TL* THE CONTACT OWNS A 1987 VOLKSWAGEN VANAGON, EQUIPPED WITH MASTER CRAFT GLACIER GRIP TIRES SIZE: 185/70/ R14. THE CONTACT WAS DRIVING 55 MPH WHEN THE FRONT PASSENGER SIDE AND REAR DRIVER SIDE WHEELS BEGAN SHAKING ABNORMALLY. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THE CONTACT THAT THE CHORDS WERE DETACHED FROM THE TIR…
Read full complaint
TL* THE CONTACT OWNS A 1987 VOLKSWAGEN VANAGON, EQUIPPED WITH MASTER CRAFT GLACIER GRIP TIRES SIZE: 185/70/ R14. THE CONTACT WAS DRIVING 55 MPH WHEN THE FRONT PASSENGER SIDE AND REAR DRIVER SIDE WHEELS BEGAN SHAKING ABNORMALLY. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THE CONTACT THAT THE CHORDS WERE DETACHED FROM THE TIRES. THE MANUFACTURER WAS NOT CONTACTED. THE TIRES WERE NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGES WERE UNKNOWN.
THE PLASTIC MATERIAL OF THE CENTER AIR FLOW DUCT, WHICH IS FASTENED BY TWO MOUNTING SCREWS TO THE CEILING OF THE PASSENGER COMPARTMENT, CAN CRACK AND EVENTUALLY BREAK.
Consequence & remedy
Consequence: IF THE PLASTIC BREAKS WHERE IT IS HELD AT THE TWOMOUNTING SCREWS, THE CENTER AIR FLOW DUCT CAN SEPARATE FROM ITS SUPPORTS ANDCAUSE INJURY TO THE PASSENGERS SITTING IN THE CENTER SEAT OF THE VEHICLE.
Remedy: DEALERS WILL INSTALL A REINFORCEMENT PLATE AT THE CONNECTIONS OF BOTH THE CENTER AND REAR AIR FLOW DUCTS.
WHEN USING THE CRUISE CONTROL THE ACCELERATOR CABLE TENSION MAY ALLOW THE CABLE TO SAG AND BECOME ENTANGLED WITH THE WATER PIPE BRACKET IMPEDING ITS RETURN TO IDLE POSITION.
Consequence & remedy
Consequence: FAILURE TO RETURN TO IDLE POSITION COULD LEAD TO ANACCIDENT.
Remedy: THE PRESENT ACCELERATOR CABLE BRACKET WILL BE REPLACED.
PIN IN SHIFT LOCKING PAWL MAY NOT BE PROPERLY WELDED TO THE PAWL.
Consequence & remedy
Consequence: IF PIN SEPARATES FROM PAWL, DRIVER WOULD BE ABLE TO MOVETHE SHIFT LEVER DURING DRIVING INTO ANY POSITION WITHOUT PRESSING SAFETYRELEASE BUTTON.
Illustration