IllustrationVEHICLE WAS IN MOTION (ABOUT 25 MPH) WHEN A FRONT END COLLISION OCCURRED WHICH RESULTED IN THE PASSENGER SIDE AIRBAG ACTIVATING ONLY. THE DRIVER SIDE STEERING WHEEL AIRBAG DID NOT ACTIVATE. DRIVER'S FACE HIT THE STEERING WHEEL.
2002 Volkswagen Beetle
Owner reports · Recalls · Investigations
More warning signs than most Beetle years
Owner complaints for the 2002 Volkswagen Beetle are substantially higher than the model-year median of 49.
About this comparison →How this year compares
Owner complaints by model year
Compare all Beetle years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
170–25K
2325–50K
3850–75K
1675–100K
15100–150K
5150K+
114 reports with mileage · 51 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 43 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 36 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
13 crash reports4 fire reports11 injury reports
Structure complaints
10 reportsTL* THE CONTACT OWNS A 2002 VOLKSWAGEN BEETLE CONVERTIBLE. WHILE DRIVING APPROXIMATELY 40 MPH IN THE RAIN, WATER SUDDENLY LEAKED INTO THE CABIN OF THE VEHICLE AND ONTO THE DRIVER. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 29…
Read full complaint
TL* THE CONTACT OWNS A 2002 VOLKSWAGEN BEETLE CONVERTIBLE. WHILE DRIVING APPROXIMATELY 40 MPH IN THE RAIN, WATER SUDDENLY LEAKED INTO THE CABIN OF THE VEHICLE AND ONTO THE DRIVER. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 29,000.
THE INTERIOR SMELLS STRONGLY OF CRAYONS AND WILL NOT GO AWAY WITH SHAMPOOING, CLEANING AND/OR OTHER METHODS OF ODOR REMOVAL. THE ODOR IS VERY STRONG AND RUBS OFF ON CLOTHING AND SKIN WHILST SEATED.
WATER LEAKING FROM MOONROOF. HEADLINER DAMP AND LOOSE. *TR
TL* THE CONTACT OWNS A 2002 VOLKSWAGEN BEETLE. THE CONTACT STATED THAT THE VEHICLE EXHIBITED AN ABNORMAL ODOR THAT CAUSED THE CONTACT TO RECEIVE HEADACHES. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHERE THE DEALER ADVISED THAT THE ODOR WAS CAUSED BY A STAIN ON THE FLOOR MATS. THE CONTACT STATED THAT THE ODOR WAS NOT COMING FR…
Read full complaint
TL* THE CONTACT OWNS A 2002 VOLKSWAGEN BEETLE. THE CONTACT STATED THAT THE VEHICLE EXHIBITED AN ABNORMAL ODOR THAT CAUSED THE CONTACT TO RECEIVE HEADACHES. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHERE THE DEALER ADVISED THAT THE ODOR WAS CAUSED BY A STAIN ON THE FLOOR MATS. THE CONTACT STATED THAT THE ODOR WAS NOT COMING FROM THE FLOOR MATS BUT THE ENTIRE CARPET KIT. THE CONTACT REMOVED THE CARPET KIT BUT THE ODOR PERSISTED. THE FAILURE MILEAGE WAS 63,000. THE VIN WAS NOT AVAILABLE.
CURRENTLY HAVE VERY LOW MILEAGE(NOW UNDER 20000) 2002 VW NEW BEETLE PURCHASED NEW. AFTER TIME WARRANTY EXPIRED BOTH POWER WINDOW(PASSENGER AND DRIVER SIDES) REGULATORS FAILED (AT DIFFERENT TIMES AND MILEAGES) SPONTANEOUSLY NOT DUE TO ANY EXTERNAL EVENT.. BOTH REGULATORS REQUIRED REPLACEMENT AT CONSIDERABLE COST. THIS IS VERY UN…
Read full complaint
CURRENTLY HAVE VERY LOW MILEAGE(NOW UNDER 20000) 2002 VW NEW BEETLE PURCHASED NEW. AFTER TIME WARRANTY EXPIRED BOTH POWER WINDOW(PASSENGER AND DRIVER SIDES) REGULATORS FAILED (AT DIFFERENT TIMES AND MILEAGES) SPONTANEOUSLY NOT DUE TO ANY EXTERNAL EVENT.. BOTH REGULATORS REQUIRED REPLACEMENT AT CONSIDERABLE COST. THIS IS VERY UNUSUAL BECAUSE AUTO WINDOW REGULATORS USUALLY ARE VERY DURABLE WHEN NOT DAMAGED BY EXTERNAL CRASH OR THE LIKE. I REPORTED THIS TO VOLKSWAGEN BUT GOT NO SATISFACTION. ON THE INTERNET I HAVE FOUND MANY OTHER COMPLAINTS FROM OWNERS ABOUT THIS PROBLEM TO THEIR DISMAY AND WITHOUT SATISFACTION FROM VOLKSWAGEN. THERE SHOULD HAVE BEEN A RECALL FOR THE DEFECTIVE PARTS! *TR
WE PURCHASED A USED 2002 VW BEETLE FOR OUR DAUGHTER. IT SMELLS LIKE BURNT CRAYONS AND GIVES HER A SERIOUS HEADACHE. ONLINE THERE A NUMEROUS PEOPLE COMPLAINING OF THIS SAME PROBLEM. IT COMES FROM SOMETHING SPRAYED ON THE UNDERCARRIAGE, THAT SMELLS MORE WHEN THE CAR IS HEATED UP. YOU MUST BE AWARE OF THIS PROBLEM. WHAT ARE YOU GOI…
Read full complaint
WE PURCHASED A USED 2002 VW BEETLE FOR OUR DAUGHTER. IT SMELLS LIKE BURNT CRAYONS AND GIVES HER A SERIOUS HEADACHE. ONLINE THERE A NUMEROUS PEOPLE COMPLAINING OF THIS SAME PROBLEM. IT COMES FROM SOMETHING SPRAYED ON THE UNDERCARRIAGE, THAT SMELLS MORE WHEN THE CAR IS HEATED UP. YOU MUST BE AWARE OF THIS PROBLEM. WHAT ARE YOU GOING TO DO. WHAT SHOULD WE DO. THE ODOR WAS COVERED UP DURING THE TEST DRIVE, BUT HAS NOW BECOME UNBEARABLE. WHAT AVENUES SHOULD WE PURSUE. LEMON LAW, RECALL, ...WHAT SHOULD WE DO...OR MORE APTLY WHAT AREN'T YOU DOING? I WANT A SOLUTION. *TR
REAR COLLISION ACCIDENT IN 2004, NOW SEATBELT LATCH MECHANISM NOT WORKING, STRUTS AND WHEEL BEARINGS DAMAGED AND NEED REPLACEMENT ALONG WITH SUBFRAME AND EMERGENCY BRAKE SYSTEM. *TR
DT : THE KEY WILL NOT TURN IN THE INGITION. HAD TO WAIT UP TO 10 MINUTES IN ORDER TO GET THE VEHICLE TO START. ONCE IT STARTED IT STAYED LOCKED/PARKED. IT WAS INTERMITTENTLY. CONTACTED THE DEALE, THEY COULD NOT DUPLICATE THE PROBLEM AND COULD NOT T REPLACE PARTS UNTIL THEY DUPLICATE. THIS STARTED ON MAY 15, 2005. ALSO THE TRUN…
Read full complaint
DT : THE KEY WILL NOT TURN IN THE INGITION. HAD TO WAIT UP TO 10 MINUTES IN ORDER TO GET THE VEHICLE TO START. ONCE IT STARTED IT STAYED LOCKED/PARKED. IT WAS INTERMITTENTLY. CONTACTED THE DEALE, THEY COULD NOT DUPLICATE THE PROBLEM AND COULD NOT T REPLACE PARTS UNTIL THEY DUPLICATE. THIS STARTED ON MAY 15, 2005. ALSO THE TRUNK RELEASE WILL NOT UNLOCK FROM THE BUTTON THAT USED INSIDE THE VEHICLE. DEALER COULD NOT DUPLICATE THIS PROBLEM EITHER. *AK
CONSUMER STATED HE HAS LEARNED THAT THE REAR SPOILER WILL DEPLOY WHEN DRIVING 45-50 MPH, CONSUMER STATED ON THE 2001 MODEL IN ORDER FOR THE REAR SPOILER TO DEPLOY, THE VEHICLE MUST BE DRIVEN AT A RATE OF 80 MPH, CONSUMER FEELS THAT THIS FEATURE WAS MISREPRESENTED AND WANTS TO RETURN THE VEHICLE OR HAVE THIS FEATURE DISENGAGED SI…
Read full complaint
CONSUMER STATED HE HAS LEARNED THAT THE REAR SPOILER WILL DEPLOY WHEN DRIVING 45-50 MPH, CONSUMER STATED ON THE 2001 MODEL IN ORDER FOR THE REAR SPOILER TO DEPLOY, THE VEHICLE MUST BE DRIVEN AT A RATE OF 80 MPH, CONSUMER FEELS THAT THIS FEATURE WAS MISREPRESENTED AND WANTS TO RETURN THE VEHICLE OR HAVE THIS FEATURE DISENGAGED SINCE THE SPOILER IS DESIGNED TO DEPLOY AT SUCH A LOW SPEED.*JB
Official recalls
207V063000 · Exterior Lighting:brake Lights:switch
Feb 20, 2007
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
06V183000 · Exterior Lighting:brake Lights:switch
May 24, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC OR MANUAL TRANSMISSIONS AND CRUISE CONTROLS, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING SAFETY RECALLS 03V-265 OR 04V-096.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 27, 2006. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2RQ06004 · Brake Light Switch Failure
Opened Feb 28, 2006 · Closed Aug 7, 2006
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:brake Lights
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
EA03002 · Brake Light Switch
Opened Apr 8, 2003 · Closed Aug 20, 2003
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch
THE BRAKE LIGHT SWITCH USED IN CRUISE CONTROL EQUIPPED MY 1998-1999 AND ALL MY 2000 AND LATER MODELS HAS UNDERGONE MULTIPLE REVISIONS.ANALYSIS OF WARRANTY AND COMPLAINT DATA INDICATES HIGH REPLACEMENT RATES OCCURRED IN VEHICLES BUILT WITH BRAKE SWITCH PART NUMBERS 1J0 945 511A AND 1J0 945 511B, THE ORIGINAL AND FIRST REVISION LEVELS, RESPECTIVELY.THE FAILURE OF THE SWITCH COULD RESULT IN FAILURE OF THE BRAKE LIGHTS TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD CAUSE THE BRAKE LAMPS TO STAY CONTINUALLY ILLUMINATED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING.UNDER SAFETY RECALL 03V-265, VOLKSWAGEN WILL INSPECT THE BRAKE LIGHT SWITCH ON ALL VEHICLES BUILT THROUGH NOVEMBER 2001.ANY AFFECTED SWITCH WILL BE REPLACED FREE OF CHARGE WITH THE MOST CURRENT VERSION, PART NUMBER 1J0 945 511D.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
THE BRAKE LIGHT SWITCH USED IN CRUISE CONTROL EQUIPPED MY 1998-1999 AND ALL MY 2000 AND LATER MODELS HAS UNDERGONE MULTIPLE REVISIONS.ANALYSIS OF WARRANTY AND COMPLAINT DATA INDICATES HIGH REPLACEMENT RATES OCCURRED IN VEHICLES BUILT WITH BRAKE SWITCH PART NUMBERS 1J0 945 511A AND 1J0 945 511B, THE ORIGINAL AND FIRST REVISION LEVELS, RESPECTIVELY.THE FAILURE OF THE SWITCH COULD RESULT IN FAILURE OF THE BRAKE LIGHTS TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD CAUSE THE BRAKE LAMPS TO STAY CONTINUALLY ILLUMINATED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING.UNDER SAFETY RECALL 03V-265, VOLKSWAGEN WILL INSPECT THE BRAKE LIGHT SWITCH ON ALL VEHICLES BUILT THROUGH NOVEMBER 2001.ANY AFFECTED SWITCH WILL BE REPLACED FREE OF CHARGE WITH THE MOST CURRENT VERSION, PART NUMBER 1J0 945 511D.
Exterior Lighting:brake Lights
THE BRAKE LIGHT SWITCH USED IN CRUISE CONTROL EQUIPPED MY 1998-1999 AND ALL MY 2000 AND LATER MODELS HAS UNDERGONE MULTIPLE REVISIONS.ANALYSIS OF WARRANTY AND COMPLAINT DATA INDICATES HIGH REPLACEMENT RATES OCCURRED IN VEHICLES BUILT WITH BRAKE SWITCH PART NUMBERS 1J0 945 511A AND 1J0 945 511B, THE ORIGINAL AND FIRST REVISION LEVELS, RESPECTIVELY.THE FAILURE OF THE SWITCH COULD RESULT IN FAILURE OF THE BRAKE LIGHTS TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD CAUSE THE BRAKE LAMPS TO STAY CONTINUALLY ILLUMINATED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING.UNDER SAFETY RECALL 03V-265, VOLKSWAGEN WILL INSPECT THE BRAKE LIGHT SWITCH ON ALL VEHICLES BUILT THROUGH NOVEMBER 2001.ANY AFFECTED SWITCH WILL BE REPLACED FREE OF CHARGE WITH THE MOST CURRENT VERSION, PART NUMBER 1J0 945 511D.