full complaint
EVERY PLACE I HAVE CONTACTED ABOUT THESE REPAIRS HAS STATED THEY ARE AWARE OF THESE TWO PRODUCT-WIDE PART DEFECTS. PER SCOTT AT DARRYL BURKE, THE MF SWITCH HAS BEEN GOING OUT ON MOST AFFECTED VEHICLES, WHICH HAS BEEN A PRODUCT-WIDE FAILURE, PRIOR TO THE 36OOO MILE WARRANTY LIMIT. PER JR AT ATLANTIC AVE. TIRE IN CARY, NC, 919 872-0786, HE AND HIS SUPPLIER ARE AWARE OF THE BROAD MF SWITCH FAILURES WHICH CAUSE LOSS OF REAR BRAKE LIGHTS AND COULD NOW BE THE MAIN FACTOR CONTRIBUTING TO MANY ACCIDENTS. ALSO,SCOTT AT DARRYL BURKE'S SVC DEPT TOLD ME TODAY NOT TO BOTHER SPENDING $340 TO REPLACE THE SEAT ADJ LEVERS AS THEY WILL JUST BREAK AGAIN AS THERE HAS NOT BEEN A PRODUCT UPGRADE ISSUED TO FIX THE ROOT CAUSE OF THIS PRODUCT WIDE PROBLEM. IF THE SEAT CAN NOT BE ADJUSTED SO THAT THE DRIVER IS COMFORTABLE AND HAS OPTIMUM VISIBILITY, THIS PROBLEM CAN CONTRIBUTE TO DRIVER ERROR AND ACCIDENTS.*AK
NHTSA ODI #753985
Mileage unknown · Oct 16, 2001
Service Brakes, HydraulicCrashInjury
WHEN BRAKES WERE APPLIED, PEDAL WENT TO FLOOR/SPEED APPROX. 15MPH./VEH. IN OFF POSITION/PEDAL HIGH/ONCE IGNITION APPLIED/PEDAL GOES TO FLOOR/POLICE REPORT VERIFIED THIS AS PER ATT ACHED/CARIBBEAN AUTO MART DID ALL SERVICING/COMPLAINTS ABOUT BRAKE PROBLEM ONGOING AND CONSISTENT. *AK
NHTSA ODI #753298
Official recalls
4May 21, 2008
GENERAL MOTORS IS RECALLING 5,862 MY 2000-2002 CHEVROLET BLAZER, MY 2000-2001 GMC JIMMY, AND MY 2000 OLDSMOBILE BRAVADA SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. THE RECALL BEGAN ON JUNE 17, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR OLDSMOBILE AT 1-800-630-6537, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> . NOTE: THIS CAMPAIGN IS AN EXPANSION OF A PREVIOUS RECALL (PLEASE SEE 01V364).
Dec 3, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Exterior Lighting:brake Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Aug 11, 1999
VEHICLE DESCRIPTION: S -TRUCKS EQUIPPED WITH 2 WHEEL DRIVE. THESE VEHICLES MAY HAVE HAD THE RIGHT-HAND ANTILOCK BRAKE SYSTEM (ABS) MODULE FEED PIPE AND/OR BRAKE CROSSOVER PIPE TUBE NUTS TIGHTENED WITHOUT SEATING THE PIPE-FLARED-ENDS ENOUGH TO WITHSTAND NORMAL ASSEMBLY AND VEHICLE INPUTS WITHOUT PARTIALLY UNSEATING. THIS DOES NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC SERVICE BRAKE NORMAL, EMERGENCY, AND PARK BRAKING PERFORMANCE."
Consequence & remedy
Consequence: IF THIS OCCURRED, THE SEATING SEAL COULD BE BROKEN DURING VEHICLE ASSEMBLY, OR FROM EARLY ROAD INPUTS OR BRAKE FLUID CYCLING, AND A LEAK COULD OCCUR INCREASING THE BRAKE STOPPING DISTANCE.
Remedy: DEALERS WILL INSPECT THE BRAKE PIPE UNION FOR SIGNS OF BRAKE FLUID, AND IF NECESSARY, INSTALL A NEW BRAKE PIPE UNION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3RQ08001 · Hazard Light Switch Failure
Opened Feb 28, 2008 · Closed Jul 9, 2008
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
RQ02012 · Front Control Arm Ball Joints
Opened Sep 10, 2002 · Closed Mar 7, 2003
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
SEE ATTACHED PAGE.
Additional source detail variants (7)
Suspension:front:control Arm
SEE ATTACHED PAGE.
Suspension:front:control Arm:lower Arm
SEE ATTACHED PAGE.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED PAGE.
Suspension:front:control Arm:upper Arm
SEE ATTACHED PAGE.
Suspension:front:control Arm:upper Ball Joint
SEE ATTACHED PAGE.
Suspension:front
SEE ATTACHED PAGE.
Suspension
SEE ATTACHED PAGE.
PE01032 · Loss Of Stop Lamp Illumination
Opened Sep 6, 2001 · Closed Dec 20, 2001
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.
Illustration