IllustrationRADIO FAILS TO RELIABLY POWER UP AND AFTER OCCASIONALLY OPERATING, CEASES TO WORK AFTER A FEW MINUTES. RADIO INTERFACES WITH REAR COLLISION AVOIDANCE SYSTEM, WHICH IS NOW NONOPERATIONAL. *TR
2004 Volvo XC90
Owner reports · Recalls · Investigations
More warning signs than most XC90 years
Owner complaints for the 2004 Volvo XC90 are substantially higher than the model-year median of 34.
About this comparison →How this year compares
Owner complaints by model year
Compare all XC90 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
230–25K
3425–50K
9550–75K
9575–100K
124100–150K
39150K+
410 reports with mileage · 52 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 158 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 145 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
9 crash reports3 fire reports7 injury reports
Equipment complaints
6 reportsTL*THE CONTACT OWNS A 2004 VOLVO XC90. THE CONTACT STATED THAT THE OWNER'S MANUAL PROVIDED INACCURATE INFORMATION PERTAINING TO THE TOWING CAPACITY; HOWEVER, THE 2005 AND 2006 OWNER'S MANUAL SPECIFIED THE ACCURATE WEIGHT REDUCTION WITH THE VEHICLE OCCUPANTS. IN ADDITION, THE ENTIRE ELECTRICAL SYSTEM BECAME INOPERATIVE INTERMITTE…
Read full complaint
TL*THE CONTACT OWNS A 2004 VOLVO XC90. THE CONTACT STATED THAT THE OWNER'S MANUAL PROVIDED INACCURATE INFORMATION PERTAINING TO THE TOWING CAPACITY; HOWEVER, THE 2005 AND 2006 OWNER'S MANUAL SPECIFIED THE ACCURATE WEIGHT REDUCTION WITH THE VEHICLE OCCUPANTS. IN ADDITION, THE ENTIRE ELECTRICAL SYSTEM BECAME INOPERATIVE INTERMITTENTLY. THE RELAY SWITCH, INTERNAL REM AND YAW MODULES WERE REPLACED AT DIFFERENT TIMES. WHILE DRIVING THE ENGINE WOULD COMPLETELY SHUT OFF WHEN THE CONTACTS KNEE WAS CLOSE TO THE IGNITION KEY. THE FAILURE CONTINUED AFTER THE VEHICLE WAS REPAIRED. CURRENTLY, DIAGNOSTIC TESTING WAS BEING PERFORMED BY THE DEALER. THE FAILURE MILEAGE WAS 10,000.
SWIVEL AND SPRING ON REMOTE CONTROL STOP WORKING. THIS HAS BEEN AN ONGOING PROBLEM FOR US, BEGINNING LESS THAN 1 YEAR AFTER WE PURCHASED CAR NEW. THE DEALERSHIP REPLACED SWIVELS ON REMOTE AND UPGRADED SWIVELS ON REMOTES. AFTER SEVERAL TIMES THEY TOLD US THERE WAS NOTHING ELSE THEY COULD DO. HAVE SINCE CHANGED THE ENGINEERING…
Read full complaint
SWIVEL AND SPRING ON REMOTE CONTROL STOP WORKING. THIS HAS BEEN AN ONGOING PROBLEM FOR US, BEGINNING LESS THAN 1 YEAR AFTER WE PURCHASED CAR NEW. THE DEALERSHIP REPLACED SWIVELS ON REMOTE AND UPGRADED SWIVELS ON REMOTES. AFTER SEVERAL TIMES THEY TOLD US THERE WAS NOTHING ELSE THEY COULD DO. HAVE SINCE CHANGED THE ENGINEERING BUT NOW, PROBABLY DUE TO THE NUMBER OF TIMES THE REMOTE FELL ON GROUND BECAUSE OF FAULTY SWIVELS, THE SPRING FOR THE ACTUAL KEY DOESN'T WORK ANYMORE AND REMOTE WILL TILT DOWN SOMETIMES WHILE DRIVING SO MY WIFE AND 16 YEAR OLD SON HAVE BOTH HAD THEIR KNEES HIT IT AND TURNED THE CAR OFF WHILE DRIVING IT. THANK GOD THEY DID NOT HAVE AN ACCIDENT. WENT TO VOLVO AND THEY SAID THIS IS A WEAR AND TEAR ITEM AND THEY WANT $400 TO REPLACE 1. INSPITE OF FACT THEY HAVE TRIED TO FIX THIS MULTIPLE TIMES AND INSPITE OF THE FACT THEY NEVER WERE ABLE TO MAKE IT WORK PROPERLY THEY WILL NOT STAND BEHIND THEIR PRODUCT. NOW IT IS DANGEROUS. I AM SHOCKED A CAR TOUTED AS "SAFE" LIKE THIS ONE WOULD HAVE THIS KIND OF PROBLEM AND THEY WOULD NOT FIX IT! *TR
DRIVING ON 210-WEST, MY CAR LOST POWER WITHOUT WARNING. THE FUEL PUMP HAD BEEN REPLACED ON JAN. 26, 2010, TO CORRECT THE STRONG SMELL OF GASOLINE INSIDE AND OUTSIDE OF THE CAR. OTHER PROBLEMS HAVE BEEN REPLACING THE BRAKE PADS TWICE, REPLACING THE ABS, FAULTY GPS AND CD PLAYER, FRONT PASSENGER DOOR AUTOMATIC LOCK NEEDS MOTOR R…
Read full complaint
DRIVING ON 210-WEST, MY CAR LOST POWER WITHOUT WARNING. THE FUEL PUMP HAD BEEN REPLACED ON JAN. 26, 2010, TO CORRECT THE STRONG SMELL OF GASOLINE INSIDE AND OUTSIDE OF THE CAR. OTHER PROBLEMS HAVE BEEN REPLACING THE BRAKE PADS TWICE, REPLACING THE ABS, FAULTY GPS AND CD PLAYER, FRONT PASSENGER DOOR AUTOMATIC LOCK NEEDS MOTOR REPLACED, SLOSHING SOUND OF WATER HEARD INSIDE THE CAR AFTER RAIN. *TR
NOV. 23, 2004 - PURCHASED A VOLVO XC90 T6 FROM LEHMAN VOLVO IN YORK, PA - THE VEHICLE HAD 10.042 MILES ON IT AT THE TIME OF PURCHASE JUNE 26, 2007 - AUTOMATIC TRANSMISSION NEEDED TO BE REPLACED - VOLVO OF CARY IN NC PAID FOR THE TRANSMISSION AND WE PAID FOR THE LABOR - $1425 - MILEAGE 68,306 FEB. 2008 - THE TRANSMISSION SE…
Read full complaint
NOV. 23, 2004 - PURCHASED A VOLVO XC90 T6 FROM LEHMAN VOLVO IN YORK, PA - THE VEHICLE HAD 10.042 MILES ON IT AT THE TIME OF PURCHASE JUNE 26, 2007 - AUTOMATIC TRANSMISSION NEEDED TO BE REPLACED - VOLVO OF CARY IN NC PAID FOR THE TRANSMISSION AND WE PAID FOR THE LABOR - $1425 - MILEAGE 68,306 FEB. 2008 - THE TRANSMISSION SERVICE REQUIRED LIGHTS/MESSAGE CAME ON PERIODICALLY WHILE WE WERE TRAVELING IN THE NE- WE CALLED VOLVO OF CARY AND THEY SAID THAT IF WE CONTINUED TO SEE THE LIGHT TO BRING IT TO A DEALER WHERE WE WERE MARCH 2008-JULY 2009 - A VARIETY OF MESSAGES WOULD APPEAR PERIODICALLY SAYING THAT TRANSMISSION SERVICE WAS REQUIRED OR URGENT JULY 7, 2009 - I TOOK THE VEHICLE TO VOLVO OF CARY WHILE THE LIGHT WAS ON STATING THAT TRANSMISSION SERVICE WAS NEEDED AS THEY INSTALLED AN UPDATED VERSION OF TRANSMISSION SOFTWARE - $123.38 MID-JULY 2009 - THE TRANSMISSION BEGAN TO SLIP NOTICEABLY JULY 22, 2009 - COTTMAN TRANSMISSION REBUILT THE EXISTING TRANSMISSION - $3643.04 - MILEAGE 116,030. *TR
ON 10/21/2008 I WAS DRIVING MY 2004 VOLVO XC90 ON THE HIGHWAY RT.93. IT WAS RAINING AND THE INTERIOR OF THE CAR WAS FOGGY. I COULD NOT SEE OUTSIDE SO I TURNED ON THE A/C BUT IT WAS NOT FUNCTIONING. ALSO, THE CD PLAYER WAS NOT WORKED. I BOUGHT MY CAR NEW IN 2004 WITH HAS ONLY 32,014 MILES ON THE CAR NOW. THE BOSTON VOLVO VILLAGE …
Read full complaint
ON 10/21/2008 I WAS DRIVING MY 2004 VOLVO XC90 ON THE HIGHWAY RT.93. IT WAS RAINING AND THE INTERIOR OF THE CAR WAS FOGGY. I COULD NOT SEE OUTSIDE SO I TURNED ON THE A/C BUT IT WAS NOT FUNCTIONING. ALSO, THE CD PLAYER WAS NOT WORKED. I BOUGHT MY CAR NEW IN 2004 WITH HAS ONLY 32,014 MILES ON THE CAR NOW. THE BOSTON VOLVO VILLAGE DEALER INSPECTED THE CAR AND SAID THE BLOWER MOTOR, RESISTOR AND THE CD PLAYER NEED TO BE REPLACED. THE COST OF PARTS AND LABOR OF THE BLOWER AND RESISTOR WAS $1,650 AND THE CD $700. I CONTACTED THE VOLVO HEAD OFFICE AND THEY WERE WILLING TO PROVIDE THE PARTS FREE BUT THE LABOR COST ON ME. I HAVE NO CHOICE TO DO IT RIGHT AWAY BECAUSE I HAVE TWO CHILDREN. I NEED THE CAR TO CARRY THEM TO SCHOOL EVERYDAY. IT IS A SAFETY ISSUE IF THE VENTILATION AND HEAT IS NOT WORKING. I CANNOT DRIVE THE CAR IF THERE IS NO VENTILATION AND THE CAR IS FOGGY DURING RAINY OR SNOWY DAYS. IF I WAS IN THE HIGHWAY, I HAVE TO PARK ON THE SIDE FOR THE POOR VISIBILITY. IT WOULD PUT ME AND MY FAMILY IN A DANGEROUS SITUATION. I PAID $1,058 FOR THE LABOR AND $57.50 FOR THE INSPECTION COST. IF THE VOLVO ADMITTED THE PARTS HAS PROBLEM AND WILLING TO REPLACE THEM FREE, THEY SHOULD NOT CHARGE ME LABOR COST. *TR
Official recalls
610V566000 · Equipment:electrical:navigational System(global Positioning System)
Nov 8, 2010
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Consequence & remedy
Consequence: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
09V483000 · Fuel System, Gasoline:delivery:fuel Pump
Dec 18, 2009
VOLVO IS RECALLING CERTAIN MODEL YEAR 2001-2005 S80, MODEL YEAR 2001-2004 V70, S60, XC70 AND MODEL YEAR 2003-2005 XC90 VEHICLES SOLD IN OR REGISTERED IN THE STATES OF ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, KENTUCKY, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, UTAH, VIRGINIA AND THE U.S. TERRITORIES. WHEN EXPOSED TO CERTAIN ENVIRONMENTAL CONDITIONS (HOT CLIMATE AND TEMPERATURE CYCLING) OVER TIME AND IN COMBINATION WITH VARYING FUEL QUALITY, THE FUEL PUMP CAN DEVELOP CRACKS IN THE FUEL PUMP FLANGE.
Consequence & remedy
Consequence: IF THE CONDITION OCCURS VEHICLE OWNERS MAY NOTICE FUEL SMELL AND/OR FUEL LEAK WHICH, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL PUMP INSTALLED IN THE VEHICLE, AND IF NECESSARY REPLACE THE FUEL PUMP WITH A PART OF A MODIFIED DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 15, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
06V155000 · Steering:linkages:tie Rod Assembly
May 5, 2006
ON CERTAIN PASSENGER VEHICLES,THE OUTER TIE ROD BALL JOINT CAN DEFORM AT HIGH LOADS CAUSING A LOSS OF THE CLAMPING FORCE AND THE NUT MAY LOOSEN, WHICH MAY EVENTUALLY LEAD TO A FATIGUE FRACTURE OF THE OUTER TIE ROD BALL JOINT.
Consequence & remedy
Consequence: THE DRIVER MAY NOTICE THAT THE VEHICLE IS DIFFICULT TO MANEUVER INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE OUTER BALL JOINT TIE RODS WITH IMPROVED OUTER BALL JOINT TIE RODS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 23, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
06V144000 · Visibility:windshield Wiper/washer
Apr 28, 2006
ON CERTAIN VEHICLES, IF THE WIPER ARM IS ACTIVATED IN EXTREME WINTER WEATHER CONDITIONS AND WITHOUT LIFTING THE WIPER ARMS AND CLEANING THE WINDSHIELD PRIOR TO MOVING, THE WIPER ARM MIGHT SLIP ON ITS DRIVESHAFT, RESULTING IN AN INABILITY TO MOVE THE WIPERS FROM THE PARK POSITION.
Consequence & remedy
Consequence: INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.
Remedy: DEALERS WILL REPLACE THE WIPER ARMS AND RETAINING NUTS. THE RECALL BEGAN ON SEPTEMBER 5, 2006. OWNERS MAY CONTACT VOLVO CARS AT 1-800-458-1552.
03V434000 · Wheels
Nov 4, 2003
ON CERTAIN SPORT UTILITY VEHICLES, THE FRONT WHEEL SPEED SENSORS MAY BE DEFECTIVE, CAUSING AN ERRONEOUS WHEEL SPEED SIGNAL.
Consequence & remedy
Consequence: THIS CAN ADVERSELY AFFECT A NUMBER OF VEHICLE FUNCTIONS, INCLUDING BRAKE, ENGINE, TRANSMISSION, AND TORQUE DISTRIBUTION CONTROL WHICH RELY ON THIS SIGNAL FOR PROPER OPERATION.
Remedy: DEALERS WILL REPLACE THE FRONT WHEEL SENSORS. OWNER NOTIFICATION BEGAN ON DECEMBER 8, 2003. OWNERS SHOULD CONTACT VOLVO CARS AT 1-800-458-1552.
03V391000 · Seat Belts:rear/other
Oct 10, 2003
ON CERTAIN SPORT UTILITY VEHICLES, THE SEAT BELT ATTACHMENT(S) FOR THE SECOND AND THIRD ROW SEAT(S) MAY NOT HAVE BEEN FITTED PROPERLY.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF INJURY.
Remedy: DEALERS WILL INSPECT AND REPAIR THE SECOND AND/OR THIRD ROW SEAT BELT ATTACHMENTS. OWNER NOTIFICATION BEGAN ON DECEMBER 8, 2003. OWNERS SHOULD CONTACT VOLVO AT 1-800-458-1552.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE10025 · Central Electronic Module Failure
Opened Jul 20, 2010 · Closed Nov 22, 2010
Status: closed (inferred from source dates) · Electrical System
Volvo acknowledged a problem affecting some subject vehicles involving water seepage into the plenum box area in the engine compartment.When this occurs water may enter into the interior / passenger compartment and track along the wiring harness for the Central Electronic Module (CEM), the device that controls many of the vehicle's electrical functions including wiper operation, lighting, and transmission operation.If the water reaches the CEM connector electrical faults may result.In response to such faults the CEM, a microprocessor controlled device, will attempt to reset by temporarily shutting down (for 100 milliseconds, or 0.1 seconds) and restarting; this effects various CEM functions including the instrument panel (IP) display, gauges, wipers and also the transmission gear (if it is in the overdrive range).During the reset owners may experience temporarily loss of the IP displays and an abnormal 'jerking' in the transmission/drivetrain.If the problem persist for 6 consecutive restart attempts, the CEM will enter a 'Limp Home' mode that disables non-essential electrical functions yet maintain safety critical functions such as low-beam headlights, low-speed wiper operation, brake lights, and non-overdrive transmission operation.Warning and error messages will also be illuminated in the IP display.Consumers reported experiencing conditions consistent with CEM resetting and the limp mode operation in their reports to both ODI and Volvo.No reports or allegations of crash or injury associated with possible CEM failures have been reported by Volvo or otherwise identified by ODI.Volvo revised the design of the wiring grommet (sealing device) and the plenum cover starting in May 2005 and October 2005 production dates respectively, the occurrence of the condition effectively ended after these changes.A technical service bulletin (TNN 37-35) has been published to diagnose and repair earlier production vehicles using the improved wiring grommet and/or new plenum cover.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstances.
PE09039 · Fuel Pump Leak
Opened Aug 31, 2009 · Closed Dec 22, 2009
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
VOLVO HAS DETERMINED THAT DUE TO EXPOSURE TO CERTAIN ENVIRONMENTAL CONDITIONS (HOT CLIMATES AND TEMPERATURE CYCLING) AND VARYING FUEL QUALITY, THE FUEL PUMP FLANGE IN THE XC90 VEHICLES CAN DEVELOP CRACKS.OWNERS MAY NOTICE FUEL SMELL AND/OR FUEL SEEPAGE.DUE TO SIMILAR MATERIAL USAGE, THIS ISSUE ALSO AFFECTS OTHER MY2001-2005 S60/S80/V70/XC70 AND MY2003/2005 XC90 VEHICLES.REVIEW OF THE VOLVO DATA INDICATE THE FREQUENCY OF COMPLAINTS/REPAIRS IS HIGHER IN THE HOT CLIMATE STATES. VOLVO WILL RECALL AND REPLACE THE FUEL PUMP WITH A PART OF A MODIFIED DESIGN/MATERIAL IN APPROXIMATELY 136,100 MY2001-2004 S60/V70/XC70, MY2001-2005 S80 AND MY2003-2005 XC90 VEHICLES IN 19 STATES.THESE STATES INCLUDE AL, AZ, AR, CA, FL, GA, HI, KY, LA, MS, NV, NM, NC, OK, SC, TN, TX, UT, VA AND THE US TERRITORIES.IN ADDITION, VOLVO WILL EXTEND THE WARRANTY COVERAGE TO 10 YEARS/150,000 MILES ON APPROXIMATELY 190,000 VEHICLES FOR THE REMAINING STATES.THIS RECALL/EXTENDED WARRANTY PROGRAM SUPERSEDES PREVIOUS 07V-152/TNN 23-198 PROGRAM ON MY2001-2002 VEHICLES.THIS INVESTIGATION IS CLOSED (SEE RECALL CAMPAIGN 09V-483).
Additional source detail variants (4)
Fuel System, Gasoline:delivery:fuel Pump
VOLVO HAS DETERMINED THAT DUE TO EXPOSURE TO CERTAIN ENVIRONMENTAL CONDITIONS (HOT CLIMATES AND TEMPERATURE CYCLING) AND VARYING FUEL QUALITY, THE FUEL PUMP FLANGE IN THE XC90 VEHICLES CAN DEVELOP CRACKS.OWNERS MAY NOTICE FUEL SMELL AND/OR FUEL SEEPAGE.DUE TO SIMILAR MATERIAL USAGE, THIS ISSUE ALSO AFFECTS OTHER MY2001-2005 S60/S80/V70/XC70 AND MY2003/2005 XC90 VEHICLES.REVIEW OF THE VOLVO DATA INDICATE THE FREQUENCY OF COMPLAINTS/REPAIRS IS HIGHER IN THE HOT CLIMATE STATES. VOLVO WILL RECALL AND REPLACE THE FUEL PUMP WITH A PART OF A MODIFIED DESIGN/MATERIAL IN APPROXIMATELY 136,100 MY2001-2004 S60/V70/XC70, MY2001-2005 S80 AND MY2003-2005 XC90 VEHICLES IN 19 STATES.THESE STATES INCLUDE AL, AZ, AR, CA, FL, GA, HI, KY, LA, MS, NV, NM, NC, OK, SC, TN, TX, UT, VA AND THE US TERRITORIES.IN ADDITION, VOLVO WILL EXTEND THE WARRANTY COVERAGE TO 10 YEARS/150,000 MILES ON APPROXIMATELY 190,000 VEHICLES FOR THE REMAINING STATES.THIS RECALL/EXTENDED WARRANTY PROGRAM SUPERSEDES PREVIOUS 07V-152/TNN 23-198 PROGRAM ON MY2001-2002 VEHICLES.THIS INVESTIGATION IS CLOSED (SEE RECALL CAMPAIGN 09V-483).
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
VOLVO HAS DETERMINED THAT DUE TO EXPOSURE TO CERTAIN ENVIRONMENTAL CONDITIONS (HOT CLIMATES AND TEMPERATURE CYCLING) AND VARYING FUEL QUALITY, THE FUEL PUMP FLANGE IN THE XC90 VEHICLES CAN DEVELOP CRACKS.OWNERS MAY NOTICE FUEL SMELL AND/OR FUEL SEEPAGE.DUE TO SIMILAR MATERIAL USAGE, THIS ISSUE ALSO AFFECTS OTHER MY2001-2005 S60/S80/V70/XC70 AND MY2003/2005 XC90 VEHICLES.REVIEW OF THE VOLVO DATA INDICATE THE FREQUENCY OF COMPLAINTS/REPAIRS IS HIGHER IN THE HOT CLIMATE STATES. VOLVO WILL RECALL AND REPLACE THE FUEL PUMP WITH A PART OF A MODIFIED DESIGN/MATERIAL IN APPROXIMATELY 136,100 MY2001-2004 S60/V70/XC70, MY2001-2005 S80 AND MY2003-2005 XC90 VEHICLES IN 19 STATES.THESE STATES INCLUDE AL, AZ, AR, CA, FL, GA, HI, KY, LA, MS, NV, NM, NC, OK, SC, TN, TX, UT, VA AND THE US TERRITORIES.IN ADDITION, VOLVO WILL EXTEND THE WARRANTY COVERAGE TO 10 YEARS/150,000 MILES ON APPROXIMATELY 190,000 VEHICLES FOR THE REMAINING STATES.THIS RECALL/EXTENDED WARRANTY PROGRAM SUPERSEDES PREVIOUS 07V-152/TNN 23-198 PROGRAM ON MY2001-2002 VEHICLES.THIS INVESTIGATION IS CLOSED (SEE RECALL CAMPAIGN 09V-483).
Fuel System, Gasoline:delivery
VOLVO HAS DETERMINED THAT DUE TO EXPOSURE TO CERTAIN ENVIRONMENTAL CONDITIONS (HOT CLIMATES AND TEMPERATURE CYCLING) AND VARYING FUEL QUALITY, THE FUEL PUMP FLANGE IN THE XC90 VEHICLES CAN DEVELOP CRACKS.OWNERS MAY NOTICE FUEL SMELL AND/OR FUEL SEEPAGE.DUE TO SIMILAR MATERIAL USAGE, THIS ISSUE ALSO AFFECTS OTHER MY2001-2005 S60/S80/V70/XC70 AND MY2003/2005 XC90 VEHICLES.REVIEW OF THE VOLVO DATA INDICATE THE FREQUENCY OF COMPLAINTS/REPAIRS IS HIGHER IN THE HOT CLIMATE STATES. VOLVO WILL RECALL AND REPLACE THE FUEL PUMP WITH A PART OF A MODIFIED DESIGN/MATERIAL IN APPROXIMATELY 136,100 MY2001-2004 S60/V70/XC70, MY2001-2005 S80 AND MY2003-2005 XC90 VEHICLES IN 19 STATES.THESE STATES INCLUDE AL, AZ, AR, CA, FL, GA, HI, KY, LA, MS, NV, NM, NC, OK, SC, TN, TX, UT, VA AND THE US TERRITORIES.IN ADDITION, VOLVO WILL EXTEND THE WARRANTY COVERAGE TO 10 YEARS/150,000 MILES ON APPROXIMATELY 190,000 VEHICLES FOR THE REMAINING STATES.THIS RECALL/EXTENDED WARRANTY PROGRAM SUPERSEDES PREVIOUS 07V-152/TNN 23-198 PROGRAM ON MY2001-2002 VEHICLES.THIS INVESTIGATION IS CLOSED (SEE RECALL CAMPAIGN 09V-483).
Fuel System, Gasoline
VOLVO HAS DETERMINED THAT DUE TO EXPOSURE TO CERTAIN ENVIRONMENTAL CONDITIONS (HOT CLIMATES AND TEMPERATURE CYCLING) AND VARYING FUEL QUALITY, THE FUEL PUMP FLANGE IN THE XC90 VEHICLES CAN DEVELOP CRACKS.OWNERS MAY NOTICE FUEL SMELL AND/OR FUEL SEEPAGE.DUE TO SIMILAR MATERIAL USAGE, THIS ISSUE ALSO AFFECTS OTHER MY2001-2005 S60/S80/V70/XC70 AND MY2003/2005 XC90 VEHICLES.REVIEW OF THE VOLVO DATA INDICATE THE FREQUENCY OF COMPLAINTS/REPAIRS IS HIGHER IN THE HOT CLIMATE STATES. VOLVO WILL RECALL AND REPLACE THE FUEL PUMP WITH A PART OF A MODIFIED DESIGN/MATERIAL IN APPROXIMATELY 136,100 MY2001-2004 S60/V70/XC70, MY2001-2005 S80 AND MY2003-2005 XC90 VEHICLES IN 19 STATES.THESE STATES INCLUDE AL, AZ, AR, CA, FL, GA, HI, KY, LA, MS, NV, NM, NC, OK, SC, TN, TX, UT, VA AND THE US TERRITORIES.IN ADDITION, VOLVO WILL EXTEND THE WARRANTY COVERAGE TO 10 YEARS/150,000 MILES ON APPROXIMATELY 190,000 VEHICLES FOR THE REMAINING STATES.THIS RECALL/EXTENDED WARRANTY PROGRAM SUPERSEDES PREVIOUS 07V-152/TNN 23-198 PROGRAM ON MY2001-2002 VEHICLES.THIS INVESTIGATION IS CLOSED (SEE RECALL CAMPAIGN 09V-483).
PE05064 · Windshield Wiper Arm Performance
Opened Dec 2, 2005 · Closed May 10, 2006
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:linkages
THE MANUFACTURER NOTIFIED NHTSA BY LETTER DATED APRIL 21, 2006, THAT A SAFETY RECALL HAS BEEN INITIATED FOR CORRECTION OF THIS PROBLEM ON CERTAIN MODEL YEAR 2003 - 2006 VOLVO XC90 VEHICLES. THE RECALL AFFECTS APPROXIMATELY 122,400 SUBJECT VEHICLES PRODUCED BETWEEN AUGUST 2002 AND OCTOBER 2005.NHTSA HAS ASSIGNED NO. 06V-144 TO THIS RECALL ACTION.THE CORRECTIVE ACTION WILL CONSIST OF REPLACING THE EXISTING WINDSHIELD WIPER ARMS WITH A NEW REINFORCED DESIGN.BASED ON THIS ACTION, THE SUBJECT PE HAS BEEN CLOSED.