Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
200–25K
1225–50K
2350–75K
2475–100K
44100–150K
22150K+
145 reports with mileage · 41 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Fuel System, Gasoline. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 36 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel/propulsion System. Review the 25 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports3 fire reports7 injury reports
What owners actually said
186 reports
77,125 miles · Jun 23, 2008
Structure
THROUGH NORMAL USE, IN THE COURSE OF THE LAST TWO YEARS BOTH OF THE FRONT INTERIOR DOOR HANDLE ASSEMBLIES HAVE BROKEN. MANUFACTURER'S SUGGESTED FIX IS TO REPLACE ENTIRE INTERIOR DOOR PANEL ASSEMBLY, AS LINKAGE FOR DOOR IS BUILT INTO DOOR PANEL, AN EXORBITANT COST AND EXTRAVAGANT FIX FOR SOMETHING SO SMALL. BROKEN INTERIOR DOOR L…
Read full complaint
THROUGH NORMAL USE, IN THE COURSE OF THE LAST TWO YEARS BOTH OF THE FRONT INTERIOR DOOR HANDLE ASSEMBLIES HAVE BROKEN. MANUFACTURER'S SUGGESTED FIX IS TO REPLACE ENTIRE INTERIOR DOOR PANEL ASSEMBLY, AS LINKAGE FOR DOOR IS BUILT INTO DOOR PANEL, AN EXORBITANT COST AND EXTRAVAGANT FIX FOR SOMETHING SO SMALL. BROKEN INTERIOR DOOR LINKAGE MEANS OCCUPANTS MUST ROLL WINDOWS DOWN, AND ACCESS EXTERIOR DOOR HANDLE THROUGH WINDOW IN ORDER TO OPEN CAR DOOR. THIS IS A POTENTIAL SAFETY CONCERN IN EVENT OF A CRASH AND EMERGENCY EGRESS NEEDS TO BE MADE FROM THE VEHICLE. *TR
NHTSA ODI #10231983
106,004 miles · Jun 22, 2008
Engine And Engine Cooling
I WAS DRIVING ON THE FREEWAY AND WITHOUT WARNING THE ENGINE LOST POWER AND THE CHECK ENGINE LIGHT CAME ON. I COASTED OFF TO THE SHOULDER AND THE ENGINE WOULD ONLY IDLE, AND EVEN THAT WAS ROUGH. THE MESSAGE INDICATOR ON THE DASH SAID SOMETHING LIKE "REDUCED ENGINE PERFORMANCE". I HAD THE CAR TOWED TO GENGRAS VOLVO IN MERIDEN. THE…
Read full complaint
I WAS DRIVING ON THE FREEWAY AND WITHOUT WARNING THE ENGINE LOST POWER AND THE CHECK ENGINE LIGHT CAME ON. I COASTED OFF TO THE SHOULDER AND THE ENGINE WOULD ONLY IDLE, AND EVEN THAT WAS ROUGH. THE MESSAGE INDICATOR ON THE DASH SAID SOMETHING LIKE "REDUCED ENGINE PERFORMANCE". I HAD THE CAR TOWED TO GENGRAS VOLVO IN MERIDEN. THEY REPLACED THE ETM , SOFTWARE AND THROTTLE BODY AT THE COST OF $1195.43. ABOUT TWO WEEKS LATER, I WAS DRIVING ON THE FREEWAY AND THE SAME THING HAPPENED. THIS TIME THE DEALERSHIP SAID THE ELECTRICAL CONNECTIONS TO THE ETM MUST BE BAD AND REPLACED SAME AT NO COST TO ME. NOW ABOUT 10 DAYS AFTER THAT REPAIR, THE SAME THING HAPPENED TO ME ON THE FREEWAY AGAIN. SINCE IT IS THE WEEKEND, I HAVE TO WAIT UNTIL MONDAY FOR THE DEALER TO GIVE ME THE DIAGNOSIS THIS TIME. SINCE THE SECOND FAILURE OF THE PART I HAVE ONLY DRIVEN IN THE RIGHT MOST LANE OF THE HIGHWAY SO THAT WHEN THE CAR DIES AGAIN I CAN GET TO THE SHOULDER SAFELY. IT IS A GOOD THING I DO THIS AS THE ISSUE COMES ON SUDDENLY AND WITHOUT ANY WARNING. *TR
NHTSA ODI #10231939
44,445 miles · Apr 22, 2008
Electrical System
ON A CAR THAT IS DRIVEN 7,500 MILES PER YEAR, I JUST SPENT $1,068 TO REPLACE AN ALTERNATOR AND $157.18 FOR A NEW BATTERY BECAUSE VOLVO REFUSED TO HAVE A RECALL OR COVER THEIR KNOWN FAILING ALTERNATORS. THIS CAUSE MY CAR TO FAIL ON THE 101 FREEWAY AND LEFT ME STRANDED IN TRAFFIC ON MILBRAE AVENUE. *TR
NHTSA ODI #10225324
Mileage unknown · Apr 20, 2008
Fuel System, Gasoline
I OWN A 2002 VOLVO S60 AND HAVE HAD A STRONG FUEL ODOR. IT DOES NOT START RIGHT AWAY WHEN TURNING THE KEY, MOST TIMES IT TAKES PUMPING THE PEDAL FOR THE CAR TO START. I LIVE IN NORTH CAROLINA WHERE THE WEATHER IS HOT. I HAVE READ IN A RECALL (NHTSA HAS A CAMPAIGN NUMBER 07V152000 AND VOLVO HAS CAMPAIGN NUMBER R176 ) THAT THIS…
Read full complaint
I OWN A 2002 VOLVO S60 AND HAVE HAD A STRONG FUEL ODOR. IT DOES NOT START RIGHT AWAY WHEN TURNING THE KEY, MOST TIMES IT TAKES PUMPING THE PEDAL FOR THE CAR TO START. I LIVE IN NORTH CAROLINA WHERE THE WEATHER IS HOT. I HAVE READ IN A RECALL (NHTSA HAS A CAMPAIGN NUMBER 07V152000 AND VOLVO HAS CAMPAIGN NUMBER R176 ) THAT THIS PROBLEM IS A RECALL BUT ONLY FOR ARIZONA AND NEVADA. THIS RECALL SHOULD BE FOR ALL STATES ESPECIALLY STATES LIKE NC AND FLORIDA THAT GET JUST AS HOT. THIS IS A SAFETY ISSUE FOR OTHER STATES ALSO. *TR
NHTSA ODI #10225188
60,000 miles · Apr 6, 2008
Fuel System, Gasoline
EXPERIENCE EXTREME GAS SMELLS WHICH PERMEATED INTO THE HOUSE VIA GARAGE WALLS. AFTER HAVING IT INSPECTED BY A MECHANIC, IT WAS DETERMINED THAT THERE WAS A CRACK IN THE DELIVERY MECHANISM OF THE TANK. REPLACED PARTS AND PROBLEM HAS BEEN CORRECTED. *TR
NHTSA ODI #10223470
55,000 miles · Jan 25, 2008
Power Train
WE ARE A 2 VOLVO FAMILY (HAVING PURCHASED THEM "PRE-CERTIFIED FROM VOLVO 2 AND 3 YEARS AGO RESPECTIVELY). BOTH CARS (2002 S60 & 2001 CROSS COUNTRY) HAVE HAD TO HAVE THEIR TRANSMISSIONS REPLACED SINCE PURCHASE - MINE ONCE (SO FAR) AND MY HUSBAND'S THREE TIMES - ALL BEFORE 55,000 MILES. I WENT ONLINE AND FOUND LITERALLY HUNDREDS…
Read full complaint
WE ARE A 2 VOLVO FAMILY (HAVING PURCHASED THEM "PRE-CERTIFIED FROM VOLVO 2 AND 3 YEARS AGO RESPECTIVELY). BOTH CARS (2002 S60 & 2001 CROSS COUNTRY) HAVE HAD TO HAVE THEIR TRANSMISSIONS REPLACED SINCE PURCHASE - MINE ONCE (SO FAR) AND MY HUSBAND'S THREE TIMES - ALL BEFORE 55,000 MILES. I WENT ONLINE AND FOUND LITERALLY HUNDREDS OF COMPLAINTS ON DEFECTIVE VOLVO TRANSMISSIONS: ALL VOLVO MODELS - FROM 2001 THROUGH 2006 AND MILEAGE RANGING FROM 20,000 TO 60,000. WHY HAS VOLVO USA NOT BEEN TAKEN TO TASK ON THESE DEFECTIVE FACTORY INSTALLED TRANSMISSIONS AND MADE TO STAND BEHIND THE MANUFACTURE OF THEIR CARS? *TR
NHTSA ODI #10216030
36,700 miles · Dec 2, 2007
Fuel System, Gasoline
THIS IS IN REFERENCE TO NHTSA CAMPAIGN NO. 07V152000. REF. FUEL SYSTEM, GASOLINE: DELIVERY:FUEL PUMP. IN THIS CASE YOU INDICATE THAT THE PROBLEM INVOLVES VEHICLES REGISTERED IN ARIZONA AND NEVADA. I AM HAVING THIS PROBLEM WITH A VEHICLE IN FLORIDA. MAYBE THIS PROBLEM IS NOT LIMITED TO ONLY 2 STATES. *TR
NHTSA ODI #10210480
69,000 miles · Nov 26, 2007
Fuel System, Other
I NOTICED A FUEL SMELL COMING FROM THE PASSENGER COMPARTMENT, WHICH STEADILY GOT WORSE. I BROUGHT IT TO MY MECHANIC AND FOUND THE FUEL PUMP WAS LEAKING. I PAID TO HAVE IT REPLACED. *TR
NHTSA ODI #10209970
68,264 miles · Nov 16, 2007
Fuel System, Gasoline
FUEL PUMP LEAKAGE AND SMELL INSIDE AND OUTSIDE OF VOLVO S60. THIS IS A KNOWN ISSUE AND VOLVO HAS ISSUED A RECALL IN THE STATES OF NEVADA AND ARIZONA FOR A DEFECTIVE PLASTIC PUMP HOUSING. R176 IS VOLVO'S RECALL NUMBER AND NHTSA'S NUMBER IS 07V152000. VOLVO REFUSED TO REPLACE MY FUEL PUMP AS I'M IN FLORIDA. THE LOCAL VOLVO DEA…
Read full complaint
FUEL PUMP LEAKAGE AND SMELL INSIDE AND OUTSIDE OF VOLVO S60. THIS IS A KNOWN ISSUE AND VOLVO HAS ISSUED A RECALL IN THE STATES OF NEVADA AND ARIZONA FOR A DEFECTIVE PLASTIC PUMP HOUSING. R176 IS VOLVO'S RECALL NUMBER AND NHTSA'S NUMBER IS 07V152000. VOLVO REFUSED TO REPLACE MY FUEL PUMP AS I'M IN FLORIDA. THE LOCAL VOLVO DEALER DID NOT HAVE THE FUEL PUMP IN STOCK BECAUSE IT WAS ON NATIONAL BACKORDER SO THEY KNOW THERE IS A PROBLEM WITH THE DESIGN YET REFUSED TO ACKNOWLEDGE ANYTHING WAS WRONG. I BELIEVE VOLVO IS BEING DISHONEST ABOUT FIXING THEIR SAFETY DEFECTS. *TR
NHTSA ODI #10209149
Mileage unknown · Nov 10, 2007
Fuel System, Gasoline
FUEL SMELL VOLVO S60 YEAR 2002 NHTSA HAS A CAMPAIGN NUMBER 07V152000 AND VOLVO HAS CAMPAIGN NUMBER R176. *TR
Volvo Car USA, LLC (Volvo Car) is recalling certain 2001-2006 S80 and 2001-2009 S60 vehicles. The driver's air bag inflator may explode during deployment, due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag, free of charge. Owner notification letters were mailed November 29, 2021. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo's number for this recall is R10125.
Volvo Car USA LLC (Volvo Car) is recalling certain 2001-2003 S80 and S60 vehicles sold or ever registered in Alabama, Arkansas, Florida, Georgia, Hawaii, Louisiana, Mississippi, North Carolina, Oklahoma, South Carolina, Tennessee, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands. The driver side frontal air bag inflator may rupture, sending metal fragments into the passage compartment, when the driver side air bag is deployed.
Consequence & remedy
Consequence: Metal fragments can strike vehicle occupants increasing the risk of serious injury or death.
Remedy: Volvo Car will notify owners, and dealers will replace the driver side air bag module, free of charge. The recall began April 20, 2021. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10058.
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Consequence & remedy
Consequence: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
VOLVO IS RECALLING CERTAIN MODEL YEAR 2001-2005 S80, MODEL YEAR 2001-2004 V70, S60, XC70 AND MODEL YEAR 2003-2005 XC90 VEHICLES SOLD IN OR REGISTERED IN THE STATES OF ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, KENTUCKY, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, UTAH, VIRGINIA AND THE U.S. TERRITORIES. WHEN EXPOSED TO CERTAIN ENVIRONMENTAL CONDITIONS (HOT CLIMATE AND TEMPERATURE CYCLING) OVER TIME AND IN COMBINATION WITH VARYING FUEL QUALITY, THE FUEL PUMP CAN DEVELOP CRACKS IN THE FUEL PUMP FLANGE.
Consequence & remedy
Consequence: IF THE CONDITION OCCURS VEHICLE OWNERS MAY NOTICE FUEL SMELL AND/OR FUEL LEAK WHICH, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL PUMP INSTALLED IN THE VEHICLE, AND IF NECESSARY REPLACE THE FUEL PUMP WITH A PART OF A MODIFIED DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 15, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
ON CERTAIN VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA, DUE TO THE COMBINATION OF FUEL QUALITY AND CLIMATE CONDITIONS, THE FUEL PUMP MAY, IN CERTAIN CASES, EXPERIENCE A REDUCED FUNCTIONALITY. THE MOST COMMON SYMPTOMS WOULD BE FUEL ODOR.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP FREE OF CHARGE. THE RECALL BEGAN ON JULY 10, 2007. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
ON CERTAIN PASSENGER VEHICLES, A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING, AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.
Consequence & remedy
Consequence: THIS RESULTED IN A HIGH NUMBER OF VEHICLES GOING INTO THE LIMP HOME MODE WITHOUT NEED.
Remedy: DEALERS WILL INSTALL THE CURRENT SOFTWARE UPGRADE ONTO THE INVOLVED VEHICLES. THE RECALL BEGAN ON DECEMBER 29, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE TIRE PRESSURE LABEL IS INCORRECT. THESE VEHICLES DID NOT HAVE THE "MAX LOAD VEHICLE CAPACITY WEIGHT" INFORMATION ON THE LABEL.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A CORRECTED LABEL. IF THE OWNER SO DESIRES, A DEALER CAN INSTALL THE LABEL FOR THEM. OWNER NOTIFICATION BEGAN ON DECEMBER 8, 2003. OWNERS SHOULD CONTACT VOLVO AT 1-800-458-1552.
CERTAIN PASSENGER CARS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE SECOND ISOFIX GUIDE WAS NOT INSTALLED IN THESE VEHICLES AND, IN CERTAIN CASES, THE OWNER'S MANUAL ISOFIX INFORMATION IS INCORRECT.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: OWNERS WILL RECEIVE A LETTER/PACKAGE CONSISTING OF THE SECOND ISOFIX GUIDE WITH INSTALLATION INSTRUCTIONS, AND IN CERTAIN CASES, THE CORRECTED OWNER'S MANUAL MAY BE PROVIDED. IF THE OWNER WANTS TO TAKE THEIR VEHICLE TO A VOLVO DEALER FOR INSTALLATION OF THE GUIDE, IT WILL BE PERFORMED AT NO CHARGE TO THE OWNER. OWNER NOTIFICATION BEGAN ON DECEMBER 19, 2003. OWNERS SHOULD CONTACT VOLVO AT 1-800-458-1552.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA05021 · Throttle Control Malfunction
Opened Dec 6, 2005 · Closed Dec 12, 2006
Status: closed (inferred from source dates) · Vehicle Speed Control
ON NOVEMBER 14, 2006 VOLVO SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING ETM FAILURES IN MODEL YEAR (MY) 1999 THROUGH 2001 VOLVO MODELS (NOT INCLUDING THE S40 AND V40), MY 2002 S60 AND V70 WITH NATURALLY ASPIRATED ENGINES AND MY 2002 V70S.ACCORDING TO VOLVO, ?A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.VOLVO FURTHER STATED THAT,THIS RESULTED IN A HIGH NUMBER OF THESE VEHICLES GOING INTO LIMP HOME MODE WITHOUT NEED.?VOLVO INDICATED THAT THIS WAS THE MOST SEVERE CONSEQUENCE OF AN ETM FAULT IN THE SUBJECT VEHICLES.THE RECALL REMEDY IS A SOFTWARE UPGRADE INTRODUCED BY VOLVO ON MARCH 16, 2006 IN A CUSTOMER SATISFACTION PROGRAM.AT THE TIME OF THE NOTIFICATION 161,202 VEHICLES OF THE POPULATION OF 331,301 HAD ALREADY HAD THE SOFTWARE UPLOADED AND WERE THEREFORE NOT INCLUDED IN THE POPULATION COUNT OF THE RECALL. ODI?S ANALYSIS OF COMPLAINTS TO ODI AND VOLVO, VOLVO FIELD REPORTS AND WARRANTY DATA FOUND THAT ETM FAILURE COULD RESULT IN (1) ENGINE STALL; (2) MECHANICAL LIMP MODE; (3) LUNGING FORWARD DURING LOW-SPEED DRIVING MANEUVERS; AND (4) FALTERING DURING HIGH SPEED MERGES OR WHEN CROSSING TRAFFIC.ODI IDENTIFIED 12 CRASHES RELATED TO ETM FAILURE, WITH 6 CAUSED BY LUNGING INCIDENTS, 3 CAUSED BY STALLING INCIDENTS, 2 CAUSED BY MECHANICAL LIMP MODE AND 1 FROM THE FALTERING CONDITION.ODI'S ANALYSIS OF COMPLAINT DATA AND INFORMATION OBTAINED FROM CONSUMER INTERVIEWS IDENTIFIED 1,289 INCIDENTS WITH SAFETY RELATED CONSEQUENCES (389.1 PER 100,000 VEHICLES), INCLUDING 479 INVOLVING ENGINE STALL (144.6 PER 100,000 VEHICLES) AND 729 INVOLVING MECHANICAL LIMP MODE (220.0 PER 100,000 VEHICLES).ODI'S ANALYSIS OF WARRANTY CLAIM NARRATIVE TEXT SHOWS AT LEAST 14,965 WARRANTY CLAIMS WITH CODES INDICATING AN ETM FAULT RESULTING IN VEHICLE OPERATION IN MECHANICAL LIMP MODE (4.5% OF THE SUBJECT VEHICLES). VOLVO?S RECALL ADDRESSES ODI?S SAFETY CONCERNS WITH ETM FAILURES.ODI WILL CONTINUE TO MONITOR THE SUBJECT VEHICLES TO DETERMINE IF ADDITIONAL ACTION IS REQUIRED.THIS ENGINEERING ANALYSIS IS CLOSED.
PE05041 · Throttle Control Malfunction
Opened Jul 26, 2005 · Closed Dec 7, 2005
Status: closed (inferred from source dates) · Vehicle Speed Control
PE05-041 WAS OPENED ON JULY, 26, 2005, BASED ON 136 CONSUMER COMPLAINTS TO ODI ALLEGING THROTTLE CONTROL MALFUNCTIONS IN THE SUBJECT VEHICLES.ODI HAS NOW RECEIVED 591 COMPLAINTS OF ETM FAILURES WHICH ALLEGE SYMPTOMS WITH POTENTIAL SAFETY RELATED CONSEQUENCES.THESE INCLUDE ALLEGATIONS OF ENGINE STALL, VEHICLE SURGING FORWARD WITHOUT ACCELERATOR INPUT, VEHICLE HESITATION UPON ACCELERATION AND SUDDEN AND UNEXPECTED TRANSITION INTO REDUCED PERFORMANCE OPERATION (LIMP MODE).VOLVO SUBMITTED OVER 2,900 COMPLAINTS CONCERNING THE ETM IN THE SUBJECT VEHICLES DURING PE05-041.ODI'S PRELIMINARY ANALYSIS OF A SAMPLE THE VOLVO COMPLAINTS IDENTIFIED APPROXIMATELY 55 PERCENT WITH ONE OR MORE OF THE SYMPTOMS DESCRIBED ABOVE.ODI IS CONTINUING ITS ASSESSMENT OF THE INFORMATION CONTAINED IN THE VOLVO COMPLAINTS. IN NOVEMBER 2005, TO RESOLVE AN INVESTIGATION BY THE CALIFORNIA AIR RESOURCES BOARD, VOLVO ANNOUNCED THAT IT WOULD EXTEND THE WARRANTY COVERAGE TO 10 YEARS / 200,000 MILES FOR THE ETM IN APPROXIMATELY 356,000 MODEL YEAR 1999 THROUGH 2002 PASSENGER CARS SOLD IN THE UNITED STATES AND CANADA.UNDER VOLVO'S POLICY, VEHICLES THAT EXPERIENCE ETM FAILURES WILL RECEIVE A VARIETY OF REPAIRS INCLUDING ETM CLEANING, REPROGRAMMING THE ENGINE CONTROL MODULE AND/OR REPLACEMENT OF THE ETM. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA05-021) TO CONTINUE TO ASSESS THE SAFETY CONSEQUENCES OF ETM FAILURES IN THE SUBJECT VEHICLES.
2002 Volvo S60 Problems, Complaints & Recalls | Skip That Year
Illustration