2004 Volvo S60

2004 VOLVO S60 PURCHASED THE CAR USED IN SEPT 04. On 7/8/24 STRANDED AT 7-11 CAR WOULDN'T START. ACTING AS IF THERE WAS POWER LOSS, AC WENT OFF, BRAKE FAILURE LIGHT ON PANEL, POWER WINDOWS AND LOCKS DID NOT WORK, TEMP 105 OUTSIDE , THEN DRIVER PANEL WENT BLACK., I WAS SCARED. ENGINE WOULDN'T START. FINALLY, AFTER WAITING 10 MINUTES...IT STARTED RUNNING BUT WAS SLUGGISH. RADIO WAS ON, POWER DOOR, LOCKS, AND WINDOWS, DID NOT WORK. CUT THE CAR OFF AND BACK ON, ALL POWER RETURNED, NOW CHECK ENGINE AND AIR BAG TROUBLE ON PANEL. CALLED VOLVO DEALER NEXT DAY NEAR MY HOME, THEY CAN NOT SEE MY CAR TIL NEXT WEEK TUESDAY. CAN NOT ACCESS ENGINE BOX, MUST GO TO DEALER.

Starting Sunday November 27 my car started dripping gasoline on the floor, on the driver side near the rear wheel. Immediately I took it to Volvo dealer Wynne in Hampton, VA. The service specialist told me there was not any existing recall for that issue and let me go. That night I put under the leak a flat pan. That night I collected one gallon in about 8 hours. I called Volvo cars USA [XXX] explained me the car have been fixed for the campaign #09V483000 in September 14, 2010. I own the car since 2015. I asked her if the recall should be possible to do it again at no cost for me, because it falls under Safety due to the fact the car may get in fire due to the leak of gas. She asked me to go back again to Wynne Volvo dealer and tell to the service specialist that I talked to them and if they wouldn't repair my car I could open a case with Volvo Cars USA. The service specialist told me I could leave the car for inspection, but I would be responsible for at least $180 to get and estimate, but never said that they would fix it under the safety recall number 09V483000 for vehicles sold or registered in the states with hot climate like Virginia. The recall started in January 15, 2010. It covers the fuel pump that can develop cracks in the fuel pump flange. The technician said the repair they did under the recall was replacing an O-Ring gasket only not the fuel pump. The person I talked to in Service is [XXX] with Title Service Advisor. Phone number [XXX]. I called again today Wednesday November 30, 2022 to Volvo Cars USA they said they can not promise to wave the repair because they need first that I pay $180 for a car diagnostic of the issue. They would probably accept to pay part of the total charge but they would be doing it at good will. I don't have $180 to pay upfront for a safety recall that it didn't last but only 12 years. The Safety recall is valid as long as the car is in service, it doesn't matter if I am or not the first owner. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA)

The contact owns a 2004 Volvo S60. The contact stated that while operating the vehicle, the instrument panel would not illuminate or operate. During the failure, the fuel gauge, speedometer, odometer, and other information was unavailable to the driver. The cause of the failure was not determined. The local dealer and manufacturer were notified of the failure, but no assistance was offered. The failure mileage was 157,000.

DRIVING HOME FROM CHURCH,, SMOKE STARTED COMING FROM THE DRIVERS SEAT,FROM THE HEATED SEAT. BURNED A HOLE THRU THE LEATHER . WAS ABLE TO TURN OFF THE SWITCH AND PUT SOME SNOW INTO THE GOLF SIZE HOLE AND PULLED THE FUSE TO THE ELECT HEAT SWITCH. NO FURTHER DAMAGE WAS NOTICED .CITY STREET. THE HOLE IS ABOUT 11/2 IN BELOW LEFT SIDE BEADING AND CLOSER TO FRONT OF SEAT. LEATHER SEAT IN VERY GOOD CODITION AND NON SMOKER. GARAGE KEEP.

MY SON WAS IN A SIDE IMPACT COLLISION ON THE PASSENGER SIDE OF HIS 2004 VOLVO S60. HE WAS IN A RURAL AREA AND EITHER DIDN'T SEE THE ONCOMING CAR OR MISSED HIS STOP SIGN AND THE ONCOMING DRIVER WAS UNABLE TO STOP. THE OTHER DRIVER IS UNINJURED BUT MY SON IN SEVERELY INJURED WITH A GRADE 3 DAI HEAD INJURY. HE WAS WEARING HIS SEAT BELT. THE SIDE AIRBAGS DEPLOYED BUT NOT THE ONE IN THE STEERING WHEEL. IN AN EMAIL VOLVO TOLD ME THIS IS HOW THE AIRBAGS ARE DESIGNED AND THAT THE DRIVER AIRBAGS WILL NOT DEPLOY ON SIDE IMPACT. IF THAT IS CORRECT INFORMATION, THIS NEEDS TO CHANGE. THE ONLY SIGNIFICANT INJURY MY SON HAS IS WHERE HIS HEAD HIT THE STEERING WHEEL, IF THAT AIRBAG HAD DEPLOYED HIS INJURIES WOULD HAVE POTENTIALLY BEEN MUCH LESS. THE AIRBAGS ARE ALREADY THERE, I DON'T UNDERSTAND WHY THEY CAN'T JUST DEPLOY ON ANY SIGNIFICANT IMPACT. I WILL INCLUDE PICTURES.

TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED WHILE ATTEMPTING TO MAKE A LEFT TURN, ANOTHER VEHICLE INTERSECTED HER LINE CAUSING IMPACT TO THE FRONT DRIVER'S SIDE. THE AIR BAGS DID NOT DEPLOY. THE CONTACT STATED THAT THE ABS WARNING LIGHT WAS ILLUMINATED PRIOR TO THE ACCIDENT. THE CONTACT STATED NO ONE SUSTAINED INJURIES OR SOUGHT MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS NOT DRIVABLE. THE VEHICLE WAS TOWED TO AN IMPOUND LOT. THE VEHICLE FAILURE HAD NOT BEEN DIAGNOSED OR REPAIRED BY A DEALER OR INDEPENDENT MECHANIC. THE MANUFACTURER HAD NOT BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 162,000. *LN*JB

TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT WHILE STATIONARY, THE ENGINE CAUGHT FIRE. THE CONTACT STATED THAT SMOKE ENTERED INTO THE CABIN OF THE VEHICLE. THE CONTACT EXITED THE VEHICLE AND OPENED THE HOOD, AND THE ENGINE WAS SURROUNDED BY FLAMES. A POLICE OR FIRE DEPARTMENT REPORT WAS NOT FILED. AN INDEPENDENT MECHANIC EXTINGUISHED THE FIRE. THERE WERE NO INJURIES SUSTAINED. A DEALER WAS NOT MADE AWARE OF THE FIRE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FIRE. THE FAILURE MILEAGE WAS APPROXIMATELY 30,000.