TWICE NOW OVER A TEN DAY PERIOD FIRST WHEN REDUCING SPEED TO A STOP OR THEN AGAIN AT A SPEED OF LESS THAN 5 MPH, THE CAR DIED...FIRST THE ENGINE DIED THEN ALL ELSE DIED. THE CAR WENT DEAD. I STILL HAD MY STEERING AND SLOWLY ROLLED TO THE CURBED THEN AS I GENTLY PUT ON THE BRAKES THE CAR JERKED TO A HALT. DURING THE SECOND INCIDE…
Read full complaint
TWICE NOW OVER A TEN DAY PERIOD FIRST WHEN REDUCING SPEED TO A STOP OR THEN AGAIN AT A SPEED OF LESS THAN 5 MPH, THE CAR DIED...FIRST THE ENGINE DIED THEN ALL ELSE DIED. THE CAR WENT DEAD. I STILL HAD MY STEERING AND SLOWLY ROLLED TO THE CURBED THEN AS I GENTLY PUT ON THE BRAKES THE CAR JERKED TO A HALT. DURING THE SECOND INCIDENT THE CAR STILL JERKED AFTER I HAD STOPPED. A LOUD SOUND OF A FAN FROM THE ENGINE COULD BE HEARD. THE FAN STOPPED AFTER 10 TO 15 SECONDS. AFTER A MINUTE I RESTARTED THE CAR AND MADE IT HOME BOTH TIMES. *TR
NHTSA ODI #10713001
98,000 miles · Dec 7, 2014
EngineFuel/propulsion SystemService Brakes
THE CAR HAD DIFFICULTY IN STARTING ALL OF A SUDDEN. IT APPEARED TO BE AN ELECTRONIC IGNITION PROBLEM. AFTER A FEW STARTS, WARNING SIGNALS STARTED COMING ON. FIRST WAS "ENGINE UNDER PERFORMANCE" AND THEN IT WAS "BREAK FAILURE". THE CAR WAS STOPPED AND TOWED TO VOLVO DEALER. THE DEALER INDICATED THAT THE CAR'S FUEL PUMP / LINES W…
Read full complaint
THE CAR HAD DIFFICULTY IN STARTING ALL OF A SUDDEN. IT APPEARED TO BE AN ELECTRONIC IGNITION PROBLEM. AFTER A FEW STARTS, WARNING SIGNALS STARTED COMING ON. FIRST WAS "ENGINE UNDER PERFORMANCE" AND THEN IT WAS "BREAK FAILURE". THE CAR WAS STOPPED AND TOWED TO VOLVO DEALER. THE DEALER INDICATED THAT THE CAR'S FUEL PUMP / LINES WERE DESIGNED AND INSTALLED OUTSIDE THE WEATHER SHIELDED HOUSING. THE SALT USED FOR SNOW MELTING CORRODES THESE LINES AND SEVERAL CARS SHOW UP WITH THIS ISSUE.SO THEY REPLACED THEM AND MOVED THEM TO WITHIN THE WEATHER PROTECTED AREA. SEARCHING THE INTERNET, I FOUND SEVERAL VOLVO CARS OF THIS ERA HAVE THIS PROBLEM AND SEVERAL OCCURRED WHILE DRIVING - BOTH LOSS OF SPEED AND BREAK FAILURE. MY CAR WAS WELL MAINTAINED, REGULAR OIL CHANGES WITH THE SYNTHETIC OIL AND MAINTAINED BY VOLVO DEALER OR SPECIALIST. I ALSO USE THE RECOMMENDED 91 OR 93 OCTANE GAS, SO IT CANNOT BE ATTRIBUTED TO LAX MAINTENANCE OR LESSER QUALITY FUEL. THE ONLINE FORUMS SEEM TO HAVE ALL KINDS OF DIAGNOSTICS FOR THIS PROBLEM. IF IT WAS A DESIGN FAULT AT MANUFACTURER, AS ADVISED BY THE VOLVO DEALER, I WOULD THINK IT WOULD SHOULD BE INVESTIGATED FOR RECALL. *TR
NHTSA ODI #10662665
63,000 miles · Sep 25, 2013
Fuel/propulsion System
TL* THE CONTACT OWNS A 2005 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE VEHICLE STALLED WITH THE ILLUMINATION OF THE CHECK ENGINE LIGHT. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE IT WAS STATED THAT THE FUEL PRESSURE SYSTEM NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS…
Read full complaint
TL* THE CONTACT OWNS A 2005 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE VEHICLE STALLED WITH THE ILLUMINATION OF THE CHECK ENGINE LIGHT. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE IT WAS STATED THAT THE FUEL PRESSURE SYSTEM NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 63,000.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2001-2006 S80 and 2001-2009 S60 vehicles. The driver's air bag inflator may explode during deployment, due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag, free of charge. Owner notification letters were mailed November 29, 2021. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo's number for this recall is R10125.
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Consequence & remedy
Consequence: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE LABEL DENOTING THE TIRE AND LOADING PRESSURE INFORMATION IS INCORRECT.
Consequence & remedy
Consequence: A MISPRINTED LABEL WOULD LEAD TO IMPROPER VEHICLE LOADING SPECIFICATIONS OR TIRE INFLATION WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL THE CORRECT LABELS FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 18, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2005 Volvo S60 Problems, Complaints & Recalls | Skip That Year
Illustration