Fuel/propulsion System. Review the 12 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

0 crash reports2 fire reports0 injury reports

Suspension complaints

2 reports

Clear category filter

116,526 miles · May 13, 2021

EngineSuspension

Read full complaint

3/23/2021 DRIVING ON I-94 IN MORNING RUSH HOUR WHEN ENGINE KILLED. WAS ABLE TO ROLL OVER TO THE MEDIAN BETWEEN AN ON-RAMP AND THE HIGHWAY BEFORE CAR STOPPED MOVING. CHARGE BATTERY LIGHT ON ON THE DASH AS WELL AS CHECK STABILIZATION WARNING. WOULD NOT TURN OVER AT ALL BUT DASH LIGHTS/WIPERS WERE ON (RAINING). TOWED TO MECHANIC I'VE TAKEN VEHICLES TO FOR PAST 4-5 CARS/TRUCKS. IT WAS FOUND THAT THE #2 PISTON RING CAME OFF AND JAMMED BETWEEN THE CYLINDER WALL AND PISTON CAUSING THE ENGINE TO SEIZE/NEED TO BE REPLACED. ONCE IT WAS REPLACED AND WHILE DOING A TEST DRIVE, THE MECHANIC FELT A VIBRATION AND THEY FOUND THAT THERE WAS MOVEMENT ON THE PASSENGER SIDE AXLE SO THEY REPLACED THAT AS WELL. THE CAR HAD 116.5K ON IT WHEN I PURCHASED ABOUT 2 WEEKS PRIOR TO THE ENGINE AND CV ASSEMBLY NEEDING TO BE REPLACED. JUST GOT CAR BACK YESTERDAY, JUST OVER A MONTH AND A HALF TO REPAIR.

NHTSA ODI #11416491

7 miles · Jul 8, 2012

SteeringSuspension

THE CAR WILL NOT GO STRAIGHT. IT KEEPS PULLING TO THE RIGHT SIDE, MY 2012 535I HAS BEEN ALIGNED TWICE BY BMW AND CAN'T CORRECT THE PROBLEM. MY SERVICE ADVISOR ADVISED ME THAT I NEEDED TO CONTACT BMW OF NORTH AMERICA AND ADDRESS THE ISSUE TO THEM. *TR

NHTSA ODI #10464642

Official recalls

16V746000 · Fuel System, Gasoline:delivery:fuel Pump

Oct 17, 2016

BMW of North America, LLC (BMW) is recalling certain model year 2007-2011 BMW X5 3.0si, X5 4.8i, X5 M, X5 xDrive30i, X5 xDrive35i, X5 xDrive48i and X5 xDrive50i, 2008-2011 X6 x Drive35i, X6 xDrive50i and X6 M, 2010-2011 X6 ActiveHybrid, 535i xDrive Gran Turismo, 535i Gran Turismo, 550i xDrive Gran Turismo and 550i Gran Turismo, 2011-2012 528i, 535i, 535i xDrive, 550i and 550i xDrive and 2012 535i ActiveHybrid, 640i Convertible, 650i Convertible, 650i xDrive Convertible, 650i Coupe and 650i Coupe xDrive vehicles. The affected vehicles have in-tank fuel pumps that may have insufficiently crimped wire contacts.

Consequence & remedy

Consequence: The loose wires may cause the connector to melt, resulting in a fuel leak. Additionally, the fuel pump may stop working, possibly causing an engine stall and increase the risk of a crash.

Remedy: BMW will notify owners, and dealers will replace the fuel pump module, free of charge. The recall began February 2017. Owners may contact BMW customer service at 1-800-525-7417.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

DP22005 · Pedestrian Alert Sounds

Opened Jan 27, 2023 · Closed Aug 7, 2023

Status: closed (inferred from source dates) · Electrical System:propulsion System

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.