Electrical System. Review the 158 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 145 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel System, Gasoline. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

9 crash reports3 fire reports7 injury reports

Tires complaints

6 reports

Clear category filter

180,740 miles · Jul 4, 2017

Tires

Read full complaint

CATASTROPHIC BLOWOUT FAILURE OF PRIMEWELL VALERA TOURING TIRE PURCHASED FROM FIRESTONE IN JACKSON, MS, ON 06/14/2016. BLOWOUT OCCURRED ON 07/03/2017 WHILE WIFE WAS DRIVING ON I-55. WE HAVE PUT LESS THAN 12K MILES ON THESE TIRES AND, NOW, DO NOT FEEL SAFE. POSSIBLE DAMAGE TO CAR (VOLVO XC90). WIFE STRANDED OVER JULY 4TH HOLIDAY IN LOUISIANA BECAUSE FIRESTONE IS CLOSED. AFTER INITIALLY TELLING US THAT THE TIRES WOULD BE REPLACED FREE BECAUSE THERE WAS A RECALL, FIRESTONE NOW SAYS WE WILL HAVE TO PAY FOR NEW TIRES BECAUSE OUR TIRES ARE NOT BEING RECALLED. EXTREMELY FRUSTRATING.

NHTSA ODI #11002965

76,000 miles · Sep 15, 2008

Engine And Engine CoolingPower TrainSteering

Read full complaint

TRANSMISSION REPLACED JUNE 08 FRONT CONTROL ARMS AND BUSHINGS AND COOLANT RESERVOIR REPLACED SEPT. 08 THERMOSTAT & HOUSING & TEMP SENSOR REPLACED JAN. 08 BRAKE VACUUM PUMP REPLACED FOR 2ND TIME JAN. 08 BRAKE VACUUM PUMP REPLACED SEPT. 07 GASKET, O-RING, HOSE CLAMP RECALL SEPT. 07 POWER STEERING PUMP AND BRAKE VACUUM PUMP INSTALLED JULY 07 STEERING RACK SOLENOID REPLACED JULY 07 - (RECALL MAY 3, 08?) NEW BRIDGESTONE TIRES MAY 07 UPPER ENGINE TORQUES MOUNT REPLACED MARCH 07 RECALL WIPER ARM 156, BALL JOINT 157 OCT. 06 BRAKE PAD & ROTORS REPLACED OCT 06 UPGRADE SOFTWARE A & C JULY 05 ABS BRAKES WARRANTY FIX MAY 06 FRONT PADS & REAR PADS & ROTORS REPLACED DEC. 05 EXHAUST RUBBING ON DRIVELINE, INSTALL KIT TO HOLD EXHAUST OFF DRIVELINE DEC. 05 LEFT REAR WHEEL BEARING & HUB, REAR PADS & ROTORS REPLACED JUNE 05 4 NEW TIRES JUNE 05 TURBO CONTROL VALVE REPLACED MARCH 05 FRONT PADS AND ROTORS REPLACED OCT. 04. *TR

NHTSA ODI #10242337

Mileage unknown · Oct 20, 2006

Tires

OUTSIDE EDGE OF TIRES WEAR OUT AFTER 15,000 MILES. AN INTERNET SEARCH INDICATES THIS IS A VERY COMMON PROBLEM. *NM

NHTSA ODI #10171447

23,000 miles · Dec 3, 2004

Fuel System, GasolineTires

WHILE CONSUMER WAS DRIVING REAR PASSENGER'S TIRE BLEW OUT, RESULTING IN DAMAGING THE FUEL LINE. CONSUMER WAS AT A GAS STATION AND REFUELED THE VEHICLE WHEN IT WAS DISCOVERED THAT FUEL WAS LEAKING FROM THE VEHICLE. *AK

NHTSA ODI #10102072

1,000 miles · Nov 17, 2004

Electrical SystemSteeringSuspension

I HAVE HAD NUMEROUS FAILURES WITH MY 1990 VOLVO: I AM ON MY THIRD SET OF TIRES, AND I HAVE 30,000 MILES. I HAVE HAD SEVERAL SHOCK ABSORBERS REPLACED ,A TIE ROD BREAK, AND MANY ELECTRICAL PROBLEMS. *AK

NHTSA ODI #10100120

Mileage unknown · Feb 18, 2004

Tires

ORIGINAL EQUIPMENT TIRES ON MY 2004 VOLVO XC90 (MICHELIN HXMXM4'S) ARE FRIGHTENING. THEY OFFER VERY LITTLE TRACTION IN THE BEST CONDITIONS; IN THE RAIN, UNINTENDED LANE CHANGES ARE COMMON DUE TO SLIDING.*AK

NHTSA ODI #10058382

Official recalls

10V566000 · Equipment:electrical:navigational System(global Positioning System)

Nov 8, 2010

VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.

Consequence & remedy

Consequence: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.

Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.

09V483000 · Fuel System, Gasoline:delivery:fuel Pump

Dec 18, 2009

VOLVO IS RECALLING CERTAIN MODEL YEAR 2001-2005 S80, MODEL YEAR 2001-2004 V70, S60, XC70 AND MODEL YEAR 2003-2005 XC90 VEHICLES SOLD IN OR REGISTERED IN THE STATES OF ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, KENTUCKY, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, UTAH, VIRGINIA AND THE U.S. TERRITORIES. WHEN EXPOSED TO CERTAIN ENVIRONMENTAL CONDITIONS (HOT CLIMATE AND TEMPERATURE CYCLING) OVER TIME AND IN COMBINATION WITH VARYING FUEL QUALITY, THE FUEL PUMP CAN DEVELOP CRACKS IN THE FUEL PUMP FLANGE.

Consequence & remedy

Consequence: IF THE CONDITION OCCURS VEHICLE OWNERS MAY NOTICE FUEL SMELL AND/OR FUEL LEAK WHICH, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL INSPECT THE FUEL PUMP INSTALLED IN THE VEHICLE, AND IF NECESSARY REPLACE THE FUEL PUMP WITH A PART OF A MODIFIED DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 15, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.

06V155000 · Steering:linkages:tie Rod Assembly

May 5, 2006

ON CERTAIN PASSENGER VEHICLES,THE OUTER TIE ROD BALL JOINT CAN DEFORM AT HIGH LOADS CAUSING A LOSS OF THE CLAMPING FORCE AND THE NUT MAY LOOSEN, WHICH MAY EVENTUALLY LEAD TO A FATIGUE FRACTURE OF THE OUTER TIE ROD BALL JOINT.

Consequence & remedy

Consequence: THE DRIVER MAY NOTICE THAT THE VEHICLE IS DIFFICULT TO MANEUVER INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE OUTER BALL JOINT TIE RODS WITH IMPROVED OUTER BALL JOINT TIE RODS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 23, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.

06V144000 · Visibility:windshield Wiper/washer

Apr 28, 2006

ON CERTAIN VEHICLES, IF THE WIPER ARM IS ACTIVATED IN EXTREME WINTER WEATHER CONDITIONS AND WITHOUT LIFTING THE WIPER ARMS AND CLEANING THE WINDSHIELD PRIOR TO MOVING, THE WIPER ARM MIGHT SLIP ON ITS DRIVESHAFT, RESULTING IN AN INABILITY TO MOVE THE WIPERS FROM THE PARK POSITION.

Consequence & remedy

Consequence: INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.

Remedy: DEALERS WILL REPLACE THE WIPER ARMS AND RETAINING NUTS. THE RECALL BEGAN ON SEPTEMBER 5, 2006. OWNERS MAY CONTACT VOLVO CARS AT 1-800-458-1552.

03V434000 · Wheels

Nov 4, 2003

ON CERTAIN SPORT UTILITY VEHICLES, THE FRONT WHEEL SPEED SENSORS MAY BE DEFECTIVE, CAUSING AN ERRONEOUS WHEEL SPEED SIGNAL.

Consequence & remedy

Consequence: THIS CAN ADVERSELY AFFECT A NUMBER OF VEHICLE FUNCTIONS, INCLUDING BRAKE, ENGINE, TRANSMISSION, AND TORQUE DISTRIBUTION CONTROL WHICH RELY ON THIS SIGNAL FOR PROPER OPERATION.

Remedy: DEALERS WILL REPLACE THE FRONT WHEEL SENSORS. OWNER NOTIFICATION BEGAN ON DECEMBER 8, 2003. OWNERS SHOULD CONTACT VOLVO CARS AT 1-800-458-1552.

03V391000 · Seat Belts:rear/other

Oct 10, 2003

ON CERTAIN SPORT UTILITY VEHICLES, THE SEAT BELT ATTACHMENT(S) FOR THE SECOND AND THIRD ROW SEAT(S) MAY NOT HAVE BEEN FITTED PROPERLY.

Consequence & remedy

Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF INJURY.

Remedy: DEALERS WILL INSPECT AND REPAIR THE SECOND AND/OR THIRD ROW SEAT BELT ATTACHMENTS. OWNER NOTIFICATION BEGAN ON DECEMBER 8, 2003. OWNERS SHOULD CONTACT VOLVO AT 1-800-458-1552.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

PE10025 · Central Electronic Module Failure

Opened Jul 20, 2010 · Closed Nov 22, 2010

Status: closed (inferred from source dates) · Electrical System

Volvo acknowledged a problem affecting some subject vehicles involving water seepage into the plenum box area in the engine compartment.When this occurs water may enter into the interior / passenger compartment and track along the wiring harness for the Central Electronic Module (CEM), the device that controls many of the vehicle's electrical functions including wiper operation, lighting, and transmission operation.If the water reaches the CEM connector electrical faults may result.In response to such faults the CEM, a microprocessor controlled device, will attempt to reset by temporarily shutting down (for 100 milliseconds, or 0.1 seconds) and restarting; this effects various CEM functions including the instrument panel (IP) display, gauges, wipers and also the transmission gear (if it is in the overdrive range).During the reset owners may experience temporarily loss of the IP displays and an abnormal 'jerking' in the transmission/drivetrain.If the problem persist for 6 consecutive restart attempts, the CEM will enter a 'Limp Home' mode that disables non-essential electrical functions yet maintain safety critical functions such as low-beam headlights, low-speed wiper operation, brake lights, and non-overdrive transmission operation.Warning and error messages will also be illuminated in the IP display.Consumers reported experiencing conditions consistent with CEM resetting and the limp mode operation in their reports to both ODI and Volvo.No reports or allegations of crash or injury associated with possible CEM failures have been reported by Volvo or otherwise identified by ODI.Volvo revised the design of the wiring grommet (sealing device) and the plenum cover starting in May 2005 and October 2005 production dates respectively, the occurrence of the condition effectively ended after these changes.A technical service bulletin (TNN 37-35) has been published to diagnose and repair earlier production vehicles using the improved wiring grommet and/or new plenum cover.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstances.

PE09039 · Fuel Pump Leak

Opened Aug 31, 2009 · Closed Dec 22, 2009

Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

VOLVO HAS DETERMINED THAT DUE TO EXPOSURE TO CERTAIN ENVIRONMENTAL CONDITIONS (HOT CLIMATES AND TEMPERATURE CYCLING) AND VARYING FUEL QUALITY, THE FUEL PUMP FLANGE IN THE XC90 VEHICLES CAN DEVELOP CRACKS.OWNERS MAY NOTICE FUEL SMELL AND/OR FUEL SEEPAGE.DUE TO SIMILAR MATERIAL USAGE, THIS ISSUE ALSO AFFECTS OTHER MY2001-2005 S60/S80/V70/XC70 AND MY2003/2005 XC90 VEHICLES.REVIEW OF THE VOLVO DATA INDICATE THE FREQUENCY OF COMPLAINTS/REPAIRS IS HIGHER IN THE HOT CLIMATE STATES. VOLVO WILL RECALL AND REPLACE THE FUEL PUMP WITH A PART OF A MODIFIED DESIGN/MATERIAL IN APPROXIMATELY 136,100 MY2001-2004 S60/V70/XC70, MY2001-2005 S80 AND MY2003-2005 XC90 VEHICLES IN 19 STATES.THESE STATES INCLUDE AL, AZ, AR, CA, FL, GA, HI, KY, LA, MS, NV, NM, NC, OK, SC, TN, TX, UT, VA AND THE US TERRITORIES.IN ADDITION, VOLVO WILL EXTEND THE WARRANTY COVERAGE TO 10 YEARS/150,000 MILES ON APPROXIMATELY 190,000 VEHICLES FOR THE REMAINING STATES.THIS RECALL/EXTENDED WARRANTY PROGRAM SUPERSEDES PREVIOUS 07V-152/TNN 23-198 PROGRAM ON MY2001-2002 VEHICLES.THIS INVESTIGATION IS CLOSED (SEE RECALL CAMPAIGN 09V-483).

Additional source detail variants (4)

Fuel System, Gasoline:delivery:fuel Pump

Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

Fuel System, Gasoline:delivery

Fuel System, Gasoline

PE05064 · Windshield Wiper Arm Performance

Opened Dec 2, 2005 · Closed May 10, 2006

Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:linkages

THE MANUFACTURER NOTIFIED NHTSA BY LETTER DATED APRIL 21, 2006, THAT A SAFETY RECALL HAS BEEN INITIATED FOR CORRECTION OF THIS PROBLEM ON CERTAIN MODEL YEAR 2003 - 2006 VOLVO XC90 VEHICLES. THE RECALL AFFECTS APPROXIMATELY 122,400 SUBJECT VEHICLES PRODUCED BETWEEN AUGUST 2002 AND OCTOBER 2005.NHTSA HAS ASSIGNED NO. 06V-144 TO THIS RECALL ACTION.THE CORRECTIVE ACTION WILL CONSIST OF REPLACING THE EXISTING WINDSHIELD WIPER ARMS WITH A NEW REINFORCED DESIGN.BASED ON THIS ACTION, THE SUBJECT PE HAS BEEN CLOSED.