NHTSA owner reports · September 18, 2026 snapshot.
Seats complaints
49 reportsClear category filterMileage unknown · Dec 27, 2003
Electrical SystemEngine And Engine CoolingFuel System, Diesel
I PURCHASED MY CHEVROLET BLAZER NEW AT THE END OF 1999 AND IT HAS BEEN IN THE SHOP SO MUCH I KNOW ALL 15 OF THE MECHANICS BY THERE FIRST NAME. THE BATTERY HAS BEEN REPLACED AT LEAST 3 TIMES, THE ALTERNATOR HAS BEEN CHANGED 3 TIMES, THE AUTOMATIC TRANSMISSION HAS BEEN REPLACES, THE SEAT HANDLES HAVE BEEN REPLACED MORE THAN ONCE, …
Read full complaint
I PURCHASED MY CHEVROLET BLAZER NEW AT THE END OF 1999 AND IT HAS BEEN IN THE SHOP SO MUCH I KNOW ALL 15 OF THE MECHANICS BY THERE FIRST NAME. THE BATTERY HAS BEEN REPLACED AT LEAST 3 TIMES, THE ALTERNATOR HAS BEEN CHANGED 3 TIMES, THE AUTOMATIC TRANSMISSION HAS BEEN REPLACES, THE SEAT HANDLES HAVE BEEN REPLACED MORE THAN ONCE, THE SEAT BELTS HAVE BEEN REPLACED FROM LOCKING UP, THE FRONT END HAS HAD WORK DONE TO IT AND STILL IS NOT FIXED, THE REAR RIGHT SPEAKER DOES NOT WORK, THE FUEL GAUGE HAS BEEN REPLACED, THE GAS PETAL STICKS I HAFT TO CLEAN THE CARD AT LEAST EVERY MONTH, THE HEATER CORE HAS BEEN REPLACED 3 TIMES AND IT STILL DOES NOT GET HOT. I WAS TOLD THAT THIS WAS CAUSED BY THE ORANGE ANTIFREEZE AND WAS TOLD THAT CHEY WOULD NOT WARRANTY THEIR 5 YEAR ANTIFREEZE AND THE DEALER TOLD ME THAT I NEEDED A $500.00 ENGINE FLUSH THAT I COULD DO MY SHELF FOR $10.00 BUT I WAS THEN TOLD THAT THE ENGINE WAS CORRODED UP INSIDE AND I WOULD NEED A NEW MOTOR AND THEY WOULD NOT PAY FOR IT EVEN UNDER WARRANTY. I CALLED GM COMPLAINT LINE AND WAS TOLD THAT THEY NEW OF THE PROBLEM AND THEY COULD NOT OFFER ME ANY HELP. THE COMPLAINT LINE WAS A JOKE AND A WASTE OF MY TIME. I WILL NEVER BUY ANOTHER CHEVY THIS IS MY SECOND VEHICLE. MY FIRST WAS A S10 AND I HAD THE SAME PROBLEMS. *AK
NHTSA ODI #10051171
55,321 miles · Dec 27, 2003
Seats
SEAT RECLINING ADJUST HANDLES ON DRIVER AND PASSENGER SEATS BROKE OFF.THEY WERE NOT HEAVELY USED.*AK
NHTSA ODI #10051156
40,000 miles · Dec 16, 2003
Seats
I HAVE A 2000 CHEVY BLAZER WITH 44,000 MILES. SINCE THE WARRANTY EXPIRED IN JULY I HAVE HAD NUMEROUS PROBLEMS THAT SEEM TO BE COMMON AMONG OWNS OF THIS TYPE OF VEHICLE. GM REFUSES TO ADDRESS THESE ITEMS SINCE THE CAR IS JUST OUT OF WARRANTY. SOME I CONSIDER TO BE SAFETY ISSUES. THEY ARE AS FOLLOWS: ACCELERATOR PEDAL STICKS,…
Read full complaint
I HAVE A 2000 CHEVY BLAZER WITH 44,000 MILES. SINCE THE WARRANTY EXPIRED IN JULY I HAVE HAD NUMEROUS PROBLEMS THAT SEEM TO BE COMMON AMONG OWNS OF THIS TYPE OF VEHICLE. GM REFUSES TO ADDRESS THESE ITEMS SINCE THE CAR IS JUST OUT OF WARRANTY. SOME I CONSIDER TO BE SAFETY ISSUES. THEY ARE AS FOLLOWS: ACCELERATOR PEDAL STICKS, SEAT RECLINER HANDLE IS BROKEN, FUEL GAUGE DOES NOT WORK PROPERLY AND 4 WHEEL DRIVE WILL NOT ENGAGE. FOR A VEHICLE THAT IS JUST OVER 3.5 YEARS OLD THIS IS UNACCEPTABLE. I WILL PROBABLY NOT PURCHASE ANOTHER GM VEHICLE DUE TO THESE PROBLEMS AND WILL PROBABLY PURCHASE A EUROPEAN AUTO, THEIR ENGINEERING AND CUSTOMER SERVICE ARE FAR SUPERIOR TO OUR US AUTOMAKERS. *AK
NHTSA ODI #10050597
Mileage unknown · Nov 4, 2003
Seats
SEAT ADJUSTMENT HANDLE BROKE OFF DRIVER'S SEAT. THIS IS A VERY EXPENSIVE REPAIR, AND HAVE FOUND OUT THAT THERE A ALOT OF THESE BREAKING. I THINK CHEVROLET SHOULD MAKE THIS INTO A RECALL SO THEIR CUSTOMERS DO NOT HAVE TO PAY FOR THEIR MISTAKES. NONE IS PERFECT, BUT AT LEAST THEY COULD MAKE THE EFFORT TO FIX THEM, AND NOT MAKE…
Read full complaint
SEAT ADJUSTMENT HANDLE BROKE OFF DRIVER'S SEAT. THIS IS A VERY EXPENSIVE REPAIR, AND HAVE FOUND OUT THAT THERE A ALOT OF THESE BREAKING. I THINK CHEVROLET SHOULD MAKE THIS INTO A RECALL SO THEIR CUSTOMERS DO NOT HAVE TO PAY FOR THEIR MISTAKES. NONE IS PERFECT, BUT AT LEAST THEY COULD MAKE THE EFFORT TO FIX THEM, AND NOT MAKE THE CUSTOMER DO SO.*AK
NHTSA ODI #10045458
45,000 miles · Oct 30, 2003
Seats
THE PASSENGER SIDE SEAT WILL NOT LOCK INTO PLACE, CAUSING THE SEAT TO SLIDE FORWARD WHILE THE VEHICLE IS IN OPERATION. THE PASSENGER SEAT LEVER ALSO BROKE OFF WHILE ATTEMPTING TO ADJUST THE RECLINE POSITION OF THE SEAT BACK. DEALER IS REPAIRING BOTH PROBLEMS WITH A COST OF OVER $600.00. *LA
NHTSA ODI #10045081
Mileage unknown · Sep 13, 2003
Seats
SEAT HANDLES ARE BROKEN AGAIN. RESULTING A RECLINING DRIVER SEAT. SEAT HANDLES BROKE UNDER WARRANTY AND WAS REPLACED, SO THIS IS THE SECOND TIME ON MY BLAZER, 2000 MODEL. GM NEEDS TO REDESIGN THESE HANDLES BECAUSE SOMEONE COULD GET INTO A ACCIDENT. *JB
NHTSA ODI #10038828
Mileage unknown · Sep 4, 2003
Seats
I JUST PURCHASED A CERTIFIED USED BLAZER IN JULY OF 2003. IT WAS IN FOR ITS SCHEDULED MAINTENANCE AND WHILE THERE THE TECHNICIAN SNAPPED OFF THE DRIVER'S SIDE SEAT ADJUSTMENT HANDLE, WHICH MY DEALER LATER REPLACED. NOT TWO WEEKS LATER THE PASSENGER SIDE HANDLE SNAPPED OFF AS WELL. MY DEALER WILL NOT REPLACE THE PASSENGER SIDE WI…
Read full complaint
I JUST PURCHASED A CERTIFIED USED BLAZER IN JULY OF 2003. IT WAS IN FOR ITS SCHEDULED MAINTENANCE AND WHILE THERE THE TECHNICIAN SNAPPED OFF THE DRIVER'S SIDE SEAT ADJUSTMENT HANDLE, WHICH MY DEALER LATER REPLACED. NOT TWO WEEKS LATER THE PASSENGER SIDE HANDLE SNAPPED OFF AS WELL. MY DEALER WILL NOT REPLACE THE PASSENGER SIDE WITHOUT CHARGING ME FOR PARTS AND LABOR.I FEEL THAT THIS IS A MANUFACTURED DEFECT. I HAVE RESEARCHED THIS SUBJECT AND HAVE FOUND MANY OTHER UNHAPPY CONSUMERS LIKE MYSELF REGARDING THIS ISSUE. *AK
NHTSA ODI #10037229
83,805 miles · Aug 22, 2003
Electrical SystemPower TrainSeats
WHILE DRIVING 25 MPH THE TRANSMISSION FAILED. THE DEALER WAS NOTIFIED ABOUT 7 MONTHS AGO BUT THEY COULD NOT DUPLICATE OR CORRECT THE PROBLEM. *AK THE DEALER WAS NOTIFIED OF THE SHRUDDERING AND SLIPPAGE OF THE TRANSMISSION AT 23863. THE FRONT DIFFERENTIAL PINION SEAL LEAKED, THE CHECK LIGHT WAS REPLACED DUE TO THE MALFUNCT…
Read full complaint
WHILE DRIVING 25 MPH THE TRANSMISSION FAILED. THE DEALER WAS NOTIFIED ABOUT 7 MONTHS AGO BUT THEY COULD NOT DUPLICATE OR CORRECT THE PROBLEM. *AK THE DEALER WAS NOTIFIED OF THE SHRUDDERING AND SLIPPAGE OF THE TRANSMISSION AT 23863. THE FRONT DIFFERENTIAL PINION SEAL LEAKED, THE CHECK LIGHT WAS REPLACED DUE TO THE MALFUNCTIONING SWITCH, THE BRAKE LIGHT HAD BECOME INOPERATIVE DUE TO AN OPEN CIRCUIT, THE HEATING SEAT WAS INOPERATIVE, THERE WAS A RATTLE IN RIGHT FRONT SUSPENSION, THE TRANSMISSION HAD NO REVERSE, AND THERE WAS HARD SHIFTING INTO THE FORWARD GEARS. *SCC
NHTSA ODI #10022306
50,810 miles · Jun 17, 2003
Fuel System, GasolineSeats
THE FUEL PUMP NEEDED TO BE REPLACED ON MY 2000 CHEVY BLAZER BECAUSE THE SENDING UNIT WAS CORRODED, ALSO THE HANDLE ON THE SIDE OF THE DRIVERS SEAT BROKE OFF WHEN I USED IT. *JB
NHTSA ODI #10023255
64,000 miles · Jun 2, 2003
Seats
THE SEAT RECLINER ON THE DRIVERS SIDE BROKE. AFTER FIXING, THE SEAT THEN SQUEAKED AND RATTLED. DEALERSHIP SAAID I HAVE A BROKEN SEAT FRAME. DEALERSHIP WON'T PAY FOR DAMANGES. *AK THIS IS THE SECOND GENERAL MOTORS VEHICLE THAT HAS A BROKEN SEAT RECLINER. THE FIRST ONE WAS A 98 GMC JIMMY. SAME THING HAPPENED.
NHTSA ODI #10020878
Official recalls
4May 21, 2008
GENERAL MOTORS IS RECALLING 5,862 MY 2000-2002 CHEVROLET BLAZER, MY 2000-2001 GMC JIMMY, AND MY 2000 OLDSMOBILE BRAVADA SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. THE RECALL BEGAN ON JUNE 17, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR OLDSMOBILE AT 1-800-630-6537, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> . NOTE: THIS CAMPAIGN IS AN EXPANSION OF A PREVIOUS RECALL (PLEASE SEE 01V364).
Dec 3, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Exterior Lighting:brake Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Aug 11, 1999
VEHICLE DESCRIPTION: S -TRUCKS EQUIPPED WITH 2 WHEEL DRIVE. THESE VEHICLES MAY HAVE HAD THE RIGHT-HAND ANTILOCK BRAKE SYSTEM (ABS) MODULE FEED PIPE AND/OR BRAKE CROSSOVER PIPE TUBE NUTS TIGHTENED WITHOUT SEATING THE PIPE-FLARED-ENDS ENOUGH TO WITHSTAND NORMAL ASSEMBLY AND VEHICLE INPUTS WITHOUT PARTIALLY UNSEATING. THIS DOES NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC SERVICE BRAKE NORMAL, EMERGENCY, AND PARK BRAKING PERFORMANCE."
Consequence & remedy
Consequence: IF THIS OCCURRED, THE SEATING SEAL COULD BE BROKEN DURING VEHICLE ASSEMBLY, OR FROM EARLY ROAD INPUTS OR BRAKE FLUID CYCLING, AND A LEAK COULD OCCUR INCREASING THE BRAKE STOPPING DISTANCE.
Remedy: DEALERS WILL INSPECT THE BRAKE PIPE UNION FOR SIGNS OF BRAKE FLUID, AND IF NECESSARY, INSTALL A NEW BRAKE PIPE UNION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3RQ08001 · Hazard Light Switch Failure
Opened Feb 28, 2008 · Closed Jul 9, 2008
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
RQ02012 · Front Control Arm Ball Joints
Opened Sep 10, 2002 · Closed Mar 7, 2003
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm; Suspension:front:control Arm:lower Ball Joint; Suspension:front:control Arm:upper Arm; Suspension:front:control Arm:upper Ball Joint
SEE ATTACHED PAGE.
Additional source detail variants (7)
Suspension:front:control Arm
SEE ATTACHED PAGE.
Suspension:front:control Arm:lower Arm
SEE ATTACHED PAGE.
Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED PAGE.
Suspension:front:control Arm:upper Arm
SEE ATTACHED PAGE.
Suspension:front:control Arm:upper Ball Joint
SEE ATTACHED PAGE.
Suspension:front
SEE ATTACHED PAGE.
Suspension
SEE ATTACHED PAGE.
PE01032 · Loss Of Stop Lamp Illumination
Opened Sep 6, 2001 · Closed Dec 20, 2001
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.
Illustration