Fuel/propulsion System. Review the 12 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

0 crash reports2 fire reports0 injury reports

Steering complaints

4 reports

Clear category filter

43,000 miles · Dec 29, 2016

Air BagsSteering

Read full complaint

I HAD TO REPLACE THE AIRBAG CLOCK SPRING IN MY CAR BECAUSE OF A CLICKING SOUND WHEN THE STEERING WHEEL WAS TURNING ANY DIRECTION, SOUND HEARD WHEN VEHICLE WAS IN DRIVE OR PARK. I HAD ABOUT 43,000 MILES ON THE VEHICLE WHEN THE NOISE STARTED. I HAD CALLED BMW TO SEE IF THERE WAS ANY WARRANTY ON THIS ITEM BEING IT IS PART OF THE SRS SYSTEM FOR THE CAR, AND THEY TOLD ME FOR MY VEHICLE VIN THERE WAS NOT. BEING APART OF THE AIRBAG SYSTEM I AM WONDERING IF THERE WAS ANY SAFETY GUIDELINES OR EXTENDED WARRANTY I AM NOT BEING INFORMED OF FOR THE PART I HAD TO REPLACE 61-31-9-354-047. *TR

NHTSA ODI #10938578

33,573 miles · Oct 25, 2013

Electrical SystemSteering

Read full complaint

THE CAR HAS BEEN IN AND OUT OF THE SHOP FOR VARIOUS PROBLEMS FROM THE MOMENT WE BOUGHT IT. THE CAR STARTED MAKING WHISTLING SOUNDS AND ENGINE LIGHTS WOULD COME ON AND HAS BEEN SEEN BY BMW RTS ALREADY 4 TIMES. BUT MOST RECENTLY MY HUSBAND WAS WAITING AT THE LIGHT TO MAKE A LEFT TURN WHEN HIS STEERING WHEEL ALL OF A SUDDEN LOCKED AND HE COULD NOT DRIVE IT. SO WE TOOK IT IN TO GET IT SERVICED AND WAS TOLD TO IMMEDIATELY CONTACT BMW OF NORTH AMERICA . 3 WEEKS LATER I FINALLY RECEIVED MY CAR AND CAUSE OF THIS STEERING ERROR READS: EPS CONTROL UNIT IS FAULTY. THE REPLACED THE EPS CONTROL UNIT, BASICALLY THE STEERING RACK, AND THE EPS CONTROL UNIT FAILED AGAIN! THEY DISCONNECTED THE BATTERY TO RESET THE CONTROL MODULES REPROGRAMMED THE EPS CONTROL UNIT, ADJUSTED THE STEERING ANGELS, INITIALIZED ALL WINDOWS AND SUNROOF, PERFORMED ACTIVE 4 WHEEL ALIGNMENT. BASICALLY THE CARS A DUD AND BMW REFUSES A BUY BACK. *TR

NHTSA ODI #10549587

400 miles · Sep 3, 2013

Steering

TL* THE CONTACT OWNS A 2012 BMW 535I. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STARTED TO PULL TO THE RIGHT. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS BUT THEY WERE UNABLE TO DUPLICATE THE PROBLEM. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE …

Read full complaint

NHTSA ODI #10541692

7 miles · Jul 8, 2012

SteeringSuspension

THE CAR WILL NOT GO STRAIGHT. IT KEEPS PULLING TO THE RIGHT SIDE, MY 2012 535I HAS BEEN ALIGNED TWICE BY BMW AND CAN'T CORRECT THE PROBLEM. MY SERVICE ADVISOR ADVISED ME THAT I NEEDED TO CONTACT BMW OF NORTH AMERICA AND ADDRESS THE ISSUE TO THEM. *TR

NHTSA ODI #10464642

Official recalls

16V746000 · Fuel System, Gasoline:delivery:fuel Pump

Oct 17, 2016

BMW of North America, LLC (BMW) is recalling certain model year 2007-2011 BMW X5 3.0si, X5 4.8i, X5 M, X5 xDrive30i, X5 xDrive35i, X5 xDrive48i and X5 xDrive50i, 2008-2011 X6 x Drive35i, X6 xDrive50i and X6 M, 2010-2011 X6 ActiveHybrid, 535i xDrive Gran Turismo, 535i Gran Turismo, 550i xDrive Gran Turismo and 550i Gran Turismo, 2011-2012 528i, 535i, 535i xDrive, 550i and 550i xDrive and 2012 535i ActiveHybrid, 640i Convertible, 650i Convertible, 650i xDrive Convertible, 650i Coupe and 650i Coupe xDrive vehicles. The affected vehicles have in-tank fuel pumps that may have insufficiently crimped wire contacts.

Consequence & remedy

Consequence: The loose wires may cause the connector to melt, resulting in a fuel leak. Additionally, the fuel pump may stop working, possibly causing an engine stall and increase the risk of a crash.

Remedy: BMW will notify owners, and dealers will replace the fuel pump module, free of charge. The recall began February 2017. Owners may contact BMW customer service at 1-800-525-7417.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

DP22005 · Pedestrian Alert Sounds

Opened Jan 27, 2023 · Closed Aug 7, 2023

Status: closed (inferred from source dates) · Electrical System:propulsion System

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.