2005 Volvo S60

TL* THE CONTACT OWNS A 2005 VOLVO S60. WHILE DRIVING AT APPROXIMATELY 40 MPH, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED AND THE ENGINE STALLED. THE VEHICLE RESTARTED, BUT THE ENGINE STALLED AGAIN. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE MASS AIR FLOW SENSOR FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 165,000.

THE CAR HAD DIFFICULTY IN STARTING ALL OF A SUDDEN. IT APPEARED TO BE AN ELECTRONIC IGNITION PROBLEM. AFTER A FEW STARTS, WARNING SIGNALS STARTED COMING ON. FIRST WAS "ENGINE UNDER PERFORMANCE" AND THEN IT WAS "BREAK FAILURE". THE CAR WAS STOPPED AND TOWED TO VOLVO DEALER. THE DEALER INDICATED THAT THE CAR'S FUEL PUMP / LINES WERE DESIGNED AND INSTALLED OUTSIDE THE WEATHER SHIELDED HOUSING. THE SALT USED FOR SNOW MELTING CORRODES THESE LINES AND SEVERAL CARS SHOW UP WITH THIS ISSUE.SO THEY REPLACED THEM AND MOVED THEM TO WITHIN THE WEATHER PROTECTED AREA. SEARCHING THE INTERNET, I FOUND SEVERAL VOLVO CARS OF THIS ERA HAVE THIS PROBLEM AND SEVERAL OCCURRED WHILE DRIVING - BOTH LOSS OF SPEED AND BREAK FAILURE. MY CAR WAS WELL MAINTAINED, REGULAR OIL CHANGES WITH THE SYNTHETIC OIL AND MAINTAINED BY VOLVO DEALER OR SPECIALIST. I ALSO USE THE RECOMMENDED 91 OR 93 OCTANE GAS, SO IT CANNOT BE ATTRIBUTED TO LAX MAINTENANCE OR LESSER QUALITY FUEL. THE ONLINE FORUMS SEEM TO HAVE ALL KINDS OF DIAGNOSTICS FOR THIS PROBLEM. IF IT WAS A DESIGN FAULT AT MANUFACTURER, AS ADVISED BY THE VOLVO DEALER, I WOULD THINK IT WOULD SHOULD BE INVESTIGATED FOR RECALL. *TR

TL* THE CONTACT OWNS A 2005 VOLVO S60. THE CONTACT STATED THAT THE VEHICLE WAS SLOW TO START. ONCE STARTED, THE VEHICLE WOULD RIVE SLUGGISH AND WAS SLOW TO ACCELERATE. THE CONTACT HAD AN INDEPENDENT MECHANIC REPLACE THE MASS AIR FLOW SENSOR MORE THAN THREE TIMES BUT THE FAILURE RECURRED. THE MASS AIR FLOW SENSOR WAS CLEANED AND THE SENSOR WAS RESET BY THE INDEPENDENT MECHANIC BUT THAT DID NOT REMEDY THE FAILURE. THE CONTACT INDICATED THAT AN INTERIM SOLUTION WAS TO DISCONNECT THE MASS AIR FLOW SENSOR AND UPON DOING SO THE VEHICLE DID NOT HAVE THE HESITATION. THE VEHICLE WAS NOT REPAIRED AND THE FAILURE WAS RECURRING INTERMITTENTLY. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.